Sailor 100 User manual

INSTALLATION MANUAL
SAILOR 100 Satellite TV

SAILOR 100 Satellite TV
Installation manual
Document number: 98-136280-B
Release date: 18 January 2013
SAILOR100IM.book Page i Friday, January 18, 2013 10:28 AM

ii 98-136280-B
Disclaimer
Any responsibility or liability for loss or damage in connection with the use of this product and the
accompanying documentation is disclaimed by Thrane & Thrane. The information in this manual is
provided for information purposes only, is subject to change without notice and may contain errors
or inaccuracies. Manuals issued by Thrane & Thrane are periodically revised and updated. Anyone
relying on this information should acquire the most current version e.g. from
http://www.thrane.com or from the distributor.Thrane & Thrane is not responsible for the content or
accuracy of any translations or reproductions, in whole or in part, of this manual from any other
source.
Copyright
© 2013 Thrane & Thrane A/S. All rights reserved.
Trademark acknowledgements
•Thrane & Thrane is a registered trademark of Thrane & Thrane A/S in the European Union and the
United States.
•SAILOR is a registered trademark of Thrane & Thrane A/S in the European Union and the United
States.
•Windows is a registered trademark of Microsoft Corporation in the United States and other
countries.
• Other product and company names mentioned in this manual may be trademarks or trade names
of their respective owners.
GPL notification
The software included in this product contains copyrighted software that is licensed under the
GPL/LGPL. The verbatim licenses can be found online at:
http://www.gnu.org/licenses/old-licenses/gpl-2.0.html
http://www.gnu.org/licenses/old-licenses/lgpl-2.1.html
You may obtain the complete corresponding source code from us for a period of three years after
our last shipment of this product, which will be no earlier than 2021, by sending a money order or
check for DKK 50 to:
SW Technology/GPL Compliance,
Thrane & Thrane A/S,
Lundtoftegaardsvej 93D
2800 Lyngby
DENMARK
Please write "source for product SAILOR 100 Satellite TV" in the memo line of your payment.
This offer is valid to anyone in receipt of this information.
SAILOR100IM.book Page ii Friday, January 18, 2013 10:28 AM

98-136280-B iii
Safety summary
The following general safety precautions must be observed during all phases of operation,
service and repair of this equipment. Failure to comply with these precautions or with
specific warnings elsewhere in this manual violates safety standards of design,
manufacture and intended use of the equipment. Thrane & Thrane A/S assumes no liability
for the customer's failure to comply with these requirements.
Distance to other equipment
Do not move the Above Deck Unit closer to radars than the minimum safe distance
specified in section Interference on page 3-12 — it may cause damage to the Above Deck
Unit.
Compass Safe Distance:
SAILOR 100 Satellite TV antenna or ADU (Above Deck Unit): min. 100 cm (IEC 945).
SAILOR 100 Satellite TV ACU (Antenna Control Unit): min. 70 cm (IEC 945)
Service
User access to the interior of the ACU is prohibited. Only a technician authorized by Thrane
& Thrane A/S may perform service - failure to comply with this rule will void the warranty.
Access to the interior of the Above Deck Unit is allowed. Replacement of certain modules
and general service may only be performed by a technician authorized by Thrane & Thrane
A/S.
Grounding, cables and connections
To minimize shock hazard and to protect against lightning, the equipment chassis and
cabinet must be connected to an electrical ground. The ACU must be grounded to the ship.
For further grounding information refer to the Installation manual.
Do not extend the cables beyond the lengths specified for the equipment. The cable
between the ACU and Above Deck Unit can be extended if it complies with the specified
data concerning cable losses etc.
Rx cables for the SAILOR 100 Satellite TV system are shielded and should not be affected by
magnetic fields. However, try to avoid running cables parallel to high power and AC/RF
wiring as it might cause malfunction of the equipment.
Power supply
The voltage range for the SAILOR 100 Satellite TV is 20 — 32 VDC. Note that the Above Deck
Unit is powered by the ACU.
If a 24 VDC power bus is not available, an external 115/230 VAC to 28 VDC power supply can
be used, for example a SAILOR 6080 Power Supply.
Do not operate in an explosive atmosphere
Do not operate the equipment in the presence of flammable gases or fumes. Operation of
any electrical equipment in such an environment constitutes a definite safety hazard.
SAILOR100IM.book Page iii Friday, January 18, 2013 10:28 AM

iv 98-136280-B
Keep away from live circuits
Operating personnel must not remove equipment covers. Component replacement and
internal adjustment must be made by qualified maintenance personnel. Do not replace
components with the power cable connected. Under certain conditions, dangerous
voltages may exist even with the power cable removed. To avoid injuries, always
disconnect power and discharge circuits before touching them.
Failure to comply with the rules above will void the warranty!
SAILOR100IM.book Page iv Friday, January 18, 2013 10:28 AM

98-136280-B v
Record of Revisions
Rev. Description Release Date Initials
A Original document 21 September 2012 UFO
B The following sections have been added:
The following sections have been edited: 1.3, 2.1, 2.1.1, 3.3.2, 3.5,
4.2, 6.3.3, 6.3.6, 6.3.10, 6.4, 6.5.1
The following figures have been added: 2-5, 6-32,
The following figures have been edited: 2-3, 2-7, 3-25, 6-2, 6-3, 6-
4, 6-6, 6-7,6-9, 6-22, 6-24, 6-30, 6-34, 6-35, 6-36, 8-2
The following tables have been added: 6-8
The following tables have been edited: 1-1, 2-1, 2-2, 4-3, 6-1, 6-2,
6-5, C-1, C-2
18 January 2013 UFO
SAILOR100IM.book Page v Friday, January 18, 2013 10:28 AM

vi 98-136280-B
SAILOR100IM.book Page vi Friday, January 18, 2013 10:28 AM

98-136280-B vii
Table of contents
Chapter 1 About this manual
1.1 Intended readers ................................................................................ 1-1
1.2 Manual overview ...............................................................................1-1
1.3 Software version ................................................................................ 1-1
1.4 Related documents ............................................................................. 1-1
1.5 Typography ....................................................................................... 1-2
1.6 Precautions ....................................................................................... 1-3
Chapter 2 Introduction
2.1 SAILOR 100 Satellite TV system ......................................................... 2-1
2.1.1 Above Deck Unit (ADU) ....................................................................2-3
2.1.2 Antenna Control Unit (ACU) .............................................................2-7
2.1.3 Control Panel for setup and operation .............................................2-9
2.1.4 Multiswitch (optional) .....................................................................2-9
2.1.5 SAILOR Transmodulator (optional) ..................................................2-9
2.1.6 Power supply (optional) ................................................................ 2-10
2.1.7 System configuration example ...................................................... 2-10
2.2 Part numbers and options ................................................................ 2-11
2.2.1 Applicable Thrane & Thrane model and part numbers .................... 2-11
2.2.2 Options for SAILOR 100 Satellite TV ................................................. 2-11
SAILOR100IM.book Page vii Friday, January 18, 2013 10:28 AM

Table of contents
viii 98-136280-B
Chapter 3 Installation
3.1 Unpacking .........................................................................................3-1
3.1.1 What’s in the box .............................................................................3-1
3.1.2 Control Panel .................................................................................. 3-2
3.1.3 Initial inspection ............................................................................. 3-2
3.1.4 Tools needed .................................................................................. 3-2
3.2 Site preparation ................................................................................ 3-3
3.2.1 General site considerations ............................................................. 3-3
3.2.2 Obstructions (ADU shadowing) ....................................................... 3-4
3.2.3 Blocking zones — azimuth and elevation .........................................3-5
3.2.4 Ship motion and offset from the ship’s motion centre .....................3-6
3.2.5 ADU mast design: Foundation and height ....................................... 3-7
3.2.6 Interference ...................................................................................3-12
3.2.7 Other precautions ..........................................................................3-15
3.3 Installation of the ADU .....................................................................3-16
3.3.1 Installing the ADU ..........................................................................3-17
3.3.2 Opening and removing the service hatch ...................................... 3-20
3.3.3 Grounding the ADU ........................................................................3-21
3.3.4 Alternative ADU cable ................................................................... 3-22
3.4 Installation of the ACU .................................................................... 3-22
3.4.1 Installing the ACU ......................................................................... 3-22
3.4.2 Grounding the ACU ....................................................................... 3-23
3.5 Installation of the Control Panel ...................................................... 3-24
SAILOR100IM.book Page viii Friday, January 18, 2013 10:28 AM

Table of contents
98-136280-B ix
Chapter 4 Interfaces
4.1 Interfaces of the SAILOR 100 Satellite TV ACU ................................... 4-1
4.1.1 LEDs, display and keypad ................................................................ 4-1
4.1.2 Connector panel — overview ............................................................ 4-1
4.1.3 DC Input connector ..........................................................................4-2
4.1.4 ADU connector ................................................................................4-3
4.1.5 Rx connector ..............................................................................4-3
4.1.6 TV output connectors (x4) ................................................................4-3
4.1.7 DC output connector ........................................................................4-3
4.1.8 NMEA 0183 connector (RS-422) .......................................................4-4
4.1.9 DB9 connector ................................................................................4-5
4.1.10 LAN1, LAN2, LAN3 and LAN4 connectors ..........................................4-5
4.2 Interfaces of the Control Panel ..........................................................4-6
4.3 Interfaces of the SAILOR Transmodulator (optional) ..........................4-6
Chapter 5 Connecting power
5.1 Power source .................................................................................... 5-1
5.2 Power cable selection .......................................................................5-2
5.2.1 Source impedance ...........................................................................5-2
5.2.2 Measuring the ship source impedance ............................................5-2
5.2.3 Power cable recommendations .......................................................5-3
5.3 Connecting power .............................................................................5-4
5.4 Power up ..........................................................................................5-5
Chapter 6 Configuration
6.1 Introduction to the configuration tools .............................................. 6-1
6.1.1 Overview ......................................................................................... 6-1
6.1.2 Connecting to the web interface ......................................................6-2
6.1.3 Connecting the Control Panel ..........................................................6-3
6.2 Calibration of the SAILOR 100 Satellite TV .........................................6-4
6.2.1 Heading and calibration of azimuth ................................................6-4
SAILOR100IM.book Page ix Friday, January 18, 2013 10:28 AM

Table of contents
x 98-136280-B
6.3 Configuration with the web interface ...............................................6-8
6.3.1 Overview and navigation .................................................................6-8
6.3.2 Using the Dashboard ..................................................................... 6-11
6.3.3 Satellite profiles .............................................................................6-14
6.3.4 TV satellites ...................................................................................6-16
6.3.5 Reference satellites ........................................................................6-18
6.3.6 Azimuth adjustment ...................................................................... 6-20
6.3.7 Setting up Blocking zones ..............................................................6-21
6.3.8 Configuring the LAN network ........................................................ 6-24
6.3.9 E-mail setup ................................................................................. 6-27
6.3.10 Sending statistics reports ..............................................................6-28
6.3.11 Sending a diagnostics report .........................................................6-31
6.3.12 Upload .......................................................................................... 6-32
6.3.13 Administration .............................................................................. 6-32
6.4 Configuration with the Control Panel .............................................. 6-37
6.4.1 Getting started .............................................................................. 6-37
6.4.2 Creating or editing a profile ..........................................................6-38
6.4.3 Selecting the active profile .............................................................6-41
6.4.4 Deleting a profile ...........................................................................6-41
6.4.5 Event list ....................................................................................... 6-42
6.4.6 Help .............................................................................................. 6-42
6.4.7 About ............................................................................................ 6-43
6.5 Keypad and menus of the ACU ........................................................ 6-44
6.5.1 ACU display and keypad ............................................................... 6-44
6.5.2 Navigating the menus ................................................................... 6-45
6.5.3 The menu tree .............................................................................. 6-45
6.5.4 Adjusting brightness of the display ............................................... 6-48
6.5.5 Resetting the system .....................................................................6-48
Chapter 7 Installation check
7.1 Installation check list: Antenna ..........................................................7-1
7.2 Installation check list: ACU, connectors and wiring ........................... 7-3
7.3 Installation check list: Control Panel ................................................. 7-4
7.4 Installation check list: Functional test in harbor ................................ 7-5
SAILOR100IM.book Page x Friday, January 18, 2013 10:28 AM

Table of contents
98-136280-B xi
Chapter 8 Service
8.1 Getting support: Helpdesk .................................................................8-2
8.1.1 Help desk and diagnostic report ......................................................8-2
8.2 Software update .............................................................................. 8-5
8.2.1 Hardware and software requirements (updating ADU and ACU) ..... 8-5
8.2.2 Software update (ADU and ACU) .................................................... 8-5
8.2.3 Verifying the software update ......................................................... 8-6
8.3 Status signalling with LEDs and status messages ..............................8-7
8.3.1 LEDs of the ADU modules ............................................................... 8-8
8.3.2 LEDs in the ACU ............................................................................. 8-8
8.4 Removal and replacement of the ACU ............................................... 8-9
8.5 Removal and replacement of ADU modules ..................................... 8-10
8.6 Troubleshooting .............................................................................. 8-13
8.6.1 Overview ....................................................................................... 8-13
8.6.2 Event list for troubleshooting ........................................................ 8-13
8.6.3 Diagnostic report for troubleshooting ............................................ 8-13
Appendix A Technical specifications
A.1 SAILOR 100 Satellite TV system components ......................................A-1
A.1.1 General specifications .....................................................................A-1
A.1.2 ADU ............................................................................................... A-2
A.1.3 ACU ................................................................................................ A-4
A.1.4 Control Panel and SAILOR Transmodulator ..................................... A-4
A.2 Outline drawings ............................................................................. A-5
A.2.1 ADU ............................................................................................... A-5
A.2.2 ACU ................................................................................................ A-6
A.2.3 N-connector interface on the ADU .................................................. A-7
Appendix B Grounding and RF protection
B.1 Why is grounding required? ..............................................................B-1
B.1.1 Reasons for grounding ....................................................................B-1
B.1.2 Safety ..............................................................................................B-1
B.1.3 ESD Protection ................................................................................B-1
B.2 Grounding Recommendations .......................................................... B-2
B.2.1 Grounding the ACU ........................................................................ B-2
B.2.2 Grounding the ADU ........................................................................ B-3
SAILOR100IM.book Page xi Friday, January 18, 2013 10:28 AM

Table of contents
xii 98-136280-B
B.3 Alternative grounding for steel hulls ................................................B-4
B.3.1 Grounding the ACU .........................................................................B-4
B.3.2 Grounding the ADU .........................................................................B-4
B.4 Alternative grounding for aluminum hulls ........................................B-6
B.4.1 Grounding the ACU .........................................................................B-6
B.4.2 Grounding the ADU .........................................................................B-6
B.5 Alternative grounding for fibre glass hulls ...................................... B-8
B.5.1 Grounding the ACU ........................................................................ B-8
B.5.2 Grounding the ADU ........................................................................ B-8
B.6 Separate ground cable ..................................................................... B-9
B.6.1 Ground cable - construction .......................................................... B-9
B.6.2 Ground cable - connection ............................................................ B-10
B.6.3 Isolation of the ADU from the mounting base ................................ B-10
B.7 Jumper cable for grounding ............................................................ B-12
B.8 RF interference ............................................................................... B-13
B.8.1 Recommendations ........................................................................ B-13
Appendix C System messages
C.1 Event messages — overview ..............................................................C-1
C.2 List of ADU events .............................................................................C-2
C.3 List of ACU events .............................................................................C-7
Glossary ............................................................................................................ Glossary-1
Index .................................................................................................................Index-1
SAILOR100IM.book Page xii Friday, January 18, 2013 10:28 AM

98-136280-B xiii
List of figures
Chapter 1 About this manual
Chapter 2 Introduction
Figure 2-1: ADU, ACU, Control Panel and Multiswitch (optional) ............................................2-2
Figure 2-2: Above Deck Unit (ADU).........................................................................................2-3
Figure 2-3: ADU modules 1/2 ..................................................................................................2-4
Figure 2-4: ADU modules 2/2................................................................................................. 2-5
Figure 2-5: Examples of LNB LO frequencies used worldwide ................................................ 2-6
Figure 2-6: SAILOR 100 Satellite TV ACU, connector overview ................................................ 2-8
Figure 2-7: SAILOR 6004 Control Panel.................................................................................. 2-9
Figure 2-8: SAILOR Transmodulator (optional)...................................................................... 2-10
Figure 2-9: ADU, ACU, Control Panel and SAILOR Transmodulator (optional)........................ 2-10
Chapter 3 Installation
Figure 3-1: Signal degradation because of obstructing objects ...............................................3-4
Figure 3-2: 2 blocking zones, azimuth (example)................................................................... 3-5
Figure 3-3: Blocking zone, elevation angle (example) ........................................................... 3-5
Figure 3-4: Maximum distance from the ship’s motion centre (h max)................................... 3-6
Figure 3-5: ADU mast flange, top and side view......................................................................3-7
Figure 3-6: ADU mast flange, recommended flatness on the mast mount plateau...................3-7
Figure 3-7: ADU mast flange, distance to the welded seam ................................................... 3-8
Figure 3-8: ADU, bottom view................................................................................................ 3-8
Figure 3-9: Free mast length and bracing for a tall mast ....................................................... 3-9
Figure 3-10: Interference with the vessel’s radar.................................................................... 3-12
Figure 3-11: Recommended distance to transmitters (m) for frequencies below 1000 MHz ..... 3-14
Figure 3-12: Drain pipe with free space .................................................................................. 3-15
Figure 3-13: Use of strong sling with a belt and tag lines for safe hoisting ............................. 3-16
Figure 3-14: Free space for access to the service hatch........................................................... 3-17
Figure 3-15: ADU installation, webbed sling attached to the 4 lifting brackets........................ 3-18
Figure 3-16: Mounting the ADU on the mast flange................................................................ 3-18
Figure 3-17: Connecting the ADU cable .................................................................................. 3-19
Figure 3-18: Opening the service hatch ..................................................................................3-20
Figure 3-19: Removing the 2 split pins ...................................................................................3-20
Figure 3-20: ADU, bolt for optimum grounding....................................................................... 3-21
Figure 3-21: ACU, On/off switch at the back............................................................................3-23
SAILOR100IM.book Page xiii Friday, January 18, 2013 10:28 AM

List of figures
xiv 98-136280-B
Figure 3-22: ACU, LAN connector at the front: Service port..................................................... 3-23
Figure 3-23: ACU, ground stud............................................................................................... 3-24
Figure 3-24: Connecting the Control Panel to the ACU, LAN4 ................................................. 3-24
Chapter 4 Interfaces
Figure 4-1: ACU, LEDs, display and keypad .............................................................................4-1
Figure 4-2: ACU, connector panels, overview ..........................................................................4-1
Figure 4-3: DC Input connector with power cable ...................................................................4-2
Chapter 5 Connecting power
Figure 5-1: Measuring the ship source impedance.................................................................5-3
Figure 5-2: Connecting power to DC Input..............................................................................5-4
Figure 5-3: ACU display after first power on (example with LAN port 1 used) ..........................5-5
Chapter 6 Configuration
Figure 6-1: LAN 3 connector used for configuring the SAILOR 100 Satellite TV........................6-2
Figure 6-2: SAILOR 100 Satellite TV Dashboard.......................................................................6-2
Figure 6-3: Web interface: SERVICE, Calibration.....................................................................6-4
Figure 6-4: Topics in the web interface (SITE MAP) ................................................................6-8
Figure 6-5: Sections of the web interface................................................................................6-9
Figure 6-6: Web interface: DASHBOARD................................................................................6-12
Figure 6-7: Web interface: SETTINGS - list of satellite profiles (example)...............................6-14
Figure 6-8: Web interface: SETTINGS, Satellite profiles — new entry (example)......................6-14
Figure 6-9: TV satellite, remove and disable..........................................................................6-16
Figure 6-10: Web interface: SERVICE - TV satellites (example) ................................................6-17
Figure 6-11: Web interface: SETTINGS > TV satellites — new entry (example) ..........................6-17
Figure 6-12: Reference satellite, remove and disable ..............................................................6-18
Figure 6-13: Web interface: SERVICE - Reference satellites (example).....................................6-19
Figure 6-14: Web interface: SETTINGS > Satellites — new entry (example)...............................6-19
Figure 6-15: Web interface: SERVICE, Calibration: Azimuth adjustment..................................6-20
Figure 6-16: Web interface: SETTINGS, Blocking zones — azimuth and elevation.................... 6-22
Figure 6-17: Blocking zone, example: 315 - 45 degrees.......................................................... 6-23
Figure 6-18: Blocking zone, example: 45 - 315 degrees .......................................................... 6-23
Figure 6-19: Web interface: SETTINGS, Network (default settings)..........................................6-24
Figure 6-20: Web interface: SETTINGS, E-mail setup (example).............................................. 6-27
Figure 6-21: Web interface: SETTINGS, Reports (example) .....................................................6-28
Figure 6-22: Statistics — how to read data for a range............................................................6-30
SAILOR100IM.book Page xiv Friday, January 18, 2013 10:28 AM

List of figures
98-136280-B xv
Figure 6-23: Statistics report (example) .................................................................................. 6-31
Figure 6-24: Web interface: Administration ............................................................................6-32
Figure 6-25: Web interface: Administration, change administrator logon and password.........6-33
Figure 6-26: Web interface: ADMINISTRATION, Reset administrator password .......................6-33
Figure 6-27: Web interface: ADMINISTRATION, User permissions...........................................6-34
Figure 6-28: Web interface: Administration, Export/import configuration ...............................6-35
Figure 6-29: Web interface: ADMINISTRATION, Factory default ..............................................6-36
Figure 6-30: Control Panel — Dashboard ................................................................................6-37
Figure 6-31: Control Panel — Editing a satellite profile ...........................................................6-39
Figure 6-32: Examples of LNB LO frequencies used worldwide .............................................. 6-40
Figure 6-33: Control Panel — Selecting a satellite profile ........................................................ 6-41
Figure 6-34: Control Panel, active events................................................................................6-42
Figure 6-35: Display (example) and keypad of the ACU...........................................................6-44
Figure 6-36: ACU menu tree ...................................................................................................6-45
Figure 6-37: Reset the system.................................................................................................6-48
Chapter 7 Installation check
Chapter 8 Service
Figure 8-1: Web interface: HELPDESK .................................................................................... 8-2
Figure 8-2: Web interface: HELPDESK, Event list .................................................................... 8-3
Figure 8-3: LAN connector used for configuring the SAILOR 100 Satellite TV .......................... 8-5
Figure 8-4: Verifying software update.................................................................................... 8-6
Figure 8-5: LEDs on the ACU.................................................................................................. 8-8
Figure 8-6: ADU modules and motor stop switch .................................................................. 8-10
Figure 8-7: Above Deck Unit modules (continued) ................................................................ 8-12
App. A Technical specifications
Figure A-1: Outline drawing: ADU.......................................................................................... A-5
Figure A-2: Outline drawing: ACU .......................................................................................... A-6
Figure A-3: N-Connector interface on the ADU....................................................................... A-7
App. B Grounding and RF protection
Figure B-1: Extending the ground plane ................................................................................ B-2
Figure B-2: Grounding the ADU ............................................................................................. B-3
Figure B-3: Grounding at a dedicated RF ground (alternative) ............................................... B-5
Figure B-4: Alternative grounding for aluminium hulls .......................................................... B-7
Figure B-5: Alternative grounding for fibreglass hulls............................................................B-8
SAILOR100IM.book Page xv Friday, January 18, 2013 10:28 AM

List of figures
xvi 98-136280-B
Figure B-6: Separate ground cable........................................................................................ B-9
Figure B-7: Isolation of the ADU from the mounting base..................................................... B-10
Figure B-8: ADU isolation and grounding cable.....................................................................B-11
Figure B-9: Jumper cable for grounding (specifications) ....................................................... B-12
App. C System messages
SAILOR100IM.book Page xvi Friday, January 18, 2013 10:28 AM

98-136280-B xvii
List of tables
Chapter 1 About this manual
Table 1-1: List of Related Documents .................................................................................... 1-2
Chapter 2 Introduction
Table 2-1: Model and part numbers for the SAILOR 100 Satellite TV system (T&T units) ........ 2-11
Table 2-2: Model and part numbers for options of the SAILOR 100 Satellite TV system ......... 2-11
Chapter 3 Installation
Table 3-1: Maximum distance from the ship’s motion center versus ship’s roll period.......... 3-6
Table 3-2: Mast dimensions without braces ........................................................................ 3-10
Table 3-3: Mast dimensions with 3 braces........................................................................... 3-10
Table 3-4: Mast dimensions with 2 braces............................................................................ 3-11
Table 3-5: Minimum radar separation, X-band ................................................................... 3-13
Table 3-6: Minimum radar separation, S-band.................................................................... 3-13
Table 3-7: ADU cable types and maximum lengths..............................................................3-22
Chapter 4 Interfaces
Table 4-1: DC Input plug, outline and pin assignment...........................................................4-2
Table 4-2: N connector, outline and pin assignment .............................................................4-3
Table 4-3: F connector, Rx, outline and pin assignment ........................................................4-3
Table 4-4: NMEA 0183/2000 connector, outline and pin assignment .....................................4-4
Table 4-5: Ethernet connector, outline and pin assignment.................................................. 4-5
Chapter 5 Connecting power
Chapter 6 Configuration
Table 6-1: Configuration tools: Web interface and Control Panel........................................... 6-1
Table 6-2: Satellite identifier and NID values........................................................................ 6-6
Table 6-3: Possible error codes during calibration ............................................................... 6-6
Table 6-4: Web interface: Event icon ................................................................................... 6-10
Table 6-5: Web interface, DASHBOARD, SAILOR 100 Satellite TV parameters ....................... 6-12
Table 6-6: Web interface, DASHBOARD, POINTING parameter............................................. 6-13
Table 6-7: Setup of LAN connectors.....................................................................................6-25
Table 6-8: Statistics report, header record...........................................................................6-29
Table 6-9: Parameters recorded in a statistics report...........................................................6-29
SAILOR100IM.book Page xvii Friday, January 18, 2013 10:28 AM

List of tables
xviii 98-136280-B
Table 6-10: Control Panel, create or edit satellite profiles.....................................................6-39
Table 6-11: Top-level menus of the ACU ............................................................................... 6-46
Table 6-12: ANTENNA menu of the ACU................................................................................6-46
Table 6-13: NETWORK menu of the ACU ............................................................................... 6-47
Table 6-14: SATELLITE menu of the ACU ............................................................................... 6-47
Table 6-15: EVENTS menu of the ACU ...................................................................................6-48
Chapter 7 Installation check
Table 7-1: Installation check list: Antenna .............................................................................7-1
Table 7-2: Installation check list: ACU, connectors and wiring ..............................................7-3
Table 7-3: Installation check list: Control Panel, connectors and wiring ................................ 7-4
Table 7-4: Installation check list: Functional test in harbour .................................................7-5
Chapter 8 Service
Table 8-1: LEDs of the ADU modules.....................................................................................8-8
Table 8-2: LEDs on the ACU ..................................................................................................8-8
App. A Technical specifications
Table A-1: General specifications .......................................................................................... A-1
Table A-2: Technical specifications for the Above Deck Unit ................................................. A-2
Table A-3: Technical specifications for the ACU.................................................................... A-4
App. B Grounding and RF protection
App. C System messages
Table C-1: ADU event messages............................................................................................C-2
Table C-2: ACU event messages ............................................................................................C-7
SAILOR100IM.book Page xviii Friday, January 18, 2013 10:28 AM