J&B Importers Sun Bicycles HT-3 Hand-Trike User manual
Notethat
spring
bracketgoes
intoUPPER
holeinfork.
Install
spring
bracket
andeye
bolt
Install
and
adjust
fork.
Installspringandusea
screwdriverasshown
(becareful,screwdriver
can besharp)toinsert
eyeboltintoframe
bracket.Youwillneed
helptoinstallthenut.
Use caution,thespring
isverystrong.
Noteproperorientation
ofeyebolt.
Installand
tighten
securlythe
hand pedal
assemblies
usinga
standard
pedal
wrench.
Adjust chain
tensionby
pullingthe
stemoutand
tighteningthe
upperclamp
bolt.
Upper
clampbolt
Notethat
spring
bracketgoes
intoUPPER
holeinfork.
Install
spring
bracket
andeye
bolt
Install
and
adjust
fork.
Installspringandusea
screwdriverasshown
(becareful,screwdriver
can besharp)toinsert
eyeboltintoframe
bracket.Youwillneed
helptoinstallthenut.
Use caution,thespring
isverystrong.
Noteproperorientation
ofeyebolt.
Install
crankand
stem
assembly.
Route chainas
shown.
2
Installand
tighten
securlythe
hand pedal
assemblies
usinga
standard
pedal
wrench.
Adjust chain
tensionby
pullingthe
stemoutand
tighteningthe
upperclamp
bolt.
Upper
clampbolt
Notethat
spring
bracketgoes
intoUPPER
holeinfork.
Install
spring
bracket
andeye
bolt
Install
and
adjust
fork.
Installspringandusea
screwdriverasshown
(becareful,screwdriver
can besharp)toinsert
eyeboltintoframe
bracket.Youwillneed
helptoinstallthenut.
Use caution,thespring
isverystrong.
Noteproperorientation
ofeyebolt.
Install
crankand
stem
assembly.
Route chainas
shown.
Installrearwheels,with
washerbehind theaxlenut.
Note:theaxlenutsmust
NOTbetootight.Their
shouldbeupto1mmofside
tosidemovementofthe
hubontheaxle.
Installseat rails
ontoframewith
theincluded
hardware,and
tightensecurly.
Installrearwheels,with
washerbehind theaxlenut.
Note:theaxlenutsmust
NOTbetootight.Their
shouldbeupto1mmofside
tosidemovementofthe
hubontheaxle.
Installseat rails
ontoframewith
theincluded
hardware,and
tightensecurly.
Installfootrestin
appropriatepositionforthe
riderontotheframe.Use
includedhardware,and
tightensecurly.
PLEASE READ THIS MANUAL BEFORE RIDING YOUR HAND-TRIKE
CONGRATULATIONS!
Congratulations on your Sun Bicycles purchase. You have selected one of the most comfortable and advanced cycles
on the market. Please read this manual before riding your Sun Bicycles HT-3. In this manual you will find many topics
covered.
We included in the preparation of this manual WARNINGS and INFORMATION for your safety.
GENERAL WARNING: Riding a Hand-Trike can be hazardous. When on a Hand-Trike you could have an accident
resulting in injury or even death. This manual makes an effort to give you enough information that could prevent riding into
danger. We cannot cover all contingencies but hope to make you an informed and aware rider.
• Municipal bicycle regulations also apply to tricycles. Most states and municipalities have regulations. It's up to you to
research those regulations and become informed. Your dealer may be able to help you with this information. Since you
will be sharing the road at times with other vehicles a good rule to follow is "If you can't do it with a car or bicycle, don't
3
Installrearwheels,with
washerbehind theaxlenut.
Note:theaxlenutsmust
NOTbetootight.Their
shouldbeupto1mmofside
tosidemovementofthe
hubontheaxle.
Installseat rails
ontoframewith
theincluded
hardware,and
tightensecurly.
Installfootrestin
appropriatepositionforthe
riderontotheframe.Use
includedhardware,and
tightensecurly.
PLEASE READ THIS MANUAL BEFORE RIDING YOUR HAND-TRIKE
CONGRATULATIONS!
Congratulations on your Sun Bicycles purchase. You have selected one of the most comfortable and advanced cycles
on the market. Please read this manual before riding your Sun Bicycles HT-3. In this manual you will find many topics
covered.
We included in the preparation of this manual WARNINGS and INFORMATION for your safety.
GENERAL WARNING: Riding a Hand-Trike can be hazardous. When on a Hand-Trike you could have an accident
resulting in injury or even death. This manual makes an effort to give you enough information that could prevent riding into
danger. We cannot cover all contingencies but hope to make you an informed and aware rider.
• Municipal bicycle regulations also apply to tricycles. Most states and municipalities have regulations. It's up to you to
research those regulations and become informed. Your dealer may be able to help you with this information. Since you
will be sharing the road at times with other vehicles a good rule to follow is "If you can't do it with a car or bicycle, don't
• A trikes widest point is behind you, if the front goes by an obstacle there is no guarantee that the rear wheels will also
clear. When riding, you must give clearance to the edge of the road or sidewalk. Stay clear of potholes and be aware
that you can lose control if any wheels should drop into a hole or ditch.
• Always ride defensively. Watch out for the unexpected. This means everything from cars to children, pets and rough
road surfaces. Be prepared to avoid danger. ALWAYS WEAR A BICYCLE HELMET. We recommend buying your
helmet from a dealer that can fit and instruct you on the correct way to wear a helmet. Protecting your head is your
primary safety responsibility.
• Always wear a CPSC approved bicycle helmet.
CHECKLIST BEFORE RIDING:
• Check your tires for proper air pressure. If you need to inflate them do not inflate over the recommended air pressure
on the side wall of your tires. If using a compressor or the air hose at a gas station, be very careful not to blow the tire
off the rim. Check the hardness of the tire and stop inflating to check the air pressure. Do not over inflate. Do not ride
on flat or underinflated tires. Riding on flat or underinflated tires can cause injury, as well as, damage to the tire, tube
and wheels of your Hand-Trike.
• Test your brakes and make sure they stop the trike. If you have any doubts do not ride your trike and see your dealer.
All Hand-Trikes are equipped with front “coaster” brake and front “caliper” parking brake as standard equipment. Under
no circumstance should the brakes be removed. When stopping your Hand-Trike always use the front coaster brake for
a safe smooth stop.
• Check that the handlebar is tight and that the ends are plugged. Now check the saddle for tightness.
• Safety check: Apply your parking brake and rock your Hand-Trike back and forth. If you hear or feel a movement
coming from the fork or front wheel or any other part of the trike, DO NOT RIDE it, have your dealer or qualified
mechanic check the Hand-Trike.
PRECAUTIONS:
• A trike does not handle like a bicycle; therefore, you cannot lean into a turn. All wheels must be on the ground at all
times. Do not make sudden changes of direction, you could unbalance the trike and have an accident.
• A trikes widest point is behind you, if the front goes by an obstacle there is no guarantee that the rear wheels will also
clear. When riding, you must give clearance to the edge of the road or sidewalk. Stay clear of potholes and be aware
that you can lose control if any wheels should drop into a hole or ditch.
• Always ride defensively. Watch out for the unexpected. This means everything from cars to children, pets and rough
road surfaces. Be prepared to avoid danger. ALWAYS WEAR A BICYCLE HELMET. We recommend buying your
helmet from a dealer that can fit and instruct you on the correct way to wear a helmet. Protecting your head is your
primary safety responsibility.
• Always wear a CPSC approved bicycle helmet.
CHECKLIST BEFORE RIDING:
• Check your tires for proper air pressure. If you need to inflate them do not inflate over the recommended air pressure
on the side wall of your tires. If using a compressor or the air hose at a gas station, be very careful not to blow the tire
off the rim. Check the hardness of the tire and stop inflating to check the air pressure. Do not over inflate. Do not ride
on flat or underinflated tires. Riding on flat or underinflated tires can cause injury, as well as, damage to the tire, tube
and wheels of your Hand-Trike.
• Test your brakes and make sure they stop the trike. If you have any doubts do not ride your trike and see your dealer.
All Hand-Trikes are equipped with front “coaster” brake and front “caliper” parking brake as standard equipment. Under
no circumstance should the brakes be removed. When stopping your Hand-Trike always use the front coaster brake for
a safe smooth stop.
• Check that the handlebar is tight and that the ends are plugged. Now check the saddle for tightness.
• Safety check: Apply your parking brake and rock your Hand-Trike back and forth. If you hear or feel a movement
coming from the fork or front wheel or any other part of the trike, DO NOT RIDE it, have your dealer or qualified
mechanic check the Hand-Trike.
PRECAUTIONS:
• A trike does not handle like a bicycle; therefore, you cannot lean into a turn. All wheels must be on the ground at all
times. Do not make sudden changes of direction, you could unbalance the trike and have an accident.
WARNING: Avoid riding over curbs. Watch for and avoid potholes, gratings and other road hazards. Walk your Hand-
Trike over railroad tracks, stairs, ditches or other such rough conditions. Do not attempt to ride up or down an incline with an
ice or oil film. Failure to do so may result in tire failure, loss of control, or other mechanical failures and may result in a serious
or fatal accident.
• We suggest you practice riding in a quiet area to get the feel of the trike.
• When beginning to ride, stay at a slow speed. You must acclimate yourself to the handling and turning of this three
wheeler. If you feel insecure, slow down, and proceed at a slower pace. With practice, you will get comfortable riding
and stopping.
• Never ride with your ears covered with earphones or anything else that would prevent hearing. Hearing your
surroundings is important for your safety.
• We recommend that you not ride at night, or at times of reduced visibility. If you should ride at night or during reduced
visibility, you must outfit your trike with a front white light and a rear red light. Relying solely on reflectors is not
adequate protection. Most municipalities require lights for night riding. Your bicycle dealer can help you in selecting the
correct lighting system for your needs.
• Avoid riding on rainy days since you don't have the same control, handling, and stopping power as on a dry day.
• Always ride with the flow of traffic, never against traffic
WARNING: DO NOT EVER Carry A CHILD, PERSON OR PET on your Hand-Trike! They could be seriously injured by
the turning wheel and/or the moving parts. The trike is made for one person and is not built to hold a passenger. DO NOT
EVER stand on the seat or frame of the Hand-Trike. DO NOT EVER carry any items that may obstruct your view or prohibit
you from operating your Hand-Trike properly.
• Weight capacity is 300 lbs.
4
• A trikes widest point is behind you, if the front goes by an obstacle there is no guarantee that the rear wheels will also
clear. When riding, you must give clearance to the edge of the road or sidewalk. Stay clear of potholes and be aware
that you can lose control if any wheels should drop into a hole or ditch.
• Always ride defensively. Watch out for the unexpected. This means everything from cars to children, pets and rough
road surfaces. Be prepared to avoid danger. ALWAYS WEAR A BICYCLE HELMET. We recommend buying your
helmet from a dealer that can fit and instruct you on the correct way to wear a helmet. Protecting your head is your
primary safety responsibility.
• Always wear a CPSC approved bicycle helmet.
CHECKLIST BEFORE RIDING:
• Check your tires for proper air pressure. If you need to inflate them do not inflate over the recommended air pressure
on the side wall of your tires. If using a compressor or the air hose at a gas station, be very careful not to blow the tire
off the rim. Check the hardness of the tire and stop inflating to check the air pressure. Do not over inflate. Do not ride
on flat or underinflated tires. Riding on flat or underinflated tires can cause injury, as well as, damage to the tire, tube
and wheels of your Hand-Trike.
• Test your brakes and make sure they stop the trike. If you have any doubts do not ride your trike and see your dealer.
All Hand-Trikes are equipped with front “coaster” brake and front “caliper” parking brake as standard equipment. Under
no circumstance should the brakes be removed. When stopping your Hand-Trike always use the front coaster brake for
a safe smooth stop.
• Check that the handlebar is tight and that the ends are plugged. Now check the saddle for tightness.
• Safety check: Apply your parking brake and rock your Hand-Trike back and forth. If you hear or feel a movement
coming from the fork or front wheel or any other part of the trike, DO NOT RIDE it, have your dealer or qualified
mechanic check the Hand-Trike.
PRECAUTIONS:
• A trike does not handle like a bicycle; therefore, you cannot lean into a turn. All wheels must be on the ground at all
times. Do not make sudden changes of direction, you could unbalance the trike and have an accident.
WARNING: Avoid riding over curbs. Watch for and avoid potholes, gratings and other road hazards. Walk your Hand-
Trike over railroad tracks, stairs, ditches or other such rough conditions. Do not attempt to ride up or down an incline with an
ice or oil film. Failure to do so may result in tire failure, loss of control, or other mechanical failures and may result in a serious
or fatal accident.
• We suggest you practice riding in a quiet area to get the feel of the trike.
• When beginning to ride, stay at a slow speed. You must acclimate yourself to the handling and turning of this three
wheeler. If you feel insecure, slow down, and proceed at a slower pace. With practice, you will get comfortable riding
and stopping.
• Never ride with your ears covered with earphones or anything else that would prevent hearing. Hearing your
surroundings is important for your safety.
• We recommend that you not ride at night, or at times of reduced visibility. If you should ride at night or during reduced
visibility, you must outfit your trike with a front white light and a rear red light. Relying solely on reflectors is not
adequate protection. Most municipalities require lights for night riding. Your bicycle dealer can help you in selecting the
correct lighting system for your needs.
• Avoid riding on rainy days since you don't have the same control, handling, and stopping power as on a dry day.
• Always ride with the flow of traffic, never against traffic
WARNING: DO NOT EVER Carry A CHILD, PERSON OR PET on your Hand-Trike! They could be seriously injured by
the turning wheel and/or the moving parts. The trike is made for one person and is not built to hold a passenger. DO NOT
EVER stand on the seat or frame of the Hand-Trike. DO NOT EVER carry any items that may obstruct your view or prohibit
you from operating your Hand-Trike properly.
• Weight capacity is 300 lbs.
GETTING STARTED:
• Please note that proper fitting to the individual rider is the responsibility of the dealer.
• Hand-Trike users should NOT be transported in any vehicle while seated in the Hand-Trike.
• Restraintsandseatpositioningstrapsarerecommendedbutnotincluded.Itisthedealers’obligationtodetermineifa
seatpositioningstrapisrequiredtoensurethesafeoperationofthisHand‐Trike.Varioustypesofrestraintsareavailable
fromyourlocalmedicalsupplydealers.SeriousinjurycouldoccurintheeventofafallfromyourHand‐Trike.
Adjustment:
• The Hand-Trike must be properly adjusted to fit the rider.
1. The hand-crank must be adjusted so the rider has a clear view in front of him/her.
2. The riders elbow must be slightly bent when the rider is sitting upright and hand is on the hand-pedal at its farthest
extension.
3.Feetmustbesecuredflatonthefootrestswithprovidedrestraintsandthekneesshouldhaveslightbend.
4. There should not be any interference with the crank, hands or knees while rotating hand-pedals and/or making a turn
with your Hand-Trike.
5. The end-user is responsible for regular upkeep and maintenance of the Hand-Trike to keep it in safe operating
condition.
6. Sun Bicycles is not responsible for failure, damage or injury caused by improper operation or maintenance of the
Hand-Trike by the end-user.
Operating Information:
1. Always wear your helmet while riding your Hand-Trike.
2. Always check your brakes before riding your Hand-Trike.
GETTING STARTED:
• Please note that proper fitting to the individual rider is the responsibility of the dealer.
• Hand-Trike users should NOT be transported in any vehicle while seated in the Hand-Trike.
• Restraintsandseatpositioningstrapsarerecommendedbutnotincluded.Itisthedealers’obligationtodetermineifa
seatpositioningstrapisrequiredtoensurethesafeoperationofthisHand‐Trike.Varioustypesofrestraintsareavailable
fromyourlocalmedicalsupplydealers.SeriousinjurycouldoccurintheeventofafallfromyourHand‐Trike.
Adjustment:
• The Hand-Trike must be properly adjusted to fit the rider.
1. The hand-crank must be adjusted so the rider has a clear view in front of him/her.
2. The riders elbow must be slightly bent when the rider is sitting upright and hand is on the hand-pedal at its farthest
extension.
3.Feetmustbesecuredflatonthefootrestswithprovidedrestraintsandthekneesshouldhaveslightbend.
4. There should not be any interference with the crank, hands or knees while rotating hand-pedals and/or making a turn
with your Hand-Trike.
5. The end-user is responsible for regular upkeep and maintenance of the Hand-Trike to keep it in safe operating
condition.
6. Sun Bicycles is not responsible for failure, damage or injury caused by improper operation or maintenance of the
Hand-Trike by the end-user.
Operating Information:
1. Always wear your helmet while riding your Hand-Trike.
2. Always check your brakes before riding your Hand-Trike.
3. Always check to make sure your tires are properly inflated before riding your Hand-Trike.
4. Always check that all hardware is properly tightened before riding your Hand-Trike.
5. Always keep hands, fingers and loose clothing away from the chain while pedaling.
6. Always keep children away from any moving parts of your hand trike.
7. Never carry any children, adults or pets as passengers on your Hand-Trike.
Transfer:
• The rider needs to determine their own safety limits. Practice transferring to and from the Hand-Trike with a qualified
health care professional before attempting use of the Hand-Trike on your own. Before attempting to transfer in or out of
your Hand-Trike, make sure to reduce the gap distance as much as possible. Position the Hand-Trike on level ground,
as close as possible to what you are transferring into or out of. The object you are transferring into or out of MUST also
be secured before attempting any transfer.
Finish Protection and Maintenance:
• Surface finish can be protected by applying and maintaining a coat of high quality, non-abrasive wax or polish
(automobile wax is suitable).
• The stainless steel (if equipped) used in your Hand-Trike is resistant to corrosion in most atmospheric conditions;
however, certain extreme environments may cause oxidizing of surfaces. We recommend either maintaining a coat of
wax or periodic polishing with a non-abrasive pad (e.g. typical dish cleaning pad). We recommend storing your Hand-
Trike away from direct sunlight.
WARNING: Never wax, polish, or lubricate the sidewall of the rims or brake shoes. Never attempt to adjust or clean the
internal gear hub with reversing brake. This should only be performed by a bicycle professional
5
GETTING STARTED:
• Please note that proper fitting to the individual rider is the responsibility of the dealer.
• Hand-Trike users should NOT be transported in any vehicle while seated in the Hand-Trike.
• Restraintsandseatpositioningstrapsarerecommendedbutnotincluded.Itisthedealers’obligationtodetermineifa
seatpositioningstrapisrequiredtoensurethesafeoperationofthisHand‐Trike.Varioustypesofrestraintsareavailable
fromyourlocalmedicalsupplydealers.SeriousinjurycouldoccurintheeventofafallfromyourHand‐Trike.
Adjustment:
• The Hand-Trike must be properly adjusted to fit the rider.
1. The hand-crank must be adjusted so the rider has a clear view in front of him/her.
2. The riders elbow must be slightly bent when the rider is sitting upright and hand is on the hand-pedal at its farthest
extension.
3.Feetmustbesecuredflatonthefootrestswithprovidedrestraintsandthekneesshouldhaveslightbend.
4. There should not be any interference with the crank, hands or knees while rotating hand-pedals and/or making a turn
with your Hand-Trike.
5. The end-user is responsible for regular upkeep and maintenance of the Hand-Trike to keep it in safe operating
condition.
6. Sun Bicycles is not responsible for failure, damage or injury caused by improper operation or maintenance of the
Hand-Trike by the end-user.
Operating Information:
1. Always wear your helmet while riding your Hand-Trike.
2. Always check your brakes before riding your Hand-Trike.
3. Always check to make sure your tires are properly inflated before riding your Hand-Trike.
4. Always check that all hardware is properly tightened before riding your Hand-Trike.
5. Always keep hands, fingers and loose clothing away from the chain while pedaling.
6. Always keep children away from any moving parts of your hand trike.
7. Never carry any children, adults or pets as passengers on your Hand-Trike.
Transfer:
• The rider needs to determine their own safety limits. Practice transferring to and from the Hand-Trike with a qualified
health care professional before attempting use of the Hand-Trike on your own. Before attempting to transfer in or out of
your Hand-Trike, make sure to reduce the gap distance as much as possible. Position the Hand-Trike on level ground,
as close as possible to what you are transferring into or out of. The object you are transferring into or out of MUST also
be secured before attempting any transfer.
Finish Protection and Maintenance:
• Surface finish can be protected by applying and maintaining a coat of high quality, non-abrasive wax or polish
(automobile wax is suitable).
• The stainless steel (if equipped) used in your Hand-Trike is resistant to corrosion in most atmospheric conditions;
however, certain extreme environments may cause oxidizing of surfaces. We recommend either maintaining a coat of
wax or periodic polishing with a non-abrasive pad (e.g. typical dish cleaning pad). We recommend storing your Hand-
Trike away from direct sunlight.
WARNING: Never wax, polish, or lubricate the sidewall of the rims or brake shoes. Never attempt to adjust or clean the
internal gear hub with reversing brake. This should only be performed by a bicycle professional
Limited Warranty:
J&B Importers, Inc. ("Sun Bicycles"), a Florida Corporation located at 11925 SW 128th St., Miami, FL 33186, makes the
following Limited Warranty concerning Sun Bicycles:
LIMITED 90-DAY WARRANTY ON COMPLETE BICYCLE
Subject to the following limitations, terms and conditions, Sun Bicycles warrants to the original owner of each new Sun
Bicycles bicycle that this bicycle when new is free of defective materials and workmanship. This warranty shall expire 90 days
from the date of the original purchase from a Sun Bicycles dealer and is conditioned upon the bicycle being operated under
normal conditions and use, and properly maintained. This warranty is void if the bicycle was not purchased new from or not
properly assembled by a Sun Bicycles dealer.
LIMITED LIFETIME WARRANTY ON STEEL BICYCLE FRAMES AND LIMITED FIVE (5) YEAR WARRANTY ON ALL
OTHER BICYCLE FRAMES
Also subject to the following limitations, terms and conditions, Sun Bicycles warrants to the original owner for the lifetime of
the original owner of each new steel framed Sun Bicycles that the bicycle frame when new is free of defective materials and
workmanship. Sun Bicycles' limited warranty for all other bicycle frames, including aluminum based bicycle frames, shall
expire five (5) years from the date of purchase from a Sun Bicycles dealer. The lifetime limited warranty and the five (5) year
limited warranty are conditioned upon the bicycle being operated under normal conditions and use, and properly maintained.
This limited warranty does not apply to paint/finish or components attached to the bicycle/frameset such as front forks,
wheels, drive train, brakes, seat post, handlebar and stem or any suspension related parts or components. Paint/finish,
components attached to the bicycle such as front forks, wheels, drive train, brakes, seat post, handlebar and stem or any
suspension related parts or components are covered under the limited 90 day warranty. This warranty is void if the bicycle
was not purchased new from or not properly assembled by a Sun Bicycles dealer.
ADDITIONAL CONDITIONS
This Limited Warranty is made only to the original owner of this new Sun Bicycles bicycle purchased from a Sun Bicycles
dealer, and it shall remain in force only as long as the original owner retains ownership of the Sun Bicycles bicycle. This
Limited Warranty is not transferable. In order to exercise your rights under this limited warranty, the bicycle must be presented
to a Sun Bicycles dealer, together with a receipt, bill of sale or other appropriate written proof of purchase which identifies the
bicycle by serial number. Should this bicycle, or any part be determined by Sun Bicycles to be covered by this warranty, it will
be repaired or replaced, at Sun Bicycles sole option, which will be conclusive and binding. The original owner shall pay all
labor charges connected with the repair or replacement of all parts. Under no circumstances does this limited warranty include
the cost of travel or shipment to and from a Sun Bicycles dealer. Such costs, if any, shall be borne by the original owner. This
limited warranty does not apply to normal wear and tear, nor to claimed defects, malfunctions or failures that result from
abuse, neglect, improper assembly, improper maintenance, alteration, collision, crash or misuse. This bicycle has not been
designed, engineered, distributed, manufactured, or retailed for uses in trick riding, ramp riding, jumping, aggressive ridin
g,
Limited Warranty:
J&B Importers, Inc. ("Sun Bicycles"), a Florida Corporation located at 11925 SW 128th St., Miami, FL 33186, makes the
following Limited Warranty concerning Sun Bicycles:
LIMITED 90-DAY WARRANTY ON COMPLETE BICYCLE
Subject to the following limitations, terms and conditions, Sun Bicycles warrants to the original owner of each new Sun
Bicycles bicycle that this bicycle when new is free of defective materials and workmanship. This warranty shall expire 90 days
from the date of the original purchase from a Sun Bicycles dealer and is conditioned upon the bicycle being operated under
normal conditions and use, and properly maintained. This warranty is void if the bicycle was not purchased new from or not
properly assembled by a Sun Bicycles dealer.
LIMITED LIFETIME WARRANTY ON STEEL BICYCLE FRAMES AND LIMITED FIVE (5) YEAR WARRANTY ON ALL
OTHER BICYCLE FRAMES
Also subject to the following limitations, terms and conditions, Sun Bicycles warrants to the original owner for the lifetime of
the original owner of each new steel framed Sun Bicycles that the bicycle frame when new is free of defective materials and
workmanship. Sun Bicycles' limited warranty for all other bicycle frames, including aluminum based bicycle frames, shall
expire five (5) years from the date of purchase from a Sun Bicycles dealer. The lifetime limited warranty and the five (5) year
limited warranty are conditioned upon the bicycle being operated under normal conditions and use, and properly maintained.
This limited warranty does not apply to paint/finish or components attached to the bicycle/frameset such as front forks,
wheels, drive train, brakes, seat post, handlebar and stem or any suspension related parts or components. Paint/finish,
components attached to the bicycle such as front forks, wheels, drive train, brakes, seat post, handlebar and stem or any
suspension related parts or components are covered under the limited 90 day warranty. This warranty is void if the bicycle
was not purchased new from or not properly assembled by a Sun Bicycles dealer.
ADDITIONAL CONDITIONS
This Limited Warranty is made only to the original owner of this new Sun Bicycles bicycle purchased from a Sun Bicycles
dealer, and it shall remain in force only as long as the original owner retains ownership of the Sun Bicycles bicycle. This
Limited Warranty is not transferable. In order to exercise your rights under this limited warranty, the bicycle must be presented
to a Sun Bicycles dealer, together with a receipt, bill of sale or other appropriate written proof of purchase which identifies the
bicycle by serial number. Should this bicycle, or any part be determined by Sun Bicycles to be covered by this warranty, it will
be repaired or replaced, at Sun Bicycles sole option, which will be conclusive and binding. The original owner shall pay all
labor charges connected with the repair or replacement of all parts. Under no circumstances does this limited warranty include
the cost of travel or shipment to and from a Sun Bicycles dealer. Such costs, if any, shall be borne by the original owner. This
limited warranty does not apply to normal wear and tear, nor to claimed defects, malfunctions or failures that result from
abuse, neglect, improper assembly, improper maintenance, alteration, collision, crash or misuse. This bicycle has not been
designed, engineered, distributed, manufactured, or retailed for uses in trick riding, ramp riding, jumping, aggressive riding,
riding on severe terrain, riding in severe climates, riding with heavy loads, commercial activities, or any similar activities; such
uses may damage the bicycle, and can cause serious injury to the rider, and in all cases will void this warranty.
USEFUL PRODUCT LIFE CYCLE
Every Sun Bicycles bicycle and frameset has a useful product life cycle. The length of that useful product life cycle will vary
with the construction and materials of the bicycle or frameset, the maintenance and care the bicycle or frameset receives over
its useful product life cycle, and the type and amount of use the bicycle or frameset is subject to. Uses in competitive events,
trick riding, ramp riding, jumping, aggressive riding, riding on severe terrain, riding in severe climates, riding with heavy loads,
commercial activities and other types of non-standard use can dramatically shorten the useful product life cycle of a Sun
Bicycles bicycle. Any one or a combination of these conditions may result in an unpredictable failure of a Sun Bicycles bicycle
that would not be covered by this warranty. All Sun Bicycle bicycles should be periodically checked by a Sun Bicycles dealer,
for indicators of stress and/or potential failure, including cracks, deformation, corrosion, paint peeling, dents, and any other
indicators of potential problems, inappropriate use, or abuse. These are important safety checks and very important to help
prevent accidents, bodily injury to the rider and shortened useful product life cycle of a Sun Bicycles bicycle.
THIS IS AN INTEGRATED AND FINAL STATEMENT OF SUN BICYCLES LIMITED WARRANTY. SUN BICYCLES DOES
NOT AUTHORIZE OR ALLOW ANYONE, INCLUDING ITS DEALERS, TO EXTEND ANY OTHER WARRANTIES, EXPRESS
OR IMPLIED, FOR SUN BICYCLES. NO OTHER REPRESENTATION, AND NO STATEMENT OF ANYONE BUT SUN
BICYCLES, INCLUDING A DEMONSTRATION OF ANY KIND BY
ANYONE SHALL CREATE ANY WARRANTY REGARDING THIS BICYCLE. ALL OF THE REMEDIES AVAILABLE TO THE
ORIGINAL OWNER ARE STATED HEREIN. IT IS AGREED THAT SUN BICYCLES' LIABILITY UNDER THIS LIMITED
WARRANTY SHALL BE NO GREATER THAN THE AMOUNT OF THE ORIGINAL PURCHASE PRICE AND IN NO EVENT
SHALL SUN BICYCLES BE LIABLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES.
DISCLAIMER
All other remedies, obligations, liabilities, rights, warranties, express or implied, arising from law or otherwise, including but not
limited to, any claimed implied warranty of merchantability, any claimed implied warranty arising from course of performance,
course of dealing or usage of trade, and any claimed implied warranty of fitness, are disclaimed by Sun Bicycles and waived
by the original owner. Some states, jurisdictions, countries, provinces, do not allow some or all of the limitations set for herein,
or the exclusion or limitation of incidental or consequential damages. If any provision is found unenforceable, only that
provision shall be stricken and all others shall apply. This limited warranty does provide the original owner with certain legal
rights and recourse and the original owner may possess other rights or recourse, depending on the state, jurisdiction, country
or province.
6
Limited Warranty:
J&B Importers, Inc. ("Sun Bicycles"), a Florida Corporation located at 11925 SW 128th St., Miami, FL 33186, makes the
following Limited Warranty concerning Sun Bicycles:
LIMITED 90-DAY WARRANTY ON COMPLETE BICYCLE
Subject to the following limitations, terms and conditions, Sun Bicycles warrants to the original owner of each new Sun
Bicycles bicycle that this bicycle when new is free of defective materials and workmanship. This warranty shall expire 90 days
from the date of the original purchase from a Sun Bicycles dealer and is conditioned upon the bicycle being operated under
normal conditions and use, and properly maintained. This warranty is void if the bicycle was not purchased new from or not
properly assembled by a Sun Bicycles dealer.
LIMITED LIFETIME WARRANTY ON STEEL BICYCLE FRAMES AND LIMITED FIVE (5) YEAR WARRANTY ON ALL
OTHER BICYCLE FRAMES
Also subject to the following limitations, terms and conditions, Sun Bicycles warrants to the original owner for the lifetime of
the original owner of each new steel framed Sun Bicycles that the bicycle frame when new is free of defective materials and
workmanship. Sun Bicycles' limited warranty for all other bicycle frames, including aluminum based bicycle frames, shall
expire five (5) years from the date of purchase from a Sun Bicycles dealer. The lifetime limited warranty and the five (5) year
limited warranty are conditioned upon the bicycle being operated under normal conditions and use, and properly maintained.
This limited warranty does not apply to paint/finish or components attached to the bicycle/frameset such as front forks,
wheels, drive train, brakes, seat post, handlebar and stem or any suspension related parts or components. Paint/finish,
components attached to the bicycle such as front forks, wheels, drive train, brakes, seat post, handlebar and stem or any
suspension related parts or components are covered under the limited 90 day warranty. This warranty is void if the bicycle
was not purchased new from or not properly assembled by a Sun Bicycles dealer.
ADDITIONAL CONDITIONS
This Limited Warranty is made only to the original owner of this new Sun Bicycles bicycle purchased from a Sun Bicycles
dealer, and it shall remain in force only as long as the original owner retains ownership of the Sun Bicycles bicycle. This
Limited Warranty is not transferable. In order to exercise your rights under this limited warranty, the bicycle must be presented
to a Sun Bicycles dealer, together with a receipt, bill of sale or other appropriate written proof of purchase which identifies the
bicycle by serial number. Should this bicycle, or any part be determined by Sun Bicycles to be covered by this warranty, it will
be repaired or replaced, at Sun Bicycles sole option, which will be conclusive and binding. The original owner shall pay all
labor charges connected with the repair or replacement of all parts. Under no circumstances does this limited warranty include
the cost of travel or shipment to and from a Sun Bicycles dealer. Such costs, if any, shall be borne by the original owner. This
limited warranty does not apply to normal wear and tear, nor to claimed defects, malfunctions or failures that result from
abuse, neglect, improper assembly, improper maintenance, alteration, collision, crash or misuse. This bicycle has not been
designed, engineered, distributed, manufactured, or retailed for uses in trick riding, ramp riding, jumping, aggressive riding,
riding on severe terrain, riding in severe climates, riding with heavy loads, commercial activities, or any similar activities; such
uses may damage the bicycle, and can cause serious injury to the rider, and in all cases will void this warranty.
USEFUL PRODUCT LIFE CYCLE
Every Sun Bicycles bicycle and frameset has a useful product life cycle. The length of that useful product life cycle will vary
with the construction and materials of the bicycle or frameset, the maintenance and care the bicycle or frameset receives over
its useful product life cycle, and the type and amount of use the bicycle or frameset is subject to. Uses in competitive events,
trick riding, ramp riding, jumping, aggressive riding, riding on severe terrain, riding in severe climates, riding with heavy loads,
commercial activities and other types of non-standard use can dramatically shorten the useful product life cycle of a Sun
Bicycles bicycle. Any one or a combination of these conditions may result in an unpredictable failure of a Sun Bicycles bicycle
that would not be covered by this warranty. All Sun Bicycle bicycles should be periodically checked by a Sun Bicycles dealer,
for indicators of stress and/or potential failure, including cracks, deformation, corrosion, paint peeling, dents, and any other
indicators of potential problems, inappropriate use, or abuse. These are important safety checks and very important to help
prevent accidents, bodily injury to the rider and shortened useful product life cycle of a Sun Bicycles bicycle.
THIS IS AN INTEGRATED AND FINAL STATEMENT OF SUN BICYCLES LIMITED WARRANTY. SUN BICYCLES DOES
NOT AUTHORIZE OR ALLOW ANYONE, INCLUDING ITS DEALERS, TO EXTEND ANY OTHER WARRANTIES, EXPRESS
OR IMPLIED, FOR SUN BICYCLES. NO OTHER REPRESENTATION, AND NO STATEMENT OF ANYONE BUT SUN
BICYCLES, INCLUDING A DEMONSTRATION OF ANY KIND BY
ANYONE SHALL CREATE ANY WARRANTY REGARDING THIS BICYCLE. ALL OF THE REMEDIES AVAILABLE TO THE
ORIGINAL OWNER ARE STATED HEREIN. IT IS AGREED THAT SUN BICYCLES' LIABILITY UNDER THIS LIMITED
WARRANTY SHALL BE NO GREATER THAN THE AMOUNT OF THE ORIGINAL PURCHASE PRICE AND IN NO EVENT
SHALL SUN BICYCLES BE LIABLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES.
DISCLAIMER
All other remedies, obligations, liabilities, rights, warranties, express or implied, arising from law or otherwise, including but not
limited to, any claimed implied warranty of merchantability, any claimed implied warranty arising from course of performance,
course of dealing or usage of trade, and any claimed implied warranty of fitness, are disclaimed by Sun Bicycles and waived
by the original owner. Some states, jurisdictions, countries, provinces, do not allow some or all of the limitations set for herein,
or the exclusion or limitation of incidental or consequential damages. If any provision is found unenforceable, only that
provision shall be stricken and all others shall apply. This limited warranty does provide the original owner with certain legal
rights and recourse and the original owner may possess other rights or recourse, depending on the state, jurisdiction, country
or province.
Table of contents
Other J&B Importers Bicycle manuals
