Sealey ACL3.V4 User manual

COMBINATION LADDER 3-SECTION
MODEL NO’S: ACL3.V4, ACL307.V2, ACL312.V3
Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,
and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
1. SAFETY
BEFORE USE:
A) Checkyourphysicaltnessbeforeusingaladder.
DO NOTuseaftertakingalcoholoranymedicinelikelytocausedrowsiness.Readthelabelofanydrugormedicines.
B) Whentransportingaladderontheroofrackofyourvehicleorinalorry,makesurethatitissecuredrmlytoavoidcausingany 
 damage.
C) Beforeusingtheladderforthersttime,checkittoensurethatallitspartsareingoodconditionandoperatecorrectly.
D) Beforeuse,checktheladdervisuallytoensurethatithasnotbeendamagedandcanbeusedincompletesafety.
E) Regularchecksareessentialforallusers.
F) Checkthattheladderissuitableforthejobtobedone.
G) DO NOTuseadamagedladder.
H) Cleantheladderofanyforeignsubstancessuchaswetpaint,mud,oilorsnow.
I) Beforeusingtheladderforprofessionalpurposes,risksmustbeassesseddependingonthelegislationofthecountryinuse.
POSITIONING AND ERECTING LADDERS:
A) Laddersmustbeputupintherightposition,i.e.atthecorrectangle(inclinedatabout1in4),withthestepsorrungsparallelfora
 leaningladder,orcompletelyopeninthecaseofatrestleladder.
B) Anyladderequippedwithlockingsystems;thelocksmustbeinthefullylockedposition.
C) Laddersmustbeplacedonatregularandrmsurface.
D) Leaningladdersmustalwaysbeplacedonaatsolidsurfaceandbestabilizedbeforeuse,forexamplebyusingtiesoranyother
 suitabledeviceforensuringtheirstability.
E) Laddersmustneverberepositionedfromapointhigh-up.
F) Wheninstallingaladdertakeaccountofanypossiblerisksofcollision,e.g.collisionswithpedestrians,vehiclesordoors.
 Ifpossible,secureanydoors(otherthanemergencyexits)andwindowsonthesite.
G) Identifyallelectricalrisksonthework-site,e.g.overheadlinesoranyotherbareelectricalequipment.
H) Laddersmustrestrmlyontheirtreadsandnotbeonrungsorsteps.
I) Laddersmustnotbeplacedonanyslipperysurfaces(e.g.ice,shinysurfacesorsurfacesclearlycoveredwithforeignsubstances)
 unlessothereffectivemeanshavebeentakentoavoidtheladderslipping.Otherwise,makesurethatalldirtyorcontaminatedsupport
 surfaceshavebeenadequatelycleaned.
USING THE LADDER:
A) DO NOTexceedthemaximumloadallowedforthetypeofladder.
B) DO NOT trytoreachapointtoofarawayfromyou;yourwaistshouldalwaysbebetweentheladder’stwouprightsandyourfeeton
 thesamesteporrungwhilstworking.
C) DO NOTclimbdownahighleaningladderwithoutusinganextrasafetysystem(forexample,atieoruseofasuitablestabilizing
 device).
D) DO NOTuseatrestleladdertogetuptoahigherlevel.
E) DO NOTstandonthetopthreestepsorrungsofaleaningladder.
F) DO NOTstandonthetoptwostepsorrungsofatrestleladderwherethereisnoplatformorsupportathandorkneeheight.
G) DO NOTstandonthetopfourstepsorrungsofatrestleladderwithanextensionladderontop.
H) Laddersshouldonlybeusedforminor,short-durationjobs.
I) Usenon-conductiveladderswhenworkingonjobswhereelectricalpowerispresent.
J) DO NOTuseladdersoutsideinunfavorableweatherconditions(highwindsforexample).
K) Takeallnecessaryprecautionstopreventchildrenfromplayingonladders.
L) Ifpossible,secureanydoorsotherthanemergencyexitsandwindowsonthesite.
M) Climbupandcomedownaladderfacingit.
N) Holdtheladderrmlywhenclimbingorcomingdown.
O) DO NOTuseladdersasbridges.
P) Alwayswearsuitableshoesforclimbingladders.
Q) Avoidallexcessivelateralconstraintssuchaswhenusingadrillinbrickandconcrete.
R) DO NOTstaytoolonguptheladderwithoutmakingregularstops(fatiguerisks).
S) Togouptohigherlevels,laddersshouldbeextendedatleastonemetreabovetheheighttobereached.
T) Light-weighteasy-to-handleequipmentshouldbeusedwhenonaladder.
U) Avoidworksthatcreatesideloadsontrestleladders,e.g.fordrillinghardmaterials(brick,concrete,etc.).
Referto
instruction
manual
Original Language Version
©JackSealeyLimited ACL3.V4,ACL307.V2,ACL312.V3,Issue:2(1)30/01/20

Original Language Version
©JackSealeyLimited
V) Holdontotheladderwithonehandwhenworking.Ifthisisnotpossible,othertypesofsafetymeasuresshouldbetaken.
 Followthethreepointsafetyrule-2feetandatleastonehandontheladderatalltimes.
W) Repairsandmaintenancemustbecarriedoutbyaqualiedpersonincompliancewiththemanufacturer’sinstructions.
X) Laddersshouldbestoredaccordingtothemanufacturer’sinstructions.
2. INTRODUCTION
AluminiumextensionladdersmanufacturedtoEN131standards.Idealforthetradesman,thisladdercanbeusedasathreesectionortwo
sectionextensionandasasingleladder,whichisidealfortwo-manuse.Canbeusedasastepandextensionstepladderwherestabilityand
heightareneeded.Compactsizeforeasyhandlingandstorage.
3. SPECIFICATION
Modelno..................................................................ACL3.V4
Max.capacity............................................................... 150kg
Max.extension............................................................. 5.92m
Max.reach................................................................... 6.82m
Min.height..................................................................... 2.6m
Modelno..............................................................ACL307.V2
Max.capacity............................................................... 150kg
Max.extension............................................................... 4.2m
Max.reach..................................................................... 5.1m
Min.height........................................................................ 2m
Modelno..............................................................ACL312.V3
Max.capacity............................................................... 150kg
Max.extension............................................................. 7.88m
Max.reach................................................................... 8.78m
Min.height..................................................................... 3.4m
3.1.
.
Sealey Group, Kempson Way, Suffolk Business Park, Bury St Edmunds, Suffolk. IP32 7AR
01284 757500 01284 703534 [e-mail] www.sealey.co.uk
ENVIRONMENT PROTECTION
Recycleunwantedmaterialsinsteadofdisposingofthemaswaste.Alltools,accessoriesandpackagingshouldbesorted,takento
arecyclingcentreanddisposedofinamannerwhichiscompatiblewiththeenvironment.Whentheproductbecomescompletely
unserviceableandrequiresdisposal,drainanyfluids(ifapplicable)intoapprovedcontainersanddisposeoftheproductandfluids
accordingtolocalregulations.
Note:Itisourpolicytocontinuallyimproveproductsandassuchwereservetherighttoalterdata,specificationsandcomponentpartswithoutprior
notice.Pleasenotethatotherversionsofthisproductareavailable.Ifyourequiredocumentationforalternativeversions,pleaseemailorcallour
technicalteamon[e-mail]or01284757505.
Important:NoLiabilityisacceptedforincorrectuseofthisproduct.
Warranty:Guaranteeis12monthsfrompurchasedate,proofofwhichisrequiredforanyclaim.
Typicalconfigurationsforallladders
(ModelshownACL3.V4)
ACL3.V4,ACL307.V2,ACL312.V3,Issue:2(1)30/01/20