Outdoor GreatRoom Company Sierra User manual

1 | P a g e
Sierra , Rivers Edge, Grandstone & San Juan Table
Installation Instructions
Toll-Free 1-877-734-2458
NorthlineExpress.com www.NorthlineExpress.com

2 | P a g e
Contents
Contents……………………………………………………..2
Required Tools…………………………………………..3
Placing the Table………………………………………4
Gas Connection………………………….…………….5
Igniter Installation…………….………………………...6
Placing the Top…………………………………………..7
Burner Installation……………………………………….8
Locating Propane tank……………………………..9
Door Installation…………………………………………...10
Toll-Free 1-877-734-2458
NorthlineExpress.com www.NorthlineExpress.com

3 | P a g e
Required Tools
Utility Knife
To cut and remove packaging
2 Open Ended Wrenches
To make gas connections
Leather Gloves
To protect hands from rough edges found
on the coffee table.
One (1) AAA Battery (not included)
Required for igniter installation for Crystal
Fire burners.
It is recommended that a
minimum of two people
assemble and install the Sierra
and San Juan Coffee Tables.
Toll-Free 1-877-734-2458
NorthlineExpress.com www.NorthlineExpress.com

4 | P a g e
Placing the Sierra/San Juan table
1. Remove access door
2. Remove the base from the box
3. Move the base without door to desired location
and set into place.
4. When locating your coffee table, refer to the
Crystal Fire manual and maintain clearance to
combustibles.
Shown with door removed
Toll-Free 1-877-734-2458
NorthlineExpress.com www.NorthlineExpress.com

5 | P a g e
Gas Connection
1. Connect the incoming gas hose to the valve.
It is not recommended to use Teflon tape or
pipe dope on the connection to the valve
with flare fittings.
LPG installations use the hose and regulator
provided with the burner.
Natural Gas installations refer to the
supplied Crystal Fire Manual.
Incoming
gas
Toll-Free 1-877-734-2458
NorthlineExpress.com www.NorthlineExpress.com

6 | P a g e
Igniter Installation
2. Install the igniter by unscrewing the top cap
and hex nut counter-clockwise. Once the
top cap and nut are separate, place the box
portion on the inside of the unit with the
threaded body through the hole. Insert one
AAA battery positive end outward. Hand
tighten the nut and cap to complete the
assembly.
1. Make sure the valve in in the OFF
position
Toll-Free 1-877-734-2458
NorthlineExpress.com www.NorthlineExpress.com

7 | P a g e
Placing the top
1. With the help of at least one other person,
remove Super Cast concrete top from
packaging and gently lower on to your fire
pit table base. Construction adhesive or
silicone may be used on the top of the base
for a more permanent placement.
Special Instructions for
CF2424 Burner
Use the following diagram and included hardware
for installation of tables containing a CF2424
burner.
Toll-Free 1-877-734-2458
NorthlineExpress.com www.NorthlineExpress.com

8 | P a g e
Burner Installation
Before Completing this step, read and understand
the Crystal Fire owner’s manual.
Lower burner on to base
Connect gas line and electrode wire
Electrode wire
Toll-Free 1-877-734-2458
NorthlineExpress.com www.NorthlineExpress.com

9 | P a g e
Locating your Tank
1. Your tank should be positioned so that
the fuel can be shut off after each use.
2. Slide the tank into the framework past
the line shown below. This is to allow
the door to close completely.
3. Confirm all hoses are clear and not
touching the burner.
Position tank behind this line
Toll-Free 1-877-734-2458
NorthlineExpress.com www.NorthlineExpress.com

10 | P a g e
Door Installation
Set door on supports and close.
Magnet will hold door in closed position.
Door support
IMPORTANT
Please consult your Crystal Fire instruction manual for detailed
instructions and important information related to hooking up your CF-
20 burner, including safety information, proper tightening of
connections with two wrenches and full burner setup and lighting
instructions.
DO NOT ATTEMPT TO INSTALL CF-20 BURNER WITHOUT FIRST
CONSULTING THE MANUAL. IF YOU ARE UNSURE OF HOW TO
COMPLETE THE STEPS OUTLINED, CONSULT A QUALIFIED
TECHNICIAN
WARNING
After consulting the manual and following instructions, remember; before operating,
all gas connections must be fully checked for leaks
Toll-Free 1-877-734-2458
NorthlineExpress.com www.NorthlineExpress.com

11 | P a g e
ENTIONALLY LEFT
AWESOME.
2015 Silver Bell Road •Suite 195 •
Toll Free: 1-866-303-4028
Warranty: Fire pit tables are covered under a 1-
year manufacturer’s warranty. Please visit
http://www.outdoorrooms.com/warranty-form
to register your product.
Toll-Free 1-877-734-2458
NorthlineExpress.com www.NorthlineExpress.com

12 | P a g e
© 2011 The Outdoor GreatRoom Company
Toll-Free 1-877-734-2458
NorthlineExpress.com www.NorthlineExpress.com