PowerWalker MBP 1-1 User manual

PDU for VFI ICR IoT 6-10kVA
Installation and user manual
Service and support:
Call your local service representative


VH. ismanualcontainsimportantinstructionst ats ould
befollowedduringinstallationandmaintenanceoft eMBP.
              

pecials'mbols
(  ) H(         ! 
!"
#$"
%& $  !      '$
()%%%* #       $    
$""
#$
+

afet'ofpersons
Terminal blocks may be ener ized even if the system is disconnected from the AC
power source.
Dan erous volta e levels are present within the system. It should be opened exclusively
by qualified service personnel.
The system must be properly rounded, always connect the earth wire first.
Product safety
The MBP connection instructions and operation described in the manual must be
followed in the indicated order.
CAUTION - To reduce the risk of fire, the unit connects only to a circuit provided with
branch circuit overcurrent protection for:
63A ratin , for 6kVA models,
80A ratin , for 10kVA models
The upstream circuit breaker for Normal AC/Bypass AC must be easily accessible. The
unit can be disconnected from AC power source by openin this circuit breaker.
Disconnection and overcurrent protection devices shall be provided by others for
permanently connected AC input (Normal AC/Bypass AC) and AC output circuits.
Check that the indications on the ratin label correspond with your AC powered system
and the actual electrical consumption of all the equipment to be connected to the
system.
For PLUGGABLE EQUIPMENT, the socket-outlet shall be installed near the equipment
and shall be easily accessible
Never install the system near liquids or in an excessively damp environment.
Never let a forei n body penetrate inside the system.
Never block the ventilation rates of the system.
Never expose the system to direct sunli ht or source of heat.
If the system must be stored prior to installation, stora e must be in a dry place.
The admissible stora e temperature ran e is -25°C to +60°C.
Special precautions
This MBP is desi ned to work with UPS.
All repairs and service should be performed by AUTHORIZED SERVICE PERSONNEL ONLY.
There are NO USER SERVICEABLE PARTS inside the MBP.

CONTENTS
1 Introduction .................................................................................................. 1
1.1 Environmental protection .............................................................................. 1
2 Product Overview ........................................................................................... 2
2.1 Model list ....................................................................................................... 2
2.2 Presentation .................................................................................................. 2
3 Installation .................................................................................................... 4
3.1 Unpackin and Inspectin .............................................................................. 4
3.2 Checkin the accessory kit ............................................................................. 4
3.3 Mechanical Installation .................................................................................. 5
3.4 Power cables connection ............................................................................... 8
4 Service operation ........................................................................................ 12
4.1 How to switch system to BYPASS mode ....................................................... 12
4.2 How to disconnect cables between MBP and UPS ...................................... 13
4.3 How to switch system to NORMAL mode .................................................... 13
4.4 How to detect the EBM to this system ........................................................ 14
5 Specifications .............................................................................................. 15

1
1 Introduction
Thank you for selectin MBP(Maintenance Bypass modular) to protect your electrical
equipment.
The MBP allows service person to service or replace the UPS without interruptin the
connected loads. Besides, it also allow you apply for below extension used
Terminal block connection desi n enable the MBP connect to other type UPS.
Rotatable ‘rail kit’ desi n for easy service operation in a rack cabinet.
Flexible position installation.
We recommend that you take the time to read this manual to take full advanta e of
the many features of your MBP.
1.1 Environmental protection
Products are developed accordin to an eco-desi n approach.
Substances
This product does not contain CFCs, HCFCs or asbestos.
Packing
To improve waste treatment and facilitate recyclin , separate the various packin
components.
The cardboard we use comprises over 50% of recycled cardboard.
Sacks and ba s are made of polyethylene.
Packin materials are recyclable
Follow all local re ulations for the disposal of packin materials.
Product
The product is mainly made up of recyclable materials.
Dismantlin and destruction must take place in compliance with all local re ulations
concernin waste. At the end of its service life, the product must be transported to
recyclin centers, re-use and treatment facilities for waste electrical and electronic
equipment (WEEE).

<
2Product Overview
+*
6 The wei ht in this table is reference only, please see the labels on the carton for details.
< .C.Dchassis only.
++
1*2*3
6 $! $6($ *
<  $! $<($ *
3  $!($*
B  "$ 
  #$7$($*
2  #$
F  #$7$(&>*
5  +GB$( %.+*
8
 0) (! *

.(*)/?/.

PDU for VFI ICR IoT 6-10kVA 1-1
<B B<2I5B(<&*I5
PDU for VFI ICRS IoT 10kVA 3-1
<5 B<2I52(<&*I5

3
+ear anel
1-2*3
1. utput socket roup (pro rammable)
<. aintenance bypass switch
3. #nput 7utput terminal (onnected to power and load)
B. #nput switch
. +GB port(includin E Detect and +T model  )
2. #nput 7utput terminal (onnected to &>)
8ront anel
+ear anel

B
- 
 " "   " " '    
$$" 
-*"!0&"!&
&$! $"
.
""(,!*
#"'$  $!$$$ 
$!       $  $      $$
 #" $ 
4 
."$!  $
! $$  
+" "$$!  
-+ !0& !!'0
4" 1
(66* (36*
&>#$7$
√ √

√  √
$$

√
!$!
√  √ 
%!(8*
√  √ 
+!(8!*
√  √ 
&
√  √ 
0 ： √ Standard confi uration; O---Option, default is Not confi ured


--! !
is odel support < installation odes1 +ac! installation and oer installation
#t is recoended to connect Ccales for &S #nput 7 OutputD and C detection
caleD to te  efore installin 
6 +eoe te coer of terinal loc!s and connect Ccales for &S #nput7 OutputD to
terinal loc!s refer to te indication on rear panel
1*2*34
1-2*34 









8or cales ell fi/ed, it is recoended to tie tese cales to te cone/ of
rear-panel

< #nstall ac! te coer of terinal loc!s and insert C detection caleD









2
--*%4
-""$&>/&>$ 
6  &> $ < $       $  

#     C9 $D  "     
  C&>#$7$DCD
9$ $$
< # C% !D       &> " B  
$/$C9$D
--+!0"4
/$ !
#     C 6D  "      
  C&>#$7$DCD

F
•6(+!*
•<(8!*
6#C+!D!"

5
<>C!D!!"<$
-.%!#!!
$&>-#07&

-.*5&$!!&
$#CD$C7-
.%%D&>  





K
 C  &> #$7 $D  &>  !   

*2*4
-2*4
-.+5&$#1!3
&>$$
+

66 36
)+2H(>*66 )+6H(>*66 )+6H(>*36
 
6< 6< 6<
#$90 2< 6< 6<
$90 2< 6< 6<
     $      /6    " 
# $6'$7
 

6
? ! 1
% $$"
"$"'$
 "   "  !   $ $ 
(0-*$LL(*
6+! 
<-!$
1*2*34

66
1-2*34
$$<  36
66
>C$9679<793DCD-
36
8   /          / 
$
3#!!

6<
.  ,!"
.*%%! '
!&>"$ 
"$$
6 +  C  D  &>    "$ 
"
<+CDA->>D$
01 
8   $      !  C
D$MA->>D!C&>D
3C$DC88D$
B-$$"


63
.+%!!!##%
C&>#$7$DCD
$/$C+!$D"
6&!$$$"

<. C&>#$7$DCD
&>
3+&>$
.D"  $
.-%%! ')
""&>"$$
6C&>#$7$DCD&>
$3B
<C#$DC0D$&>"$#
&>D "$ "$ "$
"
3 +     C&>D $  !  C
D$
B&>9.$&>

6B
..%!  '
C %D"(&>=*C%
D

6
5  "!$!
6%$N&>$$
<%$N&>$$
$! $ 0$ 6-O62-
 $ 6-O62-
! $( *9." J
P"QPQP"Q" 
PQ$$"$"
 E  "    ! $ ( *   
   !
3%
$ $

RB ℃ 
BR ℃   E
R3 ℃  #%!62-
3RB ℃  #%!6-
> $ <2
$ <
+" KE 
$  S3(. 6! 6E"$
6*
B
>" #%7%02<B6
% #%7%02<B<3