Sunrise Medical Switch-It CTRL+5 User manual

Switch-It CTRL+5® with
Assignable Buttons
000247780.01
Owner’s Manual

2247780 Switch-It CTRL+5 with Assignable Buons Rev.A
WARNING!
Please read these instrucons carefully before you start the installaon work. If you do not understand and follow the installaon
instrucons, including the Warnings and Cauons this can lead to injury to the user and the guarantee can bevoided by this. If you
have any quesons please call your local Sunrise Medical branch (contact details on the back page).
NOTE: Check all parts for shipping damage. In case of damage DO NOT use. Contact Carrier/Sunrise Medical for further instrucons.
WARNING
DO NOT install this equipment without rst reading and understanding this manual. If you are unable to understand the Warnings,
Cauons, and Instrucons, contact a qualied clinician or supplier - otherwise injury or damage may occur.
WARNING
This device can be aected by Electro-Magnec Interference (EMI) and Radio Frequency Interference (RFI).
• Radio wave sources, such as radio staons, TV staons, amateur radio (HAM) transmiers, two-way radios, and cellular phones
can aect powered control.
• If unintended movement or brake release occurs, turn the power wheelchair OFF and do not operate unl inspected, repaired,
and/or replaced.
• If the chair acts in an errac manner, turn the power wheelchair OFF and do not operate unl inspected, repaired, and/or
replaced.
• If the joysck stem is damaged, it can cause the chair to operate erracally, turn the power wheelchair OFF and do not operate
unl inspected, repaired, and/or replaced.
• If any of the device cabling becomes frayed, cut, or disconnected in any way, turn the power OFF and do not operate unl
inspected, repaired, and/or replaced.

3247780 Switch-It CTRL+5 with Assignable Buons Rev.A
User informaon
Congratulaons on choosing a Switch-It product. Sunrise
Medical’s high-quality mobility products are designed to
enhance independence and make your everyday life easier.
As a part of our ongoing product improvement iniave, Sunrise
Medical reserves the right to change specicaons and design
without noce.
This user manual
This user manual will help you to use and maintain your product
safely.
Dealer: This owner’s manual must be given to the rider of this
wheelchair.
Rider: Before using this wheelchair read this enre manual and
save it for future reference.
SMART TECHNOLOGIES
If you are visually impaired, this
document can be viewed in PDF
format at
www.SunriseMedical.co.uk

4247780 Switch-It CTRL+5 with Assignable Buons Rev.A
General Warnings
WARNING!
• Do not open or tamper with the Ctrl+5 enclosure. Tampering
could cause the internal circuit to fail.
• Do not tamper with fasteners on the Ctrl+5 unless
performing roune maintenance.
• Ensure mounng hardware is hand ght.
• Check mounng hardware every month to ensure it is hand
ght.
• The wire harness from the Ctrl+5 should not be loose or
in the way of the seat funcons. Ensure that wires are not
pinched as the power chair is actuated.
• This product is intended for a single user.
• Always use parts and/or accessories that have been
recommended or approved by Sunrise Medical when
servicing this chair.
• Never pull on cables. This can result in wires breaking inside
the connector or harness. To remove a plug or connector,
always grasp the plug or connector itself.
• If a buon on the Ctrl+5 is accidentally pushed that funcon
will become acve.
• Do not reuse any mounng hardware including fasteners.
• Product labeling may fall o due to environment heat, sun
exposure, or moisture. Contact your dealer for a new label if
this occurs.
• Ensure powerchair is o when not in use.
• Ensure powerchair is o when operang a motor vehicle.
• Ensure not to hit, lean on, or hang things from your Ctrl+5.
• Do not use your chair in a shower, pool or other body of
water.
• Avoid excess moisture (for example, do not leave your chair
in a damp bathroom while taking a shower).
• Dry your Ctrl+5 immediately if it gets wet or damp, or if you
use water to clean it.
• Avoid contact with salt or salty condions as this may cause
damage to the Ctrl+5.
Safety Warnings
Safety: Temperature
WARNING!
• If you do not use the Ctrl+5, ensure that it is not exposed to
direct sunlight for lengthy periods of me. Certain parts of
the Ctrl+5, such as the keypad, the cable, and the enclosure
can become hot or brile if they have been exposed to full
sunlight for too long. This may cause burns or to the skin or
render the Ctrl+5 inoperable.
• Extended sun exposure can result in product labels becoming
discolored, illegible or falling o.
Safety: Electromagnec radiaon
CAUTION!
The standard version of your Ctrl+5 device has been
tested on the applicable requirements with respect to
electromagnec radiaon (EMC requirements) in spite of these
tests:
It cannot be excluded that electromagnec radiaon may have
an inuence on the Ctrl+5.
For example:
• Mobile telephones.
• Large scale medical apparatus.
• Other sources of electromagnec radiaon.
It cannot be excluded that the Ctrl+5 may interfere with
electromagnec elds.
For example:
• Shop doors.
• Burglar alarm systems in shops.
• Garage door openers.
If an EMC event occurs there may be unintended operaon of
your Ctrl+5 device.
In the unlikely event that such problems do occur, we request
that you nofy you authorized dealer immediately.
Safety: Choking hazard
DANGER!
This mobility aid uses small parts which under certain
circumstances may present a choking hazard to young children.
Safety: Assignable controls
WARNING!
It is possible to assign a funcon to an input control (buons,
jacks) to your seang system. If controls have been assigned
to perform a dual or alternate funcon ensure you know what
each control operates.
Please contact your authorized dealer or the Sunrise Medical
technical service department if you do not receive this
informaon. Failure to do so may result in product or property
damage and/or injury.

5247780 Switch-It CTRL+5 with Assignable Buons Rev.A
Maintenance ps
The wheelchair’s lifespan is dependant on it being well
maintained.
For informaon concerning specic sengs, maintenance, or
repair work, please contact your authorized Sunrise Medical
dealer.
Storage Tips:
WARNING!
• Store your Ctrl+5 in a clean, dry area. If you fail to do so, parts
may rust or corrode.
• Before using your Ctrl+5, make sure it is in proper working
order.
• If you store this Ctrl+5 for more than three months, have it
inspected by an Authorized Dealer before use.
Cleaning and disinfecng:
• The Ctrl+5 should be wiped down once per week.
• If a foreign substance is present wipe down (with a slightly
damp, not wet) cloth.
• Make sure that you dry all parts of the Ctrl+5 prior to use.
• Be sure to clean your Ctrl+5 regularly. This will help you nd
loose or worn parts. If you nd loose, damaged or worn parts
replace before use.
CAUTION!
Make sure that you dry all parts of your wheelchair if it
becomes wet or damp, such as when cleaning, or if it is used in
a wet or damp atmosphere.
CAUTION!
• Do not use solvents, bleaches, abrasives. synthec detergents,
wax polishes, or aerosols.
• Disinfectants may be used in diluon as specied by the
manufacturer.
• Ensure surfaces are rinsed with clean water and dried
throughly.
System Pre-check
Before each use perform the following:
• Ensure your powerchair is on and charged.
• Ensure your buons are programmed to the desired intended
funcon.
• To ensure buons are programmed as intended, press each
buon to verify funconality.
• Ensure label above keypad matches the funconality of the
buon.

6247780 Switch-It CTRL+5 with Assignable Buons Rev.A
A. Product Descripon:
The Switch-It CTRL+5® with Assignable Buons is a switch box device
that plugs into the PG Drives R-Net system and allows for the set up of a
maximum of ten dierent funcons in ten discrete buons (each switch is
two buons). The Ctrl+5 switches are pre- programmed from the factory
to default values for the actuators on the chairs, however this parcular
model uses the Sunrise Medical patented Assignable Buons feature.
This feature allows the buon assignments to be changed to any of the
Assignable Buons funcons to best suit each unique user. The system
allows for having two standard Ctrl+5s or one standard Ctrl+5 and one
Ctrl+5 with Remote Seang on the same power wheelchair, if desired, for
a total of up to 20 dierent funcons in twenty discrete buons.
B. Technical Informaon:
• Control Type: Switched/Digital Power Wheelchair. Peripheral Funcon
Control Peripheral Funcon Control.
• Acvaon Type: Mechanical switch
• Feedback: Acvaon of programmed power wheelchair funcons (i.e.
seat funcons).
• Connector Type: R-net cable (male) to power wheelchair data-bus
connecng block
• Dimensions: approximately 4.25” (108 mm) W x 2.5” (63.5 mm) H x
1.25” (31.75 mm) D.
• USB port on the Ctrl+5 provides up to 2.0 Amps
C. Compability:
• Penny & Giles R-Net Electronics required. Power wheelchair must have
assignable buons feature.
• In order to use the Switch-It Remote Seang app with your powerchair
you must have the Remote Seang enabled Ctrl+5 (Part Numbers
247375 and 247376) and a complex seang module, CxSM, with
soware version 5.0 or greater.
D. Key Features:
The user may choose from two dierent Ctrl+5 keypad versions: a at
push buon version, Figure 1, or a toggle version, Figure 2.
Customizable access - patented Assignable Buon technology and
programming, with use of the power wheelchair dealer’s PC Programmer
and dongle, provide the user with direct access to up to 20 dierent
funcons (10 per CTRL+5).
The CTRL+5 may be mounted in several ways for convenient access to
seat funcon controls:
• Arm rest mount (cover picture).
• Seat rail mount — mounts similar to seat control in automobiles,
Figure 3.
• Back cane mount — for aendant control of powerchair peripherals,
Figure 4.
The Ctrl+5 has a built-in USB port is for charging or powering peripheral
devices, Figure 5. The current is limited to 2.0 Amps, which is sucient
to charge most smartphones and tablets. The port is also on a pigtail so
it can be moved from one side to the other depending on how the user
prefers to access it.
Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5

7247780 Switch-It CTRL+5 with Assignable Buons Rev.A
INSTALLATION
Install the CTRL+5 in a locaon that is easy for the intended user to
access.
Only authorized Sunrise Medical dealer should install this product.
INDICATORS
The behavior of the indicators is dependent on the seang module in the
system.
1. With an Intelligent Seang Module (ISM) the indicators, Figure 6,will all
be green or yellow.
• Yellow indicates a drive inhibit is acve and green indicates there is
no drive inhibit.
• All white indicators meant the module has not authencated with the
powerchair.
2. With a Complex Seang Module (CxSM) the indicators, Figure 6, are
linked to the buon below them.
• When a buon is assigned to any other opon but seang, the light
will be solid white.
• When a buon is assigned to a seang Memory axis, and that axis is
running, the light will be blinking green.
• When a buon is assigned to a seang Memory axis and a drive
inhibit occurs the LED will change to the drive inhibit color once the
axis is stopped.
• When a buon is assigned to a seang Memory axis other than a
Memory axis the drive inhibit color change will happen when the
inhibit happens.
• The LED color will be Red for a lockout drive inhibit.
• When a buon is assigned to any seang axis and no actuator
channel within that axis has called for a drive inhibit the LED color will
be Green.
Fig. 6
Fig. 7
Fig. 8
PROGRAMMING ASSIGNABLE BUTTONS
1. Changing the assignable buons of the Ctrl+5 should only be done
by an authorized Sunrise Medical dealer.
2. Connect powerchair to PC Programmer using a Programming
Dongle.
3. Read Chair into the programmer by clicking on the blue down arrow
in the toolbar, shown at right.
4. Open the Switch-It folder and the module you wish to change.
Figure 7 shows Buon 1 of module 1 is assigned to Speed Up and
Speed Down.
5. To change this double click on the current assignment. In this case
you would double click on the “Speed Up” text. This brings up the
window as shown in Figure 8.
6. Now select the funcon you need that buon to do by clicking the
checkbox, then click OK.
7. Connue this process unl all buons have the desired funcon
8. Now click the upload buon, shown at right.
9. Now power cycle the chair. Your new assignments are now updated.
Indicator Window

8247780 Switch-It CTRL+5 with Assignable Buons Rev.A
Troubleshoong:
Issue: Powerchair hourglass shows on display and does not go away
Soluon:
1. Unplug Ctrl+5 and turn chair o.
2. Plug Ctrl+5 back in and turn chair on.
Issue: New buon assignments are not loading on the device.
Soluon:
1. Unplug Ctrl+5 and turn chair o.
2. Power cycle (turn o and turn back on) the chair and retry buon
assignments to ensure they funcon as intended.
If you have any quesons please call your local Sunrise Medical branch
(contact details on the back page).

9247780 Switch-It CTRL+5 with Assignable Buons Rev.A
Warranty
THIS GUARANTEE DOES NOT AFFECT YOUR LEGAL RIGHTS IN ANY WAY.
Sunrise Medical* provides a guarantee, as set out in the warranty condions, for products to its customers covering the following.
Warranty condions:
1. Should a part or parts of the product require repair or replacement as a result of a manufacturing and/or material fault within 24
months, then the aected part or parts will be repaired or replaced free of charge. The warranty will only cover manufacturing
defects.
2. To enforce the warranty, please contact Sunrise Medical Customer Service with the exact details of the nature of the diculty.
Should you be using the product outside the area covered by the Sunrise Medical customer service agent, repairs or replacement
will be carried out by another agency as designated by the manufacturer The product must be repaired by a Sunrise Medical
designated Customer Service agent, (dealer).
3. For parts, which have been repaired or exchanged within the scope of this warranty, we provide a warranty in accordance with
these warranty condions for the remaining warranty period for the product in accordance with point 1.
4. For original spare parts which have been ed at the customer’s expense, these will have a 12 months guarantee, (following the
ng), in accordance with these warranty condions.
5. Claims from this warranty shall not arise, if a repair or replacement of a product or a part is required for the following reasons:
a. Normal wear and tear, which include but is not limited to the following parts where ed; baeries, armrest pads, upholstery,
tyres, brakes shoes, ferrules, etc.
b. Any overloading of the product, please check the EC label for maximum user weight.
c. The product or part has not been maintained or serviced in accordance with the manufacturer’s recommendaons as shown
in the user instrucons and/or the service instrucons.
d. Accessories have been used which are not specied as original accessories.
e. The product or part having been damaged by neglect, accident or improper use.
f. Changes/modicaons have been made to the product or parts, which deviate from the manufacturer’s specicaons.
g. Repairs have been carried out, before our Customer Service has been informed of the circumstances.
6. This guarantee is subject to the law of the country in which the product was purchased from Sunrise Medical“
* Means the Sunrise Medical facility from which the product was purchased.
DISPOSAL AND RECYCLING INFORMATION
When this product reaches the end of its life, please take it to an approved collecon or recycling point designated by your local
or state government. This Seang system is manufactured using a variety of materials, Your product should not be disposed of as
ordinary household waste.
You should dispose of your system properly, according to local laws and regulaons. Most materials that are used in the construcon
of this product are fully recyclable.
The separate collecon and recycling of your product at the me of disposal will help conserve natural resources and ensure that it is
disposed in a manner that protects the environment.
Ensure you are the legal owner of the product prior to arranging for the product disposal in accordance with the above
recommendaons.

10 247780 Switch-It CTRL+5 with Assignable Buons Rev.A

11247780 Switch-It CTRL+5 with Assignable Buons Rev.A

247780_OM_Switch-It CTRL5 with Assignable Buons
RevA_2018-08-10
EC REP
Sunrise Medical GmbH
Kahlbachring 2-4
69254 Malsch/Heidelberg
Deutschland
Tel.: [phone]
Fax: [phone]
www.SunriseMedical.de
Sunrise Medical
Thorns Road
Brierley Hill
West Midlands
DY5 2LD
England
Phone: [phone]
Fax: [phone]
www.SunriseMedical.co.uk
Sunrise Medical S.L.
Polígono Bakiola, 41
48498 Arrankudiaga – Vizcaya
España
Tel.: [phone]
Fax: [phone]
www.SunriseMedical.es
Sunrise Medical Poland
Sp. z o.o.
ul. Elektronowa 6,
94-103 Łódź
Polska
Telefon: + 48 42 275 83 38
Fax: + 48 42 209 35 23
E-mail: [email protected]
www.Sunrise-Medical.pl
Sunrise Medical B.V.
Groningenhaven 18-20
3433 PE NIEUWEGEIN
The Netherlands
T: +31 (0)30 – 60 82 100
F: +31 (0)30 – 60 55 880
E: inf[email protected]
www.SunriseMedical.nl
Sunrise Medical HCM B.V.
Vossenbeemd 104
5705 CL Helmond
The Netherlands
T: [phone]
E: cust[email protected]
www.SunriseMedical.nl
www.SunriseMedical.eu
(International)
Sunrise Medical S.A.S
ZAC de la Vrillonnerie
17 Rue Mickaël Faraday
37170 Chambray-Lès-Tours
Tel : + 33 (0) 247554400
Fax : [phone]
www.sunrisemedical.fr
Sunrise Medical S.r.l.
Via Riva, 20 – Montale
29122 Piacenza
Italia
Tel.: [phone]
Fax: [phone]
www.SunriseMedical.it
Sunrise Medical AG
Erlenauweg 17
CH-3110 Münsingen
Schweiz/Suisse/Svizzera
Fon [phone]
Fax [phone]
www.SunriseMedical.ch
Sunrise Medical AS
Delitoppen 3
1540 Vestby
Norge
Telefon: [phone]
Faks: [phone]
[email protected]
www.SunriseMedical.no
Sunrise Medical AB
Box 9232
400 95 Göteborg
Sweden
Tel: [phone]
Fax: [phone]
www.SunriseMedical.se
MEDICCO s.r.o.
H – Park, Heršpická 1013/11d,
625 00 Brno
Czech Republic
Tel.: [phone]
Fax: [phone]
www.medicco.cz
inf[email protected]
Bezplatná linka 800 900 809
Sunrise Medical ApS
Park Allé 289 G
DK-2605 Brøndby
Tlf. 70 22 43 49
Email: inf[email protected]
www.SunriseMedical.dk
Sunrise Medical Pty. Ltd.
6 Healey Circuit, Huntingwood,
NSW 2148,
Australia
Phone: [phone],
Orders Fax: [phone],
Admin Fax: [phone].
Australia
www.sunrisemedical.com.au
Sunrise Medical
North American Headquarters
2842 Business Park Avenue
Fresno, CA, 93727, USA
[phone]
[phone]
www.SunriseMedical.com