Kenmore 758.154140 User manual

SP6593 Sears Kenmore 7/21/@5 2:16 PH _ge 1
READ AND SAVE THESE INSTRUCTIONS
Operator's Manua_
®
WHOLE HOUSE HUMIDIFIER
14 Galton Output with
innovative Twin Fan Technonogy
Model 758.154140
CAUTION: Before using this
product, read this manual and
follow aH its Safety Ru_es and
Operating instructions.
oSafety
°Assembly
oOperation
°Maintenance
oParts
°EspaSoL p. 17
Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A.
wwwosearsocom
Part No=SP6593 Printed in Canada

SP6593 Sears Kenmore 7/21/@5 2:16 PH _ge 2
_"ONE YEAR FULL WARRANTY ON KENMORE HUMIDIFIER _
ff any part of this humidifier fails due to a defect in materiam or workmanship
within one year from the date of purchase, or it the humidifier motor fans due
to a defect in materiam or workmanship during the second year from the date
of purchase, RETURN THE HUMmDmFiER TO THE NEAREST SEARS PARTS &
REPAIR CENTER, and it win be repaired free of charge. This warranty does
not incmude humidifier filters, which are e×pendabme parts that can wear out
from normal use in messthan one year. This warranty gives you specific megam
rights, and you may also have other rights which vary from state to state.
Sears, Roebuck and Co., Dept. 817WA, Hoffman Estates, mL80179
GENERAL SAFETY iNSTRUCTiONS
Safety Signal Words
DANGER: means if the safety
information is not followed someone wHI
be seriously injured or killed.
WARNING: means if the safety
information is not followed someone
toured be seriously iniured or killed.
CAUTION: means if the safety
information is not followed someone may
be iniured.
1. To reduce the risk of fire or shock
hazard, plug humidifier directly into a
120V, A.C. electrical outlet. Do not use
extension cords.
2. Keep the electric cord out of traffic
areas. To reduce the risk of fire
hazard, never put the electric cord
under rugs, near heat registers,
radiators, stoves or heaters.
3. Always unplug the humidifier before
moving it, before cleaning, or
whenever the humidifier is not in
service.
4. Keep the humidifier clean.
5. Do not put foreign objects inside the
humidifier.
6. Do not allow to be used as a toy.
Close attention is necessary when
used by or near children.
7. Never use your humidifier while any
part is missing or damaged in any
manner.
8. To reduce the risk of electrical
hazard or damage to humidifier, do
not tilt, jolt or tip humidifier while unit
is running.
9. To reduce the risk of damage to
humidifier, unplug when not in use.
10. To reduce the risk of accidental
electrical shock, do not touch the
cord or controls with wet hands.
11. Note the warning label shown below.
WARNING: To reduce risk of fire,
electric shock, or injury always unplug
before servicing or cleaning.
Table of Contents
Water Fill .............................................. 6-7
Operating Humidifier Controls ............ 7-8
Using Your Humidifier .......................... 8@
Operating Tips for Best Performance .....9
Replacement and Care of Filters .......9-11
Cleaning and Maintenance .............. 11-12
Troubleshooting ................................... 13
Repair Parts ..................................... 14-15
q>

SP6593 Sears Kenmore 7/21/@5 2:16 PH _ge 3
To Save A Service Carl
Check the following if your humidifier is
not operating.
1. Is power cord attached to outlet?
2. Is there electrical power to outlet?
3. Is aifflow control in operating position?
4. Is humidity control set high enough?
5. Is the cabinet sitting on a level
surface?
Know Your Humidifier --
Controms
Filter
Housing
Fi_ters:
Repmacement
FHter 32-14911
Pivoting Lid Removed For Clarity
Description
Gailon Output/24 hrs
Capacity of Bottles
Sq. Ft. Coverage
Fan Speeds
Filters
Independent Bottle Gauges
FilI Indicator
Auto Shut Off
Auto Humidistat
Controls
CUL Listed
Volts
Hertz
Amps
Watts
758.154140
14
2-3/8 Gallons Each
2900
3
Set of 4 (32-14911)
Yes
Yes (independent Bottle)
Yes
Yes
Rotary
Yes
120 A.C.
6O
2.88
165
Based on an area with average insulation and an 8 foot
ceiling height
ANSI/AHAM HU-ld997, SEC. 8.1
q>

SP6593 Sears Kenmore 7/21/@5 2:16 PH _ge 4
How Your Humidifier Works
Your new Kenmore humidifier is designed
to satisfy home humidity requirements
through the principle of evaporation of
water in the air.
After water is added to the bottle, the
filters begin to soak up the water and
become totally saturated in approxi-
mately 30 minutes. Air is drawn in from
the rear of the humidifier and through the
filters by means of circulation fans. As air
passes through the filters, moisture is
absorbed into the air and then released
in the form of vapor. No water droplets
will enter the home. AII evaporation into
the air takes place in the humidifier,
which means that the residue left by
evaporating water is not passed into the
home, but remains in the filter.
CAUTION: Use only 32-14900 EPA
Registered Bacteriostat available
from Sears Retail store. Under no
circumstances should you use water
treatment products designed for
Rots belt or Ultrasonic humidifiers.
Humidified Air is Then
Remeased Through the Top
Dry Air
Enters
Through
the Rear
CAUTION: To reduce the risk of
injury, fire or damage to humidifier,
use only cleaners specifically
recommended for humidifiers. Never
use flammabie, combustible or
poisonous materials to clean your
humidifier.
To reduce the risk of scalds and
damage to humidifier, never put hot
water in humidifier.
Assembly
Your new Sears Kenmore humidifier is
completely assembled for you to use.
Remove the bag pack containing two
plastic caster pads from top of humidifier
and retain for future use if required. See
the following Step 1 for instructions.
Remove the packaging material from
inside your humidifier and follow the
instructions of this operator's manual for
proper usage. The packaging material is
located under the fan assembly. Remove
the packaging material and discard.

SP6593 Sears Kenmore 7/21/@5 2:16 PH _ge 5
Location Instructions
WARNING: For your own safety, do
not use humidifier if any parts are
damaged or missing.
Step 1:
Place humidifier on a flat level surface in
an area of your house where humidity is
needed most, or in an area which would
likely result in moist air being circuiated
throughout the house, such as near a
cold air return.
Placing the unit level is very important if
the humidifier is located on carpeting.
NOTE: The 14 gailon humidifier contains
water bottles. The weight of the bottles in
the front of the cabinet may cause the
front casters to sink deeper into the
carpet. If this happens, the water level
will be higher towards the front of the
humidifier, and !ower towards the back.
The water level float (located at the rear
of the cabinet) may not sense the water
so the filI light wilI be on and the unit wilI
not energize. If this happens, the unit will
need to be Ieveied in order for the
humidifier to be energized. To level the
humidifier when located on carpet, place
the included caster pads under the front
two casters of the humidifier only.
NOTE: Due to release of cool, moist air
from humidifier, it is best to direct air
away from home thermostat and hot air
registers. It is best to position humidifier
next to an inside wall. Hot air registers
and cold air from outside wails can affect
the efficiencies of the controls. Unit
should not be placed where warm air
from a hot air register blows directly on
unit.
Moist air (humidity) produced will
disperse into the whole house, but area
closest to the unit wilI have the highest
humidity. If the unit is positioned close to
a window, condensation may form on the
window pane. If this is not appropriate
the unit should be repositioned in another
location.
Step 2:
The humidifier should be positioned with
the back (cord exit side), at least 2
inches away from the wall. Air needs to
enter through the louvers in the rear
panel in order for the humidifier to
operate at peak efficiency.
At Leaet 2+' Frorn WaN Front of
,__ ..... Cabinet
Front
.... Caster
Caster Pad
t7777T/Tn_ Carpet
Surface
NOTE: If positioning on
carpet, place caster pads
// under front casters only
to level (if necessary),
Electrical Hook-Up
Locate nearest 120V A.C. wall socket in
the location desired, preferably on inside
wail. With the humidifier in the desired
location, route the electrical cord safely
so no one wilI trip or upset the humidifier.
Plug in the electrical cord.
WARNING: To reduce the risk of fire
or shock hazard, humidifier should
be plugged into a 120V A.C. outlet.
Do not use extension cords.
To reduce the risk of electrical shock, this
humidifier has a polarized plug (one
blade is wider than the other). This plug
will fit in a polarized outlet only one way.
If the plug does not fit fully in the outlet,
reverse plug. If it still does not fit, contact
a qualified electrician to install the proper
outlet. Do not change the plug in any way.

SP6593 Sears Kenmore 7/21/@5 2:16 PH _ge 6
Water Fifl
WARNING: To reduce the risk of
shock, always unplug humidifier
before cleaning or servicing.
WARNING: To reduce the risk of fire
or shock hazard, do not pour or spill
water into control or motor area.
If controls get wet, Iet them dry
completely and have unit checked by
authorized service personnel before
plugging in.
This humidifier is designed for use with
the two water bottles that are located
under the pivoting lid.
Open the pivoting Iid of the humidifier.
Remove the water bottles by lifting them
straight up and out of the cabinet.
Notice the water bottles are designed as
right and Ieft hand units. Position them in
the correct location so the humidifier can
function properly. The water bottles
should rest in the front of the cabinet.
Each "E-Z-FilI Side-Cap" must be facing
the rear of the unit.
Each water bottle is designed with an
"E-Z-FilI Side-Cap" that is easily
removable. Remove the "E-Z-FilI Side-
Cap" on the side of the water bottle by
twisting counterclockwise.
Place the opening of the water bottle
under a water faucet (the bottle should fit
under a four-inch clearance faucet). FilI
with recommended mixture of cotd water
and Sears Bacteriostat #32-14900 (if
necessary) only. Solid debris could make
the valve leak.
Install the "E-Z-Fill Side-Cap" by twisting
clockwise. Hand tighten only.
Check for possible leaks by
performing the following:
1. Grasp bottle handle and hold the bottle
upright over a sink.
2. Press up on the valve cap plunger for
about one second to let out a little
water.
3. Release the plunger.
4. Listen for air bubbles Look for leaks
around the "E-Z-Fill Side-Cap".
5. If you hear air bubbles or see leaks,
retighten the "E-Z-Fill Side-Cap" and
repeat Steps 1-4.
/Fan Aesembmy
Pivoting
Lid
Bottles
"E-Z-Fill Side-Cap" Shoumd
Amways Face Rear
Turn Countercmockwise
lo Remove Cap

SP6593 Sears Kenmore 7/21/@5 2:16 PH _ge 7
Water Fill (continued)
Wipe off excess water from the bottle.
Position the water bottle back into the
unit by grasping the water bottle handIe
and lower it into the cabinet until the
bottle sits on pads at bottom of cabinet.
The "E-Z-Fill Side-Cap" must be facing
the rear of the cabinet. When positioned
properly, the plunger wiII open and water
will flow into the cabinet. The water leveI
will automatically rema+n at approximately
1/2" until the bottles are empty.
AIIow the fiIter to saturate for 30 minutes
before operation.
NOTE: Ensure that the raised section of
the water bottle falIs into the hole in
stationary Iid in order for the bottle
gauges to function properly.
Stationary Raised
Lid Home Section
/
Pivoting Lid Removed for Cmarity
Operating Humidifier Controls
The operating controIs of your Kenmore
Quiet Comfort whole house humidifier are
located on the top center of the
humidifier. The controls are found under
the smoked control cover, located
between the air circuIating fans.
Lift the centre+ cover by @acing your
finger in the round cutout and I+fting+The
cover will stay open. Now you can cIearIy
see the controls area. FamiIiarize yourself
with the controts and reference the
diagram of the controt area for the correct
naming used in this manual
To Operate the Controls
Humidity Control." @
Adjust the amount of humidity depending
on your needs. The humidifier will turn on
the off as required to maintain leveI of
humidity seIected+ A medium setting is
recommended, but there are times when
low or high amount of humidity may be
preferred. For constant operation of
humidifier, rotate humidity knob aiI the
way clockwise. This allows for the
maximum amount of hum+dity to be
evaporated into the air continuously.
IMPORTANT: Water damage may result
if condensation starts to form on windows
or walls. Humidity Control setting should
be lowered until condensation no longer
forms.
Speed Control: @
The unit ie adjusted from off" I " to high
",, ,,,+"with a rotary speed control. The
higher the air flow speed, the more water
is evaporated and released into the air.
Low speed ",," is the quietest and is
provided for conditions that may not
require as high an evaporation rate.
VJSI+FILL Water Bottle Gauges and FiN
Lights:
This humidifier is equipped with
independent (left and right) water level
bottle gauges. When the unit is energized
the center area of the controi panel
containing the gauges and fill indicators
will illuminate red to depict the operation
mode. The right bottle as viewed from the
front of the humidifier wilI always empty
first. As it empties the number of red bars
will decrease. When it is totally empty,
the fill indicator, beside the bars, will
illuminate immediately.
NOTE: The humidifier will not shut off at
this stage.

SP6593 Sears Kenmore 7/21/@5 2:16 PH _ge 8
Operating Humidifier Controls (cont'd.)
Once the right bottle empties, the
humidifier will begin to use the water from
the Ieft bottle until it is depleted. At this
time the filI indicator beside it will
illuminate. There will still be a slight delay
in the unit shutting off while it depletes
the water in the bottom of the cabinet. At
this time or anytime during normal
operation you may filI the water bottles to
continue operation.
NOTE: A small amount of water remains
in the cabinet after both filI indicators turn
on and the unit shuts off.
Left
Bottle
Gauc
Manuat Oryout:
At the end of the humidification season or
if you do not plan to run the humidifier for
one week or more, you can override the
automatic shutoff function to completely
dry the hum[differ cabinet out.
To do this, simply slide the float retainer
located at the back of the humidifier
cabinet to the top position of the slot it is
located in. This will hold the float in an
upward position and the fans wilI run until
you turn the power off.
NOTE: Be sure to position float retainer
to the normal operating mode (lowest
position in slot) for hum[differ operation.
The following diagram is of the slot the
float retainer is located in at the back of
the cabinet.
Bottle
ght Gauge Back of Cabinet
Bottle Bottle
Fill Indicator Fill Indicator
Top Position
ie for Manua_
Dryout
Bottom Position
is for Normam
Operation Mode
\Hoat
Retainer
S_ot
Using Your Humidifier
Step 1:
Be sure humidifier is futl of water and
plugged in.
Step 2:
Set Speed Control " _ " to lowest
speed ",,".
Step 3:
Set Humidity Control " _ " to medium
position.
NOTE: Hum[differ should operate with
humidity control on the recommended
medium setting. If it does not, the
humidity is at a relatively high level
To test the unit under this condition, turn
Humidity Control all the way to clockwise
and unit should begin to operate. After
the unit has been tested, set Humidity
Control to medium or desired level.
Step 4:
if humidifier stops running and BOTH Fill
indicators are not on, the humidity level is
at the normal requirements for that
setting or it is adjusting to the home
conditions. The chart on page 9 shows
recommended indoor humidity levels.
The following figure shows approximate
relative humidity percentages which
correspond to the various settings of the
Humidity Control.
q>

SP6593 Sears Kenmore 7/21/@5 2:17 PH _ge 9
Using Your Humidifier (cont'd.)
When Outdoor
Temperature is:
-IO°F
O°F
10°F
20°F
Recommended Indoor
Relative Humidity is:
2O%
25%
3O%
35%
Operating Tips for Best Performance
1. Position the humidifier at least 2 inches
from any wall and away from any heat
registers=
2. Do not restrict airflow from entering or
exiting the humidifier=
3. Use Sears recommended bacteriostat
32-14900 to retard bacteria growth
that may cause odors and may be
harmful to your health=
4= Perform regular cleaning as instructed
in "Cleaning and Maintenance" section
of this manual
5= Re@ace the evaporative wicking filters
at least once per humidification
season or more depending on water
conditions in your area=
Replacement and Care of Filters
WARNING: To reduce the risk of
shock or injury from moving parts,
always unplug humidifier before
removing or replacing any parts.
CAUTION: To help retard bacteria
growth and keep maximum efficiency,
the filter should be replaced at least
once per season, or more often
under hard water conditions. Use
Kenmore 32-14911 recommended
replacement filter=
The filters may be rinsed periodicaily in
clear water only. Take care not to damage
paper. To replace evaporative wicking
filters in your Kenmore Quiet Comfort
Whole House humidifier, follow these
instructions=
9

SP6593 Sears Kenmore 7/21/@5 2:17 PH _ge 1@
Replacement and Care of Filters (conrd.)
1. Unplug humidifier and proceed to
clean. Before removing the fiIters, we Lid
recommend moving the humidifier to Fan Assembmy
an area where floor coverings are not //
susceptible to water damage, Le.
kitchen or bath areas. Humidifier
2. Open the pivoting lid and remove
water bottles and set aside. Grasp the /
/"
fan assembly front center and rear
center. Lift off and set aside on a clean
flat surface. The filter housings are
now accessible.
3. Lift filter housing out of cabinet and
place where you may work on them
comfortably. With a soft, absorbent
cloth remove any remaining water or
loose mineral deposits not trapped in
the filter from the humidifier cabinet.
Spring
tTabs
/\
/I
Filter
Housing
4. To open filter housing for easy access
to filters:
a. Deflect the two spring tabs on top of
filter housing. Lift top cover off of
the filter housing and set aside.
b. Remove the two filters and dispose
of properly. Clean internal parts of
humidifier per the "Cleaning and
Maintenance" section of your
operator's manual.
c. Install new filters in the filter housing
track with the glue beads of the
wicking pad to the inside of the filter
housing.
d. Return the top cover of the filter
housing by installing cover over the
fixed tabs on the rear of the lower
filter housing and pivoting the cover
down over the top of the filters.
Snap the cover over the two spring
tabs.
e. Replace the filter housing in the
cabinet.
Spring
Tabs
Front of
Humidifier
Fixed Tabs
Filter
zHousing
/
Rear of
Humidifier
Top
/Cover
!
Spring
10 Tabs

SP6593 Sears Kenmore 7/21/@5 2:17 PH _ge 11
Replacement and Care of Filters (conrd.)
NOTE: There is a front and back
orientation. To position the filter
housings correctly:
,, Be sure that the spring tabs of filter
housings are towards front of
cabinet.
,, Align the lower portion of the filter
assembly over the six ribs located
at the bottom rear of the humidifier
cabinet.
f. Position fan assembly onto the
cabinet. Make sure the fan venturi
(lowest cylinder section below the
fan) is placed inside the filter
housing.
g. Replace water bottles.
h. Close the pivoting Iid.
i. The unit is ready for use or to be
stored away for next season.
Plat Portion of Filter Housing
Towards Sack of Cabinet
Spring Tabs Towards Front of Cabinet
Step 4e
Cleaning and Maintenance
WARNING: To reduce the risk of injury,
fire or damage to humidifier, use only
cleaners specifically recommended for
humidifiers. Never use flammable,
combustible or poisonous materials to
clean your humidifier. To reduce the
risk of scalds and damage to
humidifier, never pat hot water in
humidifier.
CAUTION: Local water purity varies
from area to area and under certain
conditions water impurities and
airborne bacteria may promote the
growth of microorganisms in the
reservoir of the humidifier.
To retard bacteria growth that may
cause odors and be harmful to your
health, use onty Sears replacement
filters. We also recommend using EPA
approved bacteriostat, 32-14900 and
humidifier cleaner, 32-14713, available
at your local Sears store.
NOTE: If it is necessary to use approved
bacteriostat, follow directions correctly.
The bottles of the whole house humidifier
will hold 2-3/8 gallons of water each.
Step 1:
To make cleaning easier, the humidifier
cabinet should be empty and completely
dried out. To accomplish this, use the
following method:
a. On the back side of the humidifier
cabinet, find the float retainer. In
normaI operating mode, the retainer
wilI be positioned in the bottom of the
slot in the cabinet. Push the retainer
up to the top slot position in the
cabinet until it Iocks in @ace. (See
"Manual Dryoat" section on page 8.)
b. AlIow the humidifier to run until there is
no water left in the cabinet.
c. Unplug humidifier.
WARNING: To reduce the risk of shock,
always unplug humidifier before
cleaning or servicing. If humidifier is not
unplugged, fan could start after
housing is removed.
11

SP6593 Sears Kenmore 7/21/@5 2:17 PH _ge 12
Cleaning and Maintenance (cont'd.)
Step 2:
To Remove Parts
a. Open the pivoting lid and remove
water bottles and set aside. Grasp the
fan assembly front center and rear
center. Lift off and set aside on a clean
flat surface. The filter housings are
now accessible.
b.
o.
Before removing the internal parts of
the humidifier cabinet, we recommend
moving the humidifier to an area
where floor covers are not susceptible
to water damage, Le.; kitchen or bath
area. Lift the filter housing assemblies
out of the cabinet and set to the side.
Remove the water level float from the
humidifier cabinet by pinching the float
retainer to release it from the cabinet.
The cabinet should be empty before
cleaning. The cabinet consists of the
lower areas of the humidifier where
the filters are during normal operation
time.
d. Empty cabinet of any remaining water.
e. Proceed to "Bi-Weekly Maintenance"
or "End of Season Maintenance".
Remove old filters and dispose of
properly as described on pages 9 -11.
Step 3:
Hnstallnew filters (purchase the correct
evaporative wicking filter pads 32-14911
for your humidifier) into the location
where the old filters were positioned.
Hnstallthe filter housings with the new
filters into the correct location. Reinstall
the water level float.
NOTE: Float retainer should be
positioned in normal operating mode.
Assure that it is positioned in the bottom
of the slot in the back of the cabinet (See
page 8 for diagram of slot).
Position the fan assembly on top of the
cabinet and return the humidifier to the
desired location for use.
Refill humidifier bottles with fresh cooI
water and return them to the cabinet.
Plug the unit into a 120 volt A.C. power
outlet and set the controls per the
"Operating Humidifier Controls" section of
this manual.
Bi-Weekmy Maintenance
Removing Scame
1. Fill the humidifier base with one 8
oz. cup of undiluted white vinegar.
Let solution stay 20 minutes.
2. Clean alI interior surfaces with a
soft brush. Dampen a soft cloth
with undiluted white vinegar and
wipe out the base to remove scale.
3. Rinse thoroughly with clean warm
water to remove scale and cleaning
solution before disinfecting cabinet.
4. Dust the fan assembiy and outside
surfaces with a soft cloth only.
Disinfecting Humidifier
Cabinet and Water Bottles
1. Fill humidifier cabinet with 1
teaspoon chlorine bleach in 1
gallon of water. Let solution stay for
20 minutes, carefully swishing
every few minutes. Wet all surfaces
normally exposed to water.
2. Empty humidifier cabinet after 20
minutes. Rinse with water until
bleach smell is gone. Allow unit to
dry out completely.
3. Water bottles should be cleaned in
the same manner.
End of Season Maintenance
1. Follow"Bi-Weekly Maintenance"
instructions at end of humidification
season.
2. Remove and throw away filters.
3. Let humidifier dry completely before
storing. Do not store with water inside
cabinet or water bottles.
4. Store in cool, dry location.
5. Hnstalla new filters in clean humidifier
before next season begins.
6. "Bi-Weekty Maintenance" procedure is
also recommended if you do not plan
to run the humidifier for one week or
more.
12

SP6593 Sears Kenmore 7/21/@5 2:17 PH _ge 13
Troubleshooting
Trouble Probable Cause Remedy
Unit will not run and no control • No Power. .Check 120 volt power source.
panel lights are illuminated.
Unit will not shut off. • Float retainer is positioned in , Slide float retainer down to
"Manual Dryout" position, normal operation mode. Refer
to "manual Dryout" section on
page 8.
Free float from obstruction.
Unit will not dry out completely.
Bottles continue to empty.
Neither bottle emptying.
Left bottle not emptying.
Fill indicators turn on before
bottles are empty.
NOTE: There may be a little
water still in bottle when Fill
indicator is illuminated. This is
normak
Float is not free.
Float is positioned in normal
operation mode.
Air is entering water bottles.
Bottle cap plunger missing
post in bottom of cabinet.
Dirty filters.
Right bottle contains water.
Unit is not set up on a level
surface. (Float will not sense
water at the rear of the
cabinet).
.This is normal. A small
amount of water remains in
the cabinet after Fill lights
come on. Position float
retainer in Manual Dryout
position to completely dry out.
See page 7.
.Check "E-Z-Fill Side-Caps"
and valve assembly caps to
ensure tightness.
Check for leak in water
bottles.
, Ensure gaskets for "E-Z-Fill
Side Caps" are in place.
, Check orientation of bottles.
Reposition so that bottle cap
plunger (stem) is depressed
by post in bottom of cabinet..
, Change to fresh new filters.
(32-14911).
.The humidifier is designed so
the right bottle empties first.
Continue to run until both fill
lights come on.
Position unit level. (Some
carpet padding may allow unit
to sit lower in front than rear
with the additional weight of
water bottles in the front of
the cabinet. Install caster
pads under front casters.
(See page 4).
CAUTION: Use only 32-14900 EPA Registered Bacteriostat available from Sears Retail store.
Use of other water treatment products may damage the filter elements.
Under no circumstances should you use water treatment products designed for Rata belt or
Ultrasonic humidifiers.

23
0
Z
9
o
0
3
m_
©

Key
No Pail No,
1 828743
2 828756
3 830891
4 828741-1
5 828855-1
6 822409
7 823912
8 828753
9 828755
10 828750
11 828751
12 828752
13 828749
14 828854
15 824690
16 828192
17 828726
18 509229-1
19 828998
Description
Cover,Dust
Knob
Label,Control
Lid, Stationary
Lid, Pivoting
Humidistat
Switch, Rotary
Cover,Actuator Arm
Spring, Compression
Light, Pilot
Arm, LH Actuator
Arm, RHActuator
Retainer,Micro Switch
Switch, Micro
"E-Z-Fill Side-Cap"
Bottle, Left(IncludesKeyNos.15& 18)
Bottle, Right (includesKeyNos.15 &18)
Cap,Valve Assembly
Cabinet
NOTE: Any attempt to repair the control assembly or motor
may create a hazard unless repair is done by a qualified
service technician. Repair service is available at your nearest
Sears store.
Key
Ne Part No.
20 823726
21 STD601107
22 828515
23 830560-1
24 32-14911
25 828197
26 828534
27 8281t5-1
28 822406q
29 828197
30 828858
31 816069_5
32 816069-6
33 STD6O0805
34 824101q
35 828200
36 828745
37 828920
-- SP6593
Description
Rail,Kick
*Screw,PanHd=Ty"AB"#'10x 3/4
Caster,TwinWheel
Support,FilterLower
t Filter,Evaporative
Support,UpperFilter
Support,Motor
Motor (includes mounting hardware)
Fan
Support,UpperFilter
Cordw/Hug
*Screw,PanHd.Ty"AB"#6x 1/2
*Screw,PanHd.Ty"AB"#6x 3/4
*Screw,PanHd.Ty"AB"#8 x t/2
Retainer,Float
Float,WaterLevel
Enclosure.Electronics
Pad,Caster(Two)
Operator'sManual(notillustrated)
* Standard Hardware Item - May be purchased locally
1 Stock item - May be secured through the Hardware
Department of most Sears retail stores.
9)
O
&
i
z
o
@
B
8
Z _
Po
_2
m_
2p_
(D
o
o

SP6593 Sears Kenmore 7/21/@5 2:17 PH _ge 16
Notes

SP6593 Sears KenmoreSP 7/21/05 1:47 P_Page 17
LEAYGUABDE ESTAStNSTBUCCIONES
Manuam_emusuario
®
HUMIDIFICADOBPABA TODA LACASA
Ptoctucci6nde14 gaionescon
tecnoiog{a innovadora de ventiiadotes gemeios
modeio 758.154140
PBECAUCI()N:Antesde utilizar este
producto,meaestemanuamysiga
todas las normasde seguridacle
instruccionesde utilizaci6m
,,Seguridad
,,Ensamblaje
oUtilizaci6n
_,IViantenimiento
.Piezas
Sears, Roebuckand Co., Heffman Estates, JL6017g U.S.A.
www.sears.com
No. de pieza8P6593 Irnpresoen Canad_
q>

SP6593 Sears KenmoreSP 7/21/05 1:47 P_Page 18
FGARANTiA COMPLETA DE UN ANO PARA EL HUIVIIDIFICADORKENMORE "_q!_
8]cualq@erpUezadeestehumidificadotfailadebJdoaun defectodematerialodefabficacU6n
denotedelplazadeuna_oa partUrdelafechade compra,osieJmotetdelhumUdificadotfaIIa
debidoaundefectodematerialodefabticacU6ndutanteelsegundoa_oapartkdelafechade
cumpta,DEVUELVAELHUMIDIFICADORAL CENTRODE PIEZA$Y REPABACIONDE$EARSMP,S
CERCANO Y ser;irepatadosinning_ncatgo_Es_agaranfiano induVelosfHtrosdel
humidilicadot,quesonpiezaspetecederasquesepuedendesgastatpotcausadelusanormal
enmenosdeunabe.Estagarant{ale confleteaustedderechoslegalesespedficosyesposible
queustedtambi_ntengaarrasdetechosquevariandeunestadoa otto,
Sears,RecheckandCo.,Dept.817WA,Haffn_aeEstates,IL6017g_
INSTRUCCmONESGENERALESDE SEGURmDAD
Pamabrasdese amdeseguridad 5. No ponga objetos extraSos dentro de{
PEUGRO: Sign[fica que si no se sigue la hurnidificador.
informaci6nde seguridad,alguien resumtar_
leslonadogravementeo morM,
ADVERTENCIA:Significa que s[ no se s[gue la
informaciOndeseguridad,algu[enpodriaresultar
leslonadogravementeo mork
PRECAUCm6N:Significa que si no se sigue la
informac[On de seguridad, alguien pudiera
resultarleslonado.
1. Parareducire[riesgodepeligrode {ncendioo
descargas e[_ctricas, enclrufe e[ humidi-
ficador directamenteen un tomacorriente de
120V C.A.No useco@onesde extensi6n.
2. Mantenga el cable el6ctrico aleiado de las
zonas de tr_.fico. Para reducir e[ rlesgo de
pellgro de incendio no ponga nunca el
cord6n el_ctrlcodeb@odea[fombrasni cerca
de sa[idas de calor radladores de calor,
estufasde cocina oc@entadores.
3. Desenchufesiempre el hurnidificador antes
de trasladarlo, antesde lirnplarlo o siernpre
queno est_enservlclo.
4. MantengaIlmpio e! humidificador.
6. Nodeje que el humidificadorseusecomo LIn
iuguete.Es necesarioprestar muchaatenci6n
cuando e[ hurnidiflcadorseausadopot nlSos
o cercadeellos.
7. No utilice nunca el humidificador mientras
alguna plezafalte o est_da_iadade cualquier
manera.
8. Para reducir el riesgo de pdigro e[_ctrlco o
dahos al humidificador,no incline, sacudani
vuelque e[ humidificador m[entras la Era[dad
est6 en marcha.
9. Para reducir el riesgo de da_os al humi-
dificador, desench@@ocuando no est_ en
USO.
10. Parareducir ei riesgode descargasel_ctricas
accidentales,no toque el cable de alimenta-
ci6n nl los controlescon las manos rnojadas.
11. Fiiese en la etiqueta de advertencia que se
muestraacontinuac[On.
ADVERTENCIA:Parareducirel riesgodeincendio,
descargas el_ctricas o lesiones, desenchufe
siempreel humidificaderantesdehacerleservicio
deaiustesy reparacionese limpiarlo.
r
/ndice
Informaci0n de garantia ...............................18
Instrucciones genera[esde seguridad .........18
Paraahorrarse una[[amadade servicio .......19
Farniliaricesecon el humidificador ..............19
C6mofunciona e! Irumid[ficador ................. 20
Ensambl@e....................................................20
Instrucciones de ublcaciOn..........................21
ConexiOnel_ctrica ...................................... 21
Llenadocon agua ........................................22
UtillzaclOnde loscontroles
d@humidificador ..............................23-24
Util[zaciOndel Irumidificador ...................24-25
Consejosde uti[izaciOnpara Iograr
el mejor rend[rniento...............................25
Reemplazoy cuidado de losfiltros ........25-26
Limpieza y mantenlrniento ......................27-28
Res@uci0nde problemas ............................29
Piezasde repuesto .................................30-31
18
q>

SP6593 Sears KenmoreSP 7/21/05 1:47 P_Page 19
Paraahorrarseuna//amadade servicio
Compruebe Io s[gu[ente si el humidificador no
funciona.
1. &EstAe[cabledealirnentaci6nconectadoaun
tomacorriente?
2. &Hayalirnentaci6ne!_ctricaaltomacorriente?
3. &EstAe[controlde!Oujodeaireenlaposici6n
defuncionarniento?
4. &Est,.elcontroldehumedadaiustadoaun
nivetIosuficientementealto?
5. &Est,.el gabineteubicadoen unasuperficie
nivelada?
Fami/iariceseconel humidificador
Cam'gasa
dellfiltro
Filtros:
No.derepuesto
32-14911 Tapa pivotante
8e ha quitado la tapa pivotante para mayor eiaHdad
Descrip¢idn
Produccidn engalones/24 h
Capacidaddelas botet[as
Coberturaen piescuadrados
Velocidadesde]vent[lador
FHtros
Calibresde botella independientes
Ind[cador de Henado
Apagadoautom_tico
Higrostatoautorn_tico
758.154140
14
2-3/8galonescadauna
2900
3
Juegode4 (32-14911)
Yes
Si (botella[ndepend[ente)
Si
Si
Controles
Catalogadopot CUL
Voltaie
Frecuencia
h_tensidad
Potencia
Giratorios
Si
120V C.A.
60 Hz
2,88A
105
Basadaen unazona con aislamiento promedio y una altura de habitaci6n
de 2,44 m (8 pies).
ANSWAHAM HU-1-1997, SEC. 8.1
19

SP6593 Sears KenmoreSP 7/21/05 1:47 P_Page 20
C6mofundonael humidNicador
Su nuevo humidificador Kenmoreest_ diseff_ado
pare satisfacer los requisitos de humedad del
hogara trav6sde!principio dela evaporaciOndel
agueenel aire.
Despu_sde aP_adirague a la botek los filtros
comienzanaabsorberel aguey sesaturantotal-
menteen aproxirnadamente30 rninutos.Sehace
entraraire de la partetraseradel humidificadory
a trav6s de los filtros por medio de los ventila-
dores decirc@aci6n.A medida queel aire pasaa
trav6sdelos filtros, absorbehurnedad,la cualse
libera a continuaciOn en forma de vapor. No
entra@n gotitas de ague en la case. Toda la
evaporaciOnal aire tiene lugar en el humidifi-
cador, Iocual significa que los residuosdeiados
porel aguequeseevaporano se pasanala case,
sino que perrnanecenen elfiltro.
PBECAUCI6N:Utilice @_icamenteun bacterio-
stato registrado por EPA 32-1490@ el cual
se puede obtener en una tienda minorista
Sears. En ninguna circunstancia debe usted
user productos de tratarniento de ague
disdiados pare humidificadores de rotocorrea
o ultras6nicos.
Luego,se expulsa aire humidificado
a trav_,,sde la parte superior
Eluire seco
entreutrav6s
dela parte
traseru
PRECAUCi6N: Pare reducir e! riesgo de
lesfones, incendio o da_os a[ humidfficador,
utilice @licamentelimpiadores recomendados
especificamente para hurnidificadores. I/o
utilice nunca materiales inflamables,combus-
tines ot6xicos parelimpiar e!humidificador.
Parereduche! rfesgode quernarsey de da_ar
el humidificador,no ponga nuncaaguecaliente
en el humidificador.
Ensamhlaje
Su nuevo humidificador Sears Kenmore viene
com@etamenteensambladolisto parequeusted
Io use. Retireel paquetede boise que contiene
dos almohadillas pare ruedecilla de pl_stico,
situado en la partede arribade! hurnidificado!;y
guD.rdelopare uso futuro, en caso de que sea
necesario.Cons@teel Paso 1 que aparecernD.s
adelantepareobtener instrucciones.
Saque el material de empaquetamiento del
interiordel humidificadory sfgalasinstrucdones
contenidas en este manual del usuario pare
utilizer correctamente el humidificador. El
material de empaquetamiento est_ ubicado
debajodelco@untode los ventiladores.Saquee!
materialdeempaquetamientoy des6chelo.
20
q>