Multiplex FreshBlender User manual

Instruction Sheet Subject: FreshBlender Caster Brake Retrofit
SCOPE: ALL MULTIPLEX FRESHBLENDER UNITS
1 of 3
 DocumentNumber:020008727 April14,2021
MULTIPLEX
645 PARK EAST BLVD SUITE 5, NEW ALBANY, IN 47150
844-724-CARE
WWW.MULTIPLEXBEVERAGE.COM
Refreshing the Experience
TwopeoplearerequiredtocompletethisCasterBrake
Retrofit.
TOOLS REQUIRED
• Clean5-gallonbucket
• FreshBlenderDoorKey
• Six(6)Boards,2”x4”boardscutto2’lengths(5cmx
10cmcutto61cmlengths)
• 14mmWrench
• 14mmSocketandDriverorCordlessImpactDrill
PARTS REQUIRED
• BlueLocTite
• 020008731CasterBrakeRetrofitKit(kitpartslisted
below)
PART NO. DESCRIPTION QTY
020008728 BrakeHardwareSet 2
020008727 Instructions 1
BrakeHardwareshownbelow(doesnotincludewheelfork):
NUT
BRAKE BRACKET
BRAKE PEDAL
WAVE WASHER
BOLT
nWarning
NeverleaveunitunattendedduringCasterBrakeRetrofit.
nWarning
Unitisheavy.DoNOTattempttoliftbyhand.
,Caution
Do NOT use a pry bar, crowbar or other sharp ended
objecttoleverageunitup.Sharpobjectswilldamageunit
refrigerationsystem.
REMOVE OLD HARDWARE
1. Pullunit12”(31cm)awayfromwall.
2. Place5-gallon(20liter)bucketunderdrain.
3. Unlockdoor.
4. Openlowerrefrigerationdoor.
5. Stackthree(3)2x4’s(5cmx10cm)flatonthefloor
perpendiculartotherightsideofunit.Positionthese
boards1”(2.5cm)behindtherearofcaster.Thesethree
(3)boardswillbeusedtosupporttheunit.
6. Stacktwo(2)boards6”(15cm)awayandparallelto
frontofunit.Theseboardswillbeusedasafulcrumto
liftfrontofunit.
7. Slideone(1)board3”(8cm)underfrontofunitandlay
perpendicularontopoftwo(2)boardslayinginfront
ofunit.Thisboardwillbeusedasalevertoliftfrontof
unit.
8. Makesurelowerrefrigerationdoorisopen.Doormust
beopentopreventdamagetodoorandunit.
9. Onepersonshouldcarefullysteponendofleverwhile
secondpersonslidesthethree(3)boardstackunder
unit.
10.Verifythethree(3)boardstackisstableandexcessive
lengthofboardscanbeseenonbothsidesofunit.

2 of 3
DocumentNumber:020008727 April14,2021
Subject:FreshBlenderCasterBrakeRetrofit
11.Gentlyreleasepressurefromleveruntilunitrestson
three(3)boardstack.Removeandsetasideleverand
fulcrumboards.Closelowerrefrigerationdoor.
12.Testunitforstability.
13.Removeoldhardware.
A. Placewrenchoncasterboltandplacesocketon
casternut.
B. Turnsockettoremovenutwhileusingwrenchto
holdbolt.Removebolt,nutandwheel.
INSTALL NEW BRAKE
14.PlaceWaveWasherontoBolt.
PlaceBrakeBracketoverwheelfork.VerifytabonBrake
Bracketisinsertedintoslotonwheelfork.
15.PlaceBrakePedalontoBrakeBracket.
16.Insertoldcasterwheelbetweenforksandpressboltinto
assemblyasshownbelow.

3 of 3
DocumentNumber:020008727 April14,2021
Subject:FreshBlenderCasterBrakeRetrofit
17.Place1-2dropsofBlueLocTiteontonutthenthreadnut
ontobolt.
18.Placewrenchoncasterboltandplacesocketoncaster
nut.Turnsockettoinstallnutwhileusingwrenchto
holdbolt.EndofBoltshouldbeflushwithendofnut.
DoNOTovertighten.WithBrakePedalinOFFposition,
wheelshouldturn.
19.Repeatsteps13-18forinstallingbrakehardwarefor
otherfrontwheel.
20.Stacktwo(2)boards6”(2.4cm)awayandparallelto
frontofunit.Theseboardswillbeusedasafulcrumto
liftfrontofunit.
21.Slideone(1)board3”(1.2cm)underfrontofunitand
layperpendicularontopoftwo(2)boardslayinginfront
ofunit.Thisboardwillbeusedasalevertoliftfrontof
unit.
22.Openlowerrefrigerationdoor.Doormustbeopento
preventdamagetodoorandunit.
23.Onepersonshouldcarefullysteponendofleverwhile
secondpersonslidesthethree(3)boardstackoutfrom
underunit.
24.Gentlylowerunitandremoveboards.
25.Testeachnewcasterbrakeassembly.Adjustif
necessary.
26.Closelowerrefrigerationdoorandlockunit.
27.Removedrainbucket.
28.Pushunitintoplace.
29.Connectdrain.