Sony SA-SC8 User manual

SA-SC8/WS8/SS-CT8/TS8
US Model
Canadian Model
AEP Model
UK Model
E Model
Australian Model
SERVICE MANUAL
SUBWOOFER/SPEAKER SYSYTEM
Sony Corporation
Audio Group
Published by Sony Engineering Corporation
9-961-138-02
2004I16-1
© 2004.09
•SA-SC8 is composed of following models.
SPECIFICATIONS
Ver 1.1 2004. 09
SA-SC8
FRONT and SURROUND speakers SS-TS8
CENTER speaker SS-CT8
SUBWOOFER SA-WS8
SA-WS8
•SA-SC8 is the speaker section in
DAV-FC9/SC8.
Front/Surround
Speaker system Bass reflex
Speaker unit 70 mm dia. cone type × 2,
25 mm dia. balance dome
Rated impedance 4 ohms
Dimensions (approx.) 250 × 1196 × 250 mm
(w/h/d, Max size with the
stand)
250 × 646 × 250 mm
(w/h/d, Min size with the
stand)
Mass (approx.) 3.62 kg
Centre
Speaker system Bass reflex
Speaker unit 70 mm dia. cone type × 2,
25 mm dia. balance dome
Rated impedance 4 ohms
Dimensions (approx.) 379 × 125 × 85 mm
(w/h/d, with the stand)
Mass (approx.) 1.07 kg
Subwoofer
Speaker system Active subwoofer,
Magnetically shielded
Speaker unit 20 cm dia. cone type
Enclosure type Advanced SAW type
Amplifier section
Continuous RMS power output
135 W (8 ohms,
20 Hz -20 kHz, 10% THD)
Power requirements
Australian and Asian models:
220 – 240 V AC, 50/60 Hz
Taiwan model: 120 V AC, 50/60 Hz
Other models: 110 – 120 V/220 – 240 V
AC, 50/60 Hz
Power consumption 90 W, 1 W(standby mode)
Dimensions (approx.) 230 390 475 mm
(w/h/d) incl. front grille
Mass (approx.) 14.5 kg
Design and specifications are subject to change
without notice.
EXCEPT US and Canadian models:
120 V AC, 60 Hz
US and Canadian models:
150 W (6 ohms,
US and Canadian models: 20 Hz – 20kHz, 10% THD)
SS-CT8 SS-TS8

SA-SC8/WS8/SS-CT8/TS8
2
TABLE OF CONTENTS
1. DIAGRAMS
1-1. CIRCUIT BOARDS LOCATION (SA-WS8) .............. 3
1-2. PRINTED WIRING BOARDS (SA-WS8)...................5
1-3. SCHEMATIC DIAGRAM (SA-WS8).......................... 6
2. EXPLODEDVIEWS
2-1. SS-CT8 (OVER ALL SECTION)··································· 7
2-2. SS-TS8 (OVERALL SECTION) ···································· 8
2-3. SS-TS8 (STAND SECTION) ········································· 9
2-4. SA-WS8 (OVERALL SECTION) ································ 10
2-5. SA-WS8 (AMP SECTION)·········································· 11
3. ELECTRICAL PARTS LIST········································· 12
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0OR DOTTED
LINE WITH MARK 0ON THE SCHEMATIC DIAGRAMS
AND IN THE PARTS LIST ARE CRITICAL TO SAFE
OPERATION. REPLACE THESE COMPONENTS WITH SONY
PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN
THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY
SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!!
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0SUR LES
DIAGRAMMESSCHÉMATIQUESET LALISTE DES PIÈCESSONT
CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE
REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY
DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU
DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
To Exposed Metal
Parts on Set
0.15
µ F1.5k
Ω
AC
voltmeter
(0.75V)
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
SAFETY CHECK-OUT
After correcting the original service problem, perform the following
safety check before releasing the set to the customer:
Check the antenna terminals, metal trim, “metallized” knobs, screws,
and all other exposed metal parts forAC leakage. Check leakage as
described below.
LEAKAGETEST
The AC leakage from any exposed metal part to earth ground and
from all exposed metal parts to any exposed metal part having a
return to chassis, must not exceed 0.5 mA (500 microamperes).
Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or RCA
WT-540A. Follow the manufacturers’ instructions to use these
instruments.
2. A battery-operated AC milliammeter. The Data Precision 245
digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of aVOM
or battery-operatedAC voltmeter. The “limit” indication is 0.75
V, so analog meters must have an accurate low-voltage scale. The
Simpson 250 and Sanwa SH-63Trd are examples of a passive
VOM that is suitable. Nearly all battery operated digital
multimeters that have a 2V AC range are suitable. (See Fig. A)

3
SA-SC8/WS8/SS-CT8/TS8
1-1. CIRCUIT BOARDS LOCATION (SA-WS8)
SECTION 1
DIAGRAMS
AUTO POWER board
MAIN board
POWER board
LED board
POWER SWITCH board
CONTROL board

SA-SC8/WS8/SS-CT8/TS8
4
Note on Schematic Diagram:
•All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
•All resistors are in Ωand 1/4W or less unless otherwise
specified.
•2: nonflammable resistor.
•5: fusible resistor.
•C: panel designation.
Note:
The components identi-
fied by mark 0or dotted
linewith mark 0arecriti-
cal for safety.
Replace only with part
number specified.
Note:
Lescomposantsidentifiés par
une marque 0sont critiques
pour la sécurité.
Ne les remplacer que par une
piéce portant le numéro
spécifié.
•A: B+ Line.
•B: B– Line.
•Voltage is dc with respect to ground under no-signal
(detuned) condition.
•Voltagesare takenwith aVOM(Input impedance10 MΩ).
Voltage variations may be noted due to normal produc-
tion tolerances.
•Signal path.
F: AUDIO
•Abbreviation
CND : Canadian model.
Note on Printed Wiring Boards:
•X: parts extracted from the component side.
•: Pattern from the side which enables seeing.
Ref.No. Location
D201 I-4
D202 H-4
D303 E-3
D304 E-3
D305 F-6
D306 D-8
D501 C-8
D502 E-8
D503 E-8
D504 E-8
D505 E-8
D506 F-7
D507 E-7
D601 I-7
D602 I-7
D603 J-7
D604 I-7
D605 H-7
D606 G-7
(D607) J-9
<D608> G-8
D701 B-5
D702 C-5
D703 C-5
D704 C-5
D801 E-10
IC101 C-3
IC102 C-2
IC104 C-5
IC201 H-3
IC202 H-1
IC203 H-3
IC204 H-4
IC301 E-2
IC701 B-6
Q101 C-1
Q301 E-3
Q302 E-2
Q303 E-2
Q304 D-2
Q305 D-3
Q306 D-3
Q307 D-3
Q308 E-7
Q309 F-6
Q310 E-6
Q311 E-6
Q401 J-3
Q402 J-3
Q403 J-2
Q404 J-5
Q501 F-7
Q502 E-7
Q601 H-7
Q602 G-7
Q701 B-5
Q702 C-6
Q703 A-7
Q704 A-7
Q705 A-7
•Semiconductor
Location
(): Except E model
<>: E model

55
SA-SC8/WS8/SS-CT8/TS8
1
A
B
C
D
E
F
G
H
I
J
234567891011121314
JW61
R201
CN201
C201 R202
JW64
R221
IC201
IC301
IC102
IC101
IC104
IC701 S701
IC203
IC204
JW59
C213
JW57
C211 C212
R215
R217
R214
D201
R210
JW60
C209
R209
R211 R220
R219
C214
C210
D202
R218
R216
R407
Q404
C401
JW56
R406
R404
CN401
Q401
Q403
Q402
JW55
R405
R402 R401 R403
JW58
R212
R213
C208
RV201
15
R205
S201
S201
MODE LEVEL
MUSIC
MOVIE
C204 R208
IC202
C207
R203
C203
R206
C206
C314
R302
C301
R301
R331
R332 R304
R328 R327
C313
R326 R325
C312
JW48
JW32
Q306
Q301 D304
D303
R311
Q302
C308
Q303
JW29
JW30
JW46
C303
R305
R307
R329
R313
C311
RY301
RY602
T601
POWER TRANSFORMER
RY601
D608
R602
C602
JW604
JW601 JW602
C5
F601
F602
C2
C1
D605
D601 D602
JW606
R335
C315
JW50
Q310
Q309 Q311
JW39
JW27 JW26 JW38
R704
R707 R706
Q703
Q704
Q705
R710
D501
R708
JW37 JW25
Q702
JW36
CN502
R141
C118
JW24
JW23
JW22
Q307
R310
R314
Q305 Q304
Q101
R309 R119
C108
J101
IN POWER
SAVE
S701
LINE
C105
R115
R117
C106
R113
R123
R122
R126 C111
R125
CN101
C110
R124
JW20
R120
C109
R121
JW1 R114
C104
R308
C511
C512
C304
C305
JW21
R118
C107
R116
JW6 JW7 JW8
C307
D701
Q701
C701
JW13
JW11
JW12 C515
JW10
R703
R702
R705
R711
R709
JW3
C516
R701
C513
C514
R139
R317
R318
JW9
D702
D703
D704
JW40
JW41
Q502
JW54
Q501
Q308
R338
R337
C316
D506
D507
C508
R504
JW51
C506
C505
D503
D502
CN501
T501
POWER TRANSFORMER
D505
D306
C503
C606
D606
C604
R601
C601
D604
D603
D607
Q601
JW609
JW608
C3
CN604
CNT1
CNT2
CN602
AC IN
CN601
JW605
JW600
S601
VOLTAGE
SELECTOR
C4
CN605
C605
C603
C504
R336
Q602
CN701
D504
R503
C317
R340 R339
JW34 JW35
JW33
R320
CN301
R330
JW47
R316
R312
R324
R315
R306
C306
R323
R322
R321
R333
R303
JW53
C309
JW49
R319
R341
D305
C509 C507
R502
R501
JW52
C501
C502
JW42
JW45
JW44
JW43
JW28
JW15
JW19
JW14
JW18
JW17
JW16
JW5
JW4
C510
CN302
C310
C202
R204
JW63
R207
JW62
C205
POWER BOARD
MAIN BOARD
CONTROL BOARD AUTO POWER BOARD
13
31
1
4
8
5
1
4
8
5
1
4
8
5
1
4
8
5
1
4
8
5
21
1
1
5
14
6
3
1
2
1
1
2
1
2
41
1-680-784- (11)
11
1-684-522- (11)
11
1-680-785-
(11)
11
1-680-786- (11)
11
1-680-789- (11)
11
1-684-553- (11)
11
85
14
85
14
8
61
5
14 85
14
LED BOARD
S1
POWER
D801
ON/STANDBY
CN1
CN801 D801
POWER SWITCH BOARD
(CHASSIS)
(CHASSIS)
1
3
SP5
SPEAKER
BLK
+
–
RED
BLU
BRN
AUTO OFF
~~
4
5
6
2
3
1
12 3
65 4
E MODEL
E MODEL
EXCEPT E MODEL
1-2. PRINTEDWIRING BOARDS (SA-WS8) • Refer to page 3 for Circuit Boards Location.

66
SA-SC8/WS8/SS-CT8/TS8
1-3. SCHEMATIC DIAGRAM (SA-WS8)
-LK -OPY-M
-OPY-M
-FEK
-TP
-72
-72
-FEK
-72
-72
-TP
-TP
-TP
-TK
-NTA2B
-NTA2B
-NTA2B
2SA1015TP-Y
-TK
-TPE2
E MODEL
-72
(E)
(EXCEPT US,CND,E)
E
E
-72
E
-72 -72
-F
-P
-F
-TP
-TPE2
-NTA2B
-NTA2B
-NTA2B
-NTA2B
-Y
MTZJ-T-77-15B
MTZJ-T-77-15B
-F
1M
-O
-72
-72
-P
-P -P
-F -F
-O
-72
-72
-NTA2B
R122C108
R118
R116
C106
R115
C104R114
C105
R113
R306
R307
Q303Q302
R308C305
C304
R309 R310 R318
R315
R701
R705
R706
R704
R707
R711
Q308
Q309
Q310
R317
C118
R139
R305
R123
R312
R311
CN502
CN302
C317
R340
R339
R338
R337
R336
C311
R319
R335
C315
R703
C701
D701
C107
C307
C308
R702 S701
CN701
R709
IC701(1/2)
IC701(2/2)
R314
Q306
Q305Q304
R404
R405
R403
R402
R401
R406
R407
C511 C110
R124 R125 R126
C512
R304
R333
R332 R331
R303
C301 R302 C314
R330
R329
R301
R324
R328 C313
R327 R326 R325
C312R322
R323
R321
R313
CN501
R501
R502
C501
C502
C503
C504
R503
R504
C507
C508
C509
C510
Q101
CN301
CN101
CN801
C201 R202
R201 C202 C203
R203
R204
C204
R205
S201
CN201
C211 C213 C212
C214
C205 C206
IC202(1/2)
IC202(2/2)
C207
R208
RV201 C208
R209
R211
R212
R210 R213
R214
R215
R216
IC204(1/2)
IC204(2/2)
R219 R220
C210
C209
R221
IC203(1/2)
IC203(2/2)
R218
R217
R117
R141
C303
C309
Q301
C306
R316
R119
C109
R120
R121
R320
R341
C316
D506
D507
R708
R710
IC104
Q307
CN401
Q404
Q403
SP5
CN604
R601
R602
CN605
CN1
S1
C601
C602
C605
C606
CN601
C604
C603
CN602
C2
C1
C5
C513
C515
C514
C516
J101 IC101
IC301(1/2)
IC301(2/2)
D303
D304
C310
Q401
Q402
C401
IC102(1/2)
IC102(2/2)
C111
Q311 D306 D305
C505
C506
Q501
Q502
D502
D503
D504
D505
T501
Q701
D702
Q702
D703
D704
Q703
Q705
Q704
D801
D605
D606
D601
D602
D603
D604
Q601
Q602
D202
D201
R206
IC201
R207
RY601
T601
F601
JW604
JW600
JW605
JW608
JW609
RY602
JW602
JW601
S601
D607
D608
C4
C3
RY301
D501
F602

7
SA-SC8/WS8/SS-CT8/TS8
1X-4955-909-1 FRAME ASSY, GRILLE (EXCEPT AEP, UK)
1X-4956-030-1 FRAME ASSY, GRILLE (AEP, UK)
24-249-787-01 BUFFLE PANEL(CENTER)
34-249-784-01 SPEAKER CABINET (CT)
41-694-836-11 TERMINAL, SPEAKER
54-249-793-01 STAND (CT)(EXCEPT AEP, UK)
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
54-251-101-01 STAND (CT)(AEP, UK)
64-246-659-01 FOOT (STAND)
SP1 1-825-592-11 SPEAKER (7cm)
SP2 1-825-591-11 SPEAKER (1.5cm)
#1 7-685-647-79 SCREW +BVTP 3X10 TYPE2 TT(B)
2-1. SS-CT8 (OVER ALL SECTION)
NOTE:
•The mechanical parts with no reference
numberin the explodedviewsare not supplied.
•Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when or-
dering these items.
•-XX, -X mean standardized parts, so they may
have some differences from the original one.
•Abbreviation
AUS: Australian model
CND : Canadian model
EA : Saudi Arabia model
RU : Russian model
1
#1
#1
#1
#1
#1
#1
#1
#1
SP1
SP2
SP1
2
3
4
not supplied
not supplied
5
6
6
SECTION 2
EXPLODED VIEWS
The components identified by mark 0or
dotted line with mark 0are critical for safety.
Replace only with part number specified.
Les composants identifiés par une marque
0sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.

SA-SC8/WS8/SS-CT8/TS8
8
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
51 X-4955-907-1 FRAME ASSY, GRILLE
52 4-249-757-01 BUFFLE PANEL(FRONT)
53 4-249-754-01 SPEAKER CABINET (FR)
54 1-694-836-11 TERMINAL, SPEAKER
55 4-249-758-01 TERMINAL BASE (FR)
56 4-251-125-01 SCREW (M5X35)
57 4-250-938-01 SCREW 3X10 +PTP
58 4-249-768-01 COVER
SP3 1-825-592-11 SPEAKER (7cm)
SP4 1-825-591-11 SPEAKER (1.5cm)
#8 7-685-548-19 SCREW +BTP 3X12 TYPE2 N-S
#9 7-685-535-14 SCREW +BTP 2.6X10 TYPE2 N-S
#10 7-685-547-19 SCREW +BTP 3X10 TYPE2 N-S
2-2. SS-TS8 (OVERALL SECTION)
#8
#8
#9
51
52
53
54
56
58
55
57
stand section
SP3
SP4
SP3
#10
#10
#10
#10
#10
#10
#10
57
57
Ver 1.1

9
SA-SC8/WS8/SS-CT8/TS8
2-3. SS-TS8 (STAND SECTION)
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
101 4-246-659-01 FOOT (STAND)
102 4-249-764-01 POLE
103 4-249-769-01 CATCHER
#2 7-682-553-09 SCREW +B 3X20
#3 7-682-247-04 SCREW +K 3X6
#3
#3
#3
103
102
not supplied
not supplied
not supplie
d
101
101
101 101
101
#2
101

SA-SC8/WS8/SS-CT8/TS8
10
2-4. SA-WS8 (OVERALL SECTION)
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
151 4-250-555-01 PANEL (R), ORNAMENTAL
152 4-250-554-01 PANEL (L), ORNAMENTAL
153 4-250-556-01 PANEL (T), ORNAMENTAL
154 X-4955-975-1 FRAME ASSY, GRILLE
155 X-4955-974-1 PANEL ASSY, FRONT
156 4-874-614-21 SCREW (1)(3.5X14), TAPPING
157 4-874-614-51 SCREW (1)(3.5X20), TAPPING
158 4-874-614-71 SCREW
159 4-227-298-01 SHEET
160 4-250-551-01 KNOB (VOL)
161 1-684-552-11 LED BOARD
162 4-250-552-01 KNOB, PUSH
163 1-684-553-11 POWER SWITCH BOARD
164 1-680-785-11 CONTROL BOARD
165 4-231-866-01 PACKING
SP5 1-529-296-11 SPEAKER (20cm)(EXCEPT US, CND)
SP5 1-825-151-11 SPEAKER (20cm)(US, CND)
#1 7-685-647-79 SCREW +P 3X10 TYPE2 NON-SLIT
#4 7-682-546-04 SCREW +P 3X5
#5 7-685-664-79 SCREW +P 4X20 TYPE1
165
155
152
151
153
154
SP5
not
supplied
not
supplied
159
160
163
156
156
157
157
158
162
161
164
#1
#5
#5
#4
not
supplied
amp section

11
SA-SC8/WS8/SS-CT8/TS8
2-5. SA-WS8 (AMP SECTION)
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
201 4-235-237-01 FOOT
202 1-680-789-11 AUTO POWER BOARD
203 1-680-786-11 POWER BOARD
204 3-905-609-01 SCREW (TRANSISTOR)
0205 1-696-570-21 CORD, POWER (UK)
0205 1-696-845-31 CORD, POWER (AUS)
0205 1-769-744-52 CORD, POWER (AEP, E , EA, RU)
0205 1-783-531-11 CORD, POWER (US, CND)
*206 3-703-244-00 BUSHING (2104), CORD
207 A-4747-847-A MAIN BOARD, COMPLETE
208 A-4713-147-A CABINET ASSY, SPEAKER (US, CND)
208 A-4741-412-A CABINET ASSY, SPEAKER (EXCEPT US, CND)
0F601 1-532-463-31 FUSE (T1AL/250V)(EXCEPT US, CND, E)
0F601 1-532-501-31 FUSE (T0.8AL/250V)(E)
0F601 1-533-418-11 FUSE, GLASS CYLINDRICAL(DIA.5)
(2.5A/125V)(US, CND)
0F602 1-532-503-31 FUSE (T1.6AL/250V)(E)
0T501 1-435-999-11 TRANSFORMER, POWER (US, CND)
0T501 1-437-219-12 TRANSFORMER, POWER (E)
0T501 1-437-246-11 TRANSFORMER, POWER
(EXCEPT US, CND, E)
0T601 1-435-993-11 TRANSFORMER, POWER (US, CND)
0T601 1-435-994-11 TRANSFORMER, POWER
(EXCEPT US, CND, E)
0T601 1-435-995-11 TRANSFORMER, POWER (E)
#1 7-685-647-79 SCREW +P 3X10 TYPE2 NON-SLIT
#6 7-685-660-19 SCREW +BVTP 4X10 TYPE2 N-S
#7 7-685-663-79 SCREW +BVTP 4X16 TYPE2 N-S
201 208
201
202
203
204
207 206
T501
not supplied
not supplied
not supplied not supplied
not supplied
not supplied
not
supplied
F601
F602
205
T601
#7
#7
#7
#7
#6
#6
#1
#1
#1
#1
#1
#1
#1
#1
#1
#1
The components identified by
mark 0or dotted line with mark
0are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque 0sont critiques
pour la sécurité.
Ne les remplacer que par une
pièceportantlenumérospécifié.

NOTE:
•Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
•-XX, -X mean standardized parts, so they may
have some difference from the original one.
•Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering
these items.
•CAPACITORS:
uF: µF
•COILS
uH: µH
•RESISTORS
All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable
•SEMICONDUCTORS
In each case, u: µ, for example:
uA...: µA... , uPA... , µPA... ,
uPB... , µPB... , uPC... , µPC... ,
uPD..., µPD...
When indicating parts by reference number,
please include the board name.
The components identified by mark 0or
dotted line with mark 0are critical for safety.
Replace only with part number specified.
Les composants identifiés par une marque
0sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
12
SECTION 3
ELECTRICAL PARTS LIST
SA-SC8/WS8/SS-CT8/TS8
•Abbreviation
AUS:Australian model
CND : Canadian model
EA : Sudi Arabia model
RU : Russian model
1-680-789-11 AUTO POWER BOARD
******************
1-533-217-11 FUSE HOLDER
< CAPACITOR >
0C2 1-113-925-11 CERAMIC 0.01uF 20.00% 250V
0C3 1-113-925-11 CERAMIC 0.01uF 20.00% 250V
(EXCEPT E)
0C4 1-113-925-11 CERAMIC 0.01uF 20.00% 250V (E)
0C5 1-113-924-11 CERAMIC 0.0047uF 20.00% 250V
C601 1-104-666-11 ELECT 220uF 20.00% 25V
C602 1-104-666-11 ELECT 220uF 20.00% 25V
C603 1-126-964-11 ELECT 10uF 20.00% 50V
C604 1-126-964-11 ELECT 10uF 20.00% 50V
C605 1-126-964-11 ELECT 10uF 20.00% 50V
C606 1-126-964-11 ELECT 10uF 20.00% 50V
< CONNECTOR >
*CN601 1-580-230-11 PIN, CONNECTOR (PC BOARD) 2P
CN602 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P
*CN604 1-564-687-11 PIN, CONNECTOR (3.96mm PITCH) 3P
CN605 1-564-507-11 PLUG, CONNECTOR 4P
< DIODE >
D601 8-719-024-99 DIODE 11ES2-NTA2B
D602 8-719-024-99 DIODE 11ES2-NTA2B
D603 8-719-024-99 DIODE 11ES2-NTA2B
D604 8-719-024-99 DIODE 11ES2-NTA2B
D605 8-719-068-42 DIODE HZ13BP-TK
D606 8-719-068-42 DIODE HZ13BP-TK
D607 8-719-991-33 DIODE 1SS133T-72 (EXCEPT E)
D608 8-719-991-33 DIODE 1SS133T-72 (E)
< TRANSISTOR >
Q601 8-729-205-11 TRANSISTOR 2SC1815Y-TPE2
Q602 8-729-231-13 TRANSISTOR 2SA1015TP-Y
< RESISTOR >
R601 1-247-843-11 CARBON 3.3K 5% 1/4W
R602 1-247-843-11 CARBON 3.3K 5% 1/4W
< RELAY >
0RY601 1-755-458-11 RELAY (EXCEPT E)
0RY602 1-755-458-11 RELAY (E)
< SWITCH >
0S601 1-771-474-11 SWITCH, POWER (VOLTAGE CHANGE)
(VOLTAGE SELECTOR)(E)
************************************************************
1-680-785-11 CONTROL BOARD
**************
< CAPACITOR >
C201 1-130-475-00 MYLAR 0.0022uF 5% 50V
C202 1-131-697-31 FILM 0.27uF 5% 50V
C203 1-131-697-31 FILM 0.27uF 5% 50V
C204 1-126-964-11 ELECT 10uF 20.00% 50V
C205 1-131-697-31 FILM 0.27uF 5% 50V
C206 1-131-697-31 FILM 0.27uF 5% 50V
C207 1-126-964-11 ELECT 10uF 20.00% 50V
C208 1-126-964-11 ELECT 10uF 20.00% 50V
C209 1-131-695-11 FILM 0.18uF 5% 50V
C210 1-131-696-11 FILM 0.22uF 5% 50V
C211 1-126-964-11 ELECT 10uF 20.00% 50V
C212 1-126-964-11 ELECT 10uF 20.00% 50V
C213 1-164-159-21 CERAMIC 0.1uF 50V
C214 1-164-159-21 CERAMIC 0.1uF 50V
< CONNECTOR >
*CN201 1-564-508-11 PLUG, CONNECTOR 5P
< DIODE >
D201 8-719-991-33 DIODE 1SS133T-77
D202 8-719-991-33 DIODE 1SS133T-77
< IC >
IC201 8-759-145-58 IC BA4558
IC202 8-759-145-58 IC BA4558
IC203 8-759-145-58 IC BA4558
IC204 8-759-145-58 IC BA4558
< RESISTOR >
R201 1-249-417-11 CARBON 1K 5% 1/4W F
R202 1-249-429-11 CARBON 10K 5% 1/4W
R203 1-247-843-11 CARBON 3.3K 5% 1/4W
R204 1-249-438-11 CARBON 56K 5% 1/4W
R205 1-249-429-11 CARBON 10K 5% 1/4W
R206 1-249-428-11 CARBON 8.2K 5% 1/4W F
AUTO POWER
CONTROL

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
13
SA-SC8/WS8/SS-CT8/TS8
R207 1-249-435-11 CARBON 33K 5% 1/4W
R208 1-249-429-11 CARBON 10K 5% 1/4W
R209 1-249-429-11 CARBON 10K 5% 1/4W
R210 1-249-431-11 CARBON 15K 5% 1/4W
R211 1-249-421-11 CARBON 2.2K 5% 1/4W F
R212 1-247-807-31 CARBON 100 5% 1/4W
R213 1-249-429-11 CARBON 10K 5% 1/4W
R214 1-249-424-11 CARBON 3.9K 5% 1/4W F
R215 1-249-424-11 CARBON 3.9K 5% 1/4W F
R216 1-249-429-11 CARBON 10K 5% 1/4W
R217 1-249-429-11 CARBON 10K 5% 1/4W
R218 1-249-429-11 CARBON 10K 5% 1/4W
R219 1-249-428-11 CARBON 8.2K 5% 1/4W F
R220 1-249-428-11 CARBON 8.2K 5% 1/4W F
R221 1-247-807-31 CARBON 100 5% 1/4W
< VARIABLE RESISTOR >
RV201 1-225-826-11 RES, VAR, CARBON 20K (LEVEL)
< SWITCH >
S201 1-771-632-12 SWITCH, ROTARY (MODE)
************************************************************
1-684-552-11 LED BOARD
**********
< CONNECTOR >
*CN801 1-564-518-11 PLUG, CONNECTOR 3P
< DIODE >
D801 8-719-061-31 DIODE SML72420CTH8F (ON/STANDBY)
************************************************************
A-4747-847-A MAIN BOARD, COMPLETE
*********************
< CAPACITOR >
C104 1-162-286-21 CERAMIC 220PF 10.00% 50V
C105 1-126-964-11 ELECT 10uF 20.00% 50V
C106 1-162-215-31 CERAMIC 47PF 5% 50V
C107 1-162-215-31 CERAMIC 47PF 5% 50V
C108 1-131-694-31 FILM 0.15uF 5% 50V
C109 1-131-690-31 FILM 0.068uF 5% 50V
C110 1-131-701-31 FILM 0.56uF 5% 50V
C111 1-131-691-11 FILM 0.082uF 5% 50V
C118 1-126-964-11 ELECT 10uF 20.00% 50V
C301 1-131-679-31 FILM 0.01uF 5% 50V
C303 1-126-964-11 ELECT 10uF 20.00% 50V
C304 1-162-282-31 CERAMIC 100PF 10% 50V
C305 1-162-302-11 CERAMIC 0.0022uF 30.00% 16V
C306 1-101-804-00 CERAMIC 10PF 5.00% 500V
C307 1-101-810-00 CERAMIC 100PF 5.00% 500V
C308 1-126-934-11 ELECT 220uF 20.00% 10V
C309 1-128-560-11 ELECT 22uF 20.00% 100V
C310 1-128-560-11 ELECT 22uF 20.00% 100V
C311 1-117-165-91 FILM 0.047uF 2.00% 100V
C312 1-136-165-00 FILM 0.1uF 5% 50V
C313 1-130-471-00 MYLAR 0.001uF 5% 50V
C314 1-131-688-31 FILM 0.047uF 5% 50V
C315 1-126-934-11 ELECT 220uF 20.00% 10V
C316 1-126-964-11 ELECT 10uF 20.00% 50V
C317 1-126-948-11 ELECT 100uF 20.00% 35V
C501 1-117-162-91 FILM 0.01uF 2.00% 100V
C502 1-117-162-91 FILM 0.01uF 2.00% 100V
C503 1-135-782-11 ELECT CHIP 10000uF 20% 80V
C504 1-135-782-11 ELECT CHIP 10000uF 20% 80V
C505 1-104-666-11 ELECT 220uF 20.00% 25V
C506 1-104-666-11 ELECT 220uF 20.00% 25V
C507 1-126-964-11 ELECT 10uF 20.00% 50V
C508 1-126-964-11 ELECT 10uF 20.00% 50V
C509 1-126-947-11 ELECT 47uF 20.00% 25V
C510 1-126-947-11 ELECT 47uF 20.00% 25V
C511 1-164-159-21 CERAMIC 0.1uF 50V
C512 1-164-159-21 CERAMIC 0.1uF 50V
C513 1-126-964-11 ELECT 10uF 20.00% 50V
C514 1-126-964-11 ELECT 10uF 20.00% 50V
C515 1-164-159-21 CERAMIC 0.1uF 50V
C516 1-164-159-21 CERAMIC 0.1uF 50V
C701 1-104-661-91 ELECT 330uF 20.00% 16V
< CONNECTOR >
*CN101 1-564-508-11 PLUG, CONNECTOR 5P
*CN301 1-564-243-11 PIN, CONNECTOR (3.96mm PITCH) 6P
CN302 1-564-320-00 PIN, CONNECTOR (3.96mm PITCH) 2P
*CN501 1-564-687-11 PIN, CONNECTOR (3.96mm PITCH) 3P
CN701 1-564-506-11 PLUG, CONNECTOR 3P
< DIODE >
D303 8-719-991-33 DIODE 1SS133T-72
D304 8-719-991-33 DIODE 1SS133T-72
D305 8-719-991-33 DIODE 1SS133T-72
D306 8-719-991-33 DIODE 1SS133T-72
D501 8-719-302-37 DIODE RBV-602
D502 8-719-024-99 DIODE 11ES2-NTA2B
D503 8-719-024-99 DIODE 11ES2-NTA2B
D504 8-719-024-99 DIODE 11ES2-NTA2B
D505 8-719-024-99 DIODE 11ES2-NTA2B
D506 8-719-110-41 DIODE MTZJ-T-77-15B
D507 8-719-110-41 DIODE MTZJ-T-77-15B
D701 8-719-991-33 DIODE 1SS133T-72
D702 8-719-991-33 DIODE 1SS133T-72
D703 8-719-991-33 DIODE 1SS133T-72
D704 8-719-991-33 DIODE 1SS133T-72
< IC >
IC101 8-759-145-58 IC BA4558
IC102 8-759-145-58 IC BA4558
IC104 8-759-145-58 IC BA4558
IC301 8-759-145-58 IC BA4558
IC701 8-759-145-58 IC BA4558
< JACK >
J101 1-770-377-31 JACK, PIN 1P (LINE)
CONTROL LED MAIN

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
14
SA-SC8/WS8/SS-CT8/TS8
< TRANSISTOR >
Q101 8-729-119-78 TRANSISTOR 2SC2785-F
Q301 8-729-117-41 TRANSISTOR 2SA1174-P
Q302 8-729-117-41 TRANSISTOR 2SA1174-P
Q303 8-729-117-41 TRANSISTOR 2SA1174-P
Q304 8-729-119-78 TRANSISTOR 2SC2785-F
Q305 8-729-119-78 TRANSISTOR 2SC2785-F
Q306 8-729-214-51 TRANSISTOR 2SA1145-O
Q307 8-729-270-51 TRANSISTOR 2SC2705-O
Q308 8-729-119-78 TRANSISTOR 2SC2785-F
Q309 8-729-178-41 TRANSISTOR 2SC2784-P
Q310 8-729-119-78 TRANSISTOR 2SC2785-F
Q311 8-729-029-86 TRANSISTOR DTC124ESA-TP
Q501 8-729-205-11 TRANSISTOR 2SC1815Y-TPE2
Q502 8-729-231-13 TRANSISTOR 2SA1015TP-Y
Q701 8-729-029-86 TRANSISTOR DTC124ESA-TP
Q702 8-729-119-77 TRANSISTOR 2SA1175TP-FEK
Q703 8-729-029-86 TRANSISTOR DTC124ESA-TP
Q704 8-729-029-40 TRANSISTOR DTA124ESA-TP
Q705 8-729-029-40 TRANSISTOR DTA124ESA-TP
< RESISTOR >
R113 1-249-417-11 CARBON 1K 5% 1/4W F
R114 1-249-441-11 CARBON 100K 5% 1/4W
R115 1-249-441-11 CARBON 100K 5% 1/4W
R116 1-249-429-11 CARBON 10K 5% 1/4W
R117 1-247-843-11 CARBON 3.3K 5% 1/4W
R118 1-249-429-11 CARBON 10K 5% 1/4W
R119 1-249-418-11 CARBON 1.2K 5% 1/4W F
R120 1-249-421-11 CARBON 2.2K 5% 1/4W F
R121 1-249-439-11 CARBON 68K 5% 1/4W
R122 1-249-417-11 CARBON 1K 5% 1/4W F
R123 1-249-435-11 CARBON 33K 5% 1/4W
R124 1-249-424-11 CARBON 3.9K 5% 1/4W F
R125 1-249-424-11 CARBON 3.9K 5% 1/4W F
R126 1-247-807-31 CARBON 100 5% 1/4W
R139 1-249-421-11 CARBON 2.2K 5% 1/4W F
R141 1-247-903-00 CARBON 1M 5% 1/4W
R301 1-249-429-11 CARBON 10K 5% 1/4W
R302 1-249-429-11 CARBON 10K 5% 1/4W
R303 1-249-429-11 CARBON 10K 5% 1/4W
R304 1-249-433-11 CARBON 22K 5% 1/4W
R305 1-249-438-11 CARBON 56K 5% 1/4W
R306 1-249-411-11 CARBON 330 5% 1/4W
R307 1-249-431-11 CARBON 15K 5% 1/4W
R308 1-249-408-11 CARBON 180 5% 1/4W F
0R309 1-249-408-11 CARBON 180 5% 1/4W F
0R310 1-249-408-11 CARBON 180 5% 1/4W F
R311 1-249-429-11 CARBON 10K 5% 1/4W
R312 1-249-433-11 CARBON 22K 5% 1/4W
0R313 1-249-407-11 CARBON 150 5% 1/4W F
0R314 1-249-401-11 CARBON 47 5% 1/4W F
R315 1-249-438-11 CARBON 56K 5% 1/4W
R316 1-249-419-11 CARBON 1.5K 5% 1/4W F
0R317 1-249-393-11 CARBON 10 5% 1/4W F
0R318 1-249-393-11 CARBON 10 5% 1/4W F
0R319 1-249-393-11 CARBON 10 5% 1/4W F
0R320 1-217-156-00 METAL 0.22 10% 5W
R321 1-249-435-11 CARBON 33K 5% 1/4W
R322 1-249-429-11 CARBON 10K 5% 1/4W
R323 1-249-415-11 CARBON 680 5% 1/4W F
R324 1-249-417-11 CARBON 1K 5% 1/4W F
R325 1-249-417-11 CARBON 1K 5% 1/4W F
R326 1-249-417-11 CARBON 1K 5% 1/4W F
R327 1-249-429-11 CARBON 10K 5% 1/4W
R328 1-249-430-11 CARBON 12K 5% 1/4W
R329 1-249-421-11 CARBON 2.2K 5% 1/4W F
R330 1-249-425-11 CARBON 4.7K 5% 1/4W F
R331 1-249-417-11 CARBON 1K 5% 1/4W F
R332 1-249-431-11 CARBON 15K 5% 1/4W
R333 1-249-420-11 CARBON 1.8K 5% 1/4W F
R335 1-249-433-11 CARBON 22K 5% 1/4W
R336 1-249-430-11 CARBON 12K 5% 1/4W
R337 1-249-438-11 CARBON 56K 5% 1/4W
R338 1-249-441-11 CARBON 100K 5% 1/4W
R339 1-249-441-11 CARBON 100K 5% 1/4W
R340 1-249-433-11 CARBON 22K 5% 1/4W
0R341 1-216-458-11 METAL OXIDE 1.8K 5% 2W
0R501 1-249-393-11 CARBON 10 5% 1/4W F
0R502 1-249-393-11 CARBON 10 5% 1/4W F
R503 1-249-421-11 CARBON 2.2K 5% 1/4W F
R504 1-249-421-11 CARBON 2.2K 5% 1/4W F
R701 1-249-441-11 CARBON 100K 5% 1/4W
R702 1-249-417-11 CARBON 1K 5% 1/4W F
R703 1-249-430-11 CARBON 12K 5% 1/4W
R704 1-249-429-11 CARBON 10K 5% 1/4W
R705 1-249-429-11 CARBON 10K 5% 1/4W
R706 1-249-441-11 CARBON 100K 5% 1/4W
R707 1-247-903-00 CARBON 1M 5% 1/4W
R708 1-249-417-11 CARBON 1K 5% 1/4W F
R709 1-249-421-11 CARBON 2.2K 5% 1/4W F
R710 1-249-421-11 CARBON 2.2K 5% 1/4W F
R711 1-249-429-11 CARBON 10K 5% 1/4W
< RELAY >
RY301 1-515-920-11 RELAY (24V)
< SWITCH >
S701 1-771-188-11 SWITCH, SLIDE (POWER SAVE)
************************************************************
1-680-786-11 POWER BOARD
*************
< CAPACITOR >
C401 1-126-947-11 ELECT 47uF 20.00% 16V
< CONNECTOR >
*CN401 1-564-243-11 PIN, CONNECTOR (3.96mm PITCH) 6P
The components identified by
mark 0or dotted line with mark
0are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque 0sont critiques
pour la sécurité.
Ne les remplacer que par une
pièceportantlenumérospécifié.
MAIN POWER

15
SA-SC8/WS8/SS-CT8/TS8
< TRANSISTOR >
Q401 8-729-141-30 TRANSISTOR 2SC3623ATP-LK
Q402 8-729-119-77 TRANSISTOR 2SA1175TP-FEK
Q403 8-749-010-25 IC MN2488-OPY-M
Q404 8-749-010-26 IC MP1620-OPY-M
< RESISTOR >
R401 1-249-437-11 CARBON 47K 5% 1/4W
R402 1-249-421-11 CARBON 2.2K 5% 1/4W F
R403 1-249-414-11 CARBON 560 5% 1/4W F
0R404 1-249-408-11 CARBON 180 5% 1/4W F
0R405 1-249-408-11 CARBON 180 5% 1/4W F
0R406 1-217-151-00 METAL 0.22 10% 2W
0R407 1-217-151-00 METAL 0.22 10% 2W
***********************************************************
1-684-553-11 POWER SWITCH BOARD
********************
< CAPACITOR >
0C1 1-113-924-11 CERAMIC 0.0047uF 20.00% 250V
< CONNECTOR >
CN1 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P
< SWITCH >
0S1 1-554-920-11 SWITCH, PUSH (AC POWER)(1 KEY)(POWER)
***********************************************************
MISCELLANEOUS
***************
41-694-836-11 TERMINAL, SPEAKER
54 1-694-836-11 TERMINAL, SPEAKER
0205 1-696-570-21 CORD, POWER (UK)
0205 1-696-845-31 CORD, POWER (AUS)
0205 1-769-744-52 CORD, POWER (AEP, E , EA, RU)
0205 1-783-531-11 CORD, POWER (US, CND)
0F601 1-532-463-31 FUSE (T1AL/250V)(EXCEPT US, CND, E)
0F601 1-532-501-31 FUSE (T0.8AL/250V)(E)
0F601 1-533-418-11 FUSE, GLASS CYLINDRICAL(DIA.5)
(2.5A/250V)(US, CND)
0F602 1-532-503-31 FUSE (T1.6AL/250V)(E)
SP1 1-825-592-11 SPEAKER (7cm)
SP2 1-825-591-11 SPEAKER (1.5cm)
SP3 1-825-592-11 SPEAKER (7cm)
SP4 1-825-591-11 SPEAKER (1.5cm)
SP5 1-529-296-11 SPEAKER (20cm)(EXCEPT US, CND)
SP5 1-825-151-11 SPEAKER (20cm)(US, CND)
0T501 1-435-999-11 TRANSFORMER, POWER (US, CND)
0T501 1-437-219-12 TRANSFORMER, POWER (E)
0T501 1-437-246-11 TRANSFORMER, POWER (EXCEPT US, CND, E)
0T601 1-435-993-11 TRANSFORMER, POWER (US, CND)
0T601 1-435-994-11 TRANSFORMER, POWER(EXCEPT US, CND, E)
0T601 1-435-995-11 TRANSFORMER, POWER (E)
Ref. No. Part No. Description Remarks
The components identified by
mark 0or dotted line with mark
0are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque 0sont critiques
pour la sécurité.
Ne les remplacer que par une
pièceportantlenumérospécifié.
POWER POWER SWITCH

SA-SC8/WS8/SS-CT8/TS8
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver. Date Description of Revision
1.0 2003.09 New
1.1 2004.09 Addition of Ref. No. 58 COVER for SS-TS8 by change of service
classification (SPM-04104)