Raypak Raytherm H-2100 User manual

Catalog No.: 2000.26M Effective: 12-1-07 Replaces: 12-1-99
Job:
Engineer:
Contractor:
Prepared By:
Model: Date:
EFFICIENT
82% thermal efficiency – highest of any atmospheric
boiler available today
THERMAL SHOCK PROOF
Twenty-year warranty against thermal shock damage
up to 150°F differential
Maximum operating temperature: 230°F
LIGHTWEIGHT
A floor load of 70 lbs./sq. ft. or less
HIGH RECOVERY
Cuts fuel costs substantially because the standby and
radiation losses normal to other boilers and tank-type
water heaters are eliminated
LOW WATER OPERATING TEMPERATURE
Operates with water temperature as low as 105°F
without condensing
Heat Exchanger
ASME Inspected and Stamped
160 PSIG
National Board Approved
Headers
Glass-lined Cast Iron – Standard
Bronze – Option A-1
Finned Tubing
Copper – Standard
Cupro Nickel – Option A-3
ASME Steel Tube Sheet
Silicone O-Rings
60 PSIG ASME Pressure Relief Valve
Temperature and Pressure Gauge
(Boiler)
Water Connections
Left Hand – Standard
Right Hand – Option A-6
Flow Configuration
Two-pass (Standard)
Single-pass (Cast Iron Only)
Controls
120V, 60Hz, 1 Ph Power Supply
120/24V Transformer
100% Pilot Shut-off/Lockout
Electronic, Intermittent Ignition (IID)
Pilot
High Limit Control, Manual Reset
High Limit Control, Auto Reset –
Models 3001-4001
On/Off Switch
Flow Switch
Economaster II Pump Time Delay
Gas Control Train
Manual Main Gas Shut-off Cock
Main Gas Pressure Regulator
Redundant Safety Shut-off Valve
Control Valve
Firing Mode
On/off (H4)
Two-stage Firing (H3)
Four-stage Firing (H9)
Motorized Modulation (H2)
B-6000 (H6)
Fuel
Natural Gas
Propane Gas
Design Certified ANSI Z21.13/
CSA 4.9
Construction
Front Controls
Stainless Steel Burners
Polytuf Powder Coat Finish
Built-in Draft Diverter
Draft Inducer
Motorized Draft Inducer –
Option D-2
Temperature Controllers
B-7 Modulating
B-5 Modulating, Outdoor Reset
B-6 Two-stage
B- Four-stage Digital
Y-241 Electronic Sequencer,
1-4 Stages
Y-281 Electronic Sequencer,
1-8 Stages
Additional Safety Controls
F-9 Low Water Cut-off Probe
I-1 High Limit Control,
Auto Reset
S-1 Low Gas Pressure Switch
S-2 High Gas Pressure Switch
Regulatory Agency Requirements
Raytherm
®
- Type H
Hydronic Heating Boilers
Commercial
Models 2100-4001 (Indoor)
Fig. 8184

Catalog No.: 2000.26M Effective: 12-1-07 Replaces: 12-1-99
Raytherm - Type H
Hydronic Heating Boilers Model
MODELS H 2100 THRU 4001
MBTUH Dimensions (inches) Approx.
Model Natural Gas Width Overall Height Gas Conn. Water Conn. Flue Dia. Shipping
No. Input Output A B G H K Weight (Lbs.)
H-2100 2100 1722 61.0 68-1/4 * 3** 24 1400
H-2500 2499 2049 70.0 68-1/4 * 3** 26 1580
H-3001 3000 2460 81-1/4 68-1/4 2 3** 28 1750
H-3500 3500 2870 92-1/2 68-1/4 2 3** 30 1920
H-4001 4000 3280 103-3/4 68-1/4 2 3** 32 2100
* 1-1/2” or 2” contingent on boiler type code requirementsNOTE: Ratings are for elevations up to 2,000 feet. For
elevations over 2,000 feet, reduce ratings 4% for
every 1,000 feet above sea level. ** 4” on one-pass option
BOILER RATE OF FLOW AND PRESSURE DROP
Model
10° ∆T 20°
∆
T 30°
∆
T 40°∆T
No. GPM
∆P FT GPM
∆
P FT GPM
∆
P FT GPM ∆P FT
H-2100 N/A N/A 172 11.0 115 5.0 N/A N/A
H-2500 N/A N/A N/A N/A 137 7.5 102 4.3
TWO-PASS H-3001 N/A N/A N/A N/A 164 11.2 123 6.5
H-3500 N/A N/A N/A N/A 191 16.2 144 9.3
H-4001 N/A N/A N/A N/A N/A N/A 164 12.8
H-2100 344 14.0 N/A N/A N/A N/A N/A N/A
H-2500 N/A N/A 205 5.3 N/A N/A N/A N/A
ONE-PASS H-3001 N/A N/A 246 7.8 N/A N/A N/A N/A
H-3500 N/A N/A 287 11.0 191 5.0 N/A N/A
H-4001 N/A N/A 328 14.8 219 6.8 N/A N/A
N/A – Not Applicable
NOTES:
Values represent maximum flows and pressure drops for closed heating systems.
Maximum acceptable flow through heat exchanger tubes is 200 GPM (two-pass); 400 GPM (one-pass)
Single-pass heat exchangers are to be used only when flow rates exceed the allowable for two-pass
Raypak, Inc. 2151 Eastman Avenue, Oxnard, CA 93030 [phone] Fax [phone] www.raypak.com