RealFlame 4098 User manual

Model # 4098
13oz Gel Fuel Can
Firebox Insert
4098_GelCanInsert_JW_010213
fireplaces
LOT: _____________
PO: _____________

Gel Fuel is flammable. Failure to follow warnings can result in property damage or serious burns.
Do not attempt to refuel a unit that is already burning. Pouring any kind of fuel on a fire can result in
flare-ups or flashbacks. Make sure the fire is out and allow the unit to cool for 20 minutes before refueling.
Use only Real Flame® 13 oz gel fuel cans in this unit. Do not use with any other fuel or flammable material.
Do not store or use gasoline or other flammable materials, including gel fuel, near this product. Vapors or leaks
from these types of items could travel to sources of flame or heat and increase the risk of fire or explosion.
In case of an emergency use a CO2 extinguisher or baking soda to extinguish the fire.
-
-
-
-
HAZARDS
2
WARNING
!!
If you have questions please call customer service at: 1-800-654-1704
RF Mantle WARNINGS 010713
Using your
Fireplace
Fireplace is designed to be used indoors.
Before using unit, be sure you have read and understood the step-by-step
instructions in this manual.
After several burns, soot may develop on the inside of the firebox. Clean with a
damp soapy rag.
During the initial burn you may experience a slight odor. Odor is temporary and
will be absent on following burns.
Real Flame® Gel Fuel contains isopropyl alcohol
Avoid contact with eyes, mucous membranes or prolonged contact with skin. May
irritate eyes. Store in a cool, dry place. Keep away from flame, heat or items that
spark. Use in well-ventilated areas. Keep out of reach of children and pets. In case
of fire, use a CO2 fire extinguisher or baking soda.
GEL FUEL
If fuel gets in eyes, flush with water for 15 minutes; get medical attention. If ingested,
do not induce vomiting; call poison control center or a doctor.
FIRST AID
-
-
-
-
Read entire label and all instructions included with gel fuel and fireplace PROPERTY DAMAGE,
SERIOUS INJURY OR DEATH may result if these warnings are not followed
1. Burn only Real Flame® 13oz Gel Cans in the fireplace. Never burn trash, paper, or wood in the unit.
2. Fireplace is not to be operated by anyone below age 18. Keep away from children and pets.
3. Make sure fireplace is placed on a flat and level surface. Failure to do so could cause the unit to tip,
resulting in property damage or serious injury. Do not place fireplace in an area with lots of traffic, such as
a hallway or entryway.
4. WARNING Never alter or dismantle the fireplace, metal firebox or logset in any manner.
5. Do not pour or scoop gel out of the can. Light Real Flame® gel fuel only when can is placed in the designated
area in unit. Wipe up spills. Use a long match or extended butane lighter to ignite fuel.
6. Never burn gel fuel cans outside the designated burn area in the metal firebox. Do not burn more than three
cans of fuel at any time.
7. Do not try to combine gel from different cans.
8. Never leave a burning fire unattended, especially around children or pets.
9. Never touch any metal surfaces during or immediately after burning gel fuel. They will be extremely HOT. Allow
surfaces to cool for 20 minutes before touching, changing cans, or moving the unit.
10. Do not wear flammable or loose clothing when operating the fire column.
11. Do not place more than 100 lbs. of weight on the top of the fireplace at anytime.
12. Exercise the same precautions as you would with any open fire.
NOTE: Users are responsible for following these instructions
and warnings and for operating this product safely.

3
Parts List
Nº Description Part Number Quantity
3
1
2
45
4
6
6
x4
1 Firebox Shell 4098010A 1
2 Log Set 4098010B 1
3 Plate 4098010C 1
4 Screen Panel 4098010D 2
5 Screen Rod 4098010E 1
6 Firebox Clip 4098010F 2
C
Hardware Kit 4098010H
x4
A
x4
B
x2
D

Step One
Slide the Screen Rod (5) through the rings on both
of the Screen Panels (4).
Do not put the Screen Rod through the last ring on
each Screen panel.
5
4
4

Step Two
Install the Screen Rod (5) under the hood of the
Firebox using one screw at each end (D).
Note: Screws for the screen rod are shipped pre
installed in the ends of the Screen Rod (5).
Leave these two
Screen Rod
5
D
D

Detail of Firebox
under hood.
Step Three
at either end and slip it into the cutout on the front
of the firebox underneath the hood.
6

Step Four
Remove the firebox clips (Figure 1) from the mantel if
they are installed. These will not be needed and may
be discarded.
NOTE: The fireplace depicted in this manual may not
resemble the fireplace that was purchased.
7
Install the firebox clips included with your firebox
using two machine screws (A) and nuts (B) and
attach the firebox clip as shown in Figure 2. The
larger side of the clip should be against the firebox.
Figure 2
Figure 1
A

Step Five
From the back of the fireplace insert the firebox into
the opening in the center of the fireplace.
8

Step Six
Attach the firebox to the back of the mantel with the
4 supplied wood screws (C). Attach the firebox to
the back of the side trim pieces as shown below.
NOTE: You may also reuse the screws that were used
to hold the original firebox clips included with the
mantel if any were included (Not all mantels will have
clips pre-attached).
9
C

10
2
Step Seven
Before installing the Log Set (2) into the firebox,
move the fireplace where you want it in your room.
Install the Log Set (2) into the firebox as shown in
the illustration. Log set should sit flat in front of the
three holes in the Plate (3). Try closing the screen
and move the log back if it is in the way.

11
Gel
Fuel
Step Eight
With the fireplace in place against a wall and the screen kit
and log set installed, place up to three gel fuel cans with
the labels removed into the firebox. One into each hole in
the plate.
NOTE: For operational safety refer to the warning information
on page 2 of this manual as well as your fireplace instructions.
Refer to the gel fuel can label for instructions on lighting and
extinguishing as well as all safety information for the gel fuel.

12
Customer Service: 1-800-654-1704 in USA
Service à la clientèle: 1-800-363-6443 in Canada
custserv@realflame.com
Warranty & Return Policies
Real Flame®
7800 Northwestern Ave.
Racine, WI 53403
Warranty
Real Flame® Company warrants Real Flame ventless fireplaces and accessories to be free from
defects in parts and workmanship under normal use and service for a period of 90 days from the
date of purchase. In the event of such defects Real Flame will, at its option, replace the defective
product or refund the purchase price. The foregoing is the exclusive remedy and Real Flame
disclaims all other warranties, including any implied warranty of merchantability or fitness for a
particular purpose. In addition, Real Flame will not be responsible for consequential damages in
excess of the purchase price of the product on which such liability is based. Electric fireplaces carry
a one-year warranty on the electric firebox only.
Return Policy
You may return your purchase within 90 days of receipt. No refunds will be issued for incomplete
or unauthorized returns. All returned products must be 100% complete, adequately packaged in
original packaging and in resalable condition. Products that have been assembled or modified will
not be eligible for return. All items must be returned in their entirety, meaning all items included
must be returned together. No returns or exchanges on discontinued items. Please begin the return
process by contacting the store or company where you bought your Real Flame item.
Replacement Parts
In the event that an item has been lost or damaged either by the manufacturer or in shipping you
may request a replacement. Replacement parts are not available for all units and only given at Real
Flame’s discretion. We will assess any damage and find a solution, which could include shipping
you a replacement. No replacements are available for discontinued items or repackaged (open
box) products. Please call Real Flame Customer Service at 800-654-1704 for replacement parts
before returning the damaged item. Please have the following information
(which can be found in your instruction manual) ready before you call Customer Service.
• Model Number of Item
• 4-8 digit Part Number
• Lot Code Number
• Shipping Address
• A picture of the damaged item may be requested. Pictures should be
sent to custserv@realflame.com
Incorrect Order Received
If you received something other than what you ordered, please contact Real Flame Customer
Service at 800-654-1704 within 48 hours of receiving the item.
Please refer to www.Realflame.com for our complete return guidelines and policies.