Raypak RAYTHERM 133 User manual

Catalog No.: 2000.20P Effective: 12-1-07 Replaces: 4-1-05
Job:
Engineer:
Contractor:
Prepared By: Date:
Model: Indoor/Outdoor:
EFFICIENT
82% thermal efficiency – highest of any atmospheric
boiler available today
THERMAL SHOCK PROOF
Twenty-year warranty against thermal shock damage
up to 150°F differential
Maximum operating temperature: 230°F
LIGHTWEIGHT
A floor load of 70 lbs./sq. ft. or less
HIGH RECOVERY
Cuts fuel costs substantially because the standby and
radiation losses normal to other boilers are eliminated
LOW WATER OPERATING TEMPERATURE
Operates with water temperature as low as 105°F
without condensing
Heat Exchanger
ASME Inspected and Stamped
160 PSIG
National Board Approved
Glass-lined Cast Iron Headers
Copper Finned Tubing
ASME Steel Tube Sheet
Silicone O-Rings
45 PSIG ASME Pressure Relief
Valve
Temperature and Pressure Gauge,
Shipped Loose
Rear Water Connection
Pump – Optional
Bronze, 1/8 HP, 120 Volt, 1∅, 60 Hz
Cast Iron, 1/8 HP, 120 Volt, 1∅,
60 Hz
Controls
120V, 60Hz, 1 Ph Power Supply
120/24V Transformer
100% Pilot Shut-off/Lockout
Electronic, Intermittent Ignition (IID)
Pilot
High Limit Control - Automatic
On/Off Switch
Operating Limit Control
Economaster II Pump Time Delay
Gas Train
Manual Main Gas Shut-off Cock
Main Gas Pressure Regulator
Redundant Safety Shut-off Valve
Control Valve
Mechanical Modulation (H1)
Fuel
Natural Gas
Propane Gas
Design Certified ANSI Z21.13/
CSA 4.9
Construction
Front Controls
Stainless Steel Burners
Polytuf Powder Coat Finish
Vent Selection
Draft Diverter (Indoor) –
Option D-10
Stackless Top (Outdoor) –
Option D-11
High-Wind Top (Outdoor) –
Option D-13
Base – Optional
Combustible Floor Shield –
Option J-1
Vent Damper – Indoor Residential
models only
NOTE: Unit cannot be installed
outdoors in residential applications.
Raytherm
®
- Type H
Hydronic Heating Boilers
Residential Commercial
Model 133
INDOOR MODEL

Catalog No.: 2000.20P Effective: 12-1-07 Replaces: 4-1-05
Raytherm - Type H
Hydronic Heating Boilers Model 133
Indoor Outdoor Shipping Weight
Model
No. Input MBTU Output MBTU AFUE Output MBTU Lbs. (Approx.)
H-133 136 112 82.7% 109 160
NOTES:
Ratings shown are for elevations up to 2,000 feet. For elevations over 2,000 feet, reduce
ratings at the rate of 4% for each 1,000 feet above sea level.
BOILER RATE OF FLOW AND PRESSURE DROP
10°∆T 20°∆T 30°∆T 40°∆T
GPM ∆P FT. GPM ∆P FT. GPM ∆P FT. GPM ∆P FT.
22 14.7 11 3.8 N/A N/A N/A N/A
Raypak, Inc. 2151 Eastman Avenue, Oxnard, CA 93030 [phone] Fax [phone] www.raypak.com