Hoshizaki FM750AKER452SB Use and care manual

FM-AKE Series
Bags Replacement
Rev. 01 : 17 Aug.2021

1 Replacement
Screwdriver
3 How to access
Diagonal
pliers
Disconnect
2 power supply
Before work, unplug the
power cord for safety.
Cable tie Tube
1) Remove front and top panel.
Plastic bag
4X1559‐07
Rev. 01

1) Locate bags and replace with tubes, one by one and
fix with cable tie. Do not take all bags off at once.
3) Re fit control box cover and front panel.
1)After work, connect the
power supply and
energize.
5 Connect power supply
Picture_A
2) Locate bags on base next to compressor.
*Refer to the following pages about
“Wiring protection methods” and “Number of bags”
4 Location of Bags

b. In the case of using “tapes”
Put the terminals inside
new bag.
Cable tie
together in one
set, cut excess
cable tie off
Place insulation tape
over the terminal
vertically, make sure to
cover the top of the
terminals.
BOM should be fully
covered with
minimal gaps on top
and bottom.
Wrap around the wire
BOM's in insulation
tape as shown.
6 Reference. Wiring protection methods
a. In the case of using “new bag”
Tie the bag with a 4X1559‐07
cable tie.(150mm)
Note : If you can not have new bags,
Please choose method “b” or “c”.
Rev. 01

6 Reference. Wiring protection methods
c. In the case of using “tubes”
Prepare UL tube.
And Put the terminal
inside the tube.
Put the tube over the
terminals and bind the
bottom of the tube with
cable tie.
Fold the tube in half.
*If the tube is too
long, cut it.

7 Reference. Number of Bags
1) Please refer to the table below to find out which models are covered, where the bags are
located and how many there are.
* Please Note * For any model, If you find the amount of bags to be less than what is on this
table, then please fit missing bag(s) to locations pictured in “4.Location of bags”
Model code Model Name
Number of bags
Picture_A
(Top View)
Picture_B
(Around CM) sum
F054
-C101
FM
-750AKE-SB N/A 1 1
F054
-C201
FM750AKER452SB
N/A 1 1
F054
-C207
FM750AKER452NSB
N/A 1 1
F083
-C107
FM
-600AKE-N-SB 3 1 4
F083
-C122
FM
-600AWKE-SB 3 1 4
F083
-C201
FM600AKER452SB
3 1 4
F083
-C207
FM600AKER452NSB
3 1 4
F083
-C223
FM600AWKER452NSB
3 1 4
F083
-C830
FM
-600AKE(SA) 3 1 4
F084
-C101
FM
-170AKE-SB 2N/A 2
F084
-C107
FM
-170AKE-N-SB 2N/A 2
F087
-C101
FM
-480AKE-HC-SB 3 1 4
F087
-C106
FM
-480AKE-HCN-S-SB 3 1 4
F087
-C107
FM
-480AKE-HCN-SB 3 1 4
F088
-C101
FM
-300AKE-HC-SB 3 1 4
F088
-C107
FM
-300AKE-HCN-SB 3 1 4
F128
-C101
FM
-150AKE-HC-SB 2N/A 2
F128
-C107
FM
-150AKE-HCN-SB 2N/A 2
F139
FM
-600ALKE-CO2-SB 2 1 3
F139
-C106
FM
-600ALKE-CO2N-SB 2 1 3
F140
FM
-1200ALKE-CO2-SB 3 1 4
F140
-C106
FM
-1200ALKE-CO2N-SB 3 1 4