Sealey CTI120 User manual

COMPACT R/CHARGE TYRE INFLATOR &
POWERBANK WITH WORK LIGHT
MODEL NO: CTI120
Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these
instructions, and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
1. SAFETY
WARNING! Read operation instructions before use.
8DO NOT leave the unit unattended while in operation.
9 Checkcapacityandmaximuminationpressureofinatablebeforecommencingination.
9 Monitorthepressuregaugewhileinoperation.
9 Thegaugeshouldbeusedasanindicationofpressureonly.Werecommendtheuseofadialpressuregaugefordenitivereading.
WARNING!Thiscompressoriscapableofproducingahighpressure.
8DO NOTinateanyitembeyonditsmaximumcapacity.
8DO NOTdirectinationhoseconnectorheadatyourself,othersoranimals.
8DO NOTcarrybythehose,oryankthehosefromaninationvalve.
8DO NOT pull the power cable from the vehicle accessory socket by the power lead.
8DO NOTgetthecompressorwetoruseintherain.
8DO NOTusethecompressorforataskitwasnotdesignedtoperform.
8DO NOToperatethecompressorifanypartsaremissingasthismaycausefailureorpossiblepersonalinjury.
8DO NOT open the unit.
9 Keepchildrenandnonessentialpersonsawayfromtheinationarea.
9 Keepthecompressorcleanandingoodcondition.
9 Avoidbendingthehoseduringination.
9 Turno󰀨thepumpimmediatelyifoverheatingoranyabnormalityisobservedduringoperation.
9 Ifnopresetpressurevalue,DO NOTleavethepumpunattendedduringinationtopreventtheairpressuregettingtoohigh.
9 Keepthepumpawayfromanyammableorcombustibleobjectsduringoperation,sincethebuilt-inDCmotormaygeneratesparks
 duringoperation.
9 Keepthepumpawayfrommoisture,sandandshock.
8DO NOTstorethepumpinextremelycoldorhotplaces.Thatwillshortenproductlife,damagebattery,ordeformthestructural.
9 Avoidusingstrongchemicalsordetergentstocleantheproduct.
8DO NOT disassemble the product. DO NOTthrowtheproductintoreorhouseholdwaste.
8DO NOT let children use the product.
8DO NOTinsertthehoseintomouth,ears,oreyesofhumansoranimals.Itmustnotbeusedasatoy.
9 Thiscompressorisnotdesignedforcontinuoususe.Operationoveranextendedperiodoftimewilloverheattheunitanddamage
 thecompressor.Itshouldnotbeusedcontinuouslyformorethan30minutes.After30minutes,turnito󰀨andletitcoolfor15 
 minutesbeforeresumingoperation.
CTI120Issue2(3)07/03/19
Original Language Version
© Jack Sealey Limited
Refer to
instructions

2. INTRODUCTION
Compactdigitaltyreinatorwithoutputof12ltr/min.Pressuregaugereadsupto120psi.140mmExtensiontubewithSchraderconnection.
MicroUSBrechargeable(cablenotsupplied).USBoutputforchargingmobilephoneetc.(5V/2A).Suppliedwithsportsballpinadaptor
andballoon/inatablesadaptor.Built-in1WSMDLEDforeaseofuseatnight.Presetthedesiredpsitobeginoperationandunitwillcutout
automaticallyoncethatpressureisreached.Autocut-outifhosekinks,toavoiddamagetopump.
1.OutletGrid 2.Pressuregauge 3. Reduce button 4.IncreaseButton
5.UnitButton 6.Start/Stopbutton 7.LEDLightingbutton 8.Indicator
9.Inletgrid 10.LEDLighting 11.HoseConnector 12.OutletGrid
13.USBoutputport 14.MicroUSBinputport 15.Airhose 16.4×Valveadapters
3. SPECIFICATION
HoseLength:.............................................................. 140mm
TypicalInationTime: .......... 0-30psiin619sec(175/70/R13)
MaximumPressure: .................................................... 120psi
Airow: ........................................................0.42cfm/12ltr/min
USB Output:................................................................. 5V/2A
Battery: ......................................................2000mAh/22.2Wh
4. OPERATION
4.1. CHARGING
4.1.1. Pleasechargethebatteryfullybeforeuse(g.2).Especially
 forthersttimeorafteritisunusedforalongtime.Recommend
 anUSBadapterwithoutputcapabilityof5V/1.5Aor5V/2A,
 about4hoursforfullcharging.Otherfunctionsoftheproduct
 arenotavailableduringcharging.
4.2. USING THE USB CHARGING PORT
4.2.1. USB output of CTI120isplugandplay
4.2.2. Theairpumpwillnotwork,whenyouare
 chargingadevicefromthetyreinator.
 TheUSBoutputwillturno󰀨automatically.
g.1
g.2
g.3
CTI120Issue2(3)07/03/18
Original Language Version
© Jack Sealey Limited

4.3. USING THE LED LIGHT
4.3.1. PresstheLEDlightbuttononce(g.4)toturnonthelight.Pressthebuttontwiceforaslowash,andthreetimesforaSOS 
 ashinglightpattern.
4.4. SETTING THE PRESSURE
NOTE:
•  Whenthepre-setvalueislowerthanthevalueofperipheralpressure,theairpumpcannotbeactivated.
• CTI120hasanintegratedmechanismfortemperatureprotection.Self-protectionwillbeactivatedtostopexternalinationwhenthe
 temperatureexceeds-15°Cto55°C.Itshouldnotbeusedcontinuouslyformorethan30minutes.After30minutes,turnito󰀨andletit
 coolfor15minutesbeforeresumingoperation.
•  Arecommendedinationrangeislabelledonthesideoftyre.
4.4.1. Turnonthepressuregaugebypressingthe‘U’button(g.5).
4.5. SELECT PRESSURE UNIT
 Afterturningonthepressuregauge,pressthe‘U’button(g.5)againtoselecttheairpressureunitsonthedisplay.
NOTE: Conversion relationship of related units is as follow
 1PSI=6.89KPA 1BAR=100KPA 1Kg/cm²=98KPA
4.5.1. Tosettheoutputpressurevaluepressthe+or-buttons(g.6).
4.6. INFLATION
 Connecttheinatableobjectasshownbelow.
4.6.1. Pressthestart/stopbutton(g.7)tostartinating.Whentheairpressureintheinatedobjectreachesthepresetairpressurevalue,
 theairpumpstopsinatingautomatically.
4.6.2. Pressthestart/stopbuttoncanpauseduringtheination,thenpressagaintoresume.
g.4 g.5 g.6 g.7
g.8
Sealey Group, Kempson Way, Suffolk Business Park, Bury St Edmunds, Suffolk. IP32 7AR
01284 757500 01284 703534 [e-mail] www.sealey.co.uk
ENVIRONMENT PROTECTION
Recycleunwantedmaterialsinsteadofdisposingofthemaswaste.Alltools,accessoriesandpackagingshouldbesorted,takento
arecyclingcentreanddisposedofinamannerwhichiscompatiblewiththeenvironment.Whentheproductbecomescompletely
unserviceableandrequiresdisposal,drainanyfluids(ifapplicable)intoapprovedcontainersanddisposeoftheproductandfluids
accordingtolocalregulations.
WEEE REGULATIONS
DisposeofthisproductattheendofitsworkinglifeincompliancewiththeEUDirectiveonWasteElectricalandElectronicEquipment
(WEEE).Whentheproductisnolongerrequired,itmustbedisposedofinanenvironmentallyprotectiveway.Contactyourlocalsolid
wasteauthorityforrecyclinginformation.
Note:Itisourpolicytocontinuallyimproveproductsandassuchwereservetherighttoalterdata,specificationsandcomponentpartswithoutprior
notice.
Important: No Liability is accepted for incorrect use of this product.
Warranty:Guaranteeis12monthsfrompurchasedate,proofofwhichisrequiredforanyclaim.
CTI120Issue2(3)07/03/19
Original Language Version
© Jack Sealey Limited