Long-run LRF-3300S User manual

ULTRASONlC
FlOWMETER
SAMPLE BOOK
TYPE:LRF-3300S
Concentrating on Flow
Measurement

Introduction
Illustrative
LRF-3300S is a wall-mount, clamp- on type
ultrasonic flowmeter which use the transfer
time technology. Clamp on type ultrasonic
flowmeter is easy to install and no need to
cut off the pipe, that saves you lots of
troubles and cost. At the same time
LRF-3300S has our unique calculate
software to ensure the high accuracy and
low velocity response.
LRF-3300S could add the RTD model
and temperature sensor become an
energy meter to monitoring the
energy use, help to save the energy.
24 hours service: [phone] Tel: [phone] Fax: [phone]
24 hours service: [phone] Tel: [phone] Fax: [phone]
E-mail: [e-mail] skype: Longruncn Website: www.ultrasonicscn.com
LRF-3300S Ultrasonic Flowmeter
0.5 Clamp-on type

Specification
Flow range
Accuracy
Repeatability
Linearity
Pipe size
Outputs
Communication
Memory
Power supply
Display
Temperature
Humidity
Transmitter
Transducer
IP68
Encapsulated design
Double-shielded transducer cable
Standard/maximum cable length:30ft/1000ft(9m/305m)
IP65
Up to 99% RH,non-condensing
240*128 back lit LCD
Transmitter: -40℉~140 ℉(-40℃~60 ℃)
Transducer: -40℉~176℉(-40℃~80℃,standard)
32℉ ~ +356℉(0℃ ~ +180℃,High Temp type)
90 to 245 VAC, 48 to 63 Hz. Or 10 to 36VDC
TF card (Max 8G)
RS232&RS485
DN25mm to DN5000mm(A pair of sensors)
Analog output: 4~20mA, max load 750 Ω.
Pulse output: 0~9999Hz, OCT, (min. and max. frequency is
adjustable)
Relay output: SPST, max 1Hz,(1A@125VAC or 2A@30VDC)
±0.5%
±0.5% of reading (for ±1.5ft/s~±40ft/s)
0.1% of measured value
±0.09ft/s ~ ±40ft/s (±0.03m/s ~ ±12m/s)
24 hours service: [phone] Tel: [phone] Fax: [phone]
E-mail: [e-mail] skype: Longruncn Website: www.ultrasonicscn.com
LRF-3300S Ultrasonic Flowmeter
0.5 Clamp-on type

Product size
Transmitter size
Transducer size
24 hours service: [phone] Tel: [phone] Fax: [phone]
E-mail: [e-mail] skype: Longruncn Website: www.ultrasonicscn.com
LRF-3300S Ultrasonic Flowmeter
0.5 Clamp-on type

Product weight
Transmitter weight
Transducer weight
Transmitter weight
Transmitter weight：
3.62kg
Transducer weight：
1.69kg
24 hours service: [phone] Tel: [phone] Fax: [phone]
E-mail: [e-mail] skype: Longruncn Website: www.ultrasonicscn.com
E-mail: [e-mail] skype: Longruncn Website: www.ultrasonicscn.com
LRF-3300S Ultrasonic Flowmeter
0.5 Clamp-on type

Installation site selection
The first condition for ultrasonic flow meter is the pipe must be full of liquid, the
bubbles will greatly influence the accuracy of the measurement, please avoid the
follow installation position:
The suggestion installation area is as following:
A is for upright pipeline, please notice the water direction is from the bottom to top.
B is for horizontal pipeline, the transducers need to be installed inside the C area,
angle for area C, max 120°.
AC
B
C
24 hours service: [phone] Tel: [phone] Fax: [phone]
E-mail: [e-mail] skype: Longruncn Website: www.ultrasonicscn.com
LRF-3300S Ultrasonic Flowmeter
0.5 Clamp-on type

Straight pipe demand
Measuring principle
We suggest avoiding the valve, T-branchpipe and elbows if the condition allow.
Please satisfied the hardest positioninstallation requirements when you face
more than one interfering resource.
Transfer time technical means the ultrasonic signal from the transducer is
transmitted and received through the moving liquid, there will be a difference
between the upstream and downstream transit time, which can be used to
calculate flow and velocity.
Valve
Elb ows
T-branch
≥10×DN ≥5×DN
≥20×DN
≥20×DN
≥15×DN
24 hours service: [phone] Tel: [phone] Fax: [phone]
E-mail: [e-mail] skype: Longruncn Website: www.ultrasonicscn.com
LRF-3300S Ultrasonic Flowmeter
0.5 Clamp-on type

Ordering confirmation
Model Transmitter
LRF-3300S
Ultrasonic flowmeter
Wall mount
Flow range ：±0.01m/s ~ ±12m/s
Accuracy ：±0.5% of the measure value
Repeatability：0.1% of the measure value
Display：240*128 backlit LCD
Power supply：90-250VAC，48-63Hz or 10-36VDC
Output：4-20Ma，OCT，Relay
Communication ：RS232/RS485，Modbus
Code
Code
Code
XXX
Transducer
Temperature sensor
Transducer cable length
Output
1
C1
C2
W1
030
PT1000
XXX
W2
2
OCT，Relay，RS232/485，4-20mA
Standard length 30ft (9m)
Max length to 1000ft (305m)
Pt1000 temperature sensor
Clamp-on, IP68. Operating temperature:
-40 ℉ ~ +176 ℉(-40℃ ~ +80 ℃)
Clamp-on, IP68. Operating temperature:
32 ℉ ~ +356℉(0℃ ~ +180℃)
Insertion, IP68. Operating temperature:
32 ℉ ~ +356℉(0℃ ~ +180℃)
Insertion, IP68. Operating temperature:
-40 ℉ ~ +266 ℉(-40℃ ~ +130 ℃)
OCT，Relay，RS232/485，4-20mA，RTD
Standard model: LRF-3300S - 2 - C1 - 030
Description: Standard ensure clamp-on type ultrasonic flowmeter, OCT, Relay,
RS485, 4-20mA, 30ft cable.
24 hours service: [phone] Tel: [phone] Fax: [phone]
E-mail: [e-mail] skype: Longruncn Website: www.ultrasonicscn.com
LRF-3300S Ultrasonic Flowmeter
0.5 Clamp-on type