HAMPTON BAY FP20517 User manual


:$51,1*
'RQRWVWRUHRUXVHJDVROLQHRURWKHU
IODPPDEOHYDSRUVDQGOLTXLGVLQWKH
YLFLQLW\ RIWKLVRUDQ\RWKHUDSSOLDQFH
$Q/3F\OLQGHUQRWFRQQHFWHGIRUXVH
VKDOOQRWEHVWRUHGLQWKHYLFLQLW\RI
WKLVRUDQ\ RWKHUDSSOLDQFH
:$51,1*
86(3523$1(*$621/<
)RUXVHZLWKWDQNVPDUNHGpropaneRQO\
'2127FRQQHFWWRDUHPRWHJDVVXSSO\
3URSDQH7DQNVVROGVHSDUDWHO\
'$1*(5
&$5%210212;,'(+$=$5'
7KLVDSSOLDQFHFDQSURGXFHFDUERQPRQR[LGHZKLFKKDVQRRGRU
8VLQJLWLQDQHQFORVHGVSDFHFDQNLOO\RX
1HYHUXVHWKLVDSSOLDQFHLQDQHQFORVHGVSDFHVXFKDVFDPSHU
WHQWFDU RUKRPH
,167$//(5
/HDYHWKLVPDQXDOZLWKWKHDSSOLDQFH
&21680(5
5HWDLQWKLVPDQXDOIRUIXWXUHUHIHUHQFH
7KLV)LUH3LWPXVWEHDWWHQGHGDWDOOWLPHV
:$51,1*
:KHQ)LUH3LWLVQRWLQXVH²GLVFRQQHFW
3URSDQH7DQN
,I)LUH3LWLVVWRUHGLQGRRUV²UHPRYH
3URSDQH7DQN
),5(25(;3/26,21+$=$5'
,I\RXVPHOOJDV
6KXWRIIJDVWRWKHDSSOLDQFH
([WLQJXLVKDQ\RSHQIODPH
3.If odor continues, leave the area
immediately.
4.After leaving the area, call your gas
supplier or fire departent. :$51,1*
,IWKHLQIRUPDWLRQLQWKLVPDQXDOLVQRW
IROORZHGH[DFWO\DILUHRUH[SORVLRQ
PD\UHVXOWFDXVLQJSURSHUW\GDPDJH
SHUVRQDO LQMXU\RUORVVRIOLIH
'$1*(5
Failure to follow these instructions
could result in fire or explosion, which
could cause property damage,
personal injury, or death.
:$51,1*
 )25287'22586(21/<
,QVWDOODWLRQDQGVHUYLFHPXVWEH
SHUIRUPHGE\DTXDOLILHGLQVWDOOHU
VHUYLFHageQF\RUWKHJDVVXSSOLHU.
:$51,1*
36" Round Concrete Propane Gas Fire Pit
USE AND CARE GUIDE
Item#
Model# FP20517

5HDGDQGIROORZDOOLQVWUXFWLRQVDQGZDUQLQJVLQWKLV2ZQHU¶V0DQXDO
WKRURXJKO\EHIRUHLQVWDOOLQJRSHUDWLQJRUVHUYLFLQJWKLVfLUHpLW
,PSURSHULQVWDOODWLRQXVHPDLQWHQDQFHDGMXVWPHQWRUVWRUDJHFDQFDXVH
ILUHRUH[SORVLRQUHVXOWLQJLQVHULRXVLQMXU\RUSURSHUW\GDPDJH
:$51,1*
SUHSDUHIRUXVH
.HHSDZD\IURP&RPEXVWLEOH)ODPPDEOH,WHPV
t Do not put any other fireplace cover or anything flammable on or beneath fire pit.
t Combustible materials should never be within 1.83 m/6 ft of the top, 1.22 m/4 ft of back or sides of fire pit.
t For use on noncombustible floor material only.
t Keep fire pit area clear and free from combustible materials, gasoline, and other flammable vapors and liquids.
,QVSHFWIRUOHDNVZHDUDQGGDPDJH
t Check for gas leaks before use - See page 7, Step # for instructions on how to check for gas leaks.
t Inspect burner and hose before use - Replace if there is evidence of excessive abrasion, wear, or damage.
t Inspect hose before each use. Hose assembly must be replaced prior to use if there is evidence of excessive abrasion
or wear or if hose is damaged. Use a manufacturer-specified replacement hose only.
3UHSDUHDUHDHQVXUHSURSHUXVHRI)LUH3LW&RYHU
t Make sure ventilation openings on sides of fire pit (BODY) are open and clear of debris.
t Do not lay nylon cover over fire pit for at least 4 hours after it is turned OFF and has completely cooled down.
t Do not use fire pit if any part has been under water. Immediately call a qualified service technician to inspect fire pit
and to replace any part of the control system and any gas control that has been under water.
t Remove nylon cover from fire pit before operating.
when in use:
Do's
• Use propane cylinders with the following required measurements only: 30.5 cm/12 in (diameter) x 45.7 cm/18 in (tall)
with capacity 9 kg/19.84 lbs.)
•If flame goes out while operating, turn gas valve OFF. Wait five minutes before attempting to relight.
•Due to high surface temperatures always keep a safe distance to avoid burning or clothes catching fire.
●Keep fuel supply hose away from any heated surfaces.
Don't's
•Never lean over the open fire pit or place hands or fingers on the upper portion while in use.
• Do not use fire pit for cooking.
t Do not burn any other materials other than what is supplied with and intended for use in fire pit.
t Solid fuels shall not be burned in this fire pit.
t Do not pour water into fire pit.
t Do not move fire pit while in operation.
t Fire pit should never be operated by children. Children must be supervised when they are anywhere near fire pit.
• Do not rest feet on fire pit.
t Do not use fire pit on vehicles or boats. Always operate fire pit on flat ground outdoors.
When not in use:
t The cylinder must be disconnected when the fire pit is not in use.
t Remove Battery from ignitor when not using fire pit for an extended length of time.
t Clean battery contacts and also those of the device prior to battery installation.

%"/(&34"/%8"3/*/(4
5)*4130%6$564&41301"/&0/-:
t 6TFQSPQBOFDZMJOEFSTXJUIUIFGPMMPXJOHSFRVJSFENFBTVSFNFOUTPOMZDNJOEJBNFUFSYDNJOUBMMXJUIDBQBDJUZ
LHMCT
t .BYHBTTVQQMZDNJOXDLQB
t 0OMZDZMJOEFSNBSLFEQSPQBOFwNBZCFVTFE
t MGZPVTFFTNFMMPSIFBSUIFIJTTPGFTDBQJOHHBTGSPNUIFQSPQBOFDZMJOEFS
1.Turn off gas supply and get away from gas cylinder and fire pit at once.
2.%POPUBUUFNQUUPDPSSFDUUIFQSPCMFNZPVSTFMG
3.Call your gas supplier and / or the fire department for help.
ϮŝŶĐŚĞƐƚŽ
ϭϬŝŶĐŚĞƐ
2EVHUYHIODPHFRORUDQGIODPHKHLJKWZKHQWKHfLUHpit DIWHUEHLQJOLW
)ODPHFRORUVKRXOGEH\HOORZ
)ODPHKHLJKWEXUQVDWLQFKHVKLJK
t A dented or rusty propane cylinder may be hazardous and should be cleared by your gas supplier prior to use.
t Do not attempt to disconnect gas regulator or any gas fitting while fire pit is in operation.
t The gas pressure regulator provided with fire pit must be used.
t Do not use a propane cylinder with a damaged valve and any other worn out parts.
t Transport and store empty propanecylinders carefully and properly.
&KLOGUHQDQGDGXOWVVKRXOGEHDOHUWHGWRWKHKD]DUGVRIKLJKVXUIDFHWHPSHUDWXUHVDQGVKRXOGVWD\DZD\WRDYRLGEXUQV
RUFORWKHVFDWFKLQJILUH
t Young children should be carefully supervised when they are in the area of fire pit.
t Clothing or other flammable materials should not be hung from fire pit or placed on or near fire pit.
1SPQBOFHBTTVQQMZDZMJOEFSUPCFVTFENVTUCF
t DPOTUSVDUFEBOENBSLFEJOBDDPSEBODFXJUIUIF64%FQBSUNFOUPGTransportation (DOT) Specifications for LP-Gas Cylinders PSUIF4UBOEBSE
GPS$ZMJOEFST4QIFSFTBOE5VCFTGPS5SBOTQPSUBUJPOPG%BOHFSPVT(PPETBOE$PNNJTTJPO$"/$4"#BTBQQMJDBCMF
t provided with a listed overfilling prevention device.
t provided with a cylinder connection device compatible with
the connection for the appliance.
ZKHQVWRULQJfLUHpLW
Storage of fire pit indoors is permissible only if the cylinder is disconnected and removed from fire pit. Cylinders must be stored
outdoors in a well-ventilated area out of reach of children. Disconnected cylinders must have threaded valve plugs tightly
installed and must not be stored in a building, garage or any other enclosed area.
Turn OFF control knob and close propane cylinder valve. Turn coupling nut counterclockwise by hand only—do not
use tools to disconnect. Loosen cylinder screw beneath bottom shelf, then lift propane cylinder up and out of shelf.
Place dust cap on cylinder valve outlet whenever the cylinder is not in use.
:$51,1* ,PSURSHULQVWDOODWLRQDGMXVWPHQWDOWHUDWLRQVHUYLFHRUPDLQWHQDQFHFDQFDXVHLQMXU\RUSURSHUW\GDPDJH5HIHUWR
WKHRZQHUVLQIRUPDWLRQPDQXDOSURYLGHGZLWKWKLVDSSOLDQFH)RUDVVLVWDQFHRUDGGLWLRQDOLQIRUPDWLRQFRQVXOWDTXDOLILHGLQVWDOOHU
VHUYLFHDJHQF\RUWKHJDVVXSSOLHU
The Propane-gas supply cylinder must be disconnected when this appliance is not in use.
Repairs should be done by a qualified service person. Fire pit should be inspected before use and at least annually be a qualified
service person.
More frequent cleaning may be required as necessary. It is imperative that the control compartment, burners, and circulating air
passageways of the appliance are kept clean.
Any guard or other protective device removed for servicing the appliance shall be replaced prior to operating the appliance.
Installation and repair should be done by a qualified service person. The appliance should be inspected before use and at least annually
by a qualified service person. More frequent cleaning may be required as necessary. It is imperative that the control compartment,
burners, and circulating air passageways of the appliance are kept clean.
FOR YOUR SAFETY: Surfaces of fire pit can remain extremely hot for a period after use. Allow 45 minutes to cool down before
touching or moving the fire pit

3


35(3$5$7,21)25$66(0%/<
3$&.$*(&217(176$1'&20321(176
Before beginning assembly of fire pit, make sure all parts are present.
Compare parts with package contents list. If any part is missing or damaged, do not attempt to assemble fire pit.
(VWLPDWHG$VVHPEO\7LPHPLQXWHV
127(<RXPXVWIROORZDOOVWHSVWRSURSHUO\DVVHPEOHfLUHpLW0DNHVXUHWKHJDVYDOYHLVWXUQHG2))EHIRUHDVVHPEOLQJ
'RQRWDWWHPSWWRDVVHPEOHZLWKRXWSURSHUWRROV
3$57 '(6&5,37,21 47<
A 1
B
C 1
D 1
E 1
F
19.8 lbs
G
1
H
1
1
:$51,1*
)DLOXUHWRSRVLWLRQWKHSDUWVLQDFFRUGDQFHZLWKWKHVH
GLDJUDPVRUIDLOXUHWRXVHRQO\SDUWVVSHFLIication
DSSURYHGZLWKWKLVDSSOLDQFHPD\UHVXOWLQ
SURSHUW\GDPDJHRUSHUVRQDOLQMXU\
A
D
EF
G
C
I
H
I
1
J
K
J
1
L
K
1
Fire Pit Body
Fire plate
Burner (preassembled)
Gas Screen (preassembled)
Control Knob (preassembled)
Electric Igniter (preassembled)
Regulator(preassembled)
Tank Holder
Fire Glass
PVC Cover
AAA Battery
Touch-Up Kit
B
1
L

$66(0%/<,16758&7,216

1
 Make sure the gas supply system is turned to “OFF”.
8"3/*/(
7KLVILUHpitUHTXLUHVDLUIORZXQGHU
WKHXQLW'RQRWSODFHRQXQHYHQ
VXUIDFHRURQJUDVVWXUIRUFDUSHW

2
G
1MBDFQSPQBOFUBOLJOUIFtank holder(PVUTJEF.BLFTVSFUIFHBTUBOLTJUTPOUIFtank holder(
DPNQMFUFMZ5VSOUIFXJOHTDSFXPOUIFPVUFSQBSUPGtank holder(DMPDLXJTFUPTFDVSFUIFHBTUBOLUJHIUMZ
OFF


"44&.#-:*/4536$5*0/4
a) Turn cylinder valve on the top of propane tank clockwise to close off gas supply. 6HH)LJXUHD
b) Screw regulator coupling clockwise by hand only. Make sure it is fastened. 6HH)LJXUHE
To install battery (K), unscrew rubber cap of electric igniter (F) and place battery (K) into the battery
case. Make sure the positive pole ("+") faces out towards cap. Screw cap back to battery case tightly.
JODMVEFE

H
Hardware Used
AAA Battery x 1
5

)LUHpLWDQGSURSDQHJDVF\OLQGHUPLQLPXPGLVWDQFHPXVWEHRYHULQFKHV6HHILJXUH3D\DWWHQWLRQ
WRWKHWLSSLQJKD]DUG

F
K


1234
5



"44&.#-:*/4536$5*0/4
8"3/*/(
.HHSfire glass DQGRWKHUREMHFWV
RIIRIVFUHHQVKRZQDWOHIW
+ROHVLQWKHVFUHHQPXVWEH
H[SRVHGLQRUGHUWRDOORZJDVWR
HVFDSH
%ORFNHGVFUHHQFDQFDXVHJDVWR
EXLOGLQVLGH)LUHpitDQG
XOWLPDWHO\FDXVHDQH[SORVLRQ
DQGULVNRIVHULRXVLQMXU\
$033&$5
#VSOFSSJOHJTDPNQMFUFMZ
DPWFSFEFYDFQUGPSTDSFFO
*/$033&$5
/PUFUIBUUIFCVSOFSSJOH
JTWJTJCMF
6b
4DSFFO
D
6c
D Place fire glass(I) evenly in fire bowl.
Use caution when handling fire glass as it is sharp. 6HH)LJXUHD
b) Do not place any fire glassover the screen.6HHILJXUHE
F Completely cover the entire burner ring with fire glass.6HHILJXUHF
Failure to completely cover the burner ring with the fire glasswill cause flame to extinguish occasionally.
 Before using fire pit, check for gas leaks.
Perform leak test in a well-ventilated area outside and where no source of spark can occur.
a) After opening door for access, open tank valve fully (counter-
clockwise).
b) Turn control knob to the OFF position.
c) Apply soapy water solution (3 drops dish detergent plus 4 oz.
water) to check all connections for leaks before attempting to light
Fire Table.
d) Coat soapy water onto all connections (shown in figure at right,
1, 2 ,3, 4, 5). 6HH)LJXUH
e) 7XUQFRQWURONQREWRWKH21SRVLWLRQ,IWKHUHDUHDQ\OHDNV
VRDS\ZDWHUZLOOEXEEOHZKHUHOHDNLVRFFXUULQJ
If a leak is found, turn tank valve off and do not use fire pit
until repairs are made.
I
#VSOFS
3JOH 4DSFFO

01&3"5*/(*/4536$5*0/4
Before each use, Ensure to inspect hose. Replace hose if there are any signs of cutting, wear or abrasion.
:$51,1*During initial lighting of the fire pit, stay away from fire pit for 0 minutes as fire glass may pop and cause
injury to the face or eyes.
1. Turn cylinder valve on top of propane tank counterclockwise to open gas supply.
2. To ignite Burner Ring: See Figure 8
a) press and hold Electric Igniter button (a),
b) at the same time, push in and turn Control Knob (b) counterclockwise, to LOW position.
c) Keep the Control Knob (b) pushed in to light the Burner Ring.
:$51,1*,ILJQLWLRQGRHV127LPPHGLDWHO\RFFXU
t release Electric Igniter Button (a) and turn Control Knob to OFF (clockwise).
t WAIT 5 MINUTES to clear out the gas!
t repeat lighting instrutions in Step 3 as above
3. After ignition, release Electric Igniter Button (a).
Continue to push and hold the Control Knob for 45 seconds.
&$5($1'0$,17(1$1&(
1RWH)ODPHVKRXOGEH\HOORZEOXHFRORU
7R([WLQJXLVK6HH)LJXUH
1. Push and turn Control Knob clockwise to "OFF" position.
2. Turn cylinder valve on gas tank to close gas supply if not in use for a long time.
:$51,1*'RQRWSODFHlLGRUn\ORQcRYHURQWRSRIfLUHpLWIRUDWOHDVWKRXUVDIWHU
XVHDQGXQWLOfLUHpiWKDVFRROHG
8
9
a
b
b
a
&DXWLRQ2QO\XVHSUHVVXUHUHJXODWRUDQGKRVHDVVHPEO\VXSSOLHGZLWKfLUHpLW5HSODFHPHQW
SUHVVXUHUHJXODWRUDQGKRVHDVVHPEOLHVPXVWEHVSHFLILHGRUVXSSOLHGE\PDQXIDFWXUHU
7R/LJKW
t Store the fire pit in a cool dry place away from direct sunlight.
t The propane tank must be disconnected and removed from the fire pit before the fire pit can be stored indoors.
t Make sure both the gas and the fire pit are turned off before changing battery. Please refer to the process of installing the
battery (Step 5).
t Use manufacturer approved or supplied replacement parts and accessories only. Use of unauthorized replacement parts
may void the warranty.
t Keep fire pit free and clear from combustible materials.
t Visually inspect burner ring for blockages (spider webs, dirt, etc.). Keep fire pit free and clear from debris.
t After burner ring and fire glass are completely cooled down, use a soft brush to get rid of mild stains, loose dirt and soil. Wipe
with a soft cloth.
The manufacturer's warranty will be voided by, and manufacturer disclaims any responsibility for following actions:
t Modification of the fire bowl and/or components including the gas valve assembly.
t Use of any component part not manufactured or approved by manufacturer.
t Use and installation other than as instructed in this manual.
88"33"33"/5"/5::
WARNING: FUELS USED IN LIQUEFIED PROPANE GAS APPLIANCES ,AND THE PRODUCTS OF
COMBUSTION OF SUCH FUELS,CAN EXPOSE YOU TO CHEMICALS INCLUDING BENZENE,WHICH IS
KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER AND CAUSE BIRTH DEFECTS OR OTHER
REPRODUCTIVE HARM For more information go to :www.P65Warnings.ca.gov
ADVERTENCIA:LOS COMBUSTIBLES USADOS EN EQUIPOS PARA LICUAR GAS PROPANO,ASi COMO
LOS PRODUCTOS DE SU COMBUSTION,PUEDEN EXPONERTE A SUSTANCIAS QUiMICAS,ENTRE ELLAS
EL BENCENO,QUE EL ESTADO DE CALIFORNIA RECONOCE COMO CAUSA DE CANCER Y DE
MALFORMACIONES CONGENITAS Y OTROS DANOS AL SISTEMA REPRODUCTOR
Para mas informacion,visite www.P65Warnings.ca.gov
8

5306#-&4)005*/(
No Igniter battery or igniter battery short of
power Replace with new igniter battery
Igniter battery is incorrectly inserted Reinsert the battery proporly
Igniter broken or cracked Call the customer service for replacement part
Ignition wire is loose or disconnected to
igniter Reinsert the ignition wire
Electricity leakage in ignition wire or the
needle of ignition wire can not aim at the
hole of burner while lighting Call the customer service for replacement part
The switch of gas cylinder was
not switch on Not switch on the valve of gas cylinder Switch on the valve of gas cylinder
Inproperly connect between
regulator and gas cylinder Regulator is loose or disconnected to gas cylinder Check and reconnect the regulator to gas cylinder
No gas in gas cylinder No or short of gas Check if the gas cylinder is empty ,if yes, replace it
Switch on the gas cylinder when the
balance gas still existed in hose cause
excess flow safety valve activated
Turn the control knob to "OFF",Swich off the valve
of gas cylinder and disconnect the regulator from the
valve of gas cylinder.Turn the control knob to
"LOW", Wait 30 seconds, Turn the control to
"OFF",Reconnect the regulator to the gas
cylinder.Light the appliance as indicated in the "To
Light"section of manual
Obvious gas leakage in gas system cause
excess flow safety valve activated Check the gas system to see if gas leakage, if yes, Call the customer service for help.
Bends or kinks in regulator Regulator was bends or kinks cause the
poor fluent gas inside of hose Straighten hose of all bends or kinks
No or short of gas See"No or Short of gas" above See"No or Short of gas" above
High or gusting winds Flame was blow out by high or gusting
winds Remove the appliance to the place without high or gusting winds
Loose connected in
thermocouple Loose connected between thermocouple and valve Call the customer service for help
Media fall into inside guard cause block
the entrance of oxygen
Media fall into inside guard and cover the
flame in burner hole which also cause the
low temperature while conduction
Guard covered by media Guard covery by media cause the
inproprely burning inside hole of guard Remove the media from the guard as indicated in manual
Too much carbon deposition
inside guard
The carbon deposition will occur since the
gas can not sufficient burning when using
the appliance
Open the top of guard by using pincer and clean the
carbon deposited in guard,thermocouple,ignition
wire,burner.lastly recover the top of guard .
Excess flow safety valve has
been activated
No or Short of
gas
No spark
between
ignition wire
and burner's
hole while
pushing the
igniter button.
Inside guard blocked by media Open and clean the guard
Flame blow out
No power in igniter
The ignition wire didn't conduct
electricity

Problem Cause Solution