Plasson Super Easy Start User manual

Plasson Super Easy Start
Adjustable For Turkey Poults
(Up to 7 weeks)
Operation Instructions
Global Presence - Local Commitment
2012
4. After taking the birds out:
 • CleanthelinesfollowingPlassonGuidetoCleaningWaterLines
 • Keepthelineslledwithwaterexceptunderfreezingconditions
1. Check your installation:
 • Aftercompletingtheinstallation,llthelinesinordertocheckthe
system.
 • TheSESAsystemisassembledonthePlassonNipplesystem.
 • Alwaysusethelongconnectingpiece(02209015)forthe
Aluminumprole.
 • Nippletypeforthisapplication:Grey.
 • RecommendednumberofTurkeyPoultsperSESA:25-30.
 • RecommendednumberofSESAper3m(10’)section:4-6.
 • Maximumlengthofline80m(260ft.).Forlongerlines,aPlasson
MidLinePressureRegulatorcanbeused.
 • Ifwaterissuppliedfromthemainpipeline,incomingpressureto
theheaderkitshouldbe1.5bar(22psi),
  max.2.7bar(40psi).
 • Ifwaterissuppliedfromaheadertank,theheadertankshouldbe
atleast4m(13ft.)aboveoorlevel.
 • A130micronor120meshltercartridgeorbettermustbe
installedbeforetheheaderkit.
 • Linesmustbesuspendedataconstantheightabovethehouse
oor(slats/litter).
 • Forlineswithmorethan15cm(6”)offallorslope,besureto
installtheheaderkitonthehighendofthelineandallowthe
watertoowdownward.Maximumpermitteddropoflinewithout
usingPlassonSlopeRegulator:15cm(6”).
 • Shockerwiremustbeinstalled.Thealuminumprolemustbe
grounded.Itisrecommendedtoperformthegroundingusing
PlassonGroundingNipple.
2. Before operating the system and prior to placement of
birds:
 • Atthestartofeachnewockandaftermedication,thesystem
mustbeushedthoroughlywithhighpressure,onelineatatime
(fordetailsseePlassonGuidetoCleaningWaterLines).Toush:
° Opendrainvalveatendofline
° TurnvalveonPressureRegulatorto“ush”position(halfturn)
° Wesuggestaminimumof10minutesperline.Oncecompleted,
turnthevalveto“regulate”positionandclosedrainvalveatthe
endoftheline.
 • Setthewaterpressure(initialsetting)to30cm(12”).(Waterlevel
insighttubeshouldbemeasuredfromthecenteroftheNipple
linepipe)
3. During the ock:
 • ItisveryimportantthattheTurkeyPoultswillbeabletoseethe
waterintheSESA-adjusttheheightoftheSESAlineandthelight
programaccordingly.
 • Recommendedwaterpressure:25-40cm(10"-16").
 • Trainingtowardsgrowout:
°IfnishingbarnisequippedwithHF*werecommendadding
oneHFper3m(10’)sectionforthelastweekofbrooding.
°IfthenishingisdoneinthesameshedandusingHF,we
recommendaddingoneHFper3m(10’)sectionfromthe3rd
weekofbroodingandcontinuereplacingtheSESAwithoneHF
everytwo/threedays(seeHFOperatinginstructions).Theextra
unusedNipplesshouldbecoveredwithPlassonSnaponPlug
forNipple(02205294).
°PlassonBellDrinker,lower5to10BellDrinkersperhousefor
thelastweekofbrooding.
 • HeightofSESASystemguidelines:followthesketchhereunder
* HF(HeavyFinish)-PlassonNippleSystemforAdultTurkeys.
 • Cleanthelterperiodicallyaccordingtowaterquality
 • ItisgoodpracticetoruncleanwaterthroughtheMedicatorafter
eachmedication
Please read all the instructions before using the Plasson
Super Easy Start Adjustable for Turkey Poults system.
The following are general recommendations:
Adjust the line’s height
enabeling the Turkey
Poults to easily see the
water upon their first
search while ensuring
the cup does not touch
the litter as this will
cause it to flood.
Day 1
Slightly raise the water
lines in order to train
the birds to drink from
the raised SESA. The lip
of the SESA should be
at bird’s chest to eye
level.
Day 3 up to
6 days
Keep the SESA lip
slightly above eye level
while enabling free
movement under the
SESA.
7 days till
end of brooding

SESA parts list
02205545
02205509
02205512
02205508
02205524
1
2
3
4
5
One time setting according to grower preference (factory setting no. 2)
Approximate Water Volume, 10cc
Approximate Water Volume, 15cc
Approximate Water Volume, 20cc
Setting 1
Setting 2
Setting 3
Setting 1
Setting 2
Setting 3
7845 6.12 B2B MARCOM
SES Adjustable Split Ring
SES Adjustable Spring
SES Adaptor
SES Adjustable Pipe
Easy Start Cup
1
1
1
1
1
Super Easy Start Adjustable - 02205546
SESA – 3 different Water level setting
PLASSON Poultry Division, 105 Ilan St. P.O.B. 108 North Industrial Estate Or - Akiva 30600, Israel
Tel:[phone]Fax: [phone]  E-mail:[email protected]www.plassonpoultry.com
www.plassonpoultry.com