Johns Manvillle GoBoard Point Drain User manual

Preassembled
Preassembled
to drain cover
C
F
A
B
G
D
EJ
I
H
x4 K
x2
Caulk Gun
3/16"
V-Notch
Utility Knife
Pencil
Tape Measure
1/4" x 1/4"
Square -Notch
1/2" Drill Bit
(if using Jig Saw)
Thin Set mixing tools are also needed
Drywall T-Square
Rubber Mallet
Straight Edge
(for cutting diagnals)
Speed Square
Level
5 Gallon Bucket
5” Hole Saw or Jig Saw
#2 Phillips Bit
Cordless or
Corded Drill
Inside Pipe Cutter
(if needed)
90˚ Putty Knife, Drywall Tool
Parts and Hardware Included in Kit
Recommended Tools
Materials Needed Sold Separately: 4–GoBoard®Wedges, 1/2"GoBoard®Panels, GoBoard®Curb
(3.5"H x 2.5"W x 48"L), GoBoard®Sealant, GoBoard®Fasteners or GoBoard®Washers, thin set mortar and PVC
primer and solvent cement.
Installation Instructions
A. Drain Cover*
B. Drain Riser
C. Clamping Collar
D. Membrane
E. PVC Drain Body**
F. Clamping Collar Screws
G. Mixing Valve Seal
H. Waterproof Pipe Seal
I. 2"Plastic Putty Knife
J. 4"Round Tape Dot
K. Drain Cover Screws
* Most conventional drain covers fit drain riser (snap on and screw on). Custom holes can be drilled in riser if needed for installation.
**The drain body accepts both threaded and unthreaded drain risers from other manufacturers that are approximately 2” inside diameter.
©2019 Johns Manville. All Rights Reserved

Site Preparation (1/2"or 5/8"GoBoard Purchased Separately)
Drain Assembly Installation
1
3
1 5/8"1 5/8"
2
5 "5 "
Fast Installation
Ultra-lightweight
Easy to cut, handle & install
Waterproof built-in*
• Install 1/2"(or 5/8") GoBoard to wall studs using
GoBoard Fasteners spaced every 8"or GoBoard
Washers spaced every 12"while leaving 1/8"gaps
between subfloor and bottom edge of GoBoard and
all board joints. Fill all gaps with GoBoard Sealant
and spread excess sealant with a putty knife at least
1"from either side of joint. For the joint near subfloor,
spread sealant roughly 2"up from subfloor. For detailed
instructions, visit https://www.jm.com/content/dam/jm/
global/en/tile-backer-boards/GB-001%20GoBoard%20
Installation%20Instructions.pdf.
* Only board joints and fastener locations require a
waterproof sealant.
Make sure floor is level (floor must be level for proper
installation). Find the center of the shower pan area (or as
close to center as framing allows). Please review page 10 for
possible layouts.
Top of waste pipe MUST be at least 1 5/8"below the top of the
subfloor. For remodels, cut existing waste pipe as needed with
inside pipe cutting tool.
Using measurements from the previous step, mark the center of
the drain hole. Cut a 5"diameter hole with jig-saw, hole saw or
other means. For remodels, ensure existing drain location fits
within the layouts and dimensions outlined on page 10 and 12.
Important Information
• Make sure the waste pipe cannot be pushed
downward during GoBoard Point Drain assembly
installation. There are numerous methods to
secure the waste pipe, but the easiest method
is to place blocking underneath the drain pipe to
achieve correct distance from subfloor.
©2019 Johns Manville. All Rights Reserved2

©2019 Johns Manville. All Rights Reserved 3
Drain Assembly Installation (continued)
Valve Seal and Pipe Collar Installation
2
1
1
1
1
1
5
D
D
J
Waste Pipe
Fins
1/4”
7
D
2
2
1
1
4
1
6
2
F
8
H
G
1
1
2
2
Fold corners of membrane (D) inward so that screw holes are
readily accessible. Add tape dot (J).
Remove tape dot (J) and unfold membrane (D) to view waste
pipe inside GoBoard Point Drain body. The waste pipe should be
within 1/4” or less from fins to ensure a secure and water tight
connection.
Install valve seal (G) over valve and waterproof pipe seal (H) over
shower pipe using GoBoard Sealant.
Fold front and back and then left and right of membrane (D) inward.
Install GoBoard Point Drain assembly and fasten to subfloor using
provided screws (F). Use PVC primer and solvent cement to glue
waste pipe and GoBoard Point Drain. If using ABS waste pipe
consult plumber.

GoBoard Curb Installation (Purchased Separately)
9
J
D
©2019 Johns Manville. All Rights Reserved4
Measure the distance between the left and right walls. Ensure
there is a 1/8” gap between curb and side of walls and each
curb section if distance is greater than 48”. Cut curb section to
correct length.
Refold membrane (D) and secure corners with tape dot (J) see
steps 5 and 6) so that edge of clamping collar is exposed.
In curb location, apply two 1/4” beads of GoBoard Sealant.
Apply several 1/4” beads on curb (both sections if more than 1 curb
required) surfaces in contact with subfloor and walls. Spread excess
GoBoard Sealant onto subfloor and curb on shower side. Remove
excess sealant on bathroom side of curb.
Optional – Secure curb to subfloor with 4 1/2” screws (1 per linear
foot) to prevent accidental curb movement during remaining steps.
Apply GoBoard Sealant over lag screw locations to ensure a water-
tight installation.
1/8”
1/8”
10
1/8”
Curbs larger
than 48”
11
12
22
1
OptionalOptional

©2019 Johns Manville. All Rights Reserved 5
GoBoard Wedge Installation
14
Front Wedge PanelFront Wedge Panel
Back Wedge Panel
Back Wedge Panel
13
Front Wedge PanelFront Wedge Panel
Back Wedge Panel
Back Wedge Panel
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warrantyinformation
VisitJM.com/GoBoardfor installation instructions
®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warrantyinformation
VisitJM.com/GoBoardfor installation instructions
®®
2015121910171
®
15
Johns Manville
Building Insulation Division
1-800-654-3103, www.JM.com/GoBoard
4-ft x 8-ft Durable, lightweight, waterproof tile backer board
Limited Warranty- Visit JM.com/GoBoard for warranty information
1/8"1/8"
1/8"1/8"
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warrantyinformation
VisitJM.com/GoBoardfor installation instructions
®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warrantyinformation
VisitJM.com/GoBoardfor installation instructions
®®
2015121910171
®
16
Transfer measurements (for back and front wedge panels) from
step 14. Cut wedge panels into rectangles (discard remainder).
Note: Thinner side of wedge panel should always face the drain.
Use straight edge for cut.
Place wedge panels (front and back) into shower pan area.
Ensure that there is a 1/8” gap at clamping collar and side walls.
Note: Thinner side of wedge panel should always face the drain.
Locate the drain center and mark 45˚ angles on left and right
wedge panels as shown (use corners of clamping collar as
reference points to draw cut lines).
IMPORTANT: DO NOT mark angles from corners of shower
pan area. Angles MUST be 45 degrees from center of drain
location.
Measure distance between side walls, back wall and clamping
collar for back panel and between side walls, curb and clamping
collar for front panel. Account for 1/8” gap when measuring and
cutting.

GoBoard Wedge Installation (continued)
17
©2019 Johns Manville. All Rights Reserved6
Measure distance between side walls, back wall, curb and
clamping collar curb for left and right wedge panels.
Place wedge panels (left and right) into shower pan area.
Note: Thinner side of wedge panel should always face the drain.
Place cut front and back wedge panels back in shower pan area
on top of uncut left and right wedge panels.
Note: Thinner side of wedge panel should always face the drain.
After removing wedge panels from shower pan area, cut along marks
on front and rear wedge panels. Dry fit panels to ensure that there is
a 1/8” gap at clamping collar, side walls and curb.
Trim wedge panels as needed to maintain 1/8” gaps.
Note: Use straight edge for cut (always cut to inside of mark 1/16”).
Transfer measurements (for left and right wedge panels) from
step 19. Cut wedge panels into rectangles discard remainder.
Note: Thinner side of wedge panel should always face the drain.
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®®
®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warrantyinformation
VisitJM.com/GoBoardfor installation instructions
®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®
2015121910171
®
18
Right
Wedge Panel
Right
Wedge Panel
Left
Wedge Panel
Left
Wedge Panel
19
Left
Wedge Panel
Left
Wedge Panel
Right
Wedge Panel
Right
Wedge Panel
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard forwarrantyinformation
VisitJM.com/GoBoardfor installation instructions
®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®
2015121910171
®
®
21
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®
2015121910171
®
®
20
Johns Manville
Building Insulation Division
1-800-654-3103, www.JM.com/GoBoard
4-ft x 8-ft Durable, lightweight, waterproof tile backer board
Limited Warranty- Visit JM.com/GoBoard for warranty information
1/8"1/8"
1/8"1/8"

©2019 Johns Manville. All Rights Reserved 7
GoBoard Wedge Installation (continued)
®
23
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warrantyinformation
VisitJM.com/GoBoardfor installation instructions
®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warrantyinformation
VisitJM.com/GoBoardfor installation instructions
®®
2015121910171
®
®
22
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warrantyinformation
VisitJM.com/GoBoardfor installation instructions
®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®
2015121910171
®
®
Johns
Manville
Building
InsulationDivision
71717thStreet
D
enver,CO80202
1-800-654-3103,
www.JM.com/Go
Board
8-ftx 8 ft durable, lightweght, warterproof backer board
LimitedWarranty–Visit JM.com/GoBoard for warranty information
®
24
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warrantyinformation
VisitJM.com/GoBoardfor installation instructions
®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®
2015121910171
®
25
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard forwarrantyinformation
VisitJM.com/GoBoardfor installation instructions
®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard forwarrantyinformation
VisitJM.com/GoBoardfor installation instructions
®
2015121910171
®
®
Johns
Manville
BuildingInsulationDivision
71717thStreet
D
enver,CO80202
1-800-654-3103,
www.JM.com/GoB
oard
8-ftx 8 ft durable, lightweght, warterproof backer board
LimitedWarranty–Visit JM.com/GoBoard for warranty information
®
26
After removing all wedge panels from shower pan, cut along marks
to final size. Ensure there is a 1/8” gap at clamping collar, outside
walls and between wedge panels.
Note: Use straight edge for cut (always cut to inside of mark 1/16”).
Dry fit all four wedge panels to ensure that there is a 1/8” gap
between wedge panels, clamping collar, side walls and curb.
Mix thin set mortar per manufacturers instructions and apply to
subfloor using a 3/16” V-notched trowel. Use a 1/4” x 1/4” square
notch trowel if additional height is needed or rough subfloor.
Install left and right wedge panels by pressing firmly into thin set.
Ensure that there is a 1/8” gap at clamping collar and side walls.
Note: Thicker side of wedge panels to outside of enclosure.
Using front and back panel edges, mark 45 degree angles on left
and right wedge panels.
IMPORTANT: DO NOT mark angles from corners of shower
pan area. Angles MUST be 45 degrees from center of drain
location.

GoBoard Wedge Installation (continued)
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warrantyinformation
VisitJM.com/GoBoardfor installation instructions
®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®
2015121910171
®
27
©2019 Johns Manville. All Rights Reserved8
Install front and back cut wedge panels by pressing firmly into
thin set. Ensure that there is a 1/8” gap at clamping collar, side
walls, curb and wedge panels.
Note: Thinner side of wedge panel should always face the drain.
Fill 1/8” gaps, including between clamping collar and wedge
panels, with sealant and spread excess sealant with a putty knife
at least 1” from either side of 1/8” gaps. For the 90 degree inside
corners, use a 90 degree putty knife to ensure the inside corners
are completely sealed.
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warrantyinformation
VisitJM.com/GoBoardfor installation instructions
®
2015121910171
®
JohnsManville
BuildingInsulationDivision
71717thStreet
Denver,CO80202
1-800-654-3103,www.JM.com/GoBoard
4-ftx8-ft Durable, lightweight, waterproof tile backer board
LimitedWarranty-Visit JM.com/GoBoard for warranty information
VisitJM.com/GoBoardfor installation instructions
®
2015121910171
®
28
1"1"
1"1"
Transition Membrane Installation
29
1"1"
30
After removing tape dot and folding membrane edges up, Apply
a 1/4” bead of GoBoard Sealant on top of clamping collar near
folded membrane, fill remaining gaps between clamping collar
and wedge panels and apply another 1/4” bead of sealant
around the perimeter of the drain base approximately 1” from
clamping collar as shown.
Unfold membrane so it is lying flat over beads of GoBoard Sealant
and wedge panels. Using a putty knife, start spreading sealant
underneath membrane closest to center of drain moving out.
Continue around drain until entire membrane is adhered to
wedge panels with sealant.
Note: Use moderate pressure when smoothing and spreading
sealant under membrane. A continuous layer of sealant MUST
remain underneath membrane.

©2019 Johns Manville. All Rights Reserved 9
Transition Membrane Installation (continued)
32
31
Apply a 1/8” bead of GoBoard Sealant around perimeter of PVC
drain flange and spread with a putty knife. Once sealant skins
over, begin installing tile.
Begin installing tile around drain. Using a rubber mallet, gently
level drain cover with surrounding tile if needed.
Spread excess GoBoard Sealant around perimeter of membrane
as shown in illustration.
Make all necessary preparations for installing tile. Mix thin set
mortar per manufacturers instructions. Using a putty knife, pack
thin set mortar underneath drain cover as shown.
Drain Cover Installation
Install the drain cover assembly into the center of the drain.
The radial fins are designed to accommodate most 2” drain
cover assemblies while allowing for easy removal and
repositioning during tiling. The final height of the drain cover
needs to match the height of the installed tile.
33
34 35

Drain Cover Installation (continued)
©2019 Johns Manville. All Rights Reserved10
36
Set remaining tile. After tile installation is complete, grout
enclosure and grout or caulk around drain riser and cover.
Make sure the drain cover remains removable.
Note: Illustration of complete installation.
Note: Shower pan areas referenced below DO NOT include GoBoard Curb.
Complete.
Recommended Layouts
1. Maximum square shower pan area using 4 – 48” x 48”
GoBoard Wedges.
2. Maximum rectangular shower pan
area using 4 – 48” x 48”
GoBoard Wedges
JohnsManville BuildingInsulation Division 71717th Street
Denver,CO 80202
1-800-654-3103, www.JM.com/GoBoard
8-ft x 8 ft durable, lightweght, warterproof backer board
Limited Warranty–VisitJM.com/GoBoard for warranty information
JohnsManville BuildingInsulation Division 71717th Street
Denver,CO 80202
1-800-654-3103, www.JM.com/GoBoard
8-ft x 8 ft durable, lightweght, warterproof backer board
Limited Warranty–VisitJM.com/GoBoard for warranty information
JohnsManville
BuildingInsulation Division
71717th Street
Denver,CO 80202
1-800-654-3103, www.JM.com/GoBoard
8-ft x 8 ft durable, lightweght, warterproof backer board
Limited Warranty–VisitJM.com/GoBoard for warranty information
JohnsManville
BuildingInsulation Division
71717th Street
Denver,CO 80202
1-800-654-3103, www.JM.com/GoBoard
8-ft x 8 ft durable, lightweght, warterproof backer board
Limited Warranty–VisitJM.com/GoBoard for warranty information
48”48”
48”48”
®
JohnsManville BuildingInsulation Division 71717th Street
Denver,CO 80202
1-800-654-3103, www.JM.com/GoBoard
8-ft x 8 ft durable, lightweght, warterproof backer board
Limited Warranty–VisitJM.com/GoBoard for warranty information
®
JohnsManville BuildingInsulation Division 71717th Street
Denver,CO 80202
1-800-654-3103, www.JM.com/GoBoard
8-ft x 8 ft durable, lightweght, warterproof backer board
Limited Warranty–VisitJM.com/GoBoard for warranty information
JohnsManville
Building
InsulationDivision
71717th
Street
De
nver,CO 80202
1-800-654-3103, www.JM.com/GoBoard
8-ft x 8 ft durable, lightweght, warterproof backer board
Limited Warranty–VisitJM.com/GoBoard for warranty information
JohnsManville
BuildingInsulation Division
71717th Street
Denver,CO 80202
1-800-654-3103, www.JM.com/GoBoard
8-ft x 8 ft durable, lightweght, warterproof backer board
Limited Warranty–VisitJM.com/GoBoard for warranty information
102”102”
48”48”