Kenmore 5303211047 User manual

b d N IAL
Kenmore Dehumidifier
Read this book[ It will tell you how to use and care for...
get the most out of...your dehumidifier.
Part Number 91SD-DOI

Jl/ll I I i i IIII"IL'JL 'l 'll'
PLEASE READ THIS OWNER'S MANOAL BEFORE YOU DO ANYTHING ELSE.
This booklet tells you how to install your dehumidifier, use it and clean it. Treat your new dehumidifier with care.
Use it only to do what home dehumidifiers are designed to don
Contents
Parts and Features... Page
Parts Identification .......................... 2
Features ................................. 3
Before Using Dehumidifier...
Electrical Requirements ............... 3
Grounding Instructions ................... 3
"Don'ts" to Remember ................... 3
Operation...
Installation ........................... 4
Page
Features and How to Use Them ......... 5,6
Care and Upkeep...
Troubleshooting ........................ 7
Cleaning Your Dehumidifier .............. 7
Warranty and Parts Ordering
Information ............. Back Cover
I PARTS AND FEATURES
CONTROLPANEL
I
EVAPORATOR COIL
HUMIDISTAT
WATER BUCKET
FAN _\\
FULL LIGHT
FRONT GRILLE
MODEL AND SERIAL
NUMBER PLATE
(Behind Bucket) \
COPY YOUR MODEL AND SERIAL NUMBERS HERE...
If you need service or call with a question, have
this information ready:
1. Complete Model and Serial Numbers (from the
plate on the rear of the unit, behind the water
bucket,,)
2. Purchase date from the sales slipo
Copy this information in these spaces,, Keep this
book, with warranty and sales slip together in a
handy place.
Model Number
Serial Number
Purchase Date
/,
Phone Numbers: Service Center/Store

FEATURES
Checkthischartfor yourdehumidifierfeatures.
Pintsof water removed each 24 hours*
Full Bucket Signal Light
Automatic ShutOff Switch
Automatic Humidistat
De-icer Control
Fan Control Switch
Removable Water Collection Bucket
*The moisture-removing ability of Sears dehumidifiers is certified in accordance
Standard B-149-1 (AHAM DH-1) at 80°F and 60% relative humidity.
Model Number
5941
40
Yes
Yes
Yes
Yes
Yes
Yes
with American National
iBEFORE USING DEHUMIDIFIER I
F' ELE,€ RICALREQUIREMENTS..........i I ,,, "DON'TS" TO REMEMBER_ I
A ll5-volt (103o5 min., 126.5 max..), 60-hertz,
AC only, 15-ampere fl_sed electrical supply is
needed (use time delay fuse or time delay circuit
breaker)° Use aseparate circuit, serving only this
appliance° Do not use an extension cord_
I" GROUNDING INSTRUCTIONS. .......... 1
OBSERVE ALL LOCAL GOVERNING CODES
AND ORDINANCES
Do not, under any circumstances, remove the
power supply cord ground prong.
For your personal safety, this appliance must be
grounded_ This appliance has apower supply cord
with a 3-prong grounding plug_ To avoid possible
shock hazard, the cord must be plugged into a
mating 3-prong grounding type wall receptacle,
grounded in accordance with the National Electri-
cal Code and local codes and ordinances. If amat-
ing wall outlet is not available, it is your
responsibility and obligation to have aproperly
grounded 3-prong wall receptacle installed by a
qualified electrician_
1,_Don't alter or change the plug on the power
supply cord of your dehumidifier. Changes would
make it unsafe, could cause serious damage to the
dehumidifier, and might void the warranty,
3-PRONG
GROUNDING TYPE
WALL RECEPTACLE
/3_PRONG
GROUNDING PLUG
POWER SU PPLY
CORD
2o Don't try to use this dehumidifier on direct cur-
rent (D.C_)o Make sure the receptacle is wired to
a60 hertz alternating current of 1 t 5 volts and
15 ampso
3. Don't use an extension cord,
4_ Don't use a circuit that will become overloaded
when dehumidifier is installed°
5. Don't plug in the dehumidifier if you're in doubt
about the grounding of your electrical system.
Consult aqualified electrician first.
6_ Do not remove tech sheet which is inside
the cabinet. Your service technician needs this
information°
3

OPERATION
!INSTALLATION.
!WARNING: Do not use Dehumidifier near
flammables, such as gasoline.
Your Kenmore dehumidifier can be placed
almost anywhere, depending on the water disposal
method°
o Place the dehumidifier at least six inches from
the wall; don't place it in a corner or near a large
piece of furniture_
• Shut all doors and windows in the area to be
dehumidified.
o Before installation allow the unit to warm to
room temperature before operating
• For the first few days, on models with a humidi-
stat, turn the humidistat to "constant" to remove
extra moisture from the furnishings as well as from
the room air. When the area has dried, change the
humidistat to a lower number,
Your dehumidifier may be placed on a table or
shelf that is strong enough to support it with afull
bucket of water (see below)_ A shelf or table may
be a better position to handle the water bucket
or to adjust controls Do not sit or stand on this
product,
)
I
Also the height of a table or shelf may help pre_
vent icing of the coils due to colder air near the
floor (such as can be found in a basement)_
Don't block either end or right side of the dehu-
midifier_ The dehumidifier takes air from the back
and blows it out from the front and side. So wher*
ever you place it, be sure there's enough room for
good air movement and water bucket removal°
Your dehumidifier can be operated in an out-of-
the_way area such as autility room and still effec-
tively dry out adjoining areas (see below). However,
it is helpful to leave doors open between these
areas so the moisture in the air can move from
room to room.
A TYPICAL BASEMENT
!
CAUTION: Dehumidifier will not work
properly at temperatures below 65°F (55°F
for models with de-icer control).
4
The coil of any dehumidifier can become blocked
with ice in room temperatures below 65 degrees. Ice
buildup on the coil stops the air flow from the dehu-
midifier and it stops dehumidifying even though it
keeps running°
Generally your furnace heat also warms the base-
ment evenly to keep the temperature above 65 °,
The problem usually starts when on warm Spring or
Autumn days the basement doesn't receive warmed
air and may be at temperatures below 65 °,espe-
cially at floor level° If icing should occur, unplug
unit (or turn it off) until ice melts and room temper-
ature is above 65 °, Models with de-icer control (see
page 5) perform this action for you, Lifting the
dehumidifier off of the floor may help because that
places it in warmer air

JFEATURES AND HOW TO USE THEM
CONTROL PANEL
IFAN CONTROL,.
This controls fan operation of the dehumidifier.
When the humidistat calls for dryer air, the com-
pressor and fan motor will run until the humidistat
setting is satisfied_ Use HI for faster air drying and
LO for quieter operation°
AUTOMATIC SHUTOFE
The automatic shutoff switch turns off the dehu-
midifier when the water bucket is filled to its preset
level To restart dehumidifier, simply remove water
bucket, empty and rehang it on the back of the unit°
HUMIDISTAT.
To adjust the humidistat control turn the knob to
the setting you prefer_
Constant.
Ifyou choose this setting, dehumidifier wilt run all
the time no matter what the humidity might be.
! thru 6 plus Constant.
This is the range of relative humidity on the humidi-
star control knob_ "Youmay adjust the humidistat
setting higher or lower to suit your needs° Higher
numbers make air dryer; lower numbers leave more
moisture in the air_ When the relative humidity is
reduced to the level you have chosen, the dehumidi-
tier will turn itself off° It will turn itself on again
when the humidity rises
Off.
This setting turns the dehumidifier off when the
dehumidifier is not needed
NOTE: If you turn your dehumidifier off and turn
it right on again, the compressor may try to start
then stop. This is normal. In about two minutes, the
compressor will start again and continue to run_
SIGNAL LIGHT.
The signal light warns when water bucket is full
for emptying and the dehumidifier has stopped Be
sure to replace bucket properly so unit will run°
DE-ICER CONTROL,
Your Kenmore dehumidifier is equipped with a
feature to help you get the most comfort from your
new appliance by permitting it to operate down to
55OE
If your dehumidifier runs when room temperature
and humidity conditions are low, frost can form on
its evaporator coil. This interferes with proper
operation.
The DE-ICER control senses frost build-up on the
evaporator coil and automatically shuts off the com-
pressor. The fan continues to run, drawing air across
the coil and melting the frost. When the coil is
defrosted, the DE-ICER control restarts the com-
pressor automatically and dehumidifying is
resumed.
Before installation, allow the unit to warm to
room temperature before operating It may not start
if temperature is below 55°E
5

WATER COLLECTION BUCKET
Your dehumidifier was supplied with a sturdy
bucket which hangs conveniently on the back of
the unit to accumulate water removed from the air,.
The Shut Off Switch (A) is activated by afloat
and:
1_ Stops the unit before the bucket fills to
overflowing.
2_ Turns the unit on again after the bucket is emp-
tied and replaced.
tf you want the water to flow directly to a drain,
connect any standard garden hose to the bucket
connection (B) or place the dehumidifier over the
drain._
Note: a standard garden hose has a ¾" diameter
connection with 11 _ threads per inch. Be sure the
hose lies flat, not kinked. A drain hose may be
bought from Sears, Part No° 9181_
When using either of these direct draining meth-
ods, break through the plastic membrane in the
bucket connection (B),. Peel away any remainder so
the opening will be clear and permit water to flow
freely_
To reseal the hose connection on the bucket, use
any standard hose end cap.,
6

CARE AND UPKEEP
............................. i i
WARNING: SHOCK OR INJURY HAZARD
before servicing be sure to unplug power cord
from outlet. Handle the Dehumidifier with care.
Watch out for the sharp metal surface and fins on
the inner coil.
CLEANING THE COILS INSIDE THE
DEHUMIDIFIER.
The refrigerant coils are al! that need cleaning
on the inside of your dehumidifier_ For the best effi-
ciency, clean the coils well at least once a year
(more often if needed) with abrush or vacuum
cleaner° Also, clean the drain hole and the connect-
ing drain hose, if used.
i ............... TROUBLESHOOTING
IF DEHUMIDIFIER STOPS RUNNING.
1. See if power cord is plugged in properly and unit
is turned ono
2_ Check the power supply to be sure the outlet
works. Plug in alamp_
3_ Check for a blown fuse or tripped circuit breaker.
Never overload acircuit
4. Check water bucket to see if it is installed prop-
erly or needs emptying_
IF IT RUNS BUT DOESN'T DEHUMIDIFY
Unit may be in defrost cycle due to frost build-up
on coil. Unit will restart as soon as frost is melted
off and temperature rises above 55°F
IF DEHUMIDIFIER STILL DOES NOT RUN RIGHT.
Call your nearest Sears Service Center_ Sears
technicians are specifically trained to do the work.
When you call, give them the complete model and
serial number You'll find the information on a metal
plate located in the rear beneath the drain buckeL
CLEANING YOUR DEHUMIDIFIER.
o Be sure to read the owner's manual and follow its
instructions°
o Always unplug the power cord before cleaning a
dehumidifier. Dust the grilles or louvers with asoft
brush or the dusting attachment of your vacuum
cleaner.
o Every few weeks wash the inside of the water con-
tainer with asponge or soft cloth and a mild deter-
gent to prevent the growth of mold, mildew and
bacteria.
° Once or twice each season remove dust and lint
from the cold coils with a soft brush.
o To clean dehumidifier cabinet, wash with warm,
mitd sudsy water° Rinse with clear water and dry
with asoft cloth° Never use solvents, cleaning fluids,
abrasive cleaners or strong detergents_ CAUTION:
Don't turn dehumidifier on until outside is com-
pletely dry.
.if outside paint chips or is damaged, you can
touch up the outside of the cabinet with agood
grade of enamel paint to prevent rusL
7

Kenmore Ordering Information.
We service what we sell,
"We Service What We Sell" is our assurance to you that you can depend on Sears for service, and Sears service is
nationwide.
Your dehumidifier has added value, when you consider that Sears-trained technicians .... professional techni-
cians specifically trained on Sears appliances, having the parts, tools and equipment to ensure that we meet our
pledge to you. °. "We Service What We Sell:'
To further add to the value of your Dehumidifier.
Buy a Sears maintenance agreement.
Sears appliances are designed, manufactured and tested for years of dependable operation. Yet, any modern
appliance may require service from time to time,. The Sears warranty plus the Sears maintenance agreement pro-
vides protection from unexpected repair bills.
Contact your Sears sales person or local Sears Service Center today for information on aSears maintenance
agreement.
_MMMMM_fl-MMMMC.-_MC_M_MMMMMI_MMMMMMM
_H_HMHI?iI6_M_IM_H_M_HMM_MMM_M(_
_ M_,_i_ M_ MMMM_OMMM_M M_ _M MMMMM_ MMMC_
SEARS, ROEBUCK AND CO., Dept. 698/731 A, Sears Tower, Chicago, IL 60684 Printedin tts ^.