Samson 08-5000 User manual

COMMERCIAL WHEATGRASS JUICER
DUE TO CONSTANT FACTORY IMPROVEMENTS, THE PRODUCT PICTURED MIGHT DIFFER
SLIGHTLY FROM THE PRODUCT IN THIS BOX.
PARCE QUE LE FABRICANT AMÉLIORE CONTINUELLEMENT LE PRODUIT, L’IMAGE DU PRODUIT
ILLUSTRÉ PEUT ÊTRE LÉGÈREMENT DIFFÉRENTE DU PRODUIT CONTENU DANS CETTE BOÎTE.
DEBIDO A LAS CONSTANTES MEJORAS DE FÁBRICA, EL PRODUCTO QUE SE MUESTRA AQUÍ
PUEDE SER LIGERAMENTE DIFERENTE DEL PRODUCTO INCLUIDO EN ESTA CAJA.
EXTRACTEUR À JUS D’HERBES COMMERCIAL
JUGUERA COMERCIAL DE HIERBA DE TRIGO
READ BEFORE USE.
LIRE AVANT UTILISTATION.
LEA ANTES DE USAR.
Le invitamos a leer cuidadosamente este
instructivo antes de usar su aparato
Samson
Brands

2
1. Read all instructions.
2. This appliance is not intended for use by persons
with reduced physical, sensory, or mental
capabilities, or lack of experience and knowledge,
unless they are closely supervised and instructed
concerning use of the appliance by a person
responsible for their safety.
3. This appliance shall not be used by children. Keep
the appliance and its cord out of reach of children.
4. Close supervision is necessary when any
appliance is used near children. Children should
be supervised to ensure that they do not use or
play with the appliance.
5. To protect against risk of electric shock, do not put
cord, plug, base, or motor in water or other liquid.
6. Read and understand all information in this manual
before using the wheatgrass juicer.
7. Clean the wheatgrass juicer before using it for the
rst time and every time after use. See the “Care
and Cleaning” section of this manual.
8. Never feed food by hand. Always use the provided
food pusher. Keep ngers clear of the auger and
cutting blades at all times. Never reach into the
Food Chute. Doing so may cause serious injury.
9. To avoid serious personal injury, never reach
into the Feed Chute. Use the stomper to push
wheatgrass into the Feed Chute.
10. Turn the appliance OFF( O ), then unplug from
outlet when not in use, before putting on or taking
off parts, and before cleaning. To unplug, grasp
the plug and pull from the outlet. Never pull from
the power cord.
11. Avoid contacting moving parts. Never feed food by
hand. Always use food Stomper.
12. Always disconnect power cord from outlet when
not in use and before cleaning, assembling,
disassembling, and servicing.
13. Do not place on or near a hot gas or electric
burner.
14. Check that the appliance is OFF ( O ) before
plugging cord into wall outlet. To disconnect, turn
the control to OFF ( O ); then remove plug from
wall outlet. To unplug, grasp the plug and pull from
the outlet. Never pull from the power cord.
15. Before plugging cord into wall outlet, turn off the
appliance. To disconnect cord, switch to OFF ( O ).
Then remove plug from wall outlet.
16. Do not operate the wheatgrass juicer without
wheatgrass in the head. Damage to the head and
auger may occur.
17. Do not operate any appliance with a damaged
supply cord or plug, or after the appliance
malfunctions or has been dropped or damaged
IMPORTANT: This operation manual should be reviewed with all equipment
operators as part of your operator training program.
WARNING – When using electrical appliances, basic safety precautions should
always be followed to reduce the risk of re, electric shock, and/or injury to
persons, including the following:
SAVE THESE INSTRUCTIONS
IMPORTANT SAFEGUARDS
in any manner. Supply cord replacement and
repairs must be conducted by the manufacturer,
its service agent, or similarly qualied persons in
order to avoid a hazard. Call the provided technical
service number for information on examination,
repair, or adjustment.
18. The use of attachments not recommended or sold
by the appliance manufacturer may cause re,
electric shock, or injury.
19. Do not use parts or attachments from other
manufacturers on the wheatgrass juicer. Use of
unauthorized parts or attachments may cause
personal injury and/or unit damage and will void
the warranty.
20. To reduce the risk of severe personal injury, and/
or damage to the juicer, tie back loose hair and
clothing, and roll up long sleeves before operating
the juicer. Remove ties, rings, watches, bracelets,
and other jewelry before operating the juicer.
21. To reduce the risk of severe personal injury, and/
or damage to the juicer, tie back long hair, roll
up long sleeves, and remove ties, watches, and
jewelry.
22. Wait until all parts have stopped moving before
toggling the wheatgrass juicer into “Reverse” or
“Forward.”
23. Do not run the Wheatgrass Juicer in “Reverse” for
more than 3 seconds at a time.Damage to the unit
may occur.
24. Do not use appliance for other than intended
purpose.
25. Do not operate the wheatgrass juicer if the juicer
motor is very cold. The temperature of the juicer
motor should be at least 45
o
F (7
o
C) before use.
26. The body and juicer motor may become warm
during use. This is normal. Do not touch these
parts while the wheatgrass juicer is running or until
they cool afterwards.
27. Avoid contact with moving parts.
28. Auger is sharp. Handle carefully.
29. Do not leave appliance unattended while it is
operating.
30. Check that the voltage indicated on the appliance
corresponds to the local main voltage before you
connect the appliance.
31. Never operate the juicer unattended. Be safe.
Disconnect the juicer from power source before
leaving the work area.
32. CAUTION! In order to avoid a hazard due to
inadvertent resetting of the thermal cut-out,
this appliance must not be supplied through an
external switching device, such as a timer, or
connected to a circuit that is regularly switched on
and off by the utility.

3
1
7
45
Power
Cord
6
10
12
Juice
Outlet
Feed
Chute
2
3
9
11
Power Switch
Circuit Breaker
Reset Button
13
8
wWARNING
Electrical Shock Hazard. This appliance is provided with a grounded
(3-prong) plug to reduce the risk of electric shock. The plug ts only one way into a grounded
outlet. Do not defeat the safety purpose of the plug by modifying the plug in any way or by
using an adapter. If the plug does not t into the outlet, have an electrician replace the outlet.
The length of the cord used on this appliance was selected to reduce the hazards of
becoming tangled in or tripping over a longer cord. If a longer cord is necessary, an approved
extension cord may be used. The electrical rating of the extension cord must be equal to or
greater than the rating of the appliance. The extension cord must be a grounding-type, 3-wire
cord. Care must be taken to arrange the extension cord so that it will not drape over the
countertop or tabletop where it can be pulled on by children or accidentally tripped over.
If the auger assembly locks and will not move, it will damage the motor.
Do not use. Call the toll-free customer service number for information.
PARTS AND FEATURES
Remove all parts from packaging material and check to be sure there are no missing parts.
Clean and sanitize the Wheatgrass Juicer as indicated in the "Care and Cleaning" section
of this manual before using it for the rst time.
DO NOT IMMERSE THE JUICER MOTOR IN WATER OR OTHER LIQUIDS.
The Wheatgrass Juicer head assembly has been upgraded to include a waste
valve washer. As with most commercial wheatgrass juicers, overtightening
the waste valve (also referred to as the end cap or outlet screw) is a common
occurrence that inhibits the production of juice, buildup of pulp, and causes
wear on the parts. The addition of the head assembly washer prevents
accidental overtightening of the waste valve and will prolong the life of parts.
OTHER SAFETY INFORMATION
56
7 8
9
10
11
12
13
14

4
PARTS AND FEATURES
The head assembly consists of:
1. Head-Aligning Cap (Part #8)
2. Waste Valve Washer (Part of #9)
3. Waste Valve (Part of #9)
HEAD ASSEMBLY PARTSHEAD ASSEMBLED
3 2 1
DIAGRAM NUMBER
NO DU SCHÉMA
NÚMERO DE DIAGRAMA
PART DESCRIPTION
DESCRIPTION DE LA PIÈCE
DESCRIPCIÓN DE LA PIEZA
1HEAD FOREUSE
CABEZAL
2HEAD-LOCKING SCREW VIS DE BLOCAGE DE FOREUSE
TORNILLO DE BLOQUEO DE CABEZAL
3AUGER BUSHING MAMELON DE RÉDUCTION DE VIS SANS FIN
COJINETE DE TORNILLO SIN FIN
4SCREEN TAMIS
FILTRO
5DRIVE SHAFT ARBRE D'ENTRAÎNEMENT
EJE IMPULSOR
COMPONENT LIST
LISTE DES COMPOSANTS
LISTA DE COMPONENTES

5
DIAGRAM NUMBER
NO DU SCHÉMA
NÚMERO DE DIAGRAMA
PART DESCRIPTION
DESCRIPTION DE LA PIÈCE
DESCRIPCIÓN DE LA PIEZA
6AUGER VIS SANS FIN
TORNILLO SIN FIN
7RUBBER GASKET JOINT D’ÉTANCHÉITÉ EN CAOUTCHOUC
ARANDELA DE GOMA
8HEAD-ALIGNING CAP CAPUCHON D’ALIGNEMENT DE LA FOREUSE
TAPA DE ALINEACIÓN DEL CABEZAL
9WASTE VALVE AND WASHER SOUPAPE D’ÉVACUATION DE RÉSIDUS ET RONDELLE
VÁLVULA Y ARANDELA DE DESPERDICIOS
10 RUBBER FEET (4) PIEDS EN CAOUTCHOUC (4)
PATAS DE GOMA (4)
11 STOMPER PILON
PISÓN
12 HEAD-ALIGNING CAP WRENCH CLÉ POUR CAPUCHON D’ALIGNEMENT DE VIS SANS FIN
LLAVE DE LA TAPA DE ALINEACIÓN DEL CABEZAL
NOT SHOWN
NON ILLUSTRÉ
NO MOSTRADO
TOGGLE SWITCH RUBBER BOOT
INTERRUPTEUR À BASCULE À GAINE CAOUTCHOUTÉE
PATA DE GOMA DEL INTERRUPTOR DE PALANCA
13
REPLACEMENT PARTS KIT
SCREEN (2)
RUBBER GASKET (2)
AUGER BUSHING (2)
TROUSSE DE PIÈCES DE RECHANGE
TAMIS (2)
JOINT D’ÉTANCHÉITÉ EN CAOUTCHOUC (2)
MAMELON DE RÉDUCTION DE VIS SANS FIN (2)
KIT DE PIEZAS DE REEMPLAZO
FILTRO (2)
ARANDELA DE GOMA (2)
COJINETE DE TORNILLO SIN FIN (2)
14 COMPLETE HEAD ASSEMBLY ASSEMBLAGE DE FOREUSE COMPLET
MONTAJE DE CABEZAL COMPLETO

6
wWARNING Entanglement Hazard.
• Disconnect power before cleaning, disassembling, or assembling.
• Never operate Wheatgrass Juicer unless it is fully and properly assembled.
• Never reach into the Head Opening.
• Only use the stomper to push wheatgrass into the Head.
• Secure hair and loose clothing.
• Read and understand all information in this manual before use.
FIGURE 1
FIGURE 2
Slot
Head
Screen
Head
Auger
Bearing
Auger
Rubber
Gasket
Head-
Aligning
Cap
Waste
Valve
Auger
Splines
FIGURE 3
NOTICE:
Make sure Screen
is properly seated
in the slot before
operation or unit
damage will occur.
FIGURE 4
Head-
Locking
Screw
Pin Inside
Receptacle
Cutout
in Head
Waste
Valve
Washer
ASSEMBLY INSTRUCTIONS
1. Slide the Screen (curved side
down) into the slot on the inside
bottom of the Head until it stops.
Make sure both sides of the Screen
are within the slot (FIGURE 1).
2. Place the Auger Bearing onto the
splined end of the Auger. Insert
the Auger into the open end of the
Head until it stops. The splines
on the end of the Auger should
protrude from the opposite end
of the Head (FIGURE 2).
3. Place the Rubber Gasket
onto the at surface on the
inside of the Head-Aligning
Cap below the threads.
The Rubber Gasket is
properly installed when it lays
at on the surface (FIGURE 3).
4. Place the Waste Valve Washer on
the Waste Valve. Then screw the
Waste Valve counterclockwise into
the tip of the Head-Aligning Cap
until it stops. Screw Head-Aligning
Cap onto Head.
5. Loosen the Head-Locking Screw
on the Juicer Motor until it no longer
protrudes into the receptacle for the
Head Assembly (FIGURE 3).
6. Install the Head Assembly onto the
Juicer Motor. You will need to align
the cutout on the Head with the
pin inside the receptacle
(FIGURE 4). Align the Auger
Splines with the keyways on the
drive shaft of the Juicer Motor. If the
parts do not align, rotate the Auger
end (it protrudes from the Head) a
bit and try again. Wiggling the Head
Assembly during installation may
help as well.
IMPORTANT: Tighten the Head-Locking
Screw until it rmly holds the Head
Assembly in place.
Stomper

7
The Wheatgrass Juicer is equipped
with a Circuit Breaker to protect it
from damage due to overload or
short circuit. If the Wheatgrass Juicer
should unexpectedly stop running,
take the following steps to get it
running again.
1. Turn the Power Switch to the
“OFF” (O) position.
2. Check for possible reasons for the
overload, i.e., a jam in the machine
or incorrect assembly.
3. Press the Circuit Breaker Reset Button (FIGURE 5).
4. Turn the Wheatgrass Juicer back on.
5. Resume normal operation.
If the Wheatgrass Juicer still does not run, check the circuit breaker to see if it
has tripped and/or try connecting the Power Cord to a different electrical outlet.
If these steps don’t work or if the Circuit Breaker repeatedly trips, turn the unit off
and disconnect it from the electrical outlet. DO NOT continue to try running the
Wheatgrass Juicer or unit damage may occur. See page 3 for Technical Services
information.
FIGURE 5
Circuit Breaker
Reset Button
CIRCUIT BREAKER INSTRUCTIONS
1. Turn the Wheatgrass Juicer to the “OFF” (O) Position. Disconnect Power Cord
from the electric outlet.
2. Loosen the Head-Aligning Cap (on the Head) by turning it clockwise. DO NOT
REMOVE the Head-Aligning Cap at this time. Use the Head-Aligning Cap
Wrench if necessary.
3. Loosen the Head-Locking Screw on the Juicer Motor until it releases the Head
Assembly.
4. Remove the Head-Assembly from the Juicer Motor.
5. Unscrew the Head-Aligning Cap from the Head by turning it clockwise.
6. Unscrew the Waste Valve from the Head-Aligning Cap by turning it clockwise.
7. Remove the Rubber Gasket from the Head-Aligning Cap.
8. Remove the Auger and Screen from the Head.
9. Allow the parts to air-dry before reassembling and storing the Wheatgrass
Juicer.
10. The Wheatgrass Juicer is NOT dishwasher-safe.
DISASSEMBLY INSTRUCTIONS
wWARNING Entaglement Hazard.
Disconnect power before cleaning, disassembling, or assembling.

8
OPERATING INSTRUCTIONS
1. Place a cup under the outlet on
the bottom of the Head to collect
juice. Place a cup or container
under the Waste Valve to collect
pulp (FIGURE 6).
2. Fill the Head with
wheatgrass.
3. Make sure the Power
Switch is in the “OFF”
(O) position. Connect
the Power Cord on
the Juicer Motor to an
electrical outlet.
4. Turn the Wheatgrass
Juicer “ON” by pushing
the Power Switch to
the “Forward” position.
5. Use the Stomper to push
wheatgrass into the Head. DO
NOT use your ngers to push
wheatgrass into the Head!
6. Add wheatgrass to the Head as
needed to keep juice owing. Always be careful. Keep your ngers clear of the
Head Opening.
7. Turn the Wheatgrass Juicer “OFF” (O) and disconnect the Power Cord from the
electrical outlet when you are done.
Head
Opening
KEEP FINGERS
CLEAR!
Power
Switch
wWARNING Entanglement Hazard.
• Never operate Wheatgrass Juicer unless it is fully and properly assembled.
• Never reach into the Head Opening.
• Only use the stomper to push wheatgrass into the Head.
• Disconnect power before cleaning, disassembling, or assembling.
• Secure hair and loose clothing.
• Read and understand all information in this manual before use.

9
WASTE VALVE SETTINGS
To extract the maximum amount of
juice from wheatgrass, we recommend
you fully close the Waste Valve with
the Waste Valve Washer in place.
DO NOT operate the juicer without
the Waste Valve Washer; it can result
in damage (FIGURE 7). A different
setting may result in more juice,
though. Experiment by adjusting the
Waste Valve in and out. Be careful not
to remove the Waste Valve while the
Wheatgrass Juicer is running.
FIGURE 7
Waste
Valve
Washer
NOTICE: DO NOT run the
Wheatgrass Juicer in reverse for
more than 3 seconds at a time. Unit
damage may occur.
Use the Reverse Function
to improve ow through the
Wheatgrass Juicer when necessary.
Briey engage “Reverse” to help
clear a jam, for example.
1. Turn the Power Switch to the “OFF” (O) position.
2. Wait until the Juicer Motor comes to a complete stop.
3. Briey hold the Power Switch in the “Reverse” position (FIGURE 8). DO NOT
hold the Power Switch in “Reverse” for more than about 3 seconds. Unit
damage may occur.
4. The Power Switch will automatically return to “OFF” (O) once released from
the “Reverse” position.
If juice ow does not improve after engaging “Reverse,” disassemble, clear the
jam, and clean the Screen holes before resuming operation.
Power
Switch
FIGURE 8
Waste
Valve
USING THE REVERSE FUNCTION
wWARNING Entanglement Hazard.
• Never operate Wheatgrass Juicer unless it is fully and properly assembled.
• Never reach into the Head Opening.
• Only use the stomper to push wheatgrass into the Head.
• Disconnect power before cleaning, disassembling, or assembling.
• Secure hair and loose clothing.
• Read and understand all information in this manual before use.

10
CARE AND CLEANING
JUICER MOTOR
1. Make sure the Power Cord on the Juicer Motor is disconnected from the
electric outlet.
2. Clean the Juicer Motor by wiping it with a damp cloth. NEVER immerse the
Juicer Motor in water or other liquid. DO NOT spray the Juicer Motor with
water.
3. Dry the Juicer Motor before storing it.
HEAD ASSEMBLY, STOMPER, and HEAD-ALIGNING CAP WRENCH
1. Fill a sink with hot water. Maintain a water temperature of at least 140oF
(60oC) throughout the washing process.
2. Add a manual dishwashing detergent formulated for commercial use to the
water per the manufacturer’s instructions.
3. Place all parts to be washed in a sink.
4. Thoroughly wash all parts with a sponge or dishcloth. Be sure to fully
remove any food residue from each part.
5. After washing, drain the sink and rell it with warm water.
6. Rinse the parts by submerging them in water. Change the water and
repeat, if necessary, to remove all of the detergent.
7. When done rinsing, drain the sink and rell it with a sanitizing solution of
water and chlorine bleach (use 1 ounce of chlorine bleach per 4 gallons of
water). Soak the parts in the solution for a minimum of 5 minutes.
8. Remove the parts from the sink.
9. Allow the parts to air-dry before reassembling and storing the Wheatgrass
Juicer.
10. Sanitize at least daily and/or immediately following each use.
NOTE! The Wheatgrass Juicer is NOT dishwasher-safe.
wWARNING Electrical Shock Hazard. Disconnect power before
cleaning, disassembling, or assembling. Do not immerse cord, plug, or motor
in water or other liquid.

11
NOTES

12
Customer Name:
Address:
City/State/Zip/Country:
Telephone Number:
E-Mail Address:
Original Date of Purchase:
Product Model #:
Serial # (if applicable):
I have read the warranty information. Initial here:
WARRANTY INFORMATION
SAVE THIS WARRANTY INFORMATION FOR YOUR RECORDS!
WARRANTY CARD
SEND THIS CARD ALONG WITH A COPY OF YOUR ORIGINAL PURCHASE RECEIPT TO:
SAMSON BRANDS 95 GOLDEN HILL ROAD DANBURY, CT 06811 USA
Copy of Receipt
Included
Samson Brands warrants to the ORIGINAL RETAIL PURCHASER of this product that if operated in accordance with
the printed instruction accompanying it, then for a period of 1 year from the date of purchase, the product shall be free from
defects in material and workmanship.
The Warranty Card, along with a copy of the original receipt, must be received by Samson Brands within 30 days from
purchase date for the warranty to apply. Failure to send the completely lled out Warranty Card, along with a copy of the
original receipt, will void the warranty.
The product must be delivered to or shipped freight prepaid to Samson Brands for warranty services, in either its
original packaging or similar packaging affording an equal degree of protection. Damage due to shipping is not the
responsibility of the company. Samson Brands charges a $35.00 per hour bench charge. NOTE: No repairs will be
started without the authorization of the customer. The return shipping cost to the customer will be added to the repair
invoice.
Prior to returning the product for Warranty Repair, the product must be thoroughly cleaned and free from any food
particles or other debris. Failure of the purchaser to comply with this standard will result in the unit being returned without
repair. In some cases, a $50 cleaning surcharge may apply.
Samson Brands will repair (or at its discretion, replace) the product free of charge, if in the judgment of the company, it
has been proven to be defective as to seller’s labor and material, within the warranty period.
New or rebuilt replacements for factory defective parts will be supplied for one (1) year from the date of purchase.
Replacement parts are warranted for the remainder of the original warranty period.
For non-warranty repairs, contact Samson Brand’s Customer Service at 888-992-7333, Hours of operation are
M-F 9:00am to 5:00pm Eastern time (Outside the United States Telephone is 001-203-848-9966) to obtain a Return
Merchandise Authorization Number (RMA Number). Samson Brands will refuse all returns that do not contain this
number. DO NOT RETURN THE UNIT WITHOUT PROPER AUTHORIZATION FROM Samson Brands.
LIMITATIONS: The warranty is void if the product is used for any purpose other than that for which it is designed.
The product must not have been previously altered, repaired, or serviced by anyone else other than Samson Brands.
If applicable, the serial number must not have been altered or removed. The product must not have been subjected
to accident in transit or while in the customer’s possession, misused, abused, or operated contrary to the instructions
contained in the instruction manual. This includes failure caused by neglect of reasonable and necessary maintenance,
improper line voltage and acts of nature. This warranty is not transferable and applies only to U.S. and Canadian sales.
Except to the extent prohibited by applicable law, no other warranties whether expressed or implied, including
warranty merchantability and tness for a particular purpose, shall apply to this product. Under no circumstances shall
Samson Brands be liable for consequential damages sustained in connection with said product and Samson Brands
neither assumes nor authorizes any representative or other person to assume for it any obligation or liability other than
such as is expressly set forth herein. Any applicable implied warranties are also limited to the one (1) year period of the
limited warranty.
This warranty covers only the product and its specic parts, not the food or other products processed in it. Samson is
not responsible for missing or damaged parts on discounted/clearance, resale or nal sale items where the seller may not
be able to guarantee full functionality or completeness of the unit.
CUT ALONG THE DOTTED LINE AND SEND THE WARRANTY CARD ALONG WITH A COPY OF YOUR
ORIGINAL PURCHASE RECEIPT TO:
Samson Brands
95 Golden Hill Road
Danbury, CT 06811 USA

13
ATTENTION!
PLEASE INSPECT THIS PACKAGE THOROUGHLY FOR MISSING PARTS OR ANY PRODUCT DAMAGE.
IF YOUR PRODUCT CONTAINS SHIPPING DAMAGE, PLEASE CONTACT RETAILER FOR ASSISTANCE.
For all other questions regarding product usage, missing parts, product damage, difculty or warranty activation,
please contact the Samson Brands Customer Service Team:
[email protected]
SAMSON BRANDS
95 GOLDEN HILL ROAD
DANBURY, CT 06811 USA
888-992-7333
Please DO NOT return this item to the retailer before contacting
Samson Brands Customer Service.
SAVE THESE INSTRUCTIONS!
Refer to them often and use them to instruct others.

840341601 5/2020