JBL DSC 500 User manual

SPECIFICATIONS:
Source Unit Section
•Signal Format System: NTSC/PAL
•Video Signal-to-Noise Ratio (DVD) : 60 dB
•Audio Frequency Response DVD (PCM) : 20Hz - 20 kHz (±1 dB)
•Audio Frequency Response CD : 20Hz - 20 kHz (±1 dB)
•Signal-to-Noise Ratio: >80 dB
•Total Harmonic Distortion: 0,0001
•Dynamic Range: DVD (PCM): >85 dB
•Dynamic Range: CD: >85 dB
Audio Section
•Surround Formats: Dolby Digital - DTS - Dolby Pro Logic
•Frequency Response at 1W (+0dB, -3dB): 45Hz - 20 kHz
•Signal-to-Noise Ratio (IHF-A): 80 dB
Satellite Section
•Frequency Response (-6db): 120 Hz-20 kHz
•Sensitivity (2.83V @ 1m): 84 dB
•Nominal Impedance: 4 Ohms
•Recommended Amplifier Power: 35 Watts RMS
•Titanium Laminate HF: 12 mm
•Paper Cone Midrange : 75 mm
•Dimensions (H x W x D): 111 x 81 x 92 mm
•Weight: 0.5 kg
•Finish: silvergray
Center Section
•Frequency Response (-6db): 120 Hz-20 kHz
•Sensitivity (2.83V @ 1m): 86 dB
•Nominal Impedance: 4 Ohms
•Recommended Amplifier Power: 35 Watts RMS (in sub)
•Titanium Laminate HF: 12 mm
•Paper Cone Midrange : dual 75 mm
•Dimensions (H x W x D): 83 x 194 x 95 mm
•Weight: 0.8 kg
•Finish: silvergray
Subwoofer Section
•Low Frequency Cut-off: 35 Hz
•High Frequency Cut-off: 160 Hz
•Built-in Power Amplifier (RMS): 35 Watts x 5 + 100 Watts
•Paper Cone Long Throw Driver : 200 mm
•Dimensions (H x W x D): 450 x 250 x 360 mm
•Weight: 13.6 kg
•Finish: beech
General Section
•Power Requirement: 230V/50-60Hz
•Power Consumption: 100 Watts
•Dimensions (H x W x D): 75 x 431 x 352 mm
•Weight: 7.9 kg
Service Manual
DSC 500
www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals

www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals
BPL40003-0102
GSP400008-0101
HSP140071-3160
FSA213012-1801
HSP140054-1080
BRF400006-0001
BRF400005-0001
BPF405006-01011
BPA400007-01011
FSA243010-1801
APE200080-0001
TWEETER
IVM110001-0001
YLB1060003-0002
DSC500 CENTER SPEAKER : AFK200003-0001

www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals
DSC500 SATELLITE : AFK200002-0001
BPL400003-0102
GSP400002-0102
FSA213012-1401
BPF405003-0101
BPA400004-0101
BRF400005-0001
BRF400006-0001
IVM000002-0004
TWEETER
FSA243010-1801
APE200040-0001

5
2
1
3
4
25
6
7
8
27
26
9
11
10
12
24
23
22
20
13
14
16
15
17
18
21
19
LOGO BADGELOGO BADGE
DOOR LENSDOOR LENS
WINDOW LENSWINDOW LENS
VOLUME KNOBVOLUME KNOB
FRONT PANELFRONT PANEL
TOP BRACKETTOP BRACKET
CONTROL PCBCONTROL PCB
RUBBER FOOT(FRONT)RUBBER FOOT(FRONT)
PLASTIC FOOTPLASTIC FOOT
RUBBER FOOT(BACK)RUBBER FOOT(BACK)
BOTTOM CABINETBOTTOM CABINET
TUNER PCBTUNER PCB
FM HOLDERFM HOLDER
REAR PANELREAR PANEL
TOP COVERTOP COVER
LINE CORDLINE CORD
SWITCHING POWER PCBSWITCHING POWER PCB
DVS LOADERDVS LOADER
LOADER HOLDERLOADER HOLDER
POWER KNOBPOWER KNOB
FUNCTION KNOBFUNCTION KNOB
BPL200001-0001BPL200001-0001
BPD200003-0001BPD200003-0001
BPN200002-0001BPN200002-0001
BPN210002-0001BPN210002-0001
BPK222001-0001BPK222001-0001
GAL200002-0001GAL200002-0001
33
11
22
55
44
66
BPF200002-0001BPF200002-0001
GSE200006-0001GSE200006-0001
GSE200003-0001GSE200003-0001
GSE200004-0001GSE200004-0001
GSE200005-0001GSE200005-0001
APE101700-0001APE101700-0001
APE200100-0001APE200100-0001
BPE100018-0001BPE100018-0001
BPH100025-0000BPH100025-0000
APE200230-0001APE200230-0001
DSS100025-0001DSS100025-0001
BRF200004-0001BRF200004-0001
VPE003012-0020VPE003012-0020
BRB200002-0001BRB200002-0001
1010
77
88
99
1212
1111
1313
1717
1414
1515
1616
1919
1818
2020
BPH210003-0001
BPK212001-0001
BPK202001-0001
IVE200008-0001
GSE200035-0001
WVD100002-0004
APE200090-0001APE200090-0001
2424
2121
2222
2323
2626
2525
2727
DVD DOORDVD DOOR
AL PANELAL PANEL
11
11
11
11
11
11
SPACERSPACER
MAIN PCBMAIN PCB
11
11
11
11
22
22
11
11
22
11
11
11
11
11
BRACKETBRACKET
SPONGESPONGE
11
11
11
11
11
11
11
www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals
Exploded view
source unit

www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals

Head unit - Main board
Installation Point Description Material No. Qty.
MAIN PCB ASSY APE101700-0001 1
CN901 CONNECTOR B12B-XH-A 12 PIN CCN250000-0112 1
CN103 CONNECTOR 20x2 PIN PLUG BASE CCN254020-0440 1
CN101 CN201 CONNECTOR 15 PIN PITCH=2.0mm CCN200000-0115 2
JK101 RCA+DIN JK 4P DIN+2RCA W/GND CJC010001-3010 1
JK401 RCA JACK 6P REDx3/WHTx3 STAND 2 RCA HOLE CJR006601-0010 1
JK201 SCART SOCK 21PIN PITCH=3.81mm CSS021001-1030 1
JK203 RCA JACK 1P BLACK W/GEND PIN CJR001301-0010 1
XL101 CRYSTAL 27 MHZ HC-49US 30ppm JQC023101-2760 1
C071 C072 C1001 C1102 C4001 C4003 COND ELECT 100uF 16V 20% PRE039540-1010 25
C534 COND ELECT 220 uF 16V 20% PRE039540-2210 1
C1000 C1009 C1010 C1012 C1015 C1016 COND ELECT 10 uF 50V 20% PRE039570-1000 51
C603 COND ELECT 1uF 50V 20% PRE039570-1090 1
C163 COND ELECT 3.3 uF 50V 20% PRE039570-3390 1
C453 C456 COND MYLAR 0.015 uF 100V 5% PRM0373A0-1530 2
C454 C457 COND METAL 0.47uF 100V 5% PRN0263A0-4740 2
C452 C455 COND MYLAR 0.0082 uF 100V 5% PRM0373A0-8220 2
Q008 Q010 Q506 Q102 Q103 XISTR NPN 2SC945P RAN200945-0001 5
Q401 Q402 XISTR NPN 2SC2878-A (TE2,.M) RAN202878-0001 2
Q009 Q011 Q403 XISTR PNP 2SA733Q,P NEC RAP200733-0001 3
R540 RESISTOR 10K OHM 1/6W 5% CF QAF065000-1030 1
R542 RESISTOR 100K OHM 1/6W 5% CF QAF065000-1040 1
R462 R463 R496 R497 RESISTOR 150 OHM 1/6W 5% CF QAF065000-1510 4
R543 RESISTOR 6.8K OHM 1/6W 5% CF QAF065000-6820 1
D102 D505 D506 D507 D509 DIODE SW; 1N4148 RAD114148-0010 16
ZD101 ZD102 ZD104 ZD105 ZD106 ZD107
ZD108 ZD109 ZD103 ZD401 ZD402 ZD403 DIODE ZENR 6.9-7.2V 0.5W RAZ005007-0020 13
L101 L102 L103 L108 CHOKE 10 uH 10% SAN001600-1000 4
L602 L603 INDUCTOR 100 uH 10% SAN001600-1010 2
L104 L105 L106 L107 INDUCTOR 2.4 uH 10% SHN001600-2490 4
L601 L605 FIXED (COLOUR) INDUC70R 0.68uH 10% SAN001600-6880 2
FB101 FB102 FB108 FB109 BEAD FERIT DIA3.5x6mm SFB001001-0030 4
J001 J003 WIRE BARE 22 GA TINNED XJP220000-0001 2
C1104 C401 C402 C403 C404 C405 C406 CHIP CAP 100 pF 50V 5% PYL410370-1010 7
C135 EMC101 EMC102 EMC103 CHIP CAP 1000 pF 50V 5% PYL410370-1020 4
C216 C217 C218 C219 C220
C221 C222 C223 C224 C225 CHIP CAP 15 pF 50V 5% PYL410370-1500 10
C133 C134 C419 C421 CHIP CAP 22 pF 50V 5% PYL410370-2200 4
C168 C173 C178 C183 C188 CHIP CAP 150 pF 50V 5% PYL410370-1510 5
C1017 C1018 C1105 C1106
C1107 C230 C416 C413 CHIP CAP 47 pF 50V 5% PYL410370-4700 8
C601 C610 C612 C615 CHIP CAP 56 pF 50V 5% PYL410370-5600 4
C492 C1 C2 C3 C4 C5 C6 C4119 C4117 CHIP CAP 560 pF 50V 5% PYL410370-5610 9
C4113 CHIP CAP 4700 pF 50V 20% PYL439570-4720 1
C193 CHIP CAP 3300 pF 50V 20% PYL439570-3320 1
JBL DSC500 230V
www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals

C101 C102 C1020 C1021 C1022 CHIP CAP 0.1 uF 50V 5% PYL456370-1040 66
C191 C192 CHIP CAP 0.0056 uF 50V 5% PYL456370-5620 2
C1005 C1006 C1007 C1008 C1011 C4010 CHIP CAP 0.1 uF 50V 10% PYL456470-1040 25
R111 R170 CHIP RES. 0 OHM JUMP WIRE QCF015020-0000 2
R109 CHIP RES. 10 OHM 1/10W 5% QCF015020-1000 1
R236 R451 R452 R453 R454 R455 R456
R179 R115 R116 R117 R118 CHIP RES. 100 OHM 1/10W 5% QCF015020-1010 12
R121 R124 R125 R128 CHIP RES. 1K OHM 1/10W 5% QCF015020-1020 32
R168 R4001 R4002 R4003 R4004 R4005 CHIP RES. 10K OHM 1/10W 5% QCF015020-1030 50
R419 R420 R171 R052 CHIP RES. 100K OHM 1/10W 5% QCF015020-1040 4
R422 R424 R449 R4120 R4116 R4121 R4101 CHIP RES. 12K OHM 1/10W 5% QCF015020-1230 7
R152 CHIP RES. 18K OHM 1/10W 5% QCF015020-1830 1
R235 CHIP RES. 200 OHM 1/10W 5% QCF015020-2010 1
R054 R058 R457 R458 R459 R460 CHIP RES. 22K OHM 1/10W 5% QCF015020-2230 17
R114 CHIP RES. 270 OHM 1/10W 5% QCF015020-2710 1
R106 R107 R151 R155 CHIP RES. 33 OHM 1/10W 5% QCF015020-3300 18
R427 R428 CHIP RES. 150K OHM 1/10W 5% QCF015020-1540 2
R053 R055 R057 R101 CHIP RES. 4.7K OHM 1/10W 5% QCF015020-4720 20
R056 R406 R425 R429 CHIP RES. 47K OHM 1/10W 5% QCF015020-4730 15
R4117 CHIP RES. 24K OHM 1/10W 5% QCF015020-2430 1
R153 CHIP RES. 560 OHM 1/10W 5% QCF015020-5610 1
R143 R147 R148 R149 R150 R471 R477
R483 R489 R495 CHIP RES. 5.6K OHM 1/10W 5% QCF015020-5620 10
R108 R4118 CHIP RES. 56K OHM 1/10W 5% QCF015020-5630 2
R411 R412 R413 R414 R417 R418 CHIP RES. 6.8K OHM 1/10W 5% QCF015020-6820 6
R426 R435 R436 R437 CHIP RES. 68K OHM 1/10W 5% QCF015020-6830 4
R177 R605 R607 CHIP RES. 75 OHM 1/10W 5% QCF015020-7500 3
R401 R402 R403 R404 R409 R410 R448 CHIP RES. 8.2K OHM 1/10W 5% QCF015020-8220 7
RA112 RA113 RA114 RES ARRAY 10 OHMx4 1/10W 5% QCP015081-1000 3
RA101 RA102 RA103 RA104 RA105 RA106 RES ARRAY 33 OHMx4 1/10W 5% QCP015081-3300 12
RA117 RA118 RES ARRAY 4x4.7K 1/10W 5% QCP015081-4720 2
IC108 IC 54 PIN 4MX16 Y3V TW StarRam RCI400160-0001 1
IC107 IC 8 PIN AT24C02N-10SI-2.7 TI RCI024002-0002 1
IC101 IC 40 PIN MX29F080TC-90CE RCI290080-0002 1
IC401 IC 16 PIN TC4052BFN CHIP RCI004052-0001 1
IC408 IC 16 PIN TC4053BFN TOSHIBA RCI004053-0001 1
IC116 IC 28 PIN AK4112BVF RCI004112-0001 1
IC110 IC111 IC112 IC402 IC403 IC409
IC411 IC412 IC413 IC414 IC415 IC416
IC417 IC419 IC420 IC421 IC 8 PIN JRC4558M JRC RCI004558-0001 16
IC103 IC 208 PIN ES6018 RCI006018-0001 1
IC410 IC 42 PIN M62446FP MITSUBISHI RCI062446-0001 1
IC104 IC 14 PIN TC74HC04AFN TOSHIBA RCI740004-0001 1
IC117 IC118 IC 20 PIN SN74HCT244DW T.I RCI740244-0001 2
IC105 IC106 IC119 IC 20 PIN 74HC374 RCI740374-0002 3
IC115 IC 20 PIN WM8739 2CH A/D RCI008739-0001 1
IC109 IC 28 PIN WM8746 6CH D/A RCI008746-0001 1
IC113 IC 3 PIN RT9164-33CLR RCI916433-0001 1
www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals

FB103 FB104 FB105 FB106 FB107 FB201
FB202 FB203 FB204 FB205 FB206 FB207
FB208 CHIP BEAD 600 OHM AT 100MHz SCB008050-6010 13
C147 C148 C150 C151 CHIP CAP 470 pF 50V 5% PYL410370-4710 8
C152 C153 C154 C149
R4006 R4016 R4026 R4056 R4066 R4046 CHIP RES. 5.1K OHM 1/10W 5% QCF015020-5120 6
R4100 R470 R476 R482 R488 R494 CHIP RES. 1.5K OHM 1/10W 5% QCF015020-1520 6
IC120 IC 3 PIN IMP809 SOT23 RESETVOL 2.93V RCI000809-0003 1
R447 CHIP RES. 3K OHM 1/10W 5% QCF015020-3020 1
C466 C471 C476 C481 C486 CHIP CAP 330 pF 50V 5% PYL410370-3310 5
C166 C167 C171 C181 C186 C182 C177
C172 C176 C187 CHIP CAP 0.01 uF 50V 5% PYL456370-1030 10
IC121 IC 4 PIN B1117N-2.85 SOT-223 1A RCI011170-0001 1
R178 CHIP RES. 120 OHM 1/10W 5% QCF015020-1210 1
IC601 IC 25PIN BH7860FP VIDEO SIGNAL PROCESSOR RCI007860-0001 1
R4112 CHIP RES. 1.2K OHM 1/10W 5% QCF015020-1220 1
R415 R416 CHIP RES. 390 OHM 1/10W 5% QCF015020-3910 2
R180 CHIP RES. 3.9K OHM 1/10W 5% QCF015020-3920 1
L606 L604 INDUCTOR 2.7uH SAN201601-2790 2
R4230 RESISTOR 150 OHM 1/4W 5% CF QAF045000-1510 1
ZD405 DIODE ZENR 6.0-6.3V 0.5W RAZ005006-0030 1
R541 RESISTOR 39K OHM 1/6W 5% CF QAF065000-3930 1
EMCD01 DIODE 1N5392 1.5A 100V RAD115392-0010 1
C616 COND ELECT 22uF 50V 20% PRE039570-2200 1
C498 C499 C495 C496 C497 C494 COND ELECT 4.7 uF 50V 20% PRE039570-4790 6
EMC001 EMC004 EMC005 EMC010 COND DISC 0.1 uF 50V +80-20% PRD249670-1040 4
EMC006 EMC008 EMC007 EMC009 EMC102 COND DISC 0.001 uF 50V +80-20% PRD249670-1020 5
12P 200mm 2468#26 RAINBOW A=2.5 B=2512V VFLC01312-2000 1
CN401 D-SUB JACK 15P D-SUB 90* CGIC RC CJF015001-2002 1
WIRE 26 GA 90 mm BLACK 4-4 VWR0151BB-0090 1
COND DISC 0.1 uF 50V +80-20% PRD249670-1040 2
WIRE 26 GA 60 mm BLACK 4-4 VWR0151BB-0060 1
Head unit - Control board (Front board)
Installation Point Description Material No. Qty.
CONTROL PCB ASSY APE200100-0001 1
XL201 CRYSTAL 4.5000 MHZ HC-49/S JQC023101-4550 1
CN203 CONNECTOR 3 PIN PITCH=2.0mm CCN200000-0103 1
IC201 IC 18 PIN CTM8B56EN(MCU1226) RHI008056-0001 1
C216 COND DISC 4700 pF 50V 10% PRD235470-4720 1
C201 COND ELECT 10uF 16V 20% PRE039540-1000 1
C208 C209 C210 C214 COND DISC 15 pF 50V 5% PRD113370-1500 4
C204 C205 COND DISC 22 pF 50V 5% PRD113370-2200 2
C220 C221 COND DISC 100 pF 50V 5% PRD113370-1010 2
C202 C206 C211 COND ELECT 100uF 16V 20% PRE039540-1010 3
C203 C207 C212 COND DISC 0.1 uF 50V +80-20% PRD249670-1040 3
C226 COND DISC 220 pF 50V 10% PRD235470-2210 1
C218 COND MULTI 0.33UF 10% 50V X7R PRL156470-3340 1
C215 COND DISC 820 pF 50V 10% PRD235470-8210 1
www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals

Q204 XISTR NPN 2SC945P RAN200945-0001 1
R225 RESISTOR 1K OHM 1/6W 5% CF QAF065000-1020 1
D201 D202 D203 D204 D208 DIODE SW; 1N4148 RAD114148-0010 5
R224 RESISTOR 68K OHM 1/6W 5% CF QAF065000-6830 1
R207 R211 R212 R213 R226 RESISTOR 100 OHM 1/6W 5% CF QAF065000-1010 5
R206 R208 RESISTOR 100K OHM 1/6W 5% CF QAF065000-1040 2
R209 RESISTOR 560 OHM 1/6W 5% CF QAF065000-5610 1
R230 R231 R201 R202 R203 R204 R20
5
R210 R215 RESISTOR 10K OHM 1/6W 5% CF QAF065000-1030 9
R219 RESISTOR 56K OHM 1/6W 5% CF QAF065000-5630 1
TA210 TA209 TA208 TA202 TA203 TA204
TA201 TA207 AI TACT SW SKHVBE3520 MAW060001-0010 8
R227 RESISTOR 2K OHM 1/6W 5% CF QAF065000-2020 1
JW201 JW202 JW203 JW204 JW205 JW206
JW207 JW208 JW209 JW210 JW211 JW212
JW213 JW214 JW215 JW216 JW217 WIRE BARE 22 GA TINNED XJP220000-0001 17
R233 RESISTOR 6.8 OHM 1/4W 5% CF QAF045000-6890 1
Q205 Q206 XISTR PNP 2SA733Q,P NEC RAP200733-0001 2
SPONGE L10 X W10 X T13.5mm IVE200009-0001 1
SN201 IRT SENSOR RPM6938-V4 RHO693804-2001 1
LCD FILTER L110xW27xT0.27mm PVC WHITE BFT211001-0001 1
LCD HOLDER ABS BPH200002-0001 1
LCD TOP ABS BPH210002-0001 1
COND FLAT CABLE 15P 250mm 2468#26 A=2mm VFLF01246-2500 1
D207 LED HI-BRIG 2x4.6mm BLUE KED600052-0010 1
POT2 R-ENCODER ;EC16B24204 ALPS MSW005007-0010 1
3P 190mm 2468#26 RAINBOW VFL301245-1900 1
CN2 CONNECTOR 4 PIN PITCH=2.0mm CCN200000-0104 1
IC202 IC 80 PIN PT6583 LCD DRIVER RCI006583-0001 1
IC201 DISPLAY IC DTE102251AIP KEYMOS KLD000052-0010 1
FILTER LENS PMMA BPN200003-0001 1
Head unit - Power board (power supply)
Installation Point Description Material No. Qty.
POWER PCB ASSY APE200090-0001 1
IC7 IC 3 PIN 7812 12V 1A RHI007812-0001 1
IC6 IC 3 PIN 7912 RHI007912-0001 1
CN902 CN907 CONNECTOR 4 PIN P=3.96mm CCN396021-0104 2
IC2 IC 3 PIN TL431 RHI004310-0001 1
T901 PWR TRANS 230V 50Hz EI28 AXIAL TTA123011-0010 1
RL001 RELAY GJ-SH-112DM MRL012004-0011 1
PH IC 4 PIN PC817A RHI008170-0001 1
IC1 IC 8 PIN DIP NCP1002P DIP FOR CNTL RHI001002-0001 1
IC5 IC 3 PIN; LM317 POS ADJ REG. RHI003170-0001 1
C3 C4 C11 COND SAFTY 0.0022uF 400V 20% PVY1705K0-2222 3
C5 COND ELECT 68 uF 400V 20% PVE0395K0-6800 1
C54 COND SAFTY 0.01uF 250V 20% PVY2705F0-1031 1
C15 C18 COND ELECT 1000 uF 10V 20% PME039530-1020 2
Q3 Q4 XISTR NPN 2N3904 FAIRCHILD RAN203904-0001 2
C1 C2 COND SAFETY 0.22uF 275V X2P 20% PVX2705G0-2240 2
www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals

C9 C17 C21 C29 C35 C37 C39 C42 C44
C46 C47 C19 C28 COND DISC 0.1 uF 50V +80-20% PRD249670-1040 13
C10 C12 C48 COND ELECT 1uF 50V 20% PRE039570-1090 3
C6 COND ELECT 2.2 uF 50V 20% PRE039570-2290 1
C24 COND ELECT 4.7 uF 50V 20% PRE039570-4790 1
C51 C52 COND ELECT 10 uF 50V 20% PRE039570-1000 2
C8 COND ELECT 100uF 50V 20% PRE039570-1010 1
C53 COND ELECT 220 uF 50V 20% PME039570-2210 1
q5 q6 XISTR NPN 2SC945P RAN200945-0001 2
C33 C34 C36 C40 C41 C43 C30 C45 C38
C31 C32 COND ELECT 330uF 25V 20% PRE039550-3310 11
C20 COND ELECT 470uF 16V 20% PRE039540-4710 1
R34 R35 RESISTOR 1.0 OHM 1/4W 5% CF QAF045000-1090 2
R4 R6 R23 RESISTOR 1.0K OHM 1/4W 5% CF QAF045000-1020 3
R1 RESISTOR 1.0M OHM 1/4W 5% CF QAF045000-1050 1
D22 D23 D20 D21 DIODE;RECTIFIER 1N4001 RAD114001-0010 4
D1 D2 D3 D4 DIODE 1N4007 RAD114007-0010 4
D6 DIODE SW; 1N4148 RAD114148-0010 1
R19 RESISTOR 4.7K OHM 1/4W 5% CF QAF045000-4720 1
ZD14 DIODE ZENR 5.6-5.9V 0.5W RAZ005006-0020 1
R33 RESISTOR 10 OHM 1/6W 5% CF QAF065000-1000 1
R16 R30 R31 R32 RESISTOR 10K OHM 1/6W 5% CF QAF065000-1030 4
R5 RESISTOR 22 OHM 1/6W 5% CF QAF065000-2200 1
R15 RESISTOR 24K OHM 1/6W 5% CF QAF065000-2430 1
R14 RESISTOR 33K OHM 1/6W 5% CF QAF065000-3330 1
R7 RESISTOR 68 OHM 1/4W 5P% CF QAF045000-6800 1
R18 RESISTOR 47K OHM 1/6W 5% CF QAF065000-4730 1
R10 RESISTOR 2.7K OHM 1/6W 5% CF QAF065000-2720 1
R9 RESISTOR 3K OHM 1/6W 5% CF QAF065000-3020 1
R17 R21 R22 RESISTOR 3K OHM 1/6W 5% CF QAF065000-3020 3
D7 D8 D9 D11 MBR 1100 1A 100V SHOTTKY BARRIER RAD101100-0010 4
D5 DIODE MUR160E 1A 800V RAD100160-0010 1
R8 RESISTOR 100 OHM 1/4W 5% CF QAF045000-1010 1
D13 DIODE ZENR 11.9-12.4V 0.5W RAZ005012-0010 1
JW3 JW4 JW5 JW6 WIRE BARE 22 GA TINNED XJP220000-0001 4
R3 RESISTOR 22K 2W 5% W/O KINK HI-AXIAL CF QHF205000-2230 1
D12 MBR1045 10A 45V MOT DRIVER W/KEY I/P FUN RHD101045-0010 1
FUSE CLIP DIA5xL20mm FUSE CFC011000-1001 2
TIN PLATE L26.5xW25xT0.8mm BRACKET GTP200002-0001 1
CONA 12P 200mm 2468#26 RAINBOW A=2.5 B=2512V VFLC01312-2000 1
L1 LINE FILTER 22mH D0.37x110TS JFT001003-0010 1
TR ER-29/32 230V 600uH PWR TRANS TSB023001-0010 1
L2 L3 L4 L5 COIL 3.3uH/3A VERTICAL PITCH 7mm SIL206001-3390 4
RV SURGE ABSORBER 10N471K RHU100471-2001 1
C7 CAP 0.01uF 1KV +80%-20% Y5 PLD3336Q0-1030 1
TIN PLATE BRACKET T=0.8mm GTP200003-0001 1
CONB CONNECTOR B4B-XH-A 4 PIN CCN250000-0104 1
C50 COND ELECT 220 uF 50V 20% PME039570-2210 1
RT NTC 5 OHM 5A DIA=13 mm RNT005130-5090 1
www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals

WIRE 22 GA 80 mm RED 14-14 mm VWR0333GG-0080 1
WIRE 22 GA 90mm RED 4-4 VWR0333BB-0090 1
SCREW T3.0xL6xP1.06mm HSP140054-1060 4
C13 COND SAFTY 0.01uF 250V 20% PLY2705F0-1030 1
FU FUSE 3.15A 250V SLOW(WALTER TSD) KSA020315-0120 1
FUSE COVER;ID19.6xW11xH5.5mm UL DCR030001-0001 1
Head unit - mechanics parts
Installation Point Description Material No. Qty.
IC5 IC7 IC8 IC6 HEAT SINK 10.5x15x24mm AL GAL100040-0002 4
FRONT PANEL HIPS BPF200002-0001 1
FUNCTION KEY ABS BPK202001-0001 1
POWER KEY ABS BPK212001-0001 1
VOLUME KNOB ABS BPK222001-0001 1
DVD DOOR HIPS PAINT PMS877C BPD200003-0001 1
DOOR LENS PMMA BPN200002-0001 1
WINDOW LENS PMMA BPN210002-0001 1
LOGO PLATE JBL ABS BPL200001-0001 1
DVD HOLDER HIPS BPD210003-0001 1
FRONT PANEL AL GAL200002-0001 1
BOTTOM CAB. SECC T=0.8mm GSE200003-0001 1
BACK PANEL SECC T=0.8mm GSE200004-0001 1
TOP COVER SECC T=0.6mm GSE200005-0001 1
TOP BRACKET SECC T=1.0mm GSE200006-0001 1
SCREW T3.0xL8xP1.06mm HSP140054-1080 8
SCREW M3.0xP0.5x8 HST143084-1080 3
SCREW T3.0x1.06PxL8mm HST140054-1080 11
SCREW M3.0xP0.5x6 HST143084-1060 13
BUSHING AC LINE BUSHING DBU001005-0010 1
WIRE TIE GT-90M 90mm DWT000001-0900 3
SPACER A=8.0mm B=1.3-1.7 PINGOOD SCB-8 DSS100022-0004 5
SPACER A=15.6 B=1.2-1.6 DSS100026-0001 2
SPONGE L100 x W8 x T1.5mm IVE200008-0001 1
SPONGE L10 X W10 X T13.5mm IVE200009-0001 1
RUBBER FOOT 19.5 x 2.5 MM BRF200004-0001 2
SCREW M3.0 X 0.5P TYPE TRIANGLE HSF143084-1080 6
LINE CORD 2P 1980mm BLK VDE W/3.96VH 4P VPE003252-0010 1
Mecha DVD LOADER DSL-710A DVS ATRAPI WVD100002-0006 1
Head unit - Tuner
Installation Point Description Material No. Qty.
TUNER PCB ASSY APE200230-0001 1
CF103 CER FILTER 450 KHZ JFT005001-0030 1
CF101 CER FILTER 10.7 MHZ JFT005002-0020 1
CF102 CER FILTER 10.7 MHZ JFT005002-0040 1
XL152 CRYSTAL 4.5000 MHZ HC-49/U JQC013101-4550 1
TC001 COND TRIM 3 - 10 PF NP0 MVC001001-0010 1
TC002 COND TRIM 4.2 - 20 PF N450 MVC001002-0010 1
C166 COND ELECT 3.3 uF 16V 20% PVE939540-3390 1
C117 C171 COND ELECT 47 uF 16V 20% PVE939540-4700 2
www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals

C014 COND POLY 560pF 50V 5% PVP026370-5610 1
VD001 VD002 DIODE TUNG AM TOSHIBA 1SV149B RHV100149-0001 2
L103 COIL 39 mH 10% D6xH11xP5mm SIL106003-3930 1
T102 AM IFT 455KHz Q=130 SIF010001-0040 1
T105 FM IFT 10.7MHz Q=60 MIN SIF020001-0050 1
T002 ANT OSC AM 4-6:10T 1-3:86T SIL013009-0011 1
T101 BIAS COIL 78 KHz SIL016001-0010 1
T103 T104 BIAS COIL 16 KHz SIL016001-0020 2
T003 OSC COIL 108uH (796 KHz) COIL SIL013010-0012 1
T001 OSC FM SUMIDA S-8N SIL013012-0010 1
SHLD CALBE 160mm BLACK 75 OHM VSW243BB2-0160 1
ANT JACK 2P+ANT PLUG BLK-BLK CJA005001-1010 1
C113 COND ELECT 47 uF 16V 20% PVE939540-4700 1
C107 COND ELECT 22 uF 16V 20% PVE939540-2200 1
EF001 TUNER PACK KWANGSUN KST-F404VA2 WTP000011-0001 1
XL151 CRYSTAL 4.332 MHZ HC-49/U JQC013101-4351 1
C104 C106 COND ELECT 33 uF 10V 20% PRE939530-3300 2
C109 C125 C126 C151 COND ELECT 10 uF 16V 20% PRE939540-1000 4
C012 C143 C163 C156 C157 COND ELECT 47 uF 16V 20% PRE939540-4700 5
C139 C140 COND ELECT 4.7 uF 16V 20% PRE939540-4790 2
C118 C123 C127 COND ELECT 1 uF 50V 20% PRE939570-1090 3
C124 COND ELECT 0.47 uF 50V 20% PRE939570-4780 1
C005 COND DISC 5 pF 50V +-0.25pF PRD113870-5090 1
C007 COND DISC 0.1 uF 50V +80-20% PRD339670-1040 1
C015 C101 C164 C167 COND DISC 0.022 uF 50V +80-20% PRD249670-2230 4
Q001 FET 2SK192A-Y/GR RAM200192-1001 1
Q104 Q105 XISTR NPN 2SC945P RAN200945-0001 2
Q101 Q102 XISTR NPN 2SC1675L NEC RAN201675-0001 2
Q103 XISTR PNP 2SA733Q,P NEC RAP200733-0001 1
R105 RESISTOR 100 OHM 1/6W 5% CF QAF065000-1010 1
R155 RESISTOR 1K OHM 1/6W 5% CF QAF065000-1020 1
R007 RESISTOR 100K OHM 1/6W 5% CF QAF065000-1040 1
R005 R104 RESISTOR 330 OHM 1/6W 5% CF QAF065000-3310 2
R110 RESISTOR 47 OHM 1/6W 5% CF QAF065000-4700 1
R123 RESISTOR 4.7K OHM 1/6W 5% CF QAF065000-4720 1
D001 D002 D003 D004 D101 DIODE SW; 1N4148 RAD114148-0010 5
L102 L104 L153 L154 L151 L152 CHOKE 10 uH 10% SAN001600-1000 6
J101 J102 J103 J104 WIRE BARE 22 GA TINNED XJP220000-0001 20
C165 CHIP CAP 1000 pF 50V 5% PYL410370-1020 1
C110 CHIP CAP 200 pF 50V 5% PYL410370-2010 1
C120 C154 C155 C173 C174 CHIP CAP 22 pF 50V 5% PYL410370-2200 5
C111 CHIP CAP 30 pF 50V 5% PYL410370-3000 1
C001 CHIP CAP 33 pF 50V 5% PYL410370-3300 1
C013 CHIP CAP 8 pF 50V 5% PYL410370-8090 1
C003 C009 C010 C105 C116 C122 C133 CHIP CAP 0.022 uF 50V 20% PYL439570-2230 13
C134 C144 C145 C169 C170 C011
C112 C114 C115 CHIP CAP 0.047 uF 50V 20% PYL439570-4730 3
C016 C006 C108 C161 CHIP CAP 0.1 uF 50V 10% PYL456470-1040 4
C135 C136 C119 CHIP CAP 1500 pF 50V 10% PYL456470-1520 3
www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals

C137 C138 CHIP CAP 0.015 uF 50V 10% PYL456470-1530 2
C008 C129 C130 C141 C142 CHIP CAP 0.0022uF 50V 10% PYL456470-2220 5
C131 C132 CHIP CAP 0.0047 uF 50V 10% PYL456470-4720 2
R107 CHIP RES. 10 OHM 1/10W 5% QCF015020-1000 1
R006 R138 CHIP RES. 100 OHM 1/10W 5% QCF015020-1010 2
R004 R009 R116 R125 R157 R135 R136 CHIP RES. 1K OHM 1/10W 5% QCF015020-1020 7
R002 R003 R109 CHIP RES. 100K OHM 1/10W 5% QCF015020-1040 3
R154 R151 CHIP RES. 1M OHM 1/10W 5% QCF015020-1050 2
R117 CHIP RES. 180K OHM 1/10W 5% QCF015020-1840 1
R139 CHIP RES. 220 OHM 1/10W 5% QCF015020-2210 1
R133 R134 CHIP RES. 2.2K OHM 1/10W 5% QCF015020-2220 2
R167 R168 CHIP RES. 22K OHM 1/10W 5% QCF015020-2230 2
R137 CHIP RES. 2.7K OHM 1/10W 5% QCF015020-2720 1
R101 R106 CHIP RES. 270K OHM 1/10W 5% QCF015020-2740 2
R124 CHIP RES. 3K OHM 1/10W 5% QCF015020-3020 1
R103 R114 CHIP RES. 330 OHM 1/10W 5% QCF015020-3310 2
R112 R115 R156 R158 CHIP RES. 3.3K OHM 1/10W 5% QCF015020-3320 4
R122 VR102 CHIP RES. 3.9K OHM 1/10W 5% QCF015020-3920 2
R102 R118 CHIP RES. 47 OHM 1/10W 5% QCF015020-4700 2
R129 R130 R159 R160 R161 R162 R163
R165 R152 R153 CHIP RES. 4.7K OHM 1/10W 5% QCF015020-4720 10
R126 CHIP RES. 47K OHM 1/10W 5% QCF015020-4730 1
R119 CHIP RES. 51 OHM 1/10W 5% QCF015020-5100 1
R001 R131 R132 CHIP RES. 6.8K OHM 1/10W 5% QCF015020-6820 3
IC101 0IC 30 PIN LA1837 SANYO RCI001837-0001 1
IC152 IC 20 PIN LC72131M SANYO RCI072131-0001 1
R108 CHIP RES. 10K OHM 1/10W 5% QCF015020-1030 1
C152 CHIP CAP 560 pF 50V 5% PYL410370-5610 1
IC151 IC 24 PIN LC72720NM RCI072720-0002 1
C153 CHIP CAP 330 pF 50V 5% PYL410370-3310 1
R008 RESISTOR 10 OHM 1/6W 5% CF QAF065000-1000 1
HOLDER FM HOLDER BPH100025-0000 1
SCREW M3.0xL6.0 mm x P0.5 HSP143084-1060 1
CON/WIRE 15P 110mm 2547#28/2468#26 VWA200098-0001 1
PAN HEAD SCREW STEEL T3.5x1.41PxL24 HSP140074-1240 2
SUPPORT ABS PCB SUPPORT TOP BPS101020-0001 2
SUPPORT ABS PCB SUPPORT BTM BPS101021-0001 2
FOOT CHROME 50X9mm BPE100018-0002 2
T=2.0 OD=39.8mm, ID=16.2mm BRB200002-0001 2
SCREW M3.0x4 NICKLE HSP143084-1040 2
TUBING SRK DIA=8 L=20 mm BLACK DTB008000-0200 2
CON/WIRE 4P 120mm 1617#18x2P VWA310013-0011 1
BEAD FERIT DIA25x15x10 mm SFB001001-0200 4
CON/WIRE 4P 220mm 1007#22 RD-BK-BK-YL VWA330040-0001 1
ATAPI CABL 40P 220mm 2551#28 VWA410001-0011 1
ROCKER SWITCH(TV-2) W/O MARK MSW008003-0020 1
BRACKET SECC T=0.8mm GSE200035-0001 1
FLAT HEAD SCREW STEEL M3x0.5PxL12 HSF143084-1120 4
SCREW T3xL16xP1.06mm HSP140054-1160 2
www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals

LED PCB ASSY APE200330-0001 1
CP2 CON/WIRE 4P 140mm UL2468#26 BLK A=2.0mm VFL41124B-1400 1
D211 D212 D213 D214 D215 D217 D218 CHIP LED WHITE SMD0805 KCD900805-0010 7
R235 R236 R237 R238 R239 R240 R241 CHIP RES. 75 OHM 1/10W 5% QCF015020-7500 7
SCREW STEEL SCREW M3xP0.5xL6mm FLAT HEAD HSF143084-1060 5
NUT M3.0xOD5.5xT2.5mm HNT130550-1230 1
Head unit - Packing
Installation Point Description Material No. Qty.
POLY BAG L80xW220mm IVA000001-0019 1
POLY BAG L610xW540mm IVA000001-0061 1
SOLDER LUG/WIRE180mm UL1007#22 BLK CSL507035-0200 1
SPONGE L25xW15xT21mm FIREPROOF IVE110002-0001 1
SPONGE L10 X W10 X T13.5mm IVE200009-0001 1
SPONGE L20xW10xT0.5mm IVE100157-0001 2
SCREW M3x10x0.5P HST143084-1100 1
WASHER FIB OD8.0xID3.5xT1.0 mm HWF118035-6100 1
PLYFOAM BOTTON ITF200012-0001 1
PLYFOAM TOP ITF200013-0001 1
MASTER CARTON ICC200004-0001 1
OWNER'S MANUAL YOM200001-0001 1
Satellites speake
r
Installation Point Description Material No. Qty.
SATE. SPK ASSY JBL AFK200002-0001 1
SPK REAR ABS BLK BPA400004-0101 4
SPK FRONT ABS BLK BPF405003-0101 4
LOGO PLATE L12xW10xT2mm BPL400003-0102 4
RUBBER FOOT OD12.5xID6xT2.5mm BRF400005-0001 8
RUBBER FOOT OD12.5xID6.2xT6.8mm BRF400006-0001 4
SPK GRILLE L80xW100xT0.6mm GSP400002-0102 4
ACCOUSTIC L80xW80xT30mm FIBER W/UL IVM000002-0004 4
SPK DRIVER D22.4mm 30W TWEETER FSA243010-1801 4
SPK DRIVER 70x70mm 4OHM 30W FOR SATE. FSA213012-1401 4
PROTECT PCB ASSY FOR REAR/SATE. APE200040-0001 4
R1 RESISTOR#6 OHM 10W 5% HI QVEA05000-6090 4
R2 RESISTOR ESC360 QVE505000-1890 4
C1 COND ELECT 100 uF 50V 20% NON-POLAR PRE399570-1010 4
C2 COND ELEC 1.5uF 100V VON-POLAR 5% BP PRE3993A0-1590 4
RB3 SPK WIRE 100mm 2P 2468#22 RD-BLK VWS331000-0100 4
PTC1 PTC 0.5Ax60x050 MEXICO RPT005001-0020 4
RB1 CON/WIRE AY 2P 130mm 2468#20 RD-BK VWA350013-0001 4
RB2 TEM WIRE 130mm 2468#20 RD-BLK A+6.4/-3.7 VWT130431-0130 4
SCREW T3.0xL8xP1.06mm HSP140054-1080 8
SCREW T3.5xL8xP1.41mm HSF140074-3120 8
SCREW T3.5xP1.41x16mm HSP140071-3160 16
ACOUSTIC ABSORB L80xW80xT10 FIBER WHT IVM110001-0001 4
Center spaeke
r
Installation Point Description Material No. Qty.
CENTER SPK ASSY JBL AFK200003-0001 1
SPK REAR ;ABS BLK (JBL) BPA400007-0101 1
www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals

SPK FRONT ABS BLK BPF405006-0101 1
LOGO PLATE L12xW10xT2mm BPL400003-0102 1
RUBBER FOOT OD12.5xID6xT2.5mm BRF400005-0001 1
RUBBER FOOT OD12.5xID6.2xT6.8mm BRF400006-0001 1
SPK DRIVER D22.4mm 30W TWEETER FSA243010-1801 1
SPK DRIVER 70x70mm 8OHM 30W FOR CENTER FSA213012-1801 2
SPK GRILLE L187xW74xH13.5mm GSP400008-0101 1
PROTECT PCB ASSY FOR CENTER APE200080-0001 1
PROTECT PCB CEM-1 45x 40mm LCG200080-0401 1
C1 COND ELECT 100 uF 50V 20% NON-POLAR PRE399570-1010 1
C2 COND ELEC 1.5uF 100V VON-POLAR 5% BP PRE3993A0-1590 1
R1 R1A RESISTOR ESC360 QVE505000-1200 2
PTC1 PTC 0.5Ax72x050 MEXICO RPT005001-0010 1
RB3 SPK WIRE 80mm RD-BLK 2468#22 VWS331000-0080 1
RI1 CON/WIRE AY 2P 130mm 2468#20 RD-BK VWA350013-0001 1
RO1 RO2 TEM.WIRE 2P 140mm 2468#20 RD-BLK JBL VWT130431-0140 2
R2 WIRE BARE 22 GA TINNED XJP220000-0001 1
SCREW T3.0xL8xP1.06mm HSP140054-1080 2
SCREW T3.5xP1.41x16mm HSP140071-3160 8
ACOUSTIC ABSORB L80xW80xT10 FIBER WHT IVM110001-0001 2
Speaker accessories
Installation Point Description Material No. Qty.
WALL BRACKET BPH200003-0001 4
BRACKET BPH200004-0001 4
WIRE ASSY L=12240mm BLK P=5mm VWP010003-0040 1
D-SUB 15P CABLE 4000mm BLK VWP000010-0010 1
WIRE ASSY L=3040mm BLK P=5mm VWP010003-0030 1
POLY BAG L260xW180mm PO IVA000001-0134 5
RUBBER FOOT NR3 BLACK 13.5xT2.0mm W/ADHE BRF200001-0001 2
POLYFORM BTM FOR SPK ASSY JBL DSC500 ITF130261-0001 1
POLYFORM TOP EPS FOR SPK ASSY JBL DSC500 ITF130260-0001 1
SILICA GEL 3 g DOT040001-0003 2
POLY BAG L300x W180xT0.03mm W/RECYCLE IVA102014-0010 1
POLY BAG L240xW180mmxT0.03mm W/RECYCLE IVA000001-0088 5
POLY BAG L100xW130xT0.03mm W/RECYCLE IVA102015-0010 17
SCART CABL SC/G-SC/G,1000mm VSC000002-0010 1
SPEAKER LABEL L40xW10mm 135SISSAT YLB106003-0001 4
CERTRE SPK LABEL L40mmxW10mm 500CC YLB106003-0002 1
SUB - main board
Installation Point Description Material No. Qty.
MAIN PCB ASSY APE200051-0001 1
J14 CONNECTOR B7B-XH-A 7 PIN CCN250000-0107 1
J15 CONNECTOR B3B-XH-A 3 PIN CCN250000-0103 1
J20 CONNECTOR 4 PIN CL3962WVO CCN396020-0104 1
J21 ON/WIRE 6P 500mm 1007#18W/BEA VWA310006-0007 1
J12 CON/WIRE 13P 500mm 1007#26FLAT VWA200097-0002 1
U1 U2 U5 IC 11 PIN LM3886T RHI003886-0001 3
IC8 IC 8 PIN JRC4558D JRC RHI004558-0001 1
SOLDR WIRE TIN 60/40% D1.2mm XSD106040-1200 1
www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals

THINER FLX UNION SOLTEK T22 XTN000022-0001 1
RL1 RL2 RL5 INDUCTOR 0.4uH 1 OHM 2W 5% SHN002501-4080 3
JP13 CON/WIRE 6P 100/80/120 1533#28 VWA020011-0001 1
JP7 CON/WIRE 2P 150mm 26AWG VFL21131B-1500 1
JP8 CON/WIRE 2P 500mm BLK VFL21131B-5000 1
C153 C253 C553 COND DISC 560 pF 50V 10% PRD235470-5610 3
C192 C292 C293 C592 C593 C193 COND DISC 0.1 uF 50V +80-20% PRD339670-1040 6
C151 C251 C31 C551 COND MYLAR 0.1 uF 100V 5% PRM0373A0-1040 4
QA01 QA02 XISTR NPN 2SC945P RAN200945-0001 2
Q4 XISTR NPN 2SC2001L NEC RAN202001-0001 1
Q5 Q6 XISTR NPN 2SC2878-A (TE2,.M) RAN202878-0001 2
Q3 XISTR PNP 2SA733Q,P NEC RAP200733-0001 1
CA02 COND ELECT 10uF 16V 20% PRE039540-1000 1
C1 C10 C11 C12 C2 C3 C4 C5 C6 C7 C8 C9 COND ELECT 100uF 25V 20% PRE039550-1010 12
C601 COND ELECT 47uF 25V 20% PRE039550-4700 1
C190 C191 C290 C590 C591 C291 COND ELECT 100uF 50V 20% PRE039570-1010 6
C101 C112 C201 C212
C301 C312 C401 C412 C501 C512 COND ELECT 1uF 50V 20% PRE039570-1090 10
C609 COND ELECT 2.2 uF 50V 20% PRE039570-2290 1
CA04 COND ELECT 4.7 uF 50V 20% PRE039570-4790 1
CA03 COND ELECT 10 uF 16V 20% PRE339540-1000 1
R155 R255 R555 RESISTOR 4.7 OHM 1/2W 5% CF QAF025000-4790 3
R1 R10 R11 R12 R2 R3 R4 R5 R6 R7 R8 R9 RESISTOR 100 OHM 1/6W 5% CF QAF065000-1010 12
R152 R154 R252 R254 R552 R554 RESISTOR 1K OHM 1/6W 5% CF QAF065000-1020 6
R151 R251 R551 RESISTOR 10K OHM 1/6W 5% CF QAF065000-1030 3
R33 RESISTOR 100K OHM 1/6W 5% CF QAF065000-1040 1
R153 R253 R553 RESISTOR 20K OHM 1/6W 5% CF QAF065000-2030 3
R34 RESISTOR 2.2K OHM 1/6W 5% CF QAF065000-2220 1
R35 RESISTOR 22K OHM 1/6W 5% CF QAF065000-2230 1
R30 R32 RESISTOR 270K OHM 1/6W 5% CF QAF065000-2740 2
R36 RESISTOR 470K OHM 1/6W 5% CF QAF065000-4740 1
R31 RESISTOR 5.6K OHM 1/6W 5% CF QAF065000-5620 1
D4 DIODE SW; 1N4148 RAD114148-0010 1
WIRE BARE 22 GA TINNED XJP220000-0001 57
C610 CHIP CAP 47 pF 50V 5% PYL410370-4700 1
C608 CHIP CAP 0.022 uF 50V 5% PYL456370-2230 1
R607 RA02 RA03 CHIP RES. 1K OHM 1/10W 5% QCF015020-1020 3
R100 R103 R200 R203 CHIP RES. 10K OHM 1/10W 5% QCF015020-1030 52
RA08 CHIP RES. 1M OHM 1/10W 5% QCF015020-1050 1
R102 R202 R302 R402 R502 CHIP RES. 5.6K OHM 1/10W 5% QCF015020-5620 5
RA05 CHIP RES. 2.2K OHM 1/10W 5% QCF015020-2220 1
R603 R604 R610 RA04 CHIP RES. 22K OHM 1/10W 5% QCF015020-2230 4
R101 R201 R301 R401 R501 R601 CHIP RES. 27K OHM 1/10W 5% QCF015020-2730 6
R611 CHIP RES. 36K OHM 1/10W 5% QCF015020-3630 1
RA01 R113 R213 R313 R413 R513 R612 CHIP RES. 3.9K OHM 1/10W 5% QCF015020-3920 7
RA10 CHIP RES. 470K OHM 1/10W 5% QCF015020-4740 1
RA07 CHIP RES. 56K OHM 1/10W 5% QCF015020-5630 1
R123 R122 R121 R120 CHIP RES. 6.8K OHM 1/10W 5% QCF015020-6820 29
R606 CHIP RES. 68K OHM 1/10W 5% QCF015020-6830 1
www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals

R605 CHIP RES. 8.2K OHM 1/10W 5% QCF015020-8220 1
DA01 DA02 CHIP DIODE LL4148 TELEFUNKEN RCD104148-0010 2
IC1 IC2 IC3 IC4 IC5 IC6 IC 14 PIN TL074CD RCI000740-0001 6
IC101 IC201 IC301 IC401 IC501 IC601 IC7B IC 8 PIN TL072CD RCI000720-0001 7
CA05 CHIP CAP 1000 pF 50V 5% PYL410370-1020 1
C103 C203 C303 C403
C503 C120 C220 C320 C420 C520 C620 CHIP CAP 220 pF 50V 5% PYL410370-2210 11
C15 C16 C17 C18 C19 CHIP CAP 0.1 uF 50V 5% PYL456370-1040 38
C602 C603 CHIP CAP 0.018 uF 50V 10% PYL456470-1830 2
C607 CHIP CAP 0.068 uF 50V 10% PYL456470-6830 1
R106 R107 R206 R207 R307 R406
R407 R506 R507 R603A R604A R605A C502
C102 C202 C302 C402 R306 CHIP RES. 0 OHM JUMP WIRE QCF015020-0000 18
C604 CHIP CAP 0.027 uF 50V 5% PYL456370-2730 1
R104 R304 R404 R504 R204 CHIP RES. 12K OHM 1/10W 5% QCF015020-1230 5
C110 C210 C310 C410 C510 C111 C211
C311 C411 C511 CHIP CAP 0.0022 uF 50V 5% PYL456370-2220 10
R111 R211 R311 R411 R511 R112 R212
R312 R412 R512 CHIP RES. 150K OHM 1/10W 5% QCF015020-1540 10
R114 R314 R414 R514 CHIP RES. 1.2K OHM 1/10W 5% QCF015020-1220 4
R613 CHIP RES. 4.7K OHM 1/10W 5% QCF015020-4720 1
R214 CHIP RES. 750 OHM 1/10W 5% QCF015020-7510 1
R609 CHIP RES. 220K OHM 1/10W 5% QCF015020-2240 1
R602 CHIP RES. 30K OHM 1/10W 5% QCF015020-3030 1
C152 C552 C252 COND ELECT 22 uF 25V 20% PRE039550-2200 3
C32 COND ELECT 22uF 50V 20% PRE039570-2200 1
SUB - Amp board
Installation Point Description Material No. Qty.
AMP PCB ASSY APE200052-0001 1
GSE0215-001 TO PCB SCREW ;T3.0x1.06PxL6mm HSW050054-3060 4
J10 CONNECTOR B2B-XH-A 2 PIN CCN250000-0102 1
J7 CONNECTOR 2 PIN LEOCO 3951 CCN396020-0102 1
J22 CONNECTOR 6 PIN CL3962WVO CCN396020-0106 1
U3 U4 U6 IC 11 PIN LM3886T RHI003886-0001 3
RL3 RL4 RL6 INDUCTOR 0.4uH 1 OHM 2W 5% SHN002501-4080 3
JP3 JP4 JP6 CON/WIRE 7P 200nn 1533x2&2547 VWA010032-0001 3
C353 C453 C653 COND DISC 560 pF 50V 10% PRD235470-5610 3
C392 C393 C492 C493 C692 C693 COND DISC 0.1 uF 50V +80-20% PRD339670-1040 6
C390 C391 C490 C491 C690 C691 COND ELECT 100uF 50V 20% PRE039570-1010 6
C352 C452 C652 COND ELECT 22 uF 25V 20% PRE039550-2200 3
C351 C451 C651 COND MYLAR 0.1 uF 100V 5% PRM0373A0-1040 3
R455 R655 R355 RESISTOR 4.7 OHM 1/2W 5% CF QAF025000-4790 3
R352 R354 R452 R454 R652 R654 RESISTOR 1K OHM 1/6W 5% CF QAF065000-1020 6
R351 R451 R651 RESISTOR 10K OHM 1/6W 5% CF QAF065000-1030 3
R453 R353 R653 RESISTOR 20K OHM 1/6W 5% CF QAF065000-2030 3
JW40 JW41 JW42 JW43 JW44 JW45
JW46 JW47 JW48 WIRE BARE 22 GA TINNED XJP220000-0001 9
HEAT SINK AL ANODIZING GAL200014-0001 1
SUB - Jack board (input board)
www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals

Installation Point Description Material No. Qty.
JACK PCB ASSY APE200053-0001 1
L501 L502 L503 L504 L505 RF COIL 1 uH MDEC T40818-08 SIL001003-1090 5
JK501 TERMINAL IACK ASSY 5 SLOT ABS BLK COT080005-0001 1
JP16 TO J93 FLAT CABLE 3P 100mm 2468#26 A=2.5mm VFL31131B-1000 1
CN401B D-SUB JACK 15P D-SUB 90* CGIC RC CJF015001-2002 1
C515 C516 C517 C518 C519 COND DISC 1000 pF 50V 10% PRD235470-1020 5
J23 CON/WIRE 4P 450mm 1007#18/BEA VWA310006-0003 1
JP23 CONNECTOR 4 PIN CL3962WVO CCN396020-0104 1
JP21 CONNECTOR 6 PIN CL3962WVO CCN396020-0106 1
CON2 CONNECTOR 13 PIN PITCH=2.0mm CCN200000-0113 1
WIRE BARE 22 GA TINNED XJP220000-0001 1
FUSE 4A 250V SLOW (WALTER TSD) KSA020400-0121 1
SUB - Control board
Installation Point Description Material No. Qty.
CNTL LED PCB ASSY APE200054-0001 1
LD1 LED 2.94DIA BLUE ROUND 2P P=2.54mm KED600003-0040 1
LED TO FRONT CAB LED HOLDER 2P H5.0xOD4.2mm LED3-5 DLH010007-0005 1
JP30 CON/WIRE 2 P 500mm P=2.0 BLK VFL21124B-5000 1
CHIP CAP 0.1 uF 50V 10% PXL456470-1040 1
SUB - mechanics parts
Installation Point Description Material No. Qty.
MICA SHEET;L22xW26xT0.1mm HIM000001-0007 6
SI RUBBER W13xH18xT0.3 mm HIS000001-0001 2
FOOT METALLIC GREY-SILVER BPE400005-0102 4
FRONT PORT METALLIC GREY-SILVER BPR410009-0101 1
RUBBER FOOT NR3 BLACK 13.5xT2.0mm W/ADHE BRF200001-0001 8
SILICA GEL 3 g DOT040001-0003 2
Woofer SPK DRIVER 60W 4 OHM FSA026080-0402 1
SONW PAD L340x W148 xH55mm EPS ICF000058-0005 2
SPONGE L7xW5xT7mm BLACK IVE000032-0007 1
DRIVER SPONGE OD210xID184xT1.0mm IVE000041-0001 1
SPONGE OD97xID67xT5mm BLK EVA IVE000246-0004 1
SPONGE L190 xW15xT1mm BLK IVE000246-0006 1
SOFT SHEET L100xW80mm IVH002001-0006 1
SUB - Power board (power supply 2/3)
Installation Point Description Material No. Qty.
POWER PCB ASSY APE200200-0001 1
DC POWER PCB ASSY APE200201-0001 1
F1 F2 FUSE 4A 250V SLOW (WALTER TSD) KSA020400-0121 2
F3 F4 FUSE 8A 250V SLOW KSA020800-0130 2
F5 F6 FUSE 1A 250V SLOW (WALTER TSD) KSA020100-0120 2
J95 CONNECTOR 3 PIN CL3962WVO CCN396020-0103 1
J96 J97 CONNECTOR 6 PIN CL3962WVO CCN396020-0106 2
J25 CONNECTOR 2 PIN PITCH=2.0mm CCN200000-0102 1
www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals

F1 F2 F3 F4 F5 F6 FUSE CLIP DIA5xL20mm FUSE CFC011000-1001 6
D1 D2 SLEEVING OD3xID2.5xL10mm DSL001001-0100 2
C17 C18 COND ELECT 2200 uF 35V 20% PVE039560-2220 2
C13 C14 COND ELECT 3300 uF 50V 20% PVE039570-3320 2
C15 C16 COND ELECT 4700 uF 50V 20% PVE039570-4720 2
CON/WIRE 3P 300mm 2877#26 BLK VFL31131B-3000 1
CON/WIRE 4P 300mm 1015#18 VWA310007-0001 1
U1 IC 3 PIN 7815 15V 1A RHI007815-0001 1
U2 IC 3 PIN AN7915T SAMSUNG RHI007915-0001 1
D2 BRIDGE KBU808 8A 800V UL RHD208080-0010 1
D1 BRIDGE RECTIFIER;RS402L 4A 100V UL RHD204010-0010 1
D3 BRIDGE RS202L 2A 100V UL RHD202010-0010 1
C19 COND DISC 0.22 uF 50V +80-20% PRD249670-2240 1
C1 C10 C11 C12 C2 C20
C3 C4 C5 C6 C7 C8 C9 COND DISC 0.1 uF 50V +80-20% PRD249670-1040 13
C22 COND ELECT 1uF 50V 20% PRE039570-1090 1
C21 COND ELECT 2.2 uF 50V 20% PRE039570-2290 1
JW90 JW91 JW92 JW93 JW94 JW95
JW96 JW97 JW98 WIRE BARE 22 GA TINNED XJP220000-0001 9
R3 RESISTOR 22K OHM 1/4W 5% CF QAF045000-2230 1
D4 DIODE;RECTIFIER 1N4001 RAD114001-0010 1
SUB - AC Power board (power supply 1/3)
Installation Point Description Material No. Qty.
AC POWER PCB ASSY APE200202-0001 1
J94 CONNECTOR B2B-XH-A 2 PIN CCN250000-0102 1
J93 CONNECTOR B3B-XH-A 3 PIN CCN250000-0103 1
J91 J92 CONNECTOR 4 PIN CL3962WVO CCN396022-0104 2
CX1 COND SAFTY 0.01uF 250V 20% PLY2705F0-1030 1
K1 RELAY 6V 250V AC/5A MRL006001-0010 1
C25 COND DISC 0.1 uF 50V +80-20% PRD249670-1040 1
R1 RESISTOR 10K OHM 1/6W 5% CF QAF065000-1030 1
R2 RESISTOR 18 OHM 1/6W 5% CF QAF065000-1800 1
WIRE TIE GT-90M 90mm DWT000001-0900 1
PCB BRACKET-R SECC GSE000253-0001 1
PCB BRACKET-L SECC GSE000254-0001 1
FUSE HOLDR FUSE HOLDER FH-B02 CFC021001-1001 1
SLEEVING OD2xID1xL18mm DSL001002-0180 2
BUSHING AC LINE BUSHING DBU001001-0010 1
TUBING; DIA=4 L=20mm BLACK DTB004000-0200 2
LINE CORD 2P 1980mm BLK VDE VPE003012-0020 1
PCB CVR F ABS BPA400010-0101 1
PCB CVR B ABS BPA400011-0101 1
WIRE TIE GT-90M 90mm DWT000001-0900 4
JACK PLATE SECC 218 x 98x3mm GSE400074-0102 1
EVA SPONGE L192xW49.6 xT1mmBLK IVE000246-0001 1
SCREW T3.0xL10xP1.06mm HSP140054-3100 17
EVA SPONGE L192xW34xT1mm BLK IVE000246-0002 2
SPONGE L216xW97.5xT2mmBLK IVE000246-0005 1
www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals

BEAD FERIT OD25.0xID15xH12.0 SFB001001-0060 1
CON/WIRE 4P 120mm 1617#18x2P VWA310013-0011 1
SPONGE L100xW30xT2mm IVE000085-0001 1
GSB BKT R SECC T=1.0mm GSE200010-0001 1
PCB BKT L SECC T=1.0mm GSE200011-0001 1
AC CONNTOR AC CONNTECOR (HW-C3) (J3615) COT010002-0001 1
POWER TRANSFORMER 230V EI-105 TTL023010-0050 1
CON/WIRE 6P 250mm 1015#18 VWA310002-0008 1
CON/WIRE AY 2 COND 430mm VWT503221-0430 1
FUSE 4A 250V SLOW (WALTER TSD) KSA020400-0121 1
SCREW M4.0xP0.7xL20 mm HSD143103-3200 4
WASHER OD8.5xID4.3xT0.6 mm HWT168543-1060 4
WASHER OD16 ID4.5 T1.0 HWS11G045-1100 4
NUT M4.0xOD7.0xT3.0mm HNT140700-1300 4
SCREW T4xL20xP1.59mm HSP140091-3200 16
SCREW T3.0xL8xP1.06mm HSW140054-3080 18
WASHER OD14xID3.2xT1.0mm HWS11E032-4100 1
SCREW TRUSS HEAD TYPE ABT3.0XP1.06XL20mm HST140051-3200 4
SCREW T4.0x1.59PxL16mm HSP140091-3160 8
PORT EDGE ABS W/SPRAY MA4810 BPR000020-0001 1
SCREW T3.5xP1.41x14mm HST140071-3140 8
TUBE SHKNG DIA=20 L=50 T=0.4 UL DTB020000-0500 1
TUBE SHKNG DIA=12 L=60mm BLACK DTB012000-0600 1
RUBBER PAD DIA14.5mm ICH080007-0001 4
WASHER OD6xID3xH2.5mm 602S-V0 DHU201001-0001 7
SUB - accessories
Installation Point Description Material No. Qty.
D-SUB 15P CABLE 4000mm BLK VWP000010-0010 1
SOFT BAG L550xW150xT0.5mm IVY001012-0001 1
SOFT SHEET L100xW80mm IVH002001-0006 1
POLY BAG L240xW355mm IVA000001-0048 1
POLY BAG L80xW220mm IVA000001-0019 1
POLY BAG L600xW850xD100mm IVA000001-0026 1
POLY BAG L240xW180mmxT0.03mm W/RECYCLE IVA000001-0088 1
POLY FOAM FOR SUBWOOFER ITF200021-0001 2
BATTERY D10x44mm UM-4 1.5V FBY006415-0003 2
ANT ASS'Y INCL.VTA9300-009&021 ASL100034-0003 1
LOOP ANT SHINTA PS-100 VTA100001-0020 1
FM ANTENNA 1500 mm 75 OHM MALE VTA400001-0030 1
ZONE LABEL L12xW12mm (EARTH 2) YLB424013-0001 3
SAFETY MANUAL L210xH297mm YOM100183-1001 1
SCREW T3.0xP1.06x8mm HST140054-3080 8
SPONGE L120xW80xT2.0mm IVE100270-0003 1
Remote control
Installation Point Description Material No. Qty.
X'MITT ASSY 50 KEY AIR250001-4301 1
FRONT PANEL ABS R/C BPI200001-0001 1
BACK CAB. FOR R/C ABS BPI200002-0001 1
BATTERY COVER BPI200003-0001 1
www.freeservicemanuals.info
11/11/2012
www.nostatech.nl
World of free manuals