Nordson Rhino SD User manual

RhinorSD Single Amber Lens 24 VDC
Light Tower for Electric Changeover Controls
Instruction Sheet: 1047114A
E2004 Nordson Corporation Issued 2/04
Description
See Figure 1. The light tower (1) mounts to Rhino SD
electric changeover controls (2). The light tower has a
single amber lens that illuminates when a fault occurs
during system operation.
24 in.
(61 cm)
Figure 1 Typical Light Tower
Repair
Use the following procedures to replace a light tower.
WARNING
SAllow only qualified personnel to perform the
following tasks. Follow the safety
instructions in this document and all other
related documentation.
SDisconnect and lock out power to the system
before performing repairs.
Remove the Light Tower
1. See Figure 2. Note the orientation of the hose
assembly (2, 3, 4A) and the upper clamp assembly
to the light tower (1).
2. Loosen the screws (3) to remove the weld plate (5)
and clamp body half (4B).
3. Disconnect the cable (6) from the light tower (1).
4. Remove the screws (3), washers (8), cover plate (9),
clamp body halves (4A, 4B), and weld plate (5) that
secure the light tower (1) to the control plate (7).
Install the New Light Tower
1. Install the new light tower in reverse order of the
removal procedure.
2. See Figure 1. Make sure that the distance between
the upper clamp body and the control plate
is 24 in. (61 cm).
3. See Figure 2. Make sure that the upper clamp
assembly and hose assembly (2) are properly
orientated to the light tower (1).
6
5
7
4A
4B
9
1
2
5
3
4A
4B
UPPER CLAMP
ASSEMBLY
TYPICAL LOWER
CLAMPASSEMBLY
4A
4B
38
38
Figure 2 Replacing a Light Tower

Rhino SD Single Amber Lens 24 VDC Light Tower for Electric Changover Controls
2
Instruction Sheet: 1047114A E2004 Nordson Corporation Issued 2/04
Parts
See Figure 3 and refer to the following parts lists.
12
3
3
5
6
6
6
4
4
4
4
7
7
8
9
10
Figure 3 Parts
Item Part Description Qty Note
— 1043658 Assembly,
light tower,
42-in., 24 vdc
1
1 1044428 SLight tower,
42-in., amber 1
2 1043384 SD-ring 1
3 983141 SWasher, lock,
internal 1/42
4 981557 SScrew, socket,
1/4-20 x 1.75 6
5 1043385 SClamp, cable 2
6 1043413 SClamp, pipe 3
7 983410 SWasher, flat, M6 4
8 1044427 SCable assembly,
18 AWG, 300 v 1
9 1046726 SLabel, cable 2
10 939110 SStrap, cable,
0.875 diameter 2
1
2
3
4
N/C
N/C
Common –
Output +
Blue
Black
LIGHT ASSEMBLYRECEPTACLE
1
2
3
4
5
C
Figure 4 Wiring Diagram
Original copyright date 2004. Nordson, the Nordson logo, and Rhino are registered trademarks of Nordson Corporation.