Muskoka Muskoka MEF2822CWG User manual

Assembly Instructions
Instructions d'assemblage
Instrucciones de montaje
MEF2822CWG
REV04
11
YEAR
ANNÉE
AÑO
I
N
H
O
M
E
W
A
R
R
A
N
T
Y
G
A
R
A
N
T
I
E
À
L
A
M
A
I
S
O
N
G
A
R
A
N
T
Í
A
E
N
S
U
P
R
O
P
I
A
C
A
S
A
save These InsTrucTIons
conserver ces InsTrucTIons
guarde esTas InsTruccIones
eLeganT eLecTrIc FIrePLace
with corner option
FoYer ÉLÉganT
avec coin facultatif
chIMenea eLeganTe
con opción para poner en rincon

BOTTOM SUPPORTER UPRIGHT SUPPORTER
TIPS FOR THE ASSEMBLY OF YOUR NEW MANTEL
 • Beforeyoubeginassembly,locatetheinstructionsandhardware.Takeoutallthepartsand
  comparethemtothediagramsbelow.Besureyouhaveallthepartsandcanidentifythem.
 • Ahelpinghandisalwaysgood.Assembleyourmantelwithanadultassistantifpossible.Somepiecesareheavy 
  andwillneedtobeheldbyahelper.Assemblytimewilltakeapproximately30-60minutes.
1
BOTTOM SUPPORTER UPRIGHT SUPPORTER
TOP 1PC
ZZ.2822CWG.08 BASE 1PC
ZZ.2822CWG.01
FIREBOX SHELF 1PC
ZZ.2822CWG.11
UPPER FACInG
PAnEL 1PC
ZZ.2822CWG.06
AnTI-TIP DEVICE 2 SETSWInGnUT AnD LOCK WASHER
2PCS 2PCS 4PCS 4PCS 4PCS
CORnER ATTACHMEnT 1PC
ZZ.2822CWG.08-1
LEFT FROnT
PAnEL 1PC
ZZ.2822CWG.05
InSIDE
VIEW
OUTSIDE
VIEW
RIGHT SIDE
PAnEL 1PC
ZZ.2822CWG.02
CORnER BOTTOM
SUPPORT 1PC
ZZ.2822CWG.09
CORnER UPRIGHT
SUPPORT 1PC
ZZ.2822CWG.10
LEFT SIDE
PAnEL 1PC
ZZ.2822CWG.03
RIGHT FROnT
PAnEL 1PC
ZZ.2822CWG.04
LOWER
FACInG PAnEL 1PC
ZZ.2822CWG.07
20PCS 20PCS
InCLUDES 1 SPARE

GET READY TO START
Beforeassembly,usescissorstounwrapthepartsfromthepackaging.DONOTuse
aboxcutterorexacto-knifeasyoumaycutintothemantelpiecesinsidetheboxand
damagethenish.Checkforthehardwarebagwhichisredandlocatedinsidethe
packaging,tapedtothetopbox.BesureyouDONOTdiscardanypieces.
Step 1
Locatethebaseandplaceitontheoor.Donotputitupagainstthewallatthispoint
intheassembly,asyouneedtogetinbehindthemanteltoinsertseveralwingnuts,lock
washersandreboxscrews.
Step 2
Locatetheleftsidepanelandtheleftfrontpanel.Facingthefrontofthebase,takethe
leftsidepanel,positioningitsotheholesintheblocksonthebottomlineupwiththe
holesonthebase.Positiontheleftfrontpanelnexttotheleftsidepanel,liningupthe
holesintheblockswiththeholesonthebase.Attachtheleftfrontandsidepanelto
thebasebyinsertingandtightening1wingnutand1lockwashertoeachpiece.Attach
theleftsideandfrontpanelstogetherbyinsertingandtightening3wingnutsand3lock
washers.
Step 3
RepeatStep2,butwiththerightsidepanelandtherightfrontpanel.
Step 4
Locatethelowerfacingpanelandthereboxshelf.Attachthelowerfacingpanelby
placingthegranitesidetothefrontthenlineuptheholesoneachsideandinsert1
wingnutand1lockwasherintoeach.Placethereboxshelfinbehind,rightupagainst
thelowerfacingpanel.
Step 5
Locatethegraniteupperfacingpanelthatwillbeattachedtotheleftandrightlegsand
willsitabovetherebox.Positionthispanelwiththegranitesidefacingthefrontof
themantel.Lineuptheholesoneachsideandinsertandtighten1wingnutand1lock
washeroneachside.
Step 6
Getyourassistantandlocatethetopofyourmantel.Thistopisveryheavy.Itwilltake
2peopletoliftandpositionitinplace.Ensurethetopgoesoverthepositioningguide
locatedontheheader.Thetopmustgooverthisguidetobepositionedcorrectly.Lineup
theholesonthetopofthemantel,insertandtighten5wingnutsandlockwashers.
2
Step 1
Step 2
Step 4
Step 5
Step 6

Step 7
Ifyouareusingthismantelinacornerapplication,locatethetriangularpieceofwood
whichattachestothemanteltocreatethecornerunit.Youmustattachthispiecefor
allcornerapplications.Slidethecornerbottomsupportintothechannellocatedatthe
middleofthebackofthehearthbase.Placethetopcornerattachmentontheoor
upsidedown.Protectitfromdamage.Attachthecorneruprightsupporttothecorner
attachmentbylininguptheholeinthecorneruprightwithholeinthecornertopinsert
with1nutand1lockwasher.Simplytakethetriangleandslidethebracketswiththe
holesontothepinswhicharealreadyattachedtothemantel.Oncethetriangleis
attached,pushitupsoitislevelwiththemantelandlockitintoplace.Tolockitinto
placesimplyturnthehorizontalwoodenblocksattachedtotheundersideofthemantel
intoaverticalpositiontosupporttheweightofthecornertriangle.Nowattachthecorner
bottomsupporttothecorneruprightsupportbyinsertandtightening1wingand1lock
washer.
Step 8
Takeyourelectricreboxoutofitspackagingandpositionitbetweenthe2legsofthe
mantel.Onceyouareclosetothewall,plugthereboxintothenearestoutlet.
Thereboxcomeswith3metalbracketsand20blackscrews.Thesemetalbrackets
mustbeattachedtoboththesidesofthereboxandthemanteltoensurethatyour
reboxdoesnotmovearoundasyouuseit.2ofthebracketshave2largeholesonone
side.Theselargeholeslineupwith2screwsonthesideoftherebox.Theotherscrews
providedmustbeinsertedintotheholesattheotherendofthebracketandintothe
rebox.Theothersideofeachbracketattachestothemantel.
The3rdbrackethasnoholeson1side.Thatsideshouldgoupagainstthereboxtop
butshouldnotbeattachedastheheatersitsrightunderneaththebracket.Onlythe
mantelsideshouldbeattached.
Ifyouhaveanyquestionsaboutthereboxpleasereferencetheinstallationinstructions
thatcomewiththerebox.PleasereferencetheQuickTipssectionofthatinstruction
manual.
NOTE: Some fireboxes come with pre-attached trims
Step 9
Youarenowreadytopositionyourmantelagainstthewall.Thissteprequires2people
tomovetheunit.
Anti-tipping device
Atthispointyoumustattachtheanti-tippingdevicetoyourmantelandyourwall.This
deviceisasafetyfeaturethatwillpreventyourmantelfromtippingoverifaweightis
appliedwhichcanunbalancetheunit.
Step 7
Step 8
Step 9
3

WARRANTY
GreenwayHomeProductsispleasedtoofferin-homewarrantyrepairs.PleaserefertoyourFireboxUseandCareGuideforwarranty
informationonyourFirebox.
DO NOT RETURN THIS PRODUCT TO THE STORE:
PleasecontactCustomerServiceat:1-866-253-0447
MondaytoThursdayfrom8:30AMto5:00PM(EST),Fridayfrom8:30AMto4:00PM(EST)
Web:www.greenwayhp.com
Email:[email protected]
Canada:  400SouthgateDr.,Guelph,Ontario,Canada,N1G4P5
USA:   6507FaireldDr.,Northwood,Ohio,USA,43619
Limited Warranty Definitions:
GreenwayHomeProducts:
(Greenway)  Manufacturer.
Mantel:  MantelmanufacturedbyGreenwayHomeProducts.
Purchaser:  PurchaseroftheMantel
Distributor:  FacilityauthorizedtosellGreenwayHomeProducts.
WarrantyCard  GreenwayHomeProductsLimitedWarrantyRegistrationCardidentifyingthePurchaserandproductmodel.
Greenway Limited Warranty:
GreenwaywarrantstothePurchaserthattheMantelisfreefromdefectsinmaterialandworkmanship,undernormaluseandservice,
for1year(1yearlimitedparts)fromthedateofpurchase.
AllwarrantyrepairsmustbepreauthorizedbyGreenwayHomeProducts.Greenwaywill,atits’option,replaceorrepairfreeofcharge
anydefectivepart,whichthePurchasershallnotifytheirDistributororGreenwayHomeProductswithinthewarrantyperiod.The
obligationofGreenwayHomeProductsunderthiswarranty,isexpresslylimitedtosuchreplacementorrepairs.
The provisions of this limited warranty shall not apply to the following:
1. Accidents.
2. Unauthorizedrepairsoralterations.
3. Normalmaintenance.
4. Changesmadetootherunitsmanufacturedafterthismantelwasmanufactured.
5. Incidentaldamagescausedbyfailureofthemantelsuchasinconvenienceorlossofuse.
6. Improperinstallation.
Theprovisionsofthislimitedwarrantyshallnotapplytodeteriorationduetowearandexposurebeyondthefollowinglimitations:
1. For180daysfromthedateofpurchaseforexteriornishedsurfaces.
Duetothepropertiesofnaturalwood,GreenwayHomeProductsmakesnowarrantyagainstmineralingofwoodcomponents.
Greenway Limited Warranty is void unless the following conditions are adhered to:
1. WarrantyregistrationmustbecompletedandreturnedtoaGreenwayHomeProducts.
2. AllwarrantyrepairsmustbepreauthorizedbyaGreenwayrepairfacility.
3. Greenwayreservestherighttoinspectdefectivepartsthathavebeenreplacedunderwarranty.Dealerisexpectedtohold
  defectivepartsfor60days.
4. Onlypartsandaccessoriesandothermaterial,availablethroughGreenwayHomeProductsaretobeusedintheperformance
  ofwarrantyservice.
5. Purchasersareresponsibleforpresenting/notifyingtheirDistributorassoonaproblemexists.Thewarrantyrepairsshouldbe
  completedinareasonableamountoftimefromthedateofauthorization.Nottoexceed30dayspastnotication.
Thislimitedwarrantyisexpresslyinlieuofanyotherexpressedorimpliedwarranty,includinganyimpliedwarrantyormerchantability
ortnessforaparticularpurposeandofanyobligationsorliabilitiesonGreenwayHomeProductswhichneitherassumesnor
authorizesanyotherpersontoassumeforitanyotherliabilityinconnectionwiththeMantel
manufacturedbyit.
Thewarrantyisnullandvoidifusedincommercialorindustrialapplications.
4