Malouf Structures E455 User manual

OWNER’S MANUAL

OWNER’S MANUAL
iii
ELECTRICAL
BEFOREUSE
•CarefullyremovepackagingTakecarenottodamagethebedframeoranyincludedparts
•Carefullyreadandfollowthesetupandinstallationinstructionsincludedwiththeproduct
IMPORTANT: PLEASE READ ALL SAFETY INSTRUCTIONS THOROUGHLY
BEFORE USING THIS PRODUCT. SAVE THESE INSTRUCTIONS. PACEMAKERS
SMALLCHILDRENANDPETS
HOMEUSE/HOSPITALDISCLAIMER
WEIGHTRESTRICTIONS
•Thisproductisforuseonastandardvoltcircuit
•AlwaysuseagroundedelectricalsurgeprotectiondevicewiththisproductThisproductshould
bepluggeddirectlyintothesurgeprotectiondeviceandthesurgeprotectiondeviceshouldbe
pluggeddirectlyintoawalloutlet
•Onlyconnectthisproducttoaproperlygroundedoutlet
•Alwaysunplugthisbedfromtheelectricaloutletbeforecleaningorservicing
•NeveroperatewithadamagedcordorplugKeepthecordawayfromthisproduct’smovingparts
•Keepthecordawayfromheatedsurfaces
•Donotusethisproductoutdoors
•Some pacemakers may detect motion by this product as a false sense of movement or exercise. This may or may
not affect your pacemaker. Talk to a physician to address any concerns.
•Immediately dispose of all packing materials that may pose a suffocation risk.
•Do not allow children or pets to play on or under the bed. Children should not operate this
product without adult supervision.
•This product is designed solely for in-home use and not as a hospital bed. The product has not been tested to
meet hospital standards. Do not use with oxygen or other flammable gasses.
•TherecommendedweightrestrictionsfortheS™EAdjustableBaseareasfollowsallweights
includetheweightofthemattressandbedding
Twinlbs|Fulllbs|TwinXLlbs|Queenlbs|SplitBedslbsperside
•ThisproductwillsupporttherecommendedweightlimitswhenweightisdistributedevenlyacrossthebaseThis
productisnotdesignedtosupportorlithisamountintheheadorfootsectionsaloneConsumersshouldnot
enterorexitthebedwhenanyportionofitisintheraisedpositionDonotsitontheheadorfootsectionswhile
intheraisedpositionExceedingtherecommendedweightrestrictionsorothermisuseofthisproductcould
damagethebedandvoidthewarranty
WARNINGS

OWNER’S MANUAL
iviii
PRODUCT
RATINGS
MOTORRATINGS
POWERRATINGS
FCCCOMPLIANCE
•TheS™EAdjustableBasemotorsarenotdesignedtooperateformorethantwo
continuousminuteswithinanminutetimeperiodExceedingthisratingwillshortenthelifeofthe
motorsandvoidthewarranty
•ThisproductisdesignedtohavenomaintenancerequirementsbytheuserPleasedonotopen
anymotorcompartmentsalterthewiringmodifythebaseorchangetheproductinanywayas
itwillvoidthewarranty
•INPUT:ACV/HzAmp
•OUTPUT:DCVA
•This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device
may not cause harmful interference, and (2) this device must accept any interference received, including interference
that may cause undesired operation.
•OperatesonGHzfrequencytransmitter
•To comply with the FCC RF exposure requirements, no change to the antenna or the device is permitted. Any change
to the antenna or the device could result in the device exceeding the RF exposure requirement and void user’s right
to operate the device.
Foranyquestionsorconcernsregardingthisproductpleasecontact®directly
IMPORTANT: USE THIS PRODUCT ONLY AS DESCRIBED IN THESE
INSTRUCTIONS. DO NOT MODIFY ANY PARTS OR COMPONENTS.

OWNER’S MANUAL
viv
CONTENTS
Overview 






Assembly
Synchronizing Two Bases
Electrical Components and Backup Battery
Test All Functions / Additional Help
Warranty Information
Remote Control

OWNER’S MANUAL
1 2
OVERVIEW
GettoKnowYourProduct
BeforebeginningassemblyoftheS™EAdjustableBaseplease
takeamomenttofamiliarizeyourselfwiththepartsandlocationofcomponents
Seetheadjacentimageforadetailedoverview
Ifanypartsorcomponentsaremissingoraredifferentthanshowninthe
adjacentimagedonotattempttocompletetheassemblyprocessandcontact
customersupport/customerservicemaloufsleepcom
RetainerBar Power Supply Box
Power Cord
() -Inch Legs
(6) End Caps
() Leg Sets Included
with King Size
() -Inch Legs
Wireless Remote Control
USB Ports
Head Motor Foot Motor
Control Box
Sync Cable
(included with Split sizes only)

OWNER’S MANUAL
3 4
ASSEMBLY
Step
Placetheboxintheroomthebedwillbeusedwiththebottomoftheboxfacingup
Carefullyremovepackagingmaterialtakingcarenottopuncturetheboxwithany
sharpobjects
Step
Removethebedbasefromtheboxandsetmattresstopsidedownonthefloor
seeimageARemoveallplasticandziptiesAllcomponentsandpartsarelocated
intheundersideofthebaseRemoveattachedpartsandsetasideinpreparationfor
assemblyseeimageBChecktomakesureallpartshavebeenincludedandarenot
damagedseepageforalistofallpartsandcomponents
Before You Begin
Aminimumoftwopeoplearerequiredtoassemblethisadjustablebase
Openboxonthefloorintheflatpositionbottomfacinguptoavoiddamage
B
A
1 2
King Size Only

6
OWNER’S MANUAL
5
ASSEMBLY
A
C
Step
HandtightenallsixlegssevenforKingsizeintothebedframeuntilsecureNote
thattherearetwolocationoptionsforeachleganoutsideplacementoraninside
placementTightenthelegsinthelocationofyourchoosingmaintainingaconsistent
insideoroutsidelocationthroughoutTakecarenottoovertightenseeimageA
To reachainchheightfromthefloortothetopofthedeckuseainchinch
inchlegassembly
Note:EnsurethebottomofeachleghasanendcapattachedseeimageB
Step
Installthepowercordbyconnectingthecordjacktothereceptacleonthebed
motorseeimageCBesurethecordisconnectedcompletelyandsecurely
MiddleLegonKingSizeOnly
Foot
Head
LegPositions
B

7 8
OWNER’S MANUAL
ASSEMBLY
Step
Withtwotofourpeoplelithebedbythemetalframeandturnitoversothe
mattresstopsideisfacingupseeimageATakecautionnottolithebedwiththe
fabricortousethelegsaspivotpointscausingangledpressureasthismaycause
damageMovethebedtothedesiredlocation
A

OWNER’S MANUAL
9 10
ASSEMBLY A
Step
Toinstallthemattressretainerbarinsertoneendoftheretainerbarinitsrespective
slotuntilitslidesfullyintoplaceseeimageAFlexretainerbartoinserttheotherend
ontheotherside
Step
Plugthepowercordintothewalloutletandrunthetestonpagesofthis
manualYoumaywanttofamiliarizeyourselfwiththeremotecontrolfunctionspages
priortorunningthetest

OWNER’S MANUAL
11 12
REMOTE
CONTROL Overview
AllofthefunctionsofthebedcanbeoperatedwiththeremotecontrolTheremote
controlcomeswithpreprogrammedbuttonsthatwillautomaticallyadjustwhenpressed
oryoucanmanuallycontroladjustmentsusingthearrowbuttonsontheremotecontrol
SeethediagramtotherightseeimageAforacompletelistofremotecontrolfunctions
RemoteControlBatteryInstallation
RemovethebatterycoveronthebacksideoftheremotecontrolInsertthetwoincluded
AAAbatteriesseeimageB
ProgrammableButtons
ZeroGravityandAntiSnorearebothpreprogrammedpositionsthatcanbeadjusted
andsavedtomatchyourpreferenceSimplyadjustyourbedtothedesiredpositionthen
holddowntheFlatbuttonthensimultaneouslypressthepositionbuttonyouwantto
reprogram
A
HeadUp
HeadDown
PresetZeroGravityPosition
orProgrammablePositionA
Flat
PresetAntiSnorePosition
orProgrammablePositionB
FootUp
FootDown
B

REMOTE
CONTROL
PAIRING
13 14
OWNER’S MANUAL
Overview
TheoriginalremotethatcomesintheboxisalreadypairedtothefoundationNofurther
actionisrequiredIntheeventthattheremoteisnotpairedwiththebasebeginby
checkingthefollowing
Step
EnsuretheremotebatteriesarefunctioningReplaceifnecessary
Step
Ensurethepowercordispluggedintoapoweredsource
Step
PressandholdtheHeadUpandFootUpbuttonssimultaneouslyseeimageAThen
alsopressandholdthebluebuttononthecontrolboxcorduntilyouheartwobeeps
seeimageB
Thebluepairingbuttoncanalsobe
usedtolowerthebasetotheflat
positionincaseofanemergency
seebatterybackupsectionon
pages
A
B

OWNER’S MANUAL
15 16
ELECTRICAL
COMPONENT
SETUP
B
A
Overview
Theelectroniccomponentsarepreinstalledandnoassemblyisnecessary
howeversomeinputlocationsareimportantforpropersetupand
functionalityseeimagesAandBtobecomefamiliarwithinputsettingand
partlocations
HeadMotorInput USBInput
SyncCableInputseepages
FootMotorInput USBInput

1817
OWNER’S MANUAL
ELECTRICAL
COMPONENT
SETUP
USBPorts
USBportsarelocatedundertheheadportionofthebedbaseattwolocations
seeimageAToaccesstheUSBportspresstheHeadUpbuttontoraisethe
bedandrevealtheUSBportsOnceyourdeviceispluggedintotheUSBport
youmayloweroradjustthebedtoyourpreference
NOTE:USBportsareforchargingoutputonly
B
A

OWNER’S MANUAL
19 20
BACKUP
BATTERY
Overview
Important: The backup battery is only to be used in case of a power outage.
Batteries are not to be used for normal operation of the bed. The backup
battery will not support repeated movement for an extended period of time.
BackupBatteryUse
UsetwoVbatteriesonlynotincludedIfapoweroutageoccursinstallthe
Vbatteriesintothepowersupplytoallowtemporarypowertothebasesee
imageA
InstallingBatteries
Unplugthepowercordfromtheoutletandremovethecoverfromthe
compartmentontheundersideofthepowersupplyseeimageBPlacetwo
Vbatteriesinsideclosethecoverandplugthepowercordbackintothewall
outletAerpowerisrestoredunplugpowercordremovethebatteries
thenplugthepowercordbackintothewallfornormaluse
AB

21 22
SYNCHRONIZING
TWOBASES
(for Twin XL and
split sizes only)
OWNER’S MANUAL
A
B
OPTIONWIRELESS
PairSingleRemotetoOperate
TwoBasesSimultaneously
Step
EnsurebothbasesAandBare
pluggedintoapowersource
Step
MakesureRemoteAwasalready
pairedtoBaseAandRemoteBwas
pairedtoBaseBIfnotpairthemby
followingtheinstructionsfoundon
pages
Step
Aerremotesarepairedtotheir
respectivebasespairRemoteAto
BaseBseepagesBothbases
cannowbeoperatedbyRemoteA

23 24
SYNCHRONIZING
TWOBASES
(for Twin XL and
split sizes only)
OWNER’S MANUAL
OPTIONWIRED
Step
PlacetwoTwinXLorsplitsizeadjustablebasesnexttoeachotherindesired
locationPluginSyncCableseeimageAtothecontrolboxofeachbaseinto
the“Program”inputseeimageBonthecontrolbox
Step
Withtheconnectingcableinstalleduseremoteandtestallfunctionsofthebed
baseseepagesIfremotesarenotworkingtroubleshoottheproblemby
followingtheinstructionsonpages
Thetwobasesarenowconnectedandreadyfornormaluse
BA

OWNER’S MANUAL
25 26
TEST ALL
FUNCTIONS
Overview
Toensurepropersetupuseremoteandtestallfunctionsforseconds
Important: Always return the base to the flat position when switching
between preset options.
HeadUp
ZeroGravity
Flat
AntiSnore
HeadDown
FootUp
FootDown

OWNER’S MANUAL
27 28
ADDITIONAL
HELP
Ifoneormorefunctionsofthebedhavestoppedworking
Checkunderthebedbasetoverifythewiredconnectionsaresecureandthere
arenocordsorbeddingobstructingthemovementofthebase
Nofunctionsofthebedwilloperate
Checktoensurethepowercordisproperlyconnected
Unplugthebaseforhourtoresettheelectroniccomponents
Plugbaseintoadifferentelectricaloutletortestcurrentoutletwithanotherworking
applianceAgroundedelectricalsurgeprotectorisrecommendedwithuseofthisproduct
Forfurtherassistancecontactusat/customerservicemaloufsleepcom
Theremotecontrolwon’toperatethebedfunctions
MakesurethebatteriesareinstalledcorrectlyorinstalltwonewAAAbatteriesinto
theremotecontrolEnsuretheremotecontrolissyncedwiththecontrolboxonthe
bedseepages
Serial Number:
NOTES:

29 30
WHAT IS COVERED
Thiswarrantycoversanydefectsinmaterialsorworkmanshipundertheconditionsandexcep
tionsstatedbelow
HOW LONG COVERAGE LASTS
Thiswarrantyrunsforuptoyearsfromthedateofpurchaseaccordingtothetierssetforth
below
WHAT MALOUF® WILL DO
YEAR 1:
Warrantycoversdefectsintheworkmanshipormaterialsforaperiodofyearfromthedateof
purchaseMalouf®willsendreplacementpartsforanydefectiveparttotheoriginalpurchaser
ONLYandMalouf®willpayallauthorizedlaborandtransportationcostsassociatedwiththe
repairorreplacementofanypartstoresidentswithinthecontinentalUS
YEARS 2 – 5:
DuringtheyearsfromthedateofpurchaseMalouf®willofferreplacementpartsfor
anydefectiveparttothepurchaserThepurchasershallbearallservicetransportation
laborandshippingcostsassociatedwiththerepairorreplacementofthedefectiveparts
The foregoing warranty shall be exclusive and in lieu of any other warranty, express or implied, including warranties of
merchantability and fitness for a particular purpose and all other warranties otherwise arising by operation of law, course of
dealing, custom, trade, or otherwise. Malouf® shall not be liable for any consequential damages or losses arising from the
purchase, installation and/or use of this product.
YEARS 6 – 20:
DuringtheyearsMalouf®willofferreplacementpartsforanymechanicalbedpartexcluding
electronicselectricalcomponentsdrivemotorsandmassagemotorsPurchasershallpay/thofthe
replacementcostofthedefectivepartmultipliedbythenumberofyearssinceyearsaerthewarranty
commencementdateandMalouf®shallbeartheremainderofthecostofthereplacementpartThepurchaser
shallbearallservicetransportationlaborandshippingcostsassociatedwiththerepairorreplacementofthe
defectiveparts
HOW TO GET SERVICE
EmailwarrantymaloufsleepcomtosubmityourwarrantyclaimPleasekeepyourreceiptsothatwemaypro
cessyourwarrantyrequest
HOW STATE LAW APPLIES
Thiswarrantygivesyouspecificlegalrightsandyoumayalsohaveotherrightswhichvaryfromstatetostate
Foranyquestionsorconcernsregardingthisproductpleasecontact®directly
YEAR
LIMITED
WARRANTY