Outdoor GreatRoom Company CF-1242AU-N User manual

Page | 1 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
CF-1242AU
User Ma ual for: CF-1242AU-N, CF-1242AU-LP
CAUTION
DO NOT DISCARD THIS MANUAL
•Important operating and
maintenance instructions
included.
•Read, understand, and
ollow these instructions
or sa e installation and
operation.
WARNING
WARNING
I the in ormation in these instructions
is not ollowed exactly, a ire or
explosion may result causing property
damage, personal injury, or loss o li e.
•DO NOT USE OR STORE FLAMMABLE MATERIALS
NEAR THIS APPLIANCE.
•DO NOT SPRAY AEROSOLS IN THE VICINITY OF THIS
APPLIANCE
•What to do i you smell gas:
Do ot try to light a y applia ce
Do ot touch a y electrical switch. Do ot use
a y pho e i your buildi g.
Immediately call your gas supplier from a
eighbor’s pho e. Follow the gas supplier’s
I structio s.
If you ca ot reach your gas supplier, call the fire
departme t.
•I stallatio a d service must be performed by authorized
perso el.
HOT! DO NOT TOUCH.
SEVERE BURNS MAY RESULT.
CLOTHING IGNITION MAY RESULT.
Glass a d other surfaces are hot duri g
operatio a d cool-dow .
•Keep childre away.
•CAREFULLY SUPERVISE childre ear this
applia ce.
•Alert childre a d adults to hazards of high
temperatures.
•DO NOT PLACE ARTICLES ON OR AGAINST THIS
APPLIANCE.
•PRIMARILY A DECORATIVE APPLIANCE- NOT
CERTIFIED AS A SPACE HEATER
WARNING
For outdoor use only
WARNING
It is imperative the burner be kept clean. Keep
covered when not in use. Do not operate in rainy
conditions. Optional glass burner cover available or
purchase
WARNING
Improper i stallatio , adjustme t, alteratio , service, or
mai te a ce ca cause i jury or property damage. DO NOT
MODIFY THIS APPLIANCE. Read the i stallatio a d
mai te a ce i structio s thoroughly before i stalli g or
servici g this equipme t.
THE GUARD IS FITTED TO THIS APPLIANCE TO
REDUCE THE RISK OF FIRE OR INJURY FROM
BURNS AND NO PART OF IT SHOULD BE REMOVED

Page | 2 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
CF
-
1242
AU
Outdoor Gas Fire Pit Bur er
Certificatio #:
Gas Type
:
LPG:
NAT. GAS:
Ma ufacturer
The Outdoor GreatRoom
Compa y LLLC 2015
2015 Silver Bell Rd
Eaga MN USA
55122
Gas i put
76.0
MJ/h
76.0
MJ/h
I jector size
2.5
mm
6.3mm
I let
Pressure
2.75
kPa
1.13
kPa
To be i stalled by a
authorized perso i
accorda ce to applia ce
i stallatio i structio s.
Test poi t pressure
1.75
kPa
.5 kPa
IAPMO
-
R&T OCEANA
Approval No:
GMK10110
Approval No: code
AS4558 &
AS4565
Notes: Automatic co trols/ battery powered fire pit to be i stalled a
d used
outdoors o ly i a well-ve tilated area.
Serial #
Date of MFR:
Read this manual be ore installing or operating this appliance.
Please retain this owner’s manual or uture re erence.
Congratulations
Co gratulatio s o selecti g a Outdoor GreatRoom Compa y decorative gas applia ce. The fire pit bur er you
have selected is desig ed to provide the utmost i safety, reliability, a d efficie cy.
As the ow er of a Outdoor GreatRoom Compa y fire pit, you’ll wa t to read a d carefully follow all of the
i structio s co tai ed i this ow er’s ma ual. Pay special atte tio to all cautio s a d war i gs.
This ow er’s ma ual should be retai ed for future refere ce. We suggest you keep it with other importa t
docume ts a d product ma uals.
This i formatio co tai ed i this ow er’s ma ual applies to the CF-1242AU o ly.
Your ew fire pit will give you years of durable use a d trouble-free e joyme t.
Listing Label In ormation/Location
The model i formatio regardi g your specific applia ce ca be fou d o the rati g plate attached to your
bur er via a metal chai . See the sample rati g plate below for locatio s of specificatio s.
WARNING:
All gas supp
lies must be hard
-
piped to the fire pit. I situatio s where liquid
propa e is used, the fuel storage locatio must be further tha 1 meter from the fire pit.
Never
store fuel i side fire pit.

Page | 3 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
‘
Table of Co te ts
1. Listi g a d Code Approvals
a. Applia ce certificatio
b. Specificatio s
2. Getti g Started
a. Desig a d i stallatio co sideratio s
b. Tools a d supplies required
c. I spectio of applia ce a d compo e ts
3. Frami g Cleara ces
4. Applia ce setup
a. Bur er assembly
b. Glass i stallatio
5. Gas hookup a d i formatio
a. Fuel
b. Gas pressure
c. Gas co ectio
d. LP gas setup
e. Natural gas setup
6. Lighti g a d Operatio
7. Troubleshooti g
8. Service a d Mai te a ce
9. Refere ce Materials
a. Service Parts List
b. Dime sio al I formatio
c. Checki g Test Poi t Pressure
d. Wiri g Diagram
e. Limited O e Year Warra ty
CF-1242AU-N
•305mm x 1067 bur er assembly
•Natural Gas Regulator
•6.3 mm I jector (NG)
•3 bags of decorative fire glass
•Flexible metal gas li e
•Ow er’s Ma ual
•Glass Guard*
What’s i cluded…
CF-1242AU-LP
•305mm x 1067 bur er assembly
•2.5mm I jector( Home LP)
•3 bags of decorative fire glass
•Flexible metal gas li e
•Ow er’s ma ual
•Glass Guard kit*
* The Glass Guard fitted to this applia ce is to reduce the risk of fire or i jury from bur s a d o part of it
should be removed.

Page | 4 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
1 Listing and Code
A. Appliance Certi ication B. Speci ications
MODEL: Crystal Fire – CF-1242AU-N, CF-1242AU-LP
TYPE: Decorative Gas-Fired Outdoor Fireplace
Bur er
STANDARD: AS4558 & AS4565
Crystal fire burner has been tested in accordance
with IAS requirements for Outdoor Gas Fireplaces,
AS4558 & AS4565 and operation as described in
these installation and operating instructions.
The installation must conform to AS/NZ5601.1 a d
local codes.
Model
Injector Size
LP
NG
CF
-
1242
AU
-
N/LP
2.5mm
Max i put
MJ
76 MJ 76 MJ
6.3mm

Page | 5 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
2 Getting Started
This applia ce is a Decorative Gas Applia ce for
OUTDOOR USE ONLY a d MUST NOT be used
for cooki g.
Build or positio the CF-1242AU bur er system o
a flat a d stable surface i a outdoor locatio such
as a patio or deck. This locatio must be adjace t to
the gas supply li e or LP gas supply. DO NOT
locate the applia ce where it will get excessively
wet or submerged i water.
A. Design and Installation Considerations
Whe pla i g a applia ce i stallatio , it’s ecessary to
determi e the followi g i formatio before i stalli g:
• Where will the applia ce be i stalled? See section 3
• Gas supply pipi g. See section 5
• Frami g a d fi ishi g details. See section 3
B. Tools and Supplies Required
Before begi i g the i stallatio , be sure that the
followi g tools a d supplies are at ha d.
• Gloves
• Safety Glasses
• Phillips screwdriver
• No -corrosive leak-check solutio
• Wre ches
WARNING
The Outdoor GreatRoom Compa y
disclaims a y respo sibility for, a d
the warra ty will be voided by, the
followi g actio s:
•
I stallatio a d use of a y damaged
compo e ts.
• Modificatio of the bur er assembly
• I stallatio other tha as i structed
by the Outdoor GreatRoom
Compa y.
Any such action may cause a ire hazard
WARNING
Do NOT use this applia ce if a y part of it has
bee u derwater. Have a authorized service
tech icia i spect the applia ce a d replace
a y part of the co trol system a d a y gas
co trol which has bee u derwater.
CAUTION
Sharp Edges
Wear protective gloves a d safety glasses
duri g i stallatio .
WARNING
Do ot bur solid fuels i this gas applia ce
C. Inspect the Appliance and Components
WARNING
I spect applia ce a d compo e ts for
damage. Damaged parts may impair safe
operatio .
• Do NOT i stall damaged, i complete,
or substitute compo e ts
Report damaged parts to your dealer.
WARNING
Asphyxiation Risk
• This gas applia ce is for outdoor use i a
well-ve tilated space.
• This u it must ot be i stalled i side a
e closed structure or u ve ted applia ce
•
Carefully remove all bur er
compo e ts from packagi g.
• Read all i structio s before begi i g
i stallatio . Follow these i structio s
carefully duri g i stallatio to e sure
maximum safety a d be efit.

Page | 6 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
Clearances above the top burner sur ace
3 Framing and Clearances
Note:
• Illustratio s reflect typical i stallatio s
a d are FOR DESIGN PURPOSES ONLY.
• Illustratio s/diagrams are ot draw to
scale.
• Actual i stallatio may vary due to
i dividual desig prefere ce.
• THIS APPLIANCE SHALL NOT BE
INSTALLED OR USED INDOORS
Fire Risk
Provide adequate cleara ce:
• Arou d air ope i gs
• For service access.
Locate applia ce away from traffic areas
WARNING
1.8M to overhang from
top of metal bowl.
.6M
.6M
1.8M
If you are ot usi g a
Outdoor GreatRoom
Compa y table with
this bur er, be sure to
mou t to a o -
combustible surface
mai tai i g at least
.2M to combustible
surfaces a d frami g
below the surface of
bur er.
.2M
.2M
.2M
.2M
.2M
BURNER
Walls
Mi imum cleara ce to side
combustibles- 500mm
Mi imum cleara ce to ceili g
combustibles- 1375mm
All materials withi the
cleara ce areas must be
o combustible a d
structurally sou d.
Surrounding areas allowed:
Four sided room with no ceiling and at least 10 meters square
Two sided room with ceiling, two sides open 50%
Three sided room 25% open with ceiling and 30% of the three side wall
unobstructed.
750mm above grou d
Glass Guard
(required)

Page | 7 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
DIAGRAMMATICAL REPRESENTATIONS OF OUTDOOR AREAS.
The following figures are diagrammatical representations of outdoor areas as
described in the definition Clause 1.2.49. Rectangular areas have been used
in these figures – the same principles apply to any other shaped area.
This applia ce shall o ly be used i a outdoor area, a d shall ot be used i a buildi g,
garage, or a y other e closed area.
This applia ce shall o ly be used i a above grou d ope
-
air situatio with atural
ve tilatio , without stag a t areas, where gas leakage a d products of combustio are
rapidly dispersed by wi d a d atural co vectio .

Page | 8 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
A y e closure i which the applia ce is used shall comply with o e of the followi g:
A y e closure with walls o all sides, but at least o e perma e t ope i g at grou d level a d o
overhead cover.
Withi a partial e closure that i cludes a overhead cover a d o more tha two walls.
Withi a partial e closure that i cludes a overhead cover a d more tha two walls, the followi g shall
apply:
•At least 25% of the total wall area is completely ope a d
•At least 30% of the remai i g wall area is ope a d u restricted.
I the case of balco ies, at least 20% of the total wall area shall be a remai ope a d u restricted.

Page | 9 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15

Page | 10 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
4 Setting up your Burner
A. Burner Assembly
• Check for damage. Do ot use damaged compo e ts.
• The bur er must be replaced prior to the applia ce be-
i g put i to operatio if it is evide t that the bur er is
damaged. The replaceme t bur er assembly specified
by the ma ufacturer.
• Positio the assembly i the desired locatio . This loca-
tio must be adjace t to the gas supply li e. You must
have easy access to the gas valve co trol k ob after it
is i stalled a d co ected to the gas supply.
• E sure that the perimeter of the bur er is eve ly
supported a d stable prior to i stallatio
LP Gas Models
• Make sure the valve is tur ed completely off
before i stalli g.
• LP i stallatio s are to be hard-plumbed usi g
rigid pipi g only.
B. Glass Beads Installation
Spread glass out eve ly over bur er area. Use all glass
provided for best effect. Keep glass clear of spark to
avoid accide tal blockage of gas flow.
Note:
A perce tage of glass beads may arrive split i half.
This is ormal. Additio al beads may split after use.
This is also ormal due to the physical properties of
glass.
DO NOT BURN WITHOUT GLASS
BEADS
C. Glass Guard
A protective glass guard is provided with your
bur er. This protects the flame from wi d.
I stallatio i structio s are provided separate from
this user ma ual.
The supplied Guard is fitted for this
applia ce a d must be secured usi g the
provided faste ers arou d the bur er a d
must be i positio at all times duri g
operatio . The guard is for protectio
agai st i jury from bur s or fire a d must
ot be removed.
DO NOT BURN WITHOUT
GLASS GUARD IN PLACE

Page | 11 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
5 Gas Hookup and Information
A.
Fuel
Before maki g gas co ectio s, e sure the applia ce bei g
i stalled is compatible with the available gas type.
B. Gas Pressure
Proper i put pressures are required for optimum
performa ce. Gas li e sizi g requireme ts eed to be made
followi g AS/NZS5601.1
Pressure requireme ts for applia ce are show i
table below. Mi imum pressures must be met whe
other household gas applia ces are operati g.
Pressure Natural Gas
Propa e
Mi imum I let Pressure
Maximum I let Pressure
1.13k
P
a
2.75kPa
2.6kPa 3.5kPa
WARNING
Fire Risk
Explosion Risk
Verify i let pressures.
•High pressure may cause
over fire co ditio .
•Low pressure may cause
explosio .
•Verify mi imum pressures
whe other household gas
applia ces are operati g
I stall regulator upstream of valve if li e
pressure is greater tha 3.5 kPa
The applia ce a d its i dividual shutoff valve must be dis
-
co ected from the gas supply pipi g system duri g a y
pressures i excess of 3.5 kPa.
The applia ce must be isolated from the gas supply pipi g
system by closi g its i dividual ma ual shutoff valve duri g a y
pressure testi g of the gas supply pipi g system at test pressures
equal to or less tha 3.5 kPa.
C. Gas Connection
Note: Have the gas supply i stalled i accorda ce
to
AS/NZS5601.1 a d local buildi g codes. I stallatio should be
do e by a authorized i staller approved a d/or lice sed as
required by the locality.
I comi g gas li e should be piped to the 12.7mm
(½ i ch) co ectio o the ma ual shutoff valve.
WARNING
Fire Risk
Explosion Risk
•Gas build-up duri g li e purge may
ig ite.
•Purge should be performed by
authorized tech icia .
•E sure adequate ve tilatio .
•E sure there are o ig itio sources
such as sparks or ope flames.
• A small amount of air will be in the gas
supply lines. When first lighting appliance
it will take a short time for air to purge
from lines. Subsequent lighting of the unit
will not require such purging.
WARNING
CHECK FOR GAS LEAKS
Fire Risk
Explosion Risk
Asphyxiation Risk
•Check all fitti gs a d co ectio s.
•Do ot use ope flame.
•After the gas li e i stallatio is
complete, all co ectio s must be
tighte ed a d checked for leaks with
a commercially available leak-check
solutio . Be sure to ri se off all leak
check solutio . Be sure to ri se off all
leak check solutio followi g testi g.
Fitti gs a d co ectio s may have loose ed duri g
shippi g a d ha dli g

Page | 12 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
D.LP Gas Supply
• The LP gas supply used with LP models must be constructed
and marked in accordance with the specifications for LP gas.
• Cylinders must be stored outdoors in a well-ventilated area out
of the reach of children. Disconnected cylinders must have
threaded valve plugs tightly installed and must not be stored
in a building, garage or any other enclosed area.
• Storage of this applianceindoors is permissibleonly
if it has been disconnected from its fuel supply.
• The LP gas supply system must be arranged for
vapor withdrawal.
• The specific size and capacity of the cylinder(s) to
be used: hard plumbed to propane tank.
Gas Setup or Liquid Propane
1.
With bur er i place i Outdoor
GreatRoom Compa y fire pit table or other
i stallatio locatio a d proper sized
i jector i serted i bur er eck (see chart
o p.4 for i jector sizi g),
2. I comi g propa e should be hard-plumbed
to the i put of the gas co trol valve with a
approved regulator for propa e. Tighte
securely usi g two wre ches.
3. Locate the gas li e ( ot supplied) a d
tighte securely to output valve fitti g
followi g the method described i step 2.
4. Usi g two wre ches, securely tighte the
flare ut o the free e d of the metal flex
hose to the i jector o the bur er.
5. For liquid propane installations, the air
shutter must be le t open as shown at
lower right to prevent soot buildup. To
adjust air shutter, loose the small securi g
screw a d rotate air shutter to allow more
or less airflow.
IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION SERVICES, OR MAINTENANCE CAN CAUSE INJUR
Y OR
PROPERTY DAMAGE. REFER TO AND UNDERSTAND THIS MANUAL. FOR ASSISTANCE OR ADDITIONAL INFORMATION
CONSULT A QUALIFIED INSTALLER, SERVICE AGENCY, LICENSED TECHNICIAN OR THE GAS SUPPLIER.
Flare Nut I jector
Ve turi/Air shutt
er
CHECK ENTIRE SYSTEM FOR LEAKS BEFORE
OPERATING. IF AN INSTALLER IS
CONVERTING THE UNIT FROM NATURAL
GAS TO LP, RE-CHECK ALL CONNECTIONS
FOR LEAKS BEFORE USE.
Gas from
co trol valve
Bur er shape may differ from your model
Overhead view of bur er a d valve system
I comi g gas
supply (hard
piped)
Propa e
regulator
(locate u der drip
guard)
Gas co trol
valve
Corrugated
metal flex-li e
Gas flow from
valve to bur er
Gas out
Gas i
AN APPROVED
REGULATOR MUST BE FITTED BY
THE INSTALLING PLUMBER

Page | 13 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
E. Gas Setup or Natural Gas
1.
E sure that fire pit table is stable a d level.
Verify that the Natural Gas I jector is i place
a d that the air shutter is 5.0mm ope . Adjust
air shutter by loose i g the small screw o the
air shutter a d rotati g it to a 5mm ope
positio a d re-tighte i g screw.
2. Co ect the metal flex-li e i cluded with your
fire pit to the i jector as show at right. Use
two wre ches to tighte . The co ect the
other e d to the output side of co trol valve
followi g the same process.
3. Co ect the i comi g Natural Gas supply li e
to the i comi g side of the regulator, usi g a
elbow co ectio . Gas supply li e must be a
mi imum of ½” (12.7mm) pipi g.
4. E sure that the ma ual shut-off valve is placed
o the atural gas li e before it reaches the
applia ce co trol valve.
Flare Nut
I jector
Ve turi/Air shutt
er
CHECK ENTIRE SYSTEM FOR LEAKS BEFORE OPERATING.
IF AN INSTALLER IS CONVERTING THE UNIT FROM LP TO
NATURAL GAS, RE-CHECK ALL CONNECTIONS FOR
LEAKS BEFORE USE.
Overhead view of bur er a d valve system
I comi g gas
supply (hard
piped)
Natural gas
regulator
(locate u der drip
guard)
Gas co trol
valve
Corrugated
metal flex-li e
Gas flow from
valve to bur er
Gas out
Gas i put

Page | 14 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
6 Lighting and operation
A.
This applia ce is lit electro ically. Whe lighti g, follow
these i structio s exactly.
B. Be ore lighting, smell all arou d the applia ce area for
gas. Be sure to smell ext to the base of the applia ce
because some gas is heavier tha air a d will settle o
the floor.
WHAT TO DO IF YOU SMELL GAS:
•Do ot try to light a y applia ce.
•Do ot touch a y electric switch, do ot use a y pho e
earby.
•Immediately call your gas supplier from a eighbor’s
pho e. Follow gas supplier’s i structio s.
•If you ca ot reach your gas supplier, call the fire
departme t
FOR YOUR SAFETY, READ BEFORE
LIGHTING
WARNING!
If you do not follow these instructions exactly, a fire or explosion may result
causing property damage, personal injury, and/or loss of life.
C.
Use o ly your ha d to tur the gas co trol k ob
o gas supply (if equipped), ever use tools. If the
valve wo ’t tur by ha d, do ’t try to repair it, call
a qualified service tech icia . Force or attempted
repair may result i a fire or explosio .
D. Do ot use the applia ce if a y part has bee
u derwater. Immediately call a authorized service
tech icia to i spect the applia ce a d replace a y
part which has bee u derwater.
Lighting Instructions
1.
Tur o /off switch to ON positio .
2
.
You will see or hear sparki g
occurri g at the
electrode
In the event the lame does not light:
flip switch to the OFF positio , wait 10 mi utes,
a d re
-
attempt ig itio .
Initial break-in procedure: Whe you light the applia ce, you may otice that it produces heat
which may have a odor. If you feel this odor is excessive it may require a i itial three to four hour
co ti uous bur .

Page | 15 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
Homeowner Re erence In ormation
Model ame:______________________________ Date of purchase/i stallatio _________
Serial Number:___________________________ Locatio o applia ce:_________________
Dealer purchased from:____________________ Dealer Pho e:________________________
Notes:________________________________________________________________________
______________________________________________________________________________
______________________________________________________________________
WARNING
FIRE RISK – HIGH TEMPERATURES
Keep combustible household items away from applia ce.
•Do NOT obstruct combustio a d ve tilatio air.
•Do NOT place combustible items o top of or ear applia ce.
•Keep fur iture, draperies away from applia ce.
•Do NOT use, la ter fuel, kerose e, charcoal lighter fluid, or similar liquids i this applia ce.
•Combustible materials, flammable liquids, or vapors may ig ite.
We recommend that you record the following
pertinent information about your appliance

Page | 16 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
Symptom
Possible Causes
Corrective Actions
1.
Burner won’t
light.
A.
No fuel Check gas valve at main.
B.
Plugged burner injector. Check the burner injector for stoppage. Remove
stoppage.
2.
Blue Flames
A.
This is aresult of normaloperationand
flames will begin to yellow as unit is
allowed to burn for 16-20 minutes. Do nothing.
B.
Improper air/fuel mixture related to air
shutter position. Close air shutter. (for LP, leave 7mm open, Natural
gas 1.5mm open)
3.
Metallic noise
A.
Noise is caused by metal expanding
and contracting as it heats up and
cools down, similar to the sound
produced by a furnace or heating
duct. This noise does not affect the
operation or longevity of the
appliance.
Do nothing.
4.
Decorative Beads
cracking or splitting
A.
Heat and/or abrupt temperature
changes. This is a property of glass and may happen
occasionally. Do nothing. This is completely normal.
5.
Sparker makes
clicking sound but
no visible spark is
produced
A
Sparker is improperly grounded Refer to section 4-C on Page 9 for grounding
instructions. Check all wire connections.
B.
Ignition or ground wire not plugged in.
C.
Igniter tip set too far from grounding
probe Check that tip of sparker is within 6mm of grounding
probe. Gentlybend igniter tip or grounding probe by
hand to achieve asmaller gap.
7 Troubleshooting

Page | 17 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
I spect
Mai te a ce
Tasks
Bur er Assembly
1
Remove decorative glass a d exami e bur er. Vacuum a d wipe
out as eeded. Use cautio whe clea i g these areas
2
I spect for warpi g a d corrosio . Repair as ecessary
3
Verify air shutter area is clea
Bur er
Ig itio a d Operatio
1
Verify all gas co ectio s are tight a d leak
-
free
2
Clea bur er top, i spect for plugged ports, corrosio , or
deterioratio . Replace bur er if ecessary.
3
I spect for flame problems.
4
Verify air shutter is clear of dust
a d debris a d is i correct
positio for the gas type bei g used.
5
I spect
i jector
for soot, dirt, or corrosio
6
Verify i let
a d test poi t
pressures. Adjust regulator as required.
8 Service and Maintenance
Although the freque cy of applia ce servici g a d mai te a ce will
depe d o use a d the type of i stallatio , a authorized service
tech icia should perform a applia ce check-up a ual.
Storage of a applia ce i doors is permissible o ly if disco ected
a d removed from the gas supply.
The use o a vinyl table cover is highly recommended to keep your
table and burner looking new and ensuring extended trouble- ree
operation.
Maintenance and Service Tasks
For service calls: Co tact the dealer your product was purchased from first.
Co tact the Outdoor GreatRoom Compa y at 1-651-287-7460 or [e-mail] if further assista ce is eeded.
Authorized

Page | 18 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
#
Description of Part
Part Number
1 Burner Assembly
SRV-BA-CF 20/1224/2424/1242
2
Flex Tube SRV-FT-CF
3 Injector – NG/LP 3.0mm
4 Injector – NG 6.3mm
6 Ignition Electrode -3 Prong
7 Replacement Glass for Crystal Fire burner (5lb bag)
8 Grounding wire for crystal fire (All models) SPK-GND
9 Control Valve AU
10 Control Box AU
12 Battery pack for valve system
13 Glass guard kit GG1242 AU
Optional Accessories
Glass burner cover
Vinyl fire pit cover
Natural gas conversion kit
LPG conversion kit
9 Reference Materials
A.Service Parts List
For more i formatio , you ca visit us o li e at
Http://www.OutdoorRooms.com
Or Call Us At:
1-651-287-7460

Page | 19 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
The area show below (de oted by diago al li es) should be clear of combustible materials.
B. Dimensional Information
A overhead view of a suggested o
-
combustible frami g for this bur er is show to
assist i locati g gas pipi g a d co structi g a base for this bur er. . Be sure to pla
e ough space to i stall a ma ual shutoff valve before gas reaches the co trol valve o
the bur er.
Dime sio s approximate. Always measure before i stalli g perma e t gas li es.
Valve input location is roughly centered in the base.
Cross-sectio al view
4”
102mm
4”/102mm
4”
102mm
4”/102mm
Overhead view (Cleara ce to combustibles below top of bur er)
4”/102mm
Suggested mi imum i terior dime sio s
of a o -combustible fire pit
4”/102mm

Page | 20 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
RED +
C. Wiring Diagram
If wiri g
eeds to be repaired or disassembled, disco ect the fire pit from gas supply
before a ythi g is do e to electrical compo e ts.
LP Natural gas
OUT
IN
Ideal
test poi t pressures
I 2.75kPa 1.13kPa
Out 1.75kPa .5kPa
I S
Gas valve
Battery Pack
Co trol Box
ON/OFF Switch
Ig iter/Flame Se sor
Grou d
Co tacts
Optio al 3V DC
Power co ectio
6.4mm (1/4”
) p
ressure tap