Life Fitness Club Series 45X User manual

CLUB SERIES 45 DEGREE
BACKEXTENSION
Part # 7199901
RevA. Revision:10/19/011
ASSEMBLY INSTRUCTIONS

PARTS LIST
PART #
72000
72006
72012
72015
69132
3202403
3102904
3233301
KEY
1
2
3
4
5
6
7
8
QTY
1
1
2
1
2
2
4
1
KEY
9
10
11
12
13
14
15
OR
PART #
3226701
3102905
3102807
3102514
6866701
3228501
6866602
6866603
DESCRIPTION
1/4” LOCK WASHER
3/8 X 3-3/4” BOLT
3/8” LOW HEIGHT LOCK NUT
3/8” SAE WASHER
3/8” RH WASHER
3/8” BLACK SAE WASHER
WHITE RH CAP
PLATINUM RH CAP
QTY
1
4
6
10
14
2
14
14
DESCRIPTION
FRAME
HIPPADADJUST
SUPPORT
FORMEDANGLE
HIP PAD
3/8 X 2-3/4” BUTTON HEAD
3/8 X 3” BOLT
5/16 X 1/2” SHOULDER BOLT
BOLT LENGTH
Tools Required forAssembly
2
NOTE:BOLTLENGTH ISMEASUREDFROMTHE UNDERSIDEOFTHEHEAD OFTHEBOLT.
Bolt Length Ruler
0123456
1/2 1/2 1/2 1/2 1/2 1/2
* Rubber mallet or hammer
* 9/16” wrench
* Ratchet with 9/16” socket

3
11
3/8” LOW
HEIGHT LOCK
NUT
12
3/8” SAE
WASHER
15
RH CAP
(WHITE/PLATINUM)
13
RH
WASHER
7 3/8 X 3” BOLT
10 3/8 X 3-3/4” BOLT
14
3/8” BLACK SAE
WASHER
6 3/8 X 2-3/4” BUTTON HEAD BOLT
9
LOCK
WASHER
8 5/16 X 1/2” SHOULDER HEAD BOLT

STEP 1:
FIGURE 1
4
• SECURELY assemble the two SUPPORTS (3) to the FRAME (1) using eight RH CAPS (15), four 3/8 X 3-3/4” BOLTS (10),
eight 3/8” SAE WASHERS (12), eight 3/8” RH WASHERS (13) and four 3/8” LOW HEIGHT LOCK NUTS (11) as shown in
FIGURE 1.
0123456
1/2 1/2 1/2 1/2 1/2 1/2
15
11
3
1
3/8 X 3-3/4” 10
1312

STEP 2:
FIGURE 2
5
• Pull back the SPRING PIN on the FRAME (1) and insert the HIP PAD ADJUST (2) as shown in FIGURE 2.
1
2
4
11 15
12
13
14 BLACK
6 3/8 X 2-3/4” BUTTON HEAD
SPRING PIN
• SECURELY assemble the FORMEDANGLE (4) to the FRAME (1) using two 3/8 X 2-3/4” BUTTON HEAD BOLTS (6), two 3/8”
BLACK SAE WASHERS (14), two 3/8” RH WASHERS (13), two 3/8” SAE WASHERS (12), two 3/8” LOW HEIGHT LOCK
NUTS (11) and two RH CAPS (15) as shown in FIGURE 2.

STEP 3:
FIGURE 3
6
2
8 5/16 X 1/2”
SHOULDER
BOLT
• SECURELY assemble one 5/16 X 1/2” SHOULDER BOLT (8) and one 1/4” LOCK WASHER (9) to the HIP PAD ADJUST (2) as
shown in FIGURE 3.
0123456
1/2 1/2 1/2 1/2 1/2 1/2
9

STEP 4:
FIGURE 4
7
2
3”
• SECURELY assemble the two HIP PADS (5) to the HIP PAD ADJUST (2) using two RH CAPS (15), two 3/8 X 3” BOLTS (7) and
two 3/8” RH WASHERS (13) as shown in FIGURE 4. (Note the the direction of the hole pattern on pad.)
3/8 X 3” 7
5
13
15

Clean:
• Upholstery with mild soap and water.
• Guide rods with a cotton cloth.
• Hand grips with mild soap and water.
• Frame damage can be repaired with touch-up paint can be purchased from your LifeFitness customer service representative at
[phone].
Inspect:
• Cables for wear or damage and proper tension (should not exceed 3/4” deflection.) Pay close attention at bends and attachment
points.
• Hardware should be checked for looseness. Tighten as required.
• Frames should be inspected for wear or damage.
• Hand Grips should be checked for wear or damage
Lubricate:
• Lube the Guide Rods. Apply the lubricant to a cotton cloth, then run the cotton cloth up and down the guide rods as needed. Do not
spray lubricant directly on the Guide Rods.
PREVENTATIVE MAINTENANCE TIPS
There is a risk assumed by individuals who use this type of equipment. To minimize risk, please
follow these rules:
2. Do not allow minors or children to play on or around this equipment.
1. Inspect equipment daily. Tighten all loose connections and replace worn parts immediately.
Failure to do so may result in serious injury.
3. Exercise with care to avoid injury.
4. Consult your physician before beginning any exercise program.
8
Thankyouforpurchasingthe LifeFitnessCLUB SERIES45 DEGREEBACKEXTENSION.Ifunsureof
properuseof equipment,callyour localLifeFitness distributoror callthe LifeFitness customerservice
department at [phone].
CAUTION-PLEASE READ
Action DAILY WEEKLY QUARTERLY BI-ANNUALLY AS NEEDED
CLEAN
Upholstery X
Guide Rods X
Hand Grips X
INSPECT
Visual Overall X
Cables X
Hardware X
Frame X
Hand Grips X
LUBRICATE
Guide Rods X
WARRANTY INFORMATION
10YEARS STRUCTURUALFRAME
3 YEARS PILLOWBLOCKS,PULLEYS,WEIGHTPLATESANDGUIDE RODS
1YEAR CABLES
90 DAYS UPHOLSTERY