Invacare TDX 4 Manual

Owner’s Operator and Maintenance Manual
DEALER: This manual MUST be given to
the user of the wheelchair.
USER: BEFORE using this wheelchair, read
this manual and save for future reference.
For more information regarding
Invacare products, parts, and services,
please visit www.invacare.com
TDX® Wheelchairs
TDX 5, TDX 4, TDX 3
including
Formula™Invisible Super Low™Tilt
Formula PTO Plus
Formula TRE
(Tilt, Recline, Elevate, Tilt/Recline, Tilt/
Elevate, Tilt/Recline/Elevate)
2G Tarsys®
(2GT™- Tilt, 2GR™- Recline, 2GTR™- Tilt/
Recline)

REFERENCE DOCUMENTS
TDX™ Wheelchairs 2Part No 1114809
 WARNING
A QUALIFIED TECHNICIAN MUST PERFORM THE INITIAL SET UP
OF THIS WHEELCHAIR. ALSO, A QUALIFIED TECHNICIAN MUST
PERFORM ALL PROCEDURES IN THE SERVICE MANUAL.
WHEELCHAIR USERS: DO NOT SERVICE OR OPERATE THIS
EQUIPMENT WITHOUT FIRST READING AND UNDERSTANDING
(1) THE OWNER’S OPERATOR AND MAINTENANCE MANUAL
AND (2) THE SEATING SYSTEM’S MANUAL (IF APPLICABLE). IF
YOU ARE UNABLE TO UNDERSTAND THE WARNINGS,
CAUTIONS, AND INSTRUCTIONS, CONTACT INVACARE
TECHNICAL SUPPORT BEFORE ATTEMPTING TO SERVICE OR
OPERATE THIS EQUIPMENT OTHERWISE INJURY OR DAMAGE
MAY RESULT.
DEALERS AND QUALIFIED TECHNICIANS: DO NOT SERVICE OR
OPERATE THIS EQUIPMENT WITHOUT FIRST READING AND
UNDERSTANDING (1) THE OWNER’S OPERATOR AND
MAINTENANCE MANUAL, (2) THE SERVICE MANUAL (IF
APPLICABLE) AND (3) THE SEATING SYSTEM’S MANUAL (IF
APPLICABLE). IF YOU ARE UNABLE TO UNDERSTAND THE
WARNINGS, CAUTIONS AND INSTRUCTIONS, CONTACT
INVACARE TECHNICAL SUPPORT BEFORE ATTEMPTING TO
SERVICE OR OPERATE THIS EQUIPMENT OTHERWISE, INJURY
OR DAMAGE MAY RESULT.
REFERENCE DOCUMENTS
Refer to the table below for part numbers of additional documents which are referenced
in this manual.
MANUAL PART NUMBER
MK5™EX™and MK5 TT-EX Electronics Manual 1114808
MK5 NX™-80 Electronics Manual 1122140
TDX Base Service Manual 111481
Formula TRE Service Manual 1123820
Formula PTO Plus Service Manual 1125031
2G Tarsys Service Manual 1114842
NOTE: Updated versions of this manual are available on www.invacare.com.

TABLE OF CONTENTS
Part No 1114809 3TDX™ Wheelchairs
TABLE OF CONTENTS
REFERENCE DOCUMENTS ................................................................. 2
REGISTER YOUR PRODUCT ............................................................... 8
SPECIAL NOTES ................................................................................ 9
LABEL LOCATIONS ......................................................................... 12
All Wheelchairs.........................................................................................................................................12
Wheelchairs with TRRO ........................................................................................................................16
Wheelchairs with ut TRRO..................................................................................................................16
Wheelchairs with F rmula Invisible Super L w Tilt ........................................................................17
Wheelchairs with F rmula TRE ............................................................................................................17
Wheelchairs with 2G Tarsys .................................................................................................................18
Wheelchairs with F rmula PTO Plus ..................................................................................................19
TYPICAL PRODUCT PARAMETERS .................................................. 20
TDX 5 .........................................................................................................................................................20
TDX 4 .........................................................................................................................................................21
TDX 3 .........................................................................................................................................................22
F rmula Invisible Super L w Tilt ..........................................................................................................23
F rmula TRE..............................................................................................................................................24
F rmula PTO Plus ....................................................................................................................................26
2G Tarsys ...................................................................................................................................................27
SECTION 1—GENERAL GUIDELINES ................................................. 29
Repair r Service Inf rmati n ...............................................................................................................29
Operati n Inf rmati n ............................................................................................................................30
Wheelchairs with TRRO r TRBKTS Only...................................................................................31
Wheelchairs with P wered Seating Systems Only.......................................................................31
Wheelchairs with Manual Recliners Only ......................................................................................32
Tire Pressure .............................................................................................................................................33
Electrical .....................................................................................................................................................33
Gr unding Instructi ns.......................................................................................................................33
Batteries......................................................................................................................................................33
Charging Batteries ...............................................................................................................................33
Rain Test.....................................................................................................................................................34
Weight Training ........................................................................................................................................34
Weight Limitati n.....................................................................................................................................34
TDX Wheelchairs with ut P wered Seating Systems................................................................34
TDX Wheelchairs with P wered Seating Systems ......................................................................35
SECTION 2—SAFETY/HANDLING OF WHEELCHAIRS ......................... 36
Stability and Balance.................................................................................................................................36
C ping with Everyday Obstacles ..........................................................................................................37
A N te t Wheelchair Assistants ........................................................................................................38

TABLE OF CONTENTS
TDX™ Wheelchairs 4Part No 1114809
TABLE OF CONTENTS
Reaching, Leaning and Bending - F rward ..........................................................................................38
Reaching, Bending - Backward...............................................................................................................39
Pinch P ints................................................................................................................................................39
Stairways.....................................................................................................................................................40
Transferring T and Fr m Other Seats ..............................................................................................42
SECTION 3—EMI INFORMATION ..................................................... 3
SECTION —SAFETY INSPECTION/TROUBLESHOOTING .................... 5
Safety Inspecti n Checklists...................................................................................................................45
All Wheelchairs ....................................................................................................................................45
Additi nal Requirements f r Wheelchairs with P wered Seating Systems...........................47
Tr ublesh ting - Mechanical ..............................................................................................................49
Tr ublesh ting - Electrical...................................................................................................................50
All Wheelchairs ....................................................................................................................................50
Wheelchairs with P wered Seating Systems.................................................................................51
Checking Battery Charge Level.............................................................................................................52
SECTION 5—WHEELCHAIR OPERATION ........................................... 53
Operating the Wheelchair......................................................................................................................53
Turning the P wer On/Off................................................................................................................53
Using the J ystick t Drive the Wheelchair..................................................................................54
A N te Ab ut Drive L ck-Out ............................................................................................................55
Operating P wered Seating Systems ...................................................................................................56
Single Functi n T ggle Switch...........................................................................................................59
Opti nal F ur-Way T ggle Switch ..................................................................................................59
Vernier Shear Reducti n (2G Tarsys Systems Only) ..................................................................61
SPJ-80 J ystick Switches and Indicat rs ..............................................................................................62
On/Off T ggle Switch .........................................................................................................................62
Speed C ntr l Kn b ...........................................................................................................................62
J ystick....................................................................................................................................................62
Battery Gauge Display ........................................................................................................................62
Charger/Pr gramming Input..............................................................................................................62
DPJ J ystick Switches and Indicat rs ...................................................................................................63
Drive Select T ggle Switch................................................................................................................63
Speed C ntr l Kn b ...........................................................................................................................63
J ystick....................................................................................................................................................63
M de (On/Off) Switch ........................................................................................................................63
Battery Gauge Display (BGD)...........................................................................................................64
MPJ J ystick Switches and Indicat rs ...................................................................................................64
Drive Select T ggle Switch................................................................................................................64
Speed C ntr l ......................................................................................................................................65
J ystick....................................................................................................................................................65
LCD Display ..........................................................................................................................................65
Emergency St p/Reset Switch...........................................................................................................66

TABLE OF CONTENTS
Part No 1114809 5TDX™ Wheelchairs
TABLE OF CONTENTS
Emergency St p/Reset Input .............................................................................................................66
Rem te On/Off Switch.......................................................................................................................66
SECTION 6—FRONT RIGGINGS ........................................................ 67
Installing/Rem ving F trests................................................................................................................67
70° and PW93.......................................................................................................................................67
70° Taper ...............................................................................................................................................68
F trest Height Adjustment ..................................................................................................................68
70° and PW93.......................................................................................................................................68
70° Taper ...............................................................................................................................................69
PHAL4A .................................................................................................................................................69
Adjusting/Replacing Telesc ping Fr nt Rigging Supp rt .................................................................70
Wheelchairs with 2G Tarsys Systems.............................................................................................70
Wheelchairs with ut 2G Tarsys Systems ......................................................................................70
Installing Adjustable Angle Flip-up F tplate Hinge .........................................................................71
Installing Adjustable Angle Flip-up F tplates....................................................................................72
Adjusting Adjustable Angle Flip-Up F tplates .................................................................................72
Depth Adjustment ...............................................................................................................................72
Angle Adjustment ................................................................................................................................72
Perpendicular and/ r Inversi n/Eversi n Adjustment.................................................................73
C mp site/Articulating F tplate Heel L p Replacement ..........................................................73
Disassembly...........................................................................................................................................73
Assembly ................................................................................................................................................73
Installing/Rem ving Elevating Legrests.................................................................................................74
Installing..................................................................................................................................................74
Rem ving ...............................................................................................................................................74
Raising/L wering Elevating Legrests and/ r Adjusting Calfpads ....................................................75
Raising/L wering Elevating Legrests ................................................................................................75
Adjusting Calfpads................................................................................................................................75
Rem ving/Installing the Center M unt F trest ..............................................................................75
Rem ving ...............................................................................................................................................75
Installing..................................................................................................................................................76
Adjusting the Height f the Center M unt F trest.......................................................................78
All Wheelchairs Except 2G Tarsys Systems..................................................................................78
2G Tarsys Systems...............................................................................................................................79
Adjusting the Angle f the Manual Center M unt F trest ..........................................................80
Adjusting the F tplate Angle ...............................................................................................................80
After 2/14/07.........................................................................................................................................80
Bef re 2/15/07 ......................................................................................................................................81
Adjusting the Tensi n f the Flip Up F tplate ................................................................................81
Calf Pad Adjustment f r P wer Center M unt F trests .............................................................82
Depth Adjustment ...............................................................................................................................82
Height and Width Adjustment..........................................................................................................82

TABLE OF CONTENTS
TDX™ Wheelchairs 6Part No 1114809
TABLE OF CONTENTS
Installing/Rem ving the P wer Elevating Legrests ............................................................................83
Installing the P wer Elevating Legrests...........................................................................................83
Rem ving the P wer Elevating Legrests.........................................................................................83
Using Mechanical Elevating/Genius Legrests ......................................................................................84
Installing/Rem ving Mechanical Elevating/Genius Legrests.............................................................85
Installing..................................................................................................................................................85
Rem ving ...............................................................................................................................................85
Adjusting Mechanical Elevating Legrests .............................................................................................86
Calfpads ..................................................................................................................................................86
F tplate Height ..................................................................................................................................86
Speed/Height .........................................................................................................................................87
Adjusting Genius Legrests ......................................................................................................................87
F tplate Height ..................................................................................................................................87
F tplate Angle ....................................................................................................................................87
Calfpad Height ......................................................................................................................................88
Calfpad Depth.......................................................................................................................................88
Legrest Height ......................................................................................................................................88
SECTION 7—ARMS ......................................................................... 89
Installing/Rem ving Flip Back Armrests ..............................................................................................89
Installing..................................................................................................................................................89
Rem ving ...............................................................................................................................................89
Adjusting Flip Back Armrests.................................................................................................................90
P siti ning Flip Back Armrests f r User Transfer .......................................................................90
P siti ning Flip Back Armrests f r Use..........................................................................................90
Adjusting ................................................................................................................................................90
Rem ving/Installing Reclining Armrests ..............................................................................................91
Rem ving Armrests.............................................................................................................................91
Installing Armrests ...............................................................................................................................91
Adjusting Reclining Armrest Height.....................................................................................................92
SECTION 8—SEAT ........................................................................... 9
Replacing Seat P siti ning Strap ...........................................................................................................94
Wheelchairs with TRRO Opti n .....................................................................................................94
Wheelchairs with ut 2G Tarsys Seating Systems r TRRO Opti n.......................................94
Wheelchairs with 2G Tarsys Seating Systems...............................................................................95
Tilting the Seat Assembly........................................................................................................................96
Tilting the Seat Assembly Back .........................................................................................................96
Tilting the Seat Assembly F rward..................................................................................................97
SECTION 9— HANDLING AND REPLACING BATTERIES .................... 98
Warnings f r Handling and Replacing Batteries................................................................................98
Using the Pr per Batteries.....................................................................................................................99
Replacing Batteries ................................................................................................................................ 100

TABLE OF CONTENTS
Part No 1114809 7TDX™ Wheelchairs
TABLE OF CONTENTS
Cleaning Battery Terminals................................................................................................................. 105
SECTION 10—TDX, FORMULA TRE, 2G TARSYS AND FORMULA PTO
PLUS BATTERIES .......................................................................... 106
Rem ving/Installing the Batteries Fr m/Int the Wheelchair..................................................... 106
Rem ving the Battery D r and Rear Shr uds......................................................................... 106
Rem ving the Batteries fr m Wheelchairs with ut Elevate................................................... 109
Rem ving the Batteries fr m Wheelchairs with Elevate......................................................... 110
Installing Batteries int Wheelchairs with ut Elevate.............................................................. 111
Installing Batteries int Wheelchairs with Elevate .................................................................... 112
Installing the Battery D r and Rear Shr ud............................................................................. 113
SECTION 11—FORMULA INVISIBLE SUPER LOW TILT BATTERIES .... 115
Rem ving/Installing Fr nt/Rear Shr uds .......................................................................................... 115
Rem ving ............................................................................................................................................ 115
Installing............................................................................................................................................... 116
Rem ving the Batteries fr m the Wheelchair................................................................................ 117
Rem ving the Actuat r/M unting Bracket Assembly .............................................................. 117
Disc nnect Battery Straps and Rem ve Batteries fr m Tray ................................................ 118
Installing Batteries int the Wheelchair........................................................................................... 118
C nnect Battery Straps and Install Batteries int Tray ........................................................... 118
Install Actuat r/M unting Bracket Assembly ............................................................................. 119
SECTION 12—CHARGING BATTERIES ............................................ 121
When t Charge Batteries.................................................................................................................. 121
DPJ and SPJ-80 J ystick.................................................................................................................... 121
MPJ J ystick ........................................................................................................................................ 121
Charging Batteries ................................................................................................................................. 122
Descripti n and Use f Battery Chargers................................................................................... 122
SECTION 13—MOTOR LOCKS/FORKS .............................................. 12
Disengaging/Engaging M t r L ck Levers........................................................................................ 124
Standard and Heavy Duty 4 P le M t rs.................................................................................... 124
Gearless Brushless GB™M t rs .................................................................................................. 124
Adjusting F rks ...................................................................................................................................... 125
SECTION 1 —ELECTRONICS .......................................................... 126
Preparing MK5 J ystick f r Use......................................................................................................... 126
Rep siti ning MK5 J ystick................................................................................................................. 126
SECTION 15—HEADREST .............................................................. 127
Rem ving/Installing/Adjusting Headrest........................................................................................... 127
Rem ving ............................................................................................................................................ 127
Installing............................................................................................................................................... 127
Adjusting Headrest Height.............................................................................................................. 128
Adjusting Headrest Depth/Directi n ........................................................................................... 128

REGISTER YOUR PRODUCT
TDX™ Wheelchairs 8Part No 1114809
Replacing Headrest ............................................................................................................................... 128
SECTION 16—VENTILATOR TRAY ................................................. 129
Using the Opti nal Ventilat r Tray................................................................................................... 129
SECTION 17—RECLINER ............................................................... 131
Recliner Operati n ............................................................................................................................... 131
Replacing Back r Headrest Uph lstery .......................................................................................... 132
Replacing Back Uph lstery ............................................................................................................. 132
Replacing Headrest Uph lstery ..................................................................................................... 132
Adjusting Back r Headrest Uph lstery .......................................................................................... 133
SECTION 18—TRANSPORT READY PACKAGE (TRRO) .................... 13
Ab ut Transp rt Ready Packages...................................................................................................... 135
C mpliance Inf rmati n ...................................................................................................................... 135
Specificati ns...................................................................................................................................... 136
Securing the Wheelchair t the Vehicle .......................................................................................... 136
P siti ning the Wheelchair in the Vehicle.................................................................................. 136
Securement P ints............................................................................................................................ 137
Securing the Wheelchair ................................................................................................................. 137
Securing the Occupant......................................................................................................................... 138
Wheelchair-Anch red Belts........................................................................................................... 138
Vehicle-Anch red Belts ................................................................................................................... 140
Seating System ................................................................................................................................... 140
P siti ning Belts ................................................................................................................................ 141
LIMITED WARRANTY ................................................................... 1
REGISTER YOUR PRODUCT
The benefits f registering include:
1. Safeguarding y ur investment.
2. Ensuring l ng-term maintenance and servicing f y ur pr duct.
3. Receiving updates with pr duct inf rmati n, maintenance tips and industry news.
Register ONLINE at warranty.invacare.com
Please have y ur m del number and purchase date available t c mplete y ur registrati n.
Any registrati n inf rmati n y u submit will nly be used by Invacare C rp rati n and pr tected
as required by applicable laws and regulati ns.

SPECIAL NOTES
Part No 1114809 9TDX™ Wheelchairs
SPECIAL NOTES
Signal words are used in this manual and apply to hazards or unsafe practices which
could result in personal injury or property damage. Refer to the table below for
definitions of the signal words.
NOTICE
THE INFORMATION CONTAINED IN THIS DOCUMENT IS SUBJECT TO
CHANGE WITHOUT NOTICE.
WHEELCHAIR USER
As a manufacturer f wheelchairs, Invacare endeav rs t supply a wide variety f
wheelchairs t meet many needs f the end user. H wever, final selecti n f the
type f wheelchair t be used by an individual rests s lely with the user and his/her
healthcare pr fessi nal capable f making such a selecti n. Invacare highly
rec mmends w rking with a certified rehab techn l gy supplier and/ r a member
f NRRTS r RESNA.
WHEELCHAIR TIE-DOWN RESTRAINTS AND SEAT RESTRAINTS (TRRO OR
TRBKTS)
TRRO includes f ur fact ry-installed transp rt brackets and a wheelchair anch red
pelvic belt. TRRO has been crash-tested in acc rdance with ANSI/RESNA WC V l 1
Secti n 19 Fr ntal Impact Test requirements f r wheelchairs with a 168 lb crash
dummy, which c rresp nds t a pers n with a weight f 114 t 209 lbs.
TRBKTS includes f ur fact ry-installed wheelchair transp rt brackets. TRBKTS has
n t been crash-tested in acc rdance with WC 19. Use these transp rt brackets nly
t secure an un ccupied wheelchair during transp rt.
As f this date, the Department f Transp rtati n has n t appr ved any tie-d wn
systems f r transp rtati n f a user while in a wheelchair, in a m ving vehicle f any
type. It is Invacare’s p siti n that users f wheelchairs sh uld be transferred int
appr priate seating in vehicles f r transp rtati n and use be made f the restraints
made available by the aut industry. Invacare cann t and d es n t rec mmend any
wheelchair transp rtati n systems.
Refer t Transp rt Ready Package (TRRO) n page 134 f r m re inf rmati n ab ut
transp rting the wheelchair.
SIGNAL WORD MEANING
DANGER
Danger indicates an imminently hazardous situation which, if not avoided,
will result in death or serious injury.
WARNING
Warning indicates a potentially hazardous situation which, if not avoided,
could result in death or serious injury.
CAUTION
Caution indicates a potentially hazardous situation which, if not avoided,
may result in property damage.

SPECIAL NOTES
TDX™ Wheelchairs 0 Part No 1114809
 TRRO AND TRBKTS WARNINGS
Only use the transp rt brackets included with TRRO and TRBKTS f r the purp ses
described in this manual.
Battery supp rt brackets MUST be installed at all times. Otherwise, the wheelchair
will n t be WC/19 c mpliant. Refer t Rem ving/Installing the Batteries Fr m/Int
the Wheelchair n page 106.
 WARNING
Invacare pr ducts are specifically designed and manufactured f r use in c njuncti n
with Invacare access ries. Access ries designed by ther manufacturers have n t
been tested by Invacare and are n t rec mmended f r use with Invacare pr ducts.
The seat p siti ning strap is a p siti ning belt ONLY. It is n t designed f r use as a
safety device withstanding high stress l ads such as aut r aircraft safety belts. If
signs f wear appear, belt MUST be replaced immediately.
The drive behavi r initially experienced by the user may be different fr m ther
wheelchairs previ usly used. This P wer Wheelchair has Invacare’s SureStep™
techn l gy, a feature that pr vides the wheelchair with ptimum tracti n and
stability when driving f rward ver transiti ns and thresh lds f up t 3-inches f r
TDX 5 and TDX 4 and 2-inches f r TDX 3. The f ll wing warnings apply specifically
t the Sure Step feature:
• DO NOT use n inclines greater than 9°.
• DO NOT use n inclines with wet, slippery, icy r ily surfaces. This may include
certain painted r therwise treated w d surfaces.
• DO NOT traverse d wn ramps at high speed. D ing s will reduce tracti n and
increase st pping distance.
• The end user’s weight can materially affect tracti n n sl ped surfaces. Great
care sh uld be taken when traversing such sl pes.
T determine and establish y ur particular safety limits, practice use f this pr duct
n vari us sl ping surfaces in the presence f a qualified healthcare pr vider
BEFORE attempting active use f this wheelchair. Other general warnings listed
within this d cument als apply.
Wheelchairs sh uld be examined during maintenance f r signs f c rr si n (water
exp sure, inc ntinence, etc.). Electrical c mp nents damaged by c rr si n sh uld
be replaced IMMEDIATELY.
Wheelchairs that are used by inc ntinent users and/ r are frequently exp sed t
water may require replacement f electrical c mp nents m re frequently.
 POWERED SEATING SYSTEM WARNINGS
This seating system has been cust m designed and will be assembled t the wheel-
chair base bef re delivery t the user. The inf rmati n c ntained in this manual is
f r maintaining and adjusting the seating system. There are very few adjustments
that can safely be made by the user. If there is a pr cedure r adjustment that
needs t be perf rmed n the seating system that is n t in this manual, DO NOT
perf rm that pr cedure. Have the seating system serviced by a qualified technician.

SPECIAL NOTES
Part No 1114809 TDX™ Wheelchairs
 MANUAL RECLINER WARNINGS TO HEALTHCARE
PROFESSIONALS/ASSISTANTS
Make sure the ccupant f the wheelchair is pr perly p siti ned.
When returning the ccupant f the wheelchair t the full upright p siti n, m re
b dy strength will be required f r appr ximately the last twenty (20) degrees f
incline (reverse recline). Make sure t use pr per b dy mechanics (use y ur legs) r
seek assistance if necessary t av id injury.

LABEL LOCATIONS
TDX™ Wheelchairs 2 Part No 1114809
LABEL LOCATIONS
All Wheelchairs
Serial Number Label is located on a
plate below the controller.
One of the labels on the
following page is located on
the inside of battery tray
door, depending on battery
type.

LABEL LOCATIONS
Part No 1114809 3 TDX™ Wheelchairs
TDX Wheelchairs Equipped with Vent Tray Only
Formula TRE Systems Equipped with
Elevate
Formula Invisi le
Super Low Tilt
Seating Systems
Only
Standard TDX
Wheelchairs, Formula
TRE Non-Elevate Systems,
2G Tarsys Systems
and
Formula PTO Plus
Systems

LABEL LOCATIONS
TDX™ Wheelchairs 4 Part No 1114809
P/N 1118367
Rev A - 3/03
DRIVE
PUSH
CAUTION
Ensure both clutches
are fully engaged
before driving chair
WARNING
USE this
battery
terminal
configuration
Positive
Terminal
Negative
Terminal
Positive
Terminal
Negative
Terminal
P/N 1114848 Rev A - 2/03
Cross Hole
DO NOT use
this battery
terminal
configuration
GP24 batteries with terminal configuration
(negative on the left and positive on the right)
as shown MUST be used. GP24 batteries that
have the reverse terminal configuration MUST
not be used. Terminals MUST have a cross
hole located as shown for proper battery
connection. See Owner's Manual, part number
1114809. These recommendations MUST be
followed otherwise injury and damage may
occur.
WARNING
USE this
battery
terminal
configuration
Positive
Terminal
Negative
Terminal
Positive
Terminal
Negative
Terminal
P/N 1114847 Rev A - 2/03
Cross Hole
DO NOT use
this battery
terminal
configuration
22NF batteries with terminal configuration
(positive on the left and negative on the right)
as shown MUST be used. 22NF batteries that
have the reverse terminal configuration MUST
not be used. Terminals MUST have a cross
hole located as shown for proper battery
connection. See Owner's Manual, part number
1114809. These recommendations MUST be
followed otherwise injury and damage may
occur.
One of these labels will appear on inside of battery tray door depending on battery type.
Located on each
2-pole motor

LABEL LOCATIONS
Part No 1114809 5 TDX™ Wheelchairs
Refer to Service Manual to
reposition the seat - otherwise serious personal injury
and damage will result.
WARNING
P/N 1114823 Rev B - 5/10/06
Weight Capacity Label located here
One of these labels will appear on the battery tray and the
battery wiring connector brac et, depending on battery type.

LABEL LOCATIONS
TDX™ Wheelchairs 6 Part No 1114809
Wheelchairs with TRRO
Wheelchairs without TRRO
NOTE: Also on opposite side.
NOTE: Also on opposite side.
NOTE: Auto style seat
positioning strap shown. This
label is also on the airline style
seat positioning strap.

LABEL LOCATIONS
Part No 1114809 7 TDX™ Wheelchairs
Wheelchairs with Formula Invisible Super Low Tilt
Wheelchairs with Formula TRE
Pinch Point Label
Pinch
Point
Label
P/N 1122124 Rev A - 9/03

LABEL LOCATIONS
TDX™ Wheelchairs 8 Part No 1114809
Wheelchairs with G Tarsys
NOTE: These labels are present on
both sides of the seating system.

LABEL LOCATIONS
Part No 1114809 9 TDX™ Wheelchairs
Wheelchairs with Formula PTO Plus
TDX 3 or TDX 4
Standard Only
TDX 3 Heavy Duty,
TDX 4 Heavy Duty or
TDX 5 Only
Rear View of
Actuator

TYPICAL PRODUCT PARAMETERS
TDX™ Wheelchairs 20 Part No 1114809
TYPICAL PRODUCT PARAMETERS
TDX 5
ADULT -
ADJUSTABLE
WIDTH
JUNIOR -
ADJUSTABLE
WIDTH
SEAT WIDTH RANGE:
ADJUSTABLE SEAT BACK ANGLE (ASBA): 16 - 24 inches 12 - 16 inches
SEAT DEPTH RANGE (1-INCH INCREMENTS): 16 - 22 inches 12 - 18 inches
BACK HEIGHT RANGE: 12 - 24 inches 12 - 22 inches
BACK ANGLE RANGE: 85° to 105° in 5°
increments
80° to 100° in 5°
increments
SEAT-TO-FLOOR
LOW:
MEDIUM:
TALL:
17 inches @ 5°
1 inches @ 5°
21 inches @ 5°
OVERALL WIDTH OF BASE: 25 inches without joystick
OVERALL HEIGHT
LOW:
MEDIUM:
TALL:
with ASBA seat, 0° seat angle
33.25 inches
35.25 inches
37.25 inches
OVERALL LENGTH
WITH CENTER MOUNT FRONT RIGGING:
WITHOUT FRONT RIGGINGS:
42. inches @ 0°
35.25 inches
WEIGHT
WITHOUT GP24 BATTERIES:
WITH TWO GP24 BATTERIES:
208 lbs
310 lbs
MOTOR: TrueTrack HD Motor Package
DRIVE AXLE: Non-adjustable
DRIVE WHEELS/TIRES: 14 x 3-inch Foam Filled or Pneumatic
CASTERS: 6 x 2-inch, Semi-pneumatic with Precision Sealed
Bearings
ARMRESTS: Flip Back, Fixed or Adjustable Height (Desk and Full
Length)
BATTERY REQUIREMENTS: Use MK p/n M24SLDG or p/n M22NFSLDG batteries
only.
WHEELCHAIR UPHOLSTERY OPTIONS: Nylon
ELECTRONICS: MK5™TT-EX™with MK5 MPJ™Joystick
FRONT RIGGINGS: Center Mount, Swingaway, Manually Elevating, Power
Elevating
FOOTRESTS: Telescoping Front Rigging Supports,
2-inch and 4-inch long Pivot Slide Tube
SEAT TILT ANGLE ADJUSTMENT: Adjustable (0° to 10°)
SEAT CUSHION: Cushion (Optional)
WEIGHT LIMITATION: Up to 400 lbs Up to 150 lbs
NOTE: All dimensions are ± . 0 inches unless otherwise indicated.