Sealey Ak2923 User manual

CORDLESS GLUE GUN 3.7V

MODEL NO: AK2923

Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,

and properly maintained, give you years of trouble free performance.

IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE

THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR

PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.

1. SAFETY

1.1. GENERAL SAFETY

9 Familiariseyourselfwiththisproductsapplicationandlimitations,aswellasthespecicpotentialhazardspeculiartothegluegun.

WARNING!Disconnectthechargingleadbeforechangingaccessories,servicingorperforminganymaintenance.

9 Maintaintheglueguningoodcondition(useanauthorisedserviceagent).

9 Replaceorrepairdamagedparts.Userecommendedpartsonly.Unauthorisedpartsmaybedangerousandwillinvalidatethe 

 warranty.

WARNING!Alwayswearapprovedeyeorfaceprotectionwhenoperatingthegluegun.

9 Keeptheworkareaclean,unclutteredandensurethereisadequatelighting.

9 Removeillttingclothing.Removeties,watches,rings,andotherloosejewellery,andcontainand/ortiebacklonghair.

9 Maintaincorrectbalanceandfooting.Ensuretheoorisnotslipperyandwearnon-slipshoes,

9 Securenonstableworkpiecewithaclamp,viceorotheradequateholdingdevice.

8DO NOTtouchthehotnozzleorthesiliconcap.

8DO NOTusethegluegunforataskitwasnotdesignedtoperform.

8DO NOT operatethegluegunifanypartsaredamagedormissingasthismaycausefailureand/orpossiblepersonalinjury.

8DO NOT holdtheworkpiecebyhand.Useclampsoravice(notincluded)tosecuretheworkpiece.AvailablefromyourSealeystockist.

8DO NOT getthegluegunwetoruseindamporwetlocationsorareaswherethereiscondensation.

8DO NOT placenozzleclosetoyourface(especiallyeyes,ears,etc)orotherpersonsoranimals.

8DO NOTallowchildrenoruntrainedpersonstooperatethegluegun.

8DO NOT operatethegluegunwhenyouaretiredorundertheinuenceofalcohol,drugsorintoxicatingmedication.

8DO NOTgetglueonyourskin.

8DO NOTinhaleanyvapourgivenoffbytheglue. 

8DO NOTcarrythegluegunwithyourngeronthepowerswitch,orcarrybythechargingcable.

8DO NOTusethegluegunwherethereareammableliquids,solidsorgasessuchaspaintsolvents,etc.

8DO NOTleavethegluegunoperating/heatingupunattended.

9 Protectworksurfacefromgluespiltduringwarmupphaseandwhilstbeingused.

9 Afteruseplacethegluegundowntocoolinasafemanner.Ensureithascooleddowncompletelybeforestorage.

9 Whennotinuseswitchthegluegunoff,removeplugfromthepowersupply,storethetoolinasafe,drychildproofarea.

NOTE:Thisapplianceisnotintendedforusebypersons(includingchildren)withreducedphysical,sensoryormentalcapabilitiesor

 lackofexperienceandknowledge,unlesstheyhavebeengivensupervisionorinstructionconcerningtheuseofthe  

 appliancebyapersonresponsiblefortheirsafety.Childrenshouldbesupervisedtoensurethattheydonotplaywiththeappliance.

1.2. ELECTRICAL SAFETY

9 Inspectthecableandconnectorforwearanddamagetoensureitemsaresafebeforeconnectingtothepowersupply.Ifwornor

 damagedDO NOTuse. 

9 Ensurethegluegunisfullychargedbeforeinitialuse. 

8DO NOTchargeindampconditions.

8DO NOTusethegluegunifyoususpectthatthebatteryorthelampcasingisdamaged.

8DO NOTleavebatteryinadischargedstate,rechargebatteryimmediately.Beforestorage,fullyrechargethebattery,subsequently

 rechargethebatteryatleastonceeverysixmonthsofnon-use.

8DO NOTattempttoopen,disassemble,modifyorservicethebatterypack.

8DO NOTcrush,puncture,shortexternalcontactsordisposeofinreorwater.

8DO NOTexposetotemperaturesabove60°C(140°F).

9 Replaceonlywiththebatterypackdesignatedforthisproduct.

9 Recycleordisposeofusedbatteryasstipulatedbylocalregulation.

9 Iftheelectrolyteinthecellsgetsonyourskin,thoroughlywashwithsoapandwater.Ifitgetsinyoureyes,rinsethoroughlywithcool

 waterandseekimmediatemedicalattention.

Original Language Version

Refer to

instruction

manual

Wear

protective

gloves

Warning!

hot

surface

AK2923|Issue:128/05/19

Original Language Version

2. INTRODUCTION

Lightweightcordlessgluegunpoweredbya3.7V1.3AhLithium-ionbattery.FeaturesLEDlightindicatorstoshowwhenfullyheatedup.Ready

tousein20seconds.Operatingtimeof30minutesonafullcharge.SuppliedwithfourgluesticksandaUSBchargingcable.Suitablefor

Ø7.2mmgluesticks.

3. SPECIFICATION

Model no................................................................... AK2923

Chargingtime.......................................................... 3-4hours

Operatingtime......................................................30minutes

Battery power................................................................1.3Ah

4. BATTERY CHARGING

4.1.  Onlyusethesuppliedchargingcable.

4.2.  Thebatteryissuppliedpartiallycharged.Chargethe

 batteryforatleast2-3hoursbeforerstuse.

4.3.  Theglueguncannotbeusedduringcharging.

4.4.  Thebatterycanbechargedatanytimewithoutreducing

 itsservicelife.Interuptingthechargingproceduredoes

 notdamagethebattery.

4.5.  Thebatteryisprotectedfromdeepdischarging.When

 thebatteryisdischagedthegluegunisswitchedoffby

 aprotectivecircuit.Theglueisnolongerheated.

4.6. BATTERY LED INDICATOR (RH)

Redashing:Batteryisbeingcharged

 Greensolid:Batteryisfullycharged

 Redashing(notpluggedintochargecable):Batteryis

 below30%capacityandshouldbecharged

4.7.  PlugchargecableintoChargingsocket.

4.8.  Disconnectwhennotusingforlongperiods.

5. OPERATION

WARNING!Riskofburns,gluereachesapproximately170°C.Ifhotgluecomesintocontactwithskin,holdunderastreamofcold

 waterforseveralminutes.

5.1.  Saveenergy,onlyswitchonwhenbeingused.

5.2. SWITCH ON

 PressbuttonOn/Offtoturnon,untiltheHeatingLEDindicatorlightsgreen.DO NOTleaveunattendedwhilstgluegunisheatingup.

 Placeonaheatproofsurface.

5.3. HEATING LED INDICATORS(LH)

 Greenashing(forapproximately20seconds):glueisbeingheated

 Greensolid:gluegunreadytouse

5.4. SWITCH OFF

PressbuttonOn/OffuntilHeatingLEDindicatorturnsoff.

5.5. AUTOMATIC SWITCH OFF

Gluegunswitchesoffautomaticallyafter2minutestosaveenergy.

5.6.  SwitchthegluegunonagainandchecktheHeatingLEDindicator.IftheBatteryLEDindicatorbrieylightsupRED,thebattery 

 mustberecharged.

5.7.  Afteruseplacegluegundowninasafemannerandallowittocooldowncompletelybeforestorage.

5.8. PREPARATION FOR GLUING

5.8.1. Surfacesmustbefreefromgrease,cleananddry.

5.8.2. Materialstobegluedaswellasthesurfaceonwhichtheworkistakingplacemustnotbeeasilyignitableorammable.

5.8.3. Checkthesuitabilityofmaterialstobegluedonatestworkpiece.

5.8.4. Ambienttemperatureofaworkpiecemustbebetween+5°Cand+50°C.

5.8.5. Materialssuchasmetals,whichcooloffthegluequickly,shouldbepreheatedwithahotairgun.

5.9. GLUING

5.9.1. Inserttheappropriategluestickintotheopeningintherearofthegluegun.

5.9.2. Switchonandallowtoheatup(see5.2above).Gluegunisreadyafterapproximately20seconds.

5.9.3. Pressthefeedtrigger,applyingmoderatepressure.

5.9.4. Applyglueontoonesideonly,pressthegluedsurfacestogether.Itisstillpossibletoadjustthelocationofthetwopiecesatthispoint.

5.9.5. Thegluedjointcanbesubjectedtoloadafteracooldownperiodofapproximatelytwominutes.

5.9.6. Removeglueresidueaftercoolingwithabluntobject.Ifnecessarygluedjointscanbeseparatedagainbyapplyingheat.

8DO NOTuseinammablesolventsforcleaningthesurfacestobeglued.Solventresiduescanignitefromhotglueorhazardous 

 vapourscoulddevelop.

8DO NOTremoveapartiallyusedgluestickfromtheendofthegluegun.

6. MAINTENANCE

WARNING!Removechargecablebeforeperformingmaintenance.

6.1.  Cleanwithadampcloth,DO NOTusesolvents.

AK2923|Issue:128/05/19

Sealey Group, Kempson Way, Suffolk Business Park, Bury St Edmunds, Suffolk. IP32 7AR

01284 757500 01284 703534 sales@sealey.co.uk www.sealey.co.uk

ENVIRONMENT PROTECTION

Recycleunwantedmaterialsinsteadofdisposingofthemaswaste.Alltools,accessoriesandpackagingshouldbesorted,takento

arecyclingcentreanddisposedofinamannerwhichiscompatiblewiththeenvironment.Whentheproductbecomescompletely

unserviceableandrequiresdisposal,drainanyfluids(ifapplicable)intoapprovedcontainersanddisposeoftheproductandfluids

accordingtolocalregulations.

Note:Itisourpolicytocontinuallyimproveproductsandassuchwereservetherighttoalterdata,specificationsandcomponentpartswithoutprior

notice.

Important:NoLiabilityisacceptedforincorrectuseofthisproduct.

Warranty:Guaranteeis12monthsfrompurchasedate,proofofwhichisrequiredforanyclaim.

WEEE REGULATIONS

DisposeofthisproductattheendofitsworkinglifeincompliancewiththeEUDirectiveonWasteElectricalandElectronicEquipment

(WEEE).Whentheproductisnolongerrequired,itmustbedisposedofinanenvironmentallyprotectiveway.Contactyourlocalsolid

wasteauthorityforrecyclinginformation.

Original Language Version

6.2.

6.3.

.

BATTERY REMOVAL