Quadra-Fire TREKKERI-MBK User manual

109/207082-154K
NOTICE: DO NOT DISCARD THIS MANUAL
R
TREKKER INSERT PELLET
APPLIANCE
MODEL NUMBERS:
TREKKERI-MBK
TREKKERI-PMH
TREKKERI-TWL
Owner’s Manual
Operation & Care
INSTALLER: Leave this manual with party responsible for use and operation.
OWNER: Retain this manual for future reference.
Contact your dealer with questions regarding installation, operation or service.
Installation and service of this appliance should be performed by
qualified personnel. Hearth & Home Technologies recommends
HHT Factory Trained or NFI certified professionals.
Tested and approved for wood pellets only. Burning of
any other type of fuel voids your warranty.
CAUTION
CAUTION
Check building codes prior to installation.
• Installation MUST comply with local, regional, state
and national codes and regulations.
• Consult local building, re o󰀩cials or authorities
having jurisdiction about restrictions, installation
inspection, and permits.
WARNING
If the information in these instructions is
not followed exactly, a re could result
causing property damage, personal injury,
or death.
• Do not store or use gasoline or other ammable
vapors and liquids in the vicinity of this or any
other appliance.
• Do not over re - If appliance or chimney connector
glows, you are over ring. Over ring will void
your warranty.
• Comply with all minimum clearances to combustibles
as specied.
Failure to comply may cause house re.
HOT SURFACES!
Glass and other surfaces are hot during
operation AND cool down. Hot glass will
cause burns.
WARNING
• Do not touch glass until it is cooled
• NEVER allow children to touch glass
• Keep children away
• CAREFULLY SUPERVISE children in same room
as replace.
• Alert children and adults to hazards of
high temperatures
• High temperatures may ignite clothing or other
ammable materials.
• Keep clothing, furniture, draperies and other
ammable materials away.
NOTE: To obtain a French translation of this
manual, please contact your dealer or visit
www.quadrare.com
REMARQUE : Pour obtenir une traduction française de
ce manuel, s’il vous plaît contacter votre
revendeur ou visitez www.quadrare.com

28 09/207082-154K
C. Service Parts List
Service Parts
RTREKKER INSERT
Beginning Manufacturing Date: June 2018
Ending Manufacturing Date: Active
Pellet Insert
Part number list on following pages. 07/20
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
17
16
18
19
20
21 22
23
24 25
26
27
28
8
29
30
31
32
33
34
35
36
37
Color SKU No. Mfg. Dates
Matte Black TREKKERI-MBK 06/18 -
Porcelain Mahogany TREKKERI-PMH 06/18 -
Sienna Bronze TREKKERI-CSB 06/18 - 05/19
Twilight TREKKERI-TWL 03/19 -

29 09/207082-154K
Service Parts
R
TREKKER INSERT
Beginning Manufacturing Date: June 2018
Ending Manufacturing Date: Active
IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or
distributor.
Hearth and Home Technologies does not sell directly to consumers . Provide
model number and serial number when requesting service parts from your dealer or distributor.
Stocked
at Depot
ITEM DESCRIPTION COMMENTS PART NUMBER
1 Hopper Lid
Matte Black 7036-107MBK
Porcelain Mahogany
7036-107PMH
Sienna Bronze 7036-107CSB
Twilight 7036-107TWL
Gasket, Extruded - Field Cut to Size 10 FT 7000-320/10
2Top Hinge Assembly SRV7036-006
3Top
Matte Black 7036-101MBK
Porcelain Mahogany
7036-101PMH
Sienna Bronze 7036-101CSB
Twilight 7036-101TWL
4 Catch Clip 7036-146
5 Elbow Catch 7000-393
6 Bracket, Catch 7036-145
7 Backer, Side Window 414-0280
8 Side
Matte Black 7036-103MBK
Porcelain Mahogany
7036-103PMH
Sienna Bronze 7036-103CSB
Twilight 7036-103TWL
9 Gasket, Door Rope SRV7034-177 Y
10 Hinge Male SRV7034-138
11 Ba󰀪e SRV7034-263 Y
12 Latch, Ba󰀪e SRV7034-149
13 Hinge Pin Retainer 7036-112
14 Front Upper
Matte Black 7082-105MBK
Porcelain Mahogany
7082-105PMH
Sienna Bronze 7082-105CSB
Twilight 7082-105TWL
15 Front Lower
Matte Black 7082-107MBK
Porcelain Mahogany
7082-107PMH
Sienna Bronze 7082-107CSB
Twilight 7082-107TWL
Additional service part numbers appear on following page.

30 09/207082-154K
Service Parts
RTREKKER INSERT
Beginning Manufacturing Date: June 2018
Ending Manufacturing Date: Active
IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or
distributor.
Hearth and Home Technologies does not sell directly to consumers . Provide
model number and serial number when requesting service parts from your dealer or distributor.
Stocked
at Depot
ITEM DESCRIPTION COMMENTS PART NUMBER
16 Door Assembly SRV7080-015
16.1 Glass Retainer 7034-136
16.2 Glass Assembly 21” W x 14” H 7034-007 Y
16.3 Hinge, Female SRV450-2910
16.4 Door Latch Assembly 413-5200
Gasket, Channel 3 Mm X 32 - Field Cut to Size 10 Ft 7000-377/10 Y
17 Ash Pan Door SRV7034-133
18 Ash Pan Assembly SRV7034-069
Twin Ball catch SRV7000-532 Y
19 Intake Shield 7034-224 Y
20 Firepot Riser Assembly (Does Not Include Floor Lever Assembly) SRV7080-082
20.1 Firepot Assembly SRV7080-083 Y
20.2 Gasket, Firepot SRV7034-190 Y
20.3 Spring Pkg of 4 7000-513/4 Y
20.4 Rail, Auto-Clean SRV7034-152 Y
20.5 Plow Weldment, Auto-Clean SRV7034-024 Y
20.6 Hitch Pin Clip 3/32 Pkg of 10 7000-374/10 Y
20.7 Firepot Bottom SRV7034-153 Y
20.8 Firepot Floor Lever Assembly (Not Included w/Firepot Riser Assembly) SRV7080-018 Y
21 Gasket, Rope, Ash Door SRV7034-178
22 Bottom
Matte Black 7036-109MBK
Sienna Bronze 7036-109CSB
Porcelain Mahogany 7036-109PMH
Twilight 7036-109TWL
Additional service part numbers appear on following page.
#16 Door Assembly #20 Firepot Riser Assembly
16.3
16.2
16.1
16.4
20.1
20.2
20.3
20.4
20.7
20.6
20.5
20.8

31 09/207082-154K
Service Parts
RTREKKER INSERT
Beginning Manufacturing Date: June 2018
Ending Manufacturing Date: Active
IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or distributor. Hearth and
Home Technologies does not sell directly to consumers. Provide model number and serial number when
requesting service parts from your dealer or distributor.
Stocked
at Depot
ITEM DESCRIPTION COMMENTS PART NUMBER
23 User Interface Post #HF2155520 SRV7080-178 Y
Battery 3V CR2477 Pkg of 2 SRV7000-869 Y
24 Extension Cable USB SRV7080-171 Y
Bluetooth Key SRV7080-156 Y
25 Control Board SRV7080-052 Y
Wire Harness SRV7080-129 Y
Fuse 5A, Slow IEC Pkg of 10 7000-490/10 Y
Wire Harness, Hall E󰀨ect SRV7080-130 Y
26 Vacuum Switch SRV7000-531 Y
Vacuum Hose 3 FT cut ro t SRV7000-373 Y
27 Latch Bracket Assembly SRV7034-049 Y
28 Snap Disc, L250, Manual Reset ( #3 ) SRV230-1290 Y
29 Combustion Blower SRV7080-106 Y
Gasket, Blower, Combustion (Between …) ...Housing & Stove SRV7080-117 Y
Gasket, Motor, Blower, Combustion (Between …) ...Housing & Motor SRV7080-107 Y
Gasket, Exhaust SRV7034-109
30 Flue Collar Assembly SRV7082-013
31 Gasket, Flue Adpator Flange SRV7036-180 Y
32 Top Vent Adapter TPVNT-4
33 Convection Blower SRV7080-105 Y
34 Feed Assembly SRV7080-010 Y
Feed Spring Assembly (Only) SRV7001-046 Y
Gasket, Feed Motor SRV7034-144
Feed Motor 812-4421 Y
35 Elbow Catch 7000-393
36 Magnetic Switch SRV7000-375 Y
37 Bracket, Hopper Magnet 7036-149
Component Pack
Matte Black SRV7082-043
Sienna Bronze SRV7082-044
Porcelain Mahogany SRV7082-045
Twilight SRV7082-046
Cleanout Tool 414-1140 Y
Paint Touch-Up
Matte Black 3-42-19905
Sienna Bronze TOUCHUP-CSB
Porcelain Mahogany 1-00-0014
Twilight 0001285
Power Cord 812-1180 Y
Additional service part numbers appear on following page.

32 09/207082-154K
Service Parts
RTREKKER INSERT
Beginning Manufacturing Date: June 2018
Ending Manufacturing Date: Active
IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or
distributor. Hearth and Home Technologies does not sell directly to consumers. Provide
model number and serial number when requesting service parts from your dealer or distributor. Stocked
at Depot
ITEM DESCRIPTION COMMENTS PART NUMBER
Heating Element Assembly 18” (Loop Igniter) Pkg of 1 SRV7000-647 Y
Pkg of 10 SRV7000-647/10 Y
Wing Thumb Screw 8-32 X 1/2 Pkg of 24 7000-223/24 Y
Wire Clip 7000-400/10 Y
Accessories
Adjustable Hearth Support ADJSPT-12 Y
Damper, 3 Inch - Tall Vertical Installs Only PEL-DAMP3 Y
Damper, 4 Inch - Tall Vertical Installs Only PEL-DAMP4
Exhaust Probe SRV7000-669
Log Set (2 Pc) Sold as set only LOGS-60-AE-B Y
Outside Air Kit OAK-3
Top Vent Adapter TPVNT-4
Flue Adapter (Required if TPVNT-4 is removed) LKADP
Surround, Std, Panel, For Cast Trim SP-MTVS-CST
Component Pack 7036-041
Surround, Std, Panel, w/Gold Trim No longer available SP-MTVS-GD
Component Pack 7036-042
Trim, Panel Set, Gold SRV250-4660
Surround, Std, Panel, Nickel Black SP-MTVS-NB
Component Pack 7036-042
Trim Set, Black Nickel 7019-027
Bracket for Trim Installation SRV7022-503G
Trim Cast
Matte Black 811-0930
Sienna Bronze TR-CAST-CSB
Porcelain Mahogany 811-0960
Twilight TR-CAST-TWL
Footer, Left
Matte Black 414-7090MBK
Sienna Bronze 414-7090CSB
Porcelain Mahogany 414-7090PMH
Twilight 414-7090TWL
Footer, Right
Matte Black 414-7100MBK
Sienna Bronze 414-7100CSB
Porcelain Mahogany 414-7100PMH
Twilight 414-7100TWL
Header
Matte Black 414-7110MBK
Sienna Bronze 414-7110CSB
Porcelain Mahogany 414-7110PMH
Twilight 414-7110TWL
Additional service part numbers appear on following page.

33 09/207082-154K
Service Parts
RTREKKER INSERT
Beginning Manufacturing Date: June 2018
Ending Manufacturing Date: Active
IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or
distributor. Hearth and Home Technologies does not sell directly to consumers. Provide
model number and serial number when requesting service parts from your dealer or distributor. Stocked
at Depot
ITEM DESCRIPTION COMMENTS PART NUMBER
Accessories
Trim Leg, Left
Matte Black 414-7120MBK
Sienna Bronze 414-7120CSB
Porcelain Mahogany 414-7120PMH
Twilight 414-7120TWL
Trim Leg, Right
Matte Black 414-7130MBK
Sienna Bronze 414-7130CSB
Porcelain Mahogany 414-7130PMH
Twilight 414-7130TWL
Fasteners
Wing Thumb Screw 8-32 X 1/2 Pkg of 24 7000-223/24 Y
Bolt, Grd 2 Tap 3/8 x 4 223-0140
Nut, Wing 1/4-20 Pkg of 12 226-0110/12 Y
Screw, Sheet Metal #8 X 1/2 S-Grip Pkg of 40 12460/40 Y
Washer, Sae Pkg of 25 227-0080/25 Y
Washer, FI 1/4 Black Pkg of 10 1202473-10
Pkg of 50 1202473PK
Screw, Hwh Ms 1/4-20 X 3/4 Ns Pkg of 25 220-0080/25 Y
Nut, Ser Flange Small 1/4-20 Pkg of 24 226-0130/24 Y
Pkg of 100 3-30-8024-100 Y
Screw 1/4-20x5/8 Phillips Pan Head Pkg of 24 7000-398/24 Y
Screw Phillips Button Head 1/4-20x3/8 Pkg of 24 7000-401/24 Y
Screw 8 - 32x3/8 HWH BK Pkg of 40 SRV060-883/40
Screw Flat Head Philips 8-32 X 1/2 Pkg of 12 220-0490/12 Y
Magnet Round SRV7000-140 Y
Hurricane Screw Pkg of 40 SRV2005-861/40
Screw, Pan Head Phillips, 10/32 X 1/4 Pkg of 24 229-1230/24 Y
Bolt, Shoulder, 5/16x1/4-20 Pkg of 20 223-0170/20 Y
Screw, Pan Head Phillips 8-32 X 3/4 Pkg of 24 229-1100/24 Y
Washer, Spring 5/16 Pkg of 4 7000-572/4 Y
Screw, Ph, Phl Tc 8-32 X 1/2 Pkg of 25 220-0030/25 Y
Screw, Pan Head Phillips 8-32 X 3/8 Pkg of 40 225-0500/40 Y