Pet Gear PG8030OB User manual

To see our full line of products, visit us online at: www.petgearinc.com
CUSTOMER SERVICE HELP DESK
[email protected]
Toll-Free 877-752-9123 - Eastern Standard Time 8am-3pm, Monday through Friday
For The ON-THE-GO Pet™
INSTRUCTION MANUAL
SPORT LITE PET STROLLER
PG8030OB/PG8030PK
Interior Dimensions:
22L x 11W x 16H

SPORT LITE PET STROLLER • PG8030OB/PG8030PK
2
PARTS LIST
OPENING THE STROLLER
Step 1. Release locking latch
Check that you have all the parts shown BEFORE assembling your product.
If any parts are missing, call Customer Service.
Step 2. Unfold as shown.
Make sure both locks snap into place.

Note Direction
of Arrow
SPORT LITE PET STROLLER • PG8030OB/PG8030PK 3
TO ASSEMBLE FRONT WHEELS
Step 1. Turn stroller over as shown.
Step 2. Push wheel assembly onto stroller leg
until it snaps into place.
Step 3. Repeat for other wheel.
Tug rmly on each wheel assembly to be sure
wheels are securely in place.
TO ASSEMBLE REAR WHEELS
Step 1. Remove and discard protective
sleeve from ends of rear axle assembly
and rear leg tubes.
Step 2. Position rear axle assembly onto
rear leg tubes at the same time.
NOTE: To remove, squeeze
tab and pull wheel off.
Note Direction
of Arrow

SPORT LITE PET STROLLER • PG8030OB/PG8030PK
4
TO ASSEMBLE REAR WHEELS
APPLYING THE BRAKES
Step 3. Slide wheel onto axle.
Step 4. Slide washer onto axle.
Step 5. Fit straight part of cotter pin
through hole on axle.
Step 6. Line up each of the tabs in the
hub cap with the slots in the wheel.
Snap hub cap into place.
Fit cover to collet by rmly pressing the
cover into place.
Step 7. Repeat for other side.
Step 1. Push levers on both rear wheels down to lock.
Step 2. Pull levers up to unlock.
WARNING: Never leave your stroller parked without applying brakes. Unlock
Lock

SPORT LITE PET STROLLER • PG8030OB/PG8030PK 5
Step 1. Before folding the stroller, lock the
brakes and close the canopy.
Step 2. Standing behind the stroller, pull up on
both side latches.
Step 3. Fold as shown.
Step 4. Engage locking latch.
NOTE: Fold stroller so wheels straddle frame. DO NOT allow wheels to press against frame
as this may damage tires.
FOLDING THE STROLLER

SPORT LITE PET STROLLER • PG8030OB/PG8030PK
6
LOOKING AFTER YOUR STROLLER
WHEEL MAINTENANCE
• Always store product in a clean, dry place.
• Not recommended for use on the beach.
• Do not put heavy items on top of the stroller.
• Clean frame by wiping with a lightly oiled cloth.
• Do not use detergent or abrasives. Spot clean fabric with dry cleaning uid or mild soap and
warm water.
• To ensure easy maneuverability and to minimize wear and tear, (especially wheels, axles, and
swivels), keep all moving parts clean and lubricated with WD40® or light machine oil.
• NOTE: Do not lubricate brake components or swivel locks.
• Regularly check stroller for loose parts. These should be tightened or replaced.
• To clean and lubricate front and rear wheels, push out locking lever under wheel housing to
release rear wheel.
• To ensure ease of maneuverability and to minimize wear and tear, keep all moving parts clean and
lubricated with WD40® or light machine oil.
• Push wheel sets back on until they click and lock in position; pull on wheel housings to ensure
they are secure.
• Push stroller back and forth and rotate swivels around to work in lubricant.
• Clean the rear wheel assembly and the rest of the frame with warm, soapy water; clean off with
warm water and dry thoroughly.
• NOTE: Do not lubricate brake components or swivel locks.

SPORT LITE PET STROLLER • PG8030OB/PG8030PK 7
WARNING!
FOR PETS ONLY.
Not intended to be used as a restraining device for aggressive or dangerous animals that dig, chew or paw
aggressively. Do not leave your pet unattended. PET GEAR is not liable for any damage caused by aggressive,
destructive, immature or untrained animals. Do not use near an open or exposed ame. Failure to follow these
warnings and the instructions could result in serious injury or death.
• Do not carry additional bags, goods, or accessories in or on stroller except as recommended
in the manufacturer’s instructions.
• Recommended use of an approved safety restraint correctly tted and adjusted.
• Do not leave pet unsupervised in stroller.
• Before making adjustments to stroller ensure that pet’s body is clear of any moving parts.
• This stroller is designed for one pet only.
• Do not hang bags from handles as this may cause the product to become unstable.
• Do not use on escalator or stairs; fold stroller and carry.
• Put on brake whenever you park the stroller.
• Ensure stroller is completely erected and check that all locks are engaged before placing pet
in stroller.
• Do not overload as stroller may become unstable; maximum weight of pet using this stroller
not to exceed 20 lbs.
• Any goods carried in the basket not to exceed 6 lbs.
REPLACEMENT PARTS
Use only PET GEAR replacement parts.
Please have your model number ready before calling.
You can also request parts: http://www.petgearinc.com/main.asp?sel=2
192 Sheldon Avenue∙West Rutland, VT∙05777∙877-752-9123∙www.petgearinc.com