Therian All-Aluminium Kuranda Bed User manual

TOOL NEEDED :
#2 Phillips Head Screwdriver
7/16 Wrench or Pliers or Adjustable Wrench
Flat surface on which to work (table preferred)
PARTS LIST:
1Fabric Mat (40oz Vinyl or Ballistic Nylon)
4lengths of Alum slotted pipe (2 long & 2 short)
4Alum legs, 4Leg caps
4top corner brackets & 4 bottom corner brackets
8machine screws & 8 lock washers and 8hex
nuts, 4 set screws for aluminium bottom corner
4pieces plastic cording for the sleeves of the
Ballistic Nylon fabric
NOTE:Heat Welded 40oz Vinyl fabrics have the
cording already encased in outer edge of fabric.
Continuing to work with the underside
of the fabric facing up, position one top
corner bracket and insert bolts through
bracket and pipe.
Lay fabric flat with underside facing up and
insert cording into sleeve.Note that 40oz
Vinyl fabric comes with cording in the sleeve.
Insert fabric sleeves into the channel on each
length of pipe.
Place rubber caps on legs and insert
legs into bottom corner.Rotate leg so
slot aligns with set screw hole.Secure
in place with set screw. This is
purposely atight fit so it will take some
effort to fully tighten screws.
Comments or Questions? Call Therian on
1800-251-766 or 07 5657-6777
1
3
2
Place abottom corner bracket over
pipes, insert bolts through openings,
secure with lock washers and hex nuts
and hand tighten.Insert and secure
second bolt.Repeat process at each of
other three corners.
4
5
Assembly Instructions For All-Aluminium Kuranda Bed

KURANDA DOG BED GUARANTEES
HOW ARE THE DOG BEDS CHEWPROOF?
Any place the fabric is in aposition to be chewed, it is protected by apoly-resin sleeve.
There are no corner gaps to bite.Once in awhile adog will bite through aleg or side piece
but it is quite rare.This image shows how the fabric fits into the frame of the bed so your
dog cannot reach the fabric.Caution:Fabrics are vulnerable to tearing by persistently
scratching or digging dogs.
KURANDA DOG BEDS ARE GUARANTEED CHEWPROOF FOR ONE FULL YEAR!
Kuranda guarantees the structural integrity of the frames and fabrics of their dog beds
against chewing by adog for aperiod of one year from date of purchase.Accordingly,
Kuranda will replace frame parts and fabric damaged by dogs chewing the bed only to the
point of not being useable at no charge during this period.This warranty excludes damage
caused by dogs scratching the fabric.This warranty includes chewing of corner fittings and
legs.Fabrics covered under this guarantee by chewing only are 40 oz solid vinyl and
Ballistic nylon.Multiple fabric replacements for the same bed will be handled on acase by
case basis.
Please call us if you have any questions in Australia on 1800-251-766.
Turn bed over and fully tighten all screws and nuts
so they are flush with the nylon insert locking
material.
6
Unit 4, 26 Commercial Drive,
Ashmore QLD 4214
Tel: [phone]
Fax: [phone]
[e-mail]
www.therian.com.au
Leg Set Screws:
Periodically check leg screws so that they do not
come out and create an ingestion hazard.
Cleaning Solutions:
Chlorine based cleaning solutions will corrode
aluminium. If using a bleach or chlorinated cleaner,
be sure to rinse thoroughly. Corrosion of rails and
corner brackets due to caustic cleaners is not
covered under Kuranda’s “Chewproof” Guarantee.