SPORTSPOWER NS-004 User manual

!
WARNINGS!
USER AND ASSEMBLY MANUAL
Tips : It will take 2 people around 30 mins to assemble this product.
- Misuse and abuse of this product can result in injury.
- Read instructions before assembly or using this product. Retain Instructions.
- Always inspect product before use, checking for worn, defective or missing parts.
- Suitable for age 9-36 months. Max user weight 25 kg.
- Adult supervision at all times.
- Only for outdoor and domestic use.
- Before you start assembly please check all parts are included, if any parts are missing or
you need advice, please call Customer Help Line: ([phone].
NS-004
NURSERY SWING

(6) SWING 1
(4) LOWER LEG 4
CROSS BAR 2
(3) RIGHT TOP LEG 2
NO. QTY
(1) TOP BAR 1
(2) LEFT TOP LEG 2
(5)
(7) PEG 4
PART LIST
(8) CAP 4
P.1
4
5
7
7
4
3
2
3
1
6
2
4
8
8
5
7
7
4 8
8
Peg Tube
NS-CAP
SW-XBAR
NS-TPLEG-LHS
SW-LOWLEG
NS-TPLEG-RHS
NS-SEAT
SW-TOPBAR

P.2
Ax2 (M8x102mm)
Mx2 (
Ф 8x100mm)
Zx1 (65mm) Wx1 (130mm)
Bx2 (M6x36mm)
Ex8 (19mm) Fx24 (14) Hx4 (13.5) Ix12 (10)
Jx4 (M8) Kx12 (M6)
Dx4 (M6x42mm)
Cx4 (M6x53mm)
GEN-UBOLTM8X102
GEN-BOLTM6X36 GEN-BOLTM6X53 GEN-BOLTM6X42
GEN-ARCWASH-19X8.5 GEN-ARCWASH-14X6.5 GEN-SPRWASH-M8 GEN-SPRWASH-10.5X1.5
GEN-CAPNUT-M8 GEN-NUT-M6 FNS-SEATPINS
GEN-SPAN5-11-13 GEN-ALWR6MM

P.3
M
M
Insert the buckle(M) to lock the swing.
step 1
M
x2

P.4
step 2
H
A E J
x4x4 x8 x2
A
A
E
H
J
E
E
E
H
J
2
2
3`
3
3
3
2
1
1
2
1
6

P.5
step 3
I
B F K
x4x4 x8 x4
2
2
3`
3
4
4
4
4
BFFIK
4

P.6
step 4
1# PLEASE ATTACH THE PLASTIC CAP (8) INTO CROSS
BAR (5) FIRST.
2# THE CROSS BAR (5) NEEDS TO BE ATTACHED TO THE
OUTSIDE OF THE SWING FRAME.
I
D F K
x4x4 x8 x4
DFI
F
K
4
5
8
4
8
8
4
4
4
5
5

P.7
step 5
I
C F J
x4x4 x8 x4
4
7
CFFIJ
7
7
7
7
4
4
4
4

P.8
step 6
7
7
7
74
4
4
4

P.9
step 7
NOTE: LOCK THE SEAT BELT TIGHTLY OVER THE CHILD.

P.10
Observing the following statements and warnings reduces
the likelihood of serious injury.
It is designed for children aged 9-36 months with maximum
weight of 25kg.
• Provide on-site adult supervision for children of all ages at
all times. Never leave children unattended.
• It is recommended that the playground equipment be
located on level ground by anchors. Be certain that all
anchoring devices (including concrete) are placed below the
level of the playing surface and covered with protective soft
material, or below ground level to prevent tripping.
• Only one child per seat at any one time.
• Teach children to sit in the centre of the swing seat, with
their full weight in the centre of the seats. DO NOT allow
children to lean to the side when on swing seats or to collide
with other playmates. DO NOT allow children to stand on
the swing seat.
• Dress children appropriately while on and around this
equipment. DO NOT allow children to wear ponchos,
scarves, jewelry, loose shoes, jackets or clothing with loose
strings and/or clothing that might be potentially hazardous
whilst using this equipment.
• DO NOT let children use this equipment in any manner
other than intended.
• DO NOT install over concrete, asphalt, gravel or any other
hard surface which may cause injury should a fall occur.
Swing set shall be placed over protective soft material such
as sand bed, soft woodbark, grass lawn. the depth of sand
and soft woodbark shall be a minimum of 6 inches.
• DO NOT let children use this equipment until it has been
properly assembled and anchored. Place equipment on level
ground not less than 2M from any structures or obstacles
such as fences, overhanging branches, laundry or electrical
lines, garages, sheds or houses.
• Instruct children to NOT swinging empty seats as this may
strike other children, or themselves. They may strike other
children, or the play equipment may come back and strike
you.
• Instruct children not to walk closely in front of, behind or
in between moving swing seat. Instruct children to keep a
safe distance away to avoid being struck by the items in use.
• Instruct children not to twist chains or ropes, or loop them
over the support bar. This adds stress, reduces strength and
may result in failure and cause injury.
• DO NOT allow children to stand on the swing seat.
•
DO NOT allow children to jump from moving swing seats.
• DO NOT allow children to climb or play on the equipment
whilst wet (slips or falls may occur).
• DO NOT allow children to climb on or swing from structural
members (eg legs, top bar and chin bars). These are
structural components ONLY and NOT play features.
• DO NOT allow children to swing more than 60 degrees.
• After completion of assembly, ensure all hex nuts are
tightened and in the correct position.
• DO NOT attach items to the playground equipment that
are not specially designed for use with this equipment, such
as, but not limited to, jump ropes, clotheslines, pet leashes,
cables and chains as they may cause strangulation hazards.
• The minimum clearance from the seat to ground is 350mm.
• At the end of each play season, remove all plastic parts
and take indoors. DO NOT allow the use of plastic items
when the temperature drops below 32°F/0°C.
• Dispose of all packaging properly after the unit has been
assembled.
• This equipment is for family domestic use and is
intended for outdoor and indoor use.
• This equipment is for family domestic use and is intended
for outdoor use only.
• Check all nuts and bolts for tightness and tighten when
required.
• Check swing seats, chains, and other means of
attachments for evidence of deterioration, replace when
required in accordance with the manufacturer’s instruc-
tions.
• This unit must be assembled by adults, ensure bolts and
small components are kept out of reach of young children.
the suspension system is secure.
• Check metal sections or components for signs of
corrosion.
• Discontinue use if weakening or breakage found.
• Young children in play are unaware of potential dangers
and hazards, therefore responsible adults supervision is
essential.Never leave children unattended.
• Failure to comply with these precautions may result in
injury.
• Disassemble and store indoors during the winter.
• Do not attach items to the equipment that are not
not limited to cables skipping ropes and chains as they may
cause strangulation hazards
• Not suitable for hiring or commercial use.
• Never use the equipment in any manner other than
intended.
gravel are considered to be acceptable shock-absorbing
depth under and around playground equipment. However
Material should be checked periodically and replenished to
maintain correct depth as determined necessary for your
equipment, otherwise serious injuries may occur from a fall.
• Toys shall be accompanied by maintenance instruc
tions drawing attention to the need of carrying out checks
and maintenance of the main parts at regular intervals, if
these checks are not carried out the toy could overturn and
otherwise become a hazard. Whenever practical, the
• Please retain these instructions for future reference.
• Warning! For domestic use only.
Tightening Nuts & Bolts
• At the start of assembling, DO NOT tighten bolt/nut all
the way, so to allow some possible adjustment for ease of
assembly.
• After all major components are assembled, go back over
all bolts and nuts properly tighten all of them before using
this product.

P.11
• The area that you choose should be policed for glass, rocks
or anything jagged or sharp that could endanger your
children’s safety. The surface underneath your play system
can cause orprevent injuries. We have additionalsuggestions
in the suggested playground surfacing section.
• Do not build your play set on top of surfacing material.
• Please install this equipment facing away from the sun to
avoid causing dizziness whilst playing.
• Check all nuts and bolts twice monthly during the season
and tighten as required. We recommend you check the
swing beam and hardware every two weeks. It is particularly
important that this procedure be followed at the beginning
of each season
•Oil all metallic moving parts monthly during the usage period.
• Check all nuts and bolts twice monthly during the season
to be certain they are in place. Replace when necessary. It is
especially important to do this at the beginning of each new
season.
• Check swing seats, ropes, cables and chains monthly
during usage season for evidence of deterioration.
Replacement should be made of any swing seat that has
developed cracks in the plastic seat or has exposed metal in
the edges of the swing seat. If there are already exposed
metal inserts on the edge of the seat, immediately remove
the seats and chains to prevent serious injury. Ropes, cables
and chains should be removed and replaced if excessive
wear is found. Contact OUR SERVICE CENTER for
replacement parts.
• Maintaining the Play set on a level location is very
important. As your children play, your Play set will slowly dig
its way into soil, and it is very important that is settles evenly.
Make sure the play set is level and true once each year or at
the beginning of each play season.
• Hardware: inspect for tightness.
• Swing hangers: check to insure correct installation. Make
sure that the bend of the swing hanger is positioned tightly
against the stop washer and swing beam. The axis of the
swing hanger bushing must be perpendicular to the swing
motion. If squeaking occurs the nylon bushings can be
sprayed with WD-40 or other house hold lubricant.
• The instructions and owner’s manual for your new play set
should be read in its entirety before assembly, to minimize
problems and safety issues. We recommend reading the
parts for your play set as discussed in the HINTS AND TIPS AS
LISTED BELOW.
• Check all coverings for bolts and sharp edges and replace
when required.
• Do not adjust the length of the swing rope.
• Never use pliers to tighten up screws –these can
cause damage to both the paintwork and the special
anti-corrosion plating
• To help maintain the products appearance, occasionally
clean the seats and metal framework with a damp cloth
lightly – but DO NOT use abrasive chemical cleaners.
• When the time comes to disassemble and dispose of this
product, please completely disassemble the unit and discard
of it in a safe place and manner so as not to present any
hazard to any individual. It is important to check and
maintain the main parts at regular intervals. If these checks
are not carried out, the toy could overturn or otherwise
become a hazard. Whenever practical, the instructions shall
Positioning Your Play Set
area of your yard to minimize ground preparation.
• Place the equipment not less than 2M from any structure
or obstruction such as a fence, garage, house, overhanging
branches. Laundry lines, or electrical wires.

P.12
PRODUCT WARRANTY
All warranty coverage extends only to the original purchaser of the product and is not assignable or transferable. The original
store or online purchase receipt must be kept as proof of purchase in order for the warranty to be valid. These documents must
be presented in the event of making a claim under warranty.
During the warranty period, Sportspower will provide repair or replacement of defective equipment or parts thereof covered by
the warranty. Any handling, transportation, delivery and other incidental charges in respect of the servicing of the equipment
shall be borne by the Purchaser. If the product includes a number of accessories, only the defective part or accessory will be
replaced.
The warranty will become void if any defects or damages are associated with the use of unauthorized replacement parts. All
replacement parts must be obtained from Sportspower authorized agents.
All decisions made by Sportspower in respect of the servicing of the equipment (including repairs, replacements or issues
relating to defects of workmanship or materials) shall be conclusive and the Purchaser agrees to be bound by such decisions.
Any defective equipment or part thereof replaced shall become the property of Sportspower.
In the event of a product or accessory being replaced during the guarantee, the guarantee on the replacement will expire at the
original date, i.e. 90 days from the original purchase date.
This warranty excludes defects caused by the product not being used in accordance with instructions, accidental damage,
misuse or being tampered with by unauthorized persons.
The Sportspower Limited Warranty does not cover:
(a) Products used for commercial or rental purposes.
(b) Loss or damage to product due to: (i) abuse, repairs and/or tampering by any person other than the authorized personnel of
Sportspower; (ii) negligence and/or misuse (including foreign object, accident, improper storage, exposure to sun/moisture,
excessive temperature, sand, dust, dirt, other pollution or other environmental conditions and failure to follow precautions or
proper operating instructions stated in the User’s Manual such as improper installations); (iii) fire, flood, lightning strike, wind
storm or other acts of God; (vi) freight or improper transport damages, and (v) improper usage (including use by under-age,
over-weight or excessive number of users permitted as stated in the User’s Manual).
(c) Defects, damages or accidents due to the malfunction, connection to or use of non-Sportspower or unauthorized parts. In
such event, Sportspower reserves the right to cancel the Limited Warranty coverage immediately.
To the extent allowed by the applicable local law, the remedies in the Limited Warranty are the Purchaser’s sole and exclusive
remedies.
SPORTSPOWER IS NOT RESPONSIBLE OR LIABLE FOR INDIRECT, SPECIAL OR CONSEQUENTIAL DAMAGES ARIS-
ING OUT OF OR IN CONNECTION WITH THE USE OR PERFORMANCE OF THE PRODUCT OR OTHER DAMAGES WITH
RESPECT TO ANY ECONOMIC LOSS, LOSS OF PROPERTY, LOSS OF REVENUE OR PROFITS, LOSS OF ENJOYMENT
OR USE, COST OF REMOVAL, INSTALLATION OR OTHER CONSEQUENTIAL DAMAGES. SOME STATES DO NOT
ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES. ACCORDINGLY, THE
ABOVE LIMITATION MAY NOT APPLY TO YOU.
THE WARRANTY EXTENDED HEREUNDER IS IN LIEU OF ALL OTHER WARRANTIES AND ANY IMPLIED WARRANTY OF
MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE IS LIMITED IN ITS SCOPE AND DURATION TO THE
TERMS SET FORTH HEREIN. SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY
LASTS. ACCORDINGLY, THE ABOVE LIMITATION MAY NOT APPLY TO YOU. THIS WARRANTY GIVES YOU SPECIFIC
LEGAL RIGHTS. YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE. THIS WARRANTY IS
VALID ONLY IN THE UNITED STATES.
SP-19-NS004-EGL-17001
CUSTOMER SERVICE/ SPARE PARTS -(+44)
0330 0904 420
Geemac Sales & Marketing Ltd.
20 Queensbridge Bedford Road Northampton,
United Kingdom, NN4 7BF
Sportspower Ltd.
20/F, Parkview Centre, 7 Lau Li Street, Causeway Bay,
Hong KongCorporate Office 1-800-497-6106