Sealey CP20VGG User manual

20V CORDLESS GLUE GUN - BODY ONLY
MODEL NO: CP20VGG
Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,
and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
1. SAFETY
1.1. GENERAL SAFETY
9 Familiariseyourselfwiththisproductsapplicationandlimitations,aswellasthespecicpotentialhazardspeculiartothegluegun.
WARNING!Disconnectthechargingleadbeforechangingaccessories,servicingorperforminganymaintenance.
9 Maintaintheglueguningoodcondition(useanauthorisedserviceagent).
9 Replaceorrepairdamagedparts.Userecommendedpartsonly.Unauthorisedpartsmaybedangerousandwillinvalidatethe 
 warranty.
WARNING!Alwayswearapprovedeyeorfaceprotectionwhenoperatingthegluegun.
9 Keeptheworkareaclean,unclutteredandensurethereisadequatelighting.
9 Removeillttingclothing.Removeties,watches,rings,andotherloosejewellery,andcontainand/ortiebacklonghair.
9 Maintaincorrectbalanceandfooting.Ensuretheoorisnotslipperyandwearnon-slipshoes,
9 Securenonstableworkpiecewithaclamp,viceorotheradequateholdingdevice.
8DO NOTtouchthehotnozzleorthesiliconcap.
8DO NOTusethegluegunforataskitwasnotdesignedtoperform.
8DO NOT operatethegluegunifanypartsaredamagedormissingasthismaycausefailureand/orpossiblepersonalinjury.
8DO NOT holdtheworkpiecebyhand.Useclampsoravice(notincluded)tosecuretheworkpiece.AvailablefromyourSealeystockist.
8DO NOT getthegluegunwetoruseindamporwetlocationsorareaswherethereiscondensation.
8DO NOT placenozzleclosetoyourface(especiallyeyes,ears,etc)orotherpersonsoranimals.
8DO NOTallowchildrenoruntrainedpersonstooperatethegluegun.
8DO NOT operatethegluegunwhenyouaretiredorundertheinuenceofalcohol,drugsorintoxicatingmedication.
8DO NOTgetglueonyourskin.
8DO NOTinhaleanyvapourgiveno󰀨bytheglue. 
8DO NOTcarrythegluegunwithyourngeronthetrigger.
8DO NOTusethegluegunwherethereareammableliquids,solidsorgasessuchaspaintsolvents,etc.
8DO NOTleavethegluegunoperating/heatingupunattended.
9 Protectworksurfacefromgluespiltduringwarmupphaseandwhilstbeingused.
9 Afteruseplacethegluegundowntocoolinasafemanner.Ensureithascooleddowncompletelybeforestorage.
9 Whennotinuseswitchtheglueguno󰀨,storethetoolinasafe,drychildproofarea.
NOTE:Thisapplianceisnotintendedforusebypersons(includingchildren)withreducedphysical,sensoryormentalcapabilitiesor
 lackofexperienceandknowledge,unlesstheyhavebeengivensupervisionorinstructionconcerningtheuseofthe  
 appliancebyapersonresponsiblefortheirsafety.Childrenshouldbesupervisedtoensurethattheydonotplaywiththeappliance.
2. INTRODUCTION
Readytousein3minutes.Cordlessoperationallowsuseanywhereintheworkshop.Compositehousingwithsoftgripforaddedcomfort.
SuitableforgluestickbetweenØ10-12mm.On/o󰀨switchandtriggerfeedcontrol.
3. SPECIFICATION
Model no............................................................... CP20VGG
Max.runningtime.........................................................3.5hr
Battery ..........................20V2Ah-4AhLi-ion(notincluded)
Glue stick diameter................................................. 10-12mm
Consumables..... AK292/2-Allpurposegluestickpackof25
Original Language Version
© Jack Sealey Limited
Refer to
instruction
manual
Wear
protective
gloves
Warning!
hot
surface
Wear eye
protection
CP20VGG|Issue:106/11/19

Original Language Version
© Jack Sealey Limited
4. OPERATION
WARNING!Riskofburns.Ifhotgluecomesintocontactwithskin,holdunderastreamofcoldwaterforseveralminutes.
4.1.  Saveenergy,onlyswitchonwhenbeingused.
WARNING! Ensure On/O󰀨 switch is in OFF position.
4.2. FIT BATTERY
4.3. SWITCH ON
 SlidebuttonOn/O󰀨toturnon,redLEDindicatorlightwillilluminate.DO NOTleaveunattended.Placeonaheatproofsurface.
4.4. SWITCH OFF
SlideOn/O󰀨buttonredLEDindicatorwillturno󰀨.
4.5.  Afteruseplacegluegundowninasafemannerandallowittocooldowncompletelybeforestorage.
4.6. PREPARATION FOR GLUING
4.6.1. Surfacesmustbefreefromgrease,cleananddry.
4.6.2. Materialstobegluedaswellasthesurfaceonwhichtheworkistakingplacemustnotbeeasilyignitableorammable.
4.6.3. Checkthesuitabilityofmaterialstobegluedonatestworkpiece.
4.6.4. Ambienttemperatureofaworkpiecemustbebetween+5°Cand+50°C.
4.6.5. Materialssuchasmetals,whichcoolo󰀨thegluequickly,shouldbepreheatedwithahotairgun.
4.7. GLUING
4.7.1. Inserttheappropriategluestickintotheopeningintherearofthegluegun.
4.7.2. Switchonandallowtoheatup.
4.7.3. Pressthefeedtrigger,applyingmoderatepressure.
4.7.4. Applyglueontoonesideonly,pressthegluedsurfacestogether.Itisstillpossibletoadjustthelocationofthetwopiecesatthispoint.
4.7.5. Thegluedjointcanbesubjectedtoloadafteracooldownperiodofapproximatelytwominutes.
4.7.6. Removeglueresidueaftercoolingwithabluntobject.Ifnecessarygluedjointscanbeseparatedagainbyapplyingheat.
8DO NOTuseinammablesolventsforcleaningthesurfacestobeglued.Solventresiduescanignitefromhotglueorhazardous 
 vapourscoulddevelop.
8DO NOTremoveapartiallyusedgluestickfromtheendofthegluegun.
5. MAINTENANCE
WARNING!Removebatterybeforeperformingmaintenance.
5.1.  Cleanwithadampcloth,DO NOTusesolvents.
.
CP20VGG|Issue:106/11/19
Sealey Group, Kempson Way, Suffolk Business Park, Bury St Edmunds, Suffolk. IP32 7AR
01284 757500 01284 703534 [e-mail] www.sealey.co.uk
ENVIRONMENT PROTECTION
Recycleunwantedmaterialsinsteadofdisposingofthemaswaste.Alltools,accessoriesandpackagingshouldbesorted,takento
arecyclingcentreanddisposedofinamannerwhichiscompatiblewiththeenvironment.Whentheproductbecomescompletely
unserviceableandrequiresdisposal,drainanyfluids(ifapplicable)intoapprovedcontainersanddisposeoftheproductandfluids
accordingtolocalregulations.
Note:Itisourpolicytocontinuallyimproveproductsandassuchwereservetherighttoalterdata,specificationsandcomponentpartswithoutprior
notice.
Important:NoLiabilityisacceptedforincorrectuseofthisproduct.
Warranty:Guaranteeis12monthsfrompurchasedate,proofofwhichisrequiredforanyclaim.
WEEE REGULATIONS
DisposeofthisproductattheendofitsworkinglifeincompliancewiththeEUDirectiveonWasteElectricalandElectronicEquipment
(WEEE).Whentheproductisnolongerrequired,itmustbedisposedofinanenvironmentallyprotectiveway.Contactyourlocalsolid
wasteauthorityforrecyclinginformation.