SportsPlay Equipment 561-451 User manual

561-451 Combination Goal with Net Supports (Pair) Page 1
Rev. 05/20/08
SportsPlay Equipment, Inc., 5642 Natural Bridge, St. Louis, MO 63120 [phone]
www.sportsplayinc.com
* IMPORTANT *
PLEASE RETAIN THIS INSTRUCTION SHEET IN YOUR FILES. IT CONTAINS IMPORTANT
REPLACEMENT PARTS INFORMATION. ALL EQUIPMENT SHOULD BE INSTALLED IN
ACCORDANCE WITH THESE INSTRUCTIONS.
IT IS IMPORTANT TO USE AND MAINTAIN ALL PUBLIC PLAYGROUND EQUIPMENT
PROPERLY. PLAYGROUND EQUIPMENT, WHICH IS IMPROPERLY MAINTAINED, CAN CAUSE
SERIOUS INJURY. PERIODICAL INSPECTIONS, MAINTENANCE, REPAIR AND/OR
REPLACEMENT OF DAMAGED PARTS IS NECESSARY FOR SAFE OPERATION OF EQUIPMENT
AND SAFETY OF USERS. RESILIENT SURFACING SHOULD BE USED UNDER ALL
PLAYGROUND EQUIPMENT. APPROPRIATE PUBLICATIONS, AVAILABLE AT NO CHARGE,
FROM THE CONSUMER PRODUCT SAFETY COMMISSION, INCLUDE “A HANDBOOK FOR
PUBLIC PLAYGROUND SAFETY.” YOU CAN RECEIVE YOUR FREE COPY BY CALLING 1-
301-504-7908.
*563-614 MUST BE INSTALLED WITH WELDED D-RINGS FACING THE REAR TOWARD 563-604 NET SUPPORTS
PACKING LIST HARDWARE BAG
1 CTN Hardware Bag 4 105-017 2 3/8” Pipe Plug
4 PIPE 1 563-604 Net Support Posts 4 pr 425-517 1 7/8” T-Clamps
4 PIPE 1 563-215 Goal Post 4 116-511 5/16” x 2 ¾” Hex Head Bolt
4 WF 1 563-314 Cross Frame 16 196-802 ½” x ½” Socket Set Screw
4 PIPE 1 596-614 Post Support 6 116-604 3/8” x 1” Hex Head Bolt
6 226-601 3/8” Lock Nut
4 226-501 5/16” Lock Nut
1 416-400 ¼” Socket Key
1 CTN 4 PIPE 5 TOTAL PCS WT 110# CLASS 70

561-451 Combination Goal with Net Supports (Pair) Page 2
Rev. 05/20/08
SportsPlay Equipment, Inc., 5642 Natural Bridge, St. Louis, MO 63120 [phone]
www.sportsplayinc.com
ASSEMBLY INSTRUCTIONS
NOTE: All threaded ends of bolts protruding beyond nuts must be cut off
and/or peened to eliminate sharp edges. No more than two threads
should extend beyond face of nut.
All washers, “T” nuts, and other fastener hardware used on round
pipe or tubing must be hammered down to conform to the curved
underlying surface to eliminate catch points.
DO NOT tighten nuts more than hand-tight until entire assembly is
completed.
STEP #1: Mark and dig footing holes
STEP #2: Place 563-614 Uprights in Footing Holes.
Brace uprights so that the bottom does not rest on the footing
hole bottom. Make sure uprights are level. At least 2’0” of
upright should be in footing hole.
STEP #3: Pour footings using:
12 – 80lb. Bags Pre-Mix Cement – 3 bags per hole.
Be sure to ‘cone’ the top of the pour for drainage.
STEP #4: Attach 563-314 Frame using:
6 – 116-604 Hex Bolts
6 – 226-601 Lock Nuts
See Frame Attachment Detail A and B.
STEP #5: Attach 563-215 Posts onto Frames using:
8 – 196-802 Socket Set Screws

561-451 Combination Goal with Net Supports (Pair) Page 3
Rev. 05/20/08
SportsPlay Equipment, Inc., 5642 Natural Bridge, St. Louis, MO 63120 [phone]
www.sportsplayinc.com
STEP #6: Attach 563-604 Net Support using:
8 - 425-517 T-Clamps
4 – 116-604 Hex Head Bolts
8 – 226-601 Lock Nuts
Place end opposite T Clamped end (see net support attachment
detail C) into remaining footing holes.
STEP #7: Mix and pour Pre-Mix concrete into net support footing holes
NOTES: Wait 48 hours for concrete to harden before using unit.
DO NOT install where overhead electrical wires are present.
MAINTENANCE INSTRUCTIONS:
Check periodically for loose bolts, broken parts and replace immediately.
Frame Attachment Detail “A”
Frame Attachment Detail “B”
N
et Support Attachment Detail “C”