Trane Thermo King TriPac Envidia User manual

Revision B
October 2020 TTKK 5566446600--1199--OOPP--EENN
TriPac®Envidia™™
Operator’s Manual

2TK 56460-19-OP-EN
Introduction
This manual is published for informational purposes onl and the
information furnished herein should not be considered as all-inclusive or
meant to cover all contingencies. If more information is required, consult
our Thermo King Service Director for the location and telephone number
of the local dealer.
TThheerrmmoo KKiinngg’’ss wwaarrrraanntt sshhaallll nnoott aappppll ttoo aann eeqquuiippmmeenntt wwhhiicchh hhaass
bbeeeenn ““ssoo iinnssttaalllleedd,, mmaaiinnttaaiinneedd,, rreeppaaiirreedd oorr aalltteerreedd aass,, iinn tthhee
mmaannuuffaaccttuurreerr’’ss jjuuddggmmeenntt,, ttoo aaffffeecctt iittss iinntteeggrriitt ..””
MMaannuuffaaccttuurreerr sshhaallll hhaavvee nnoo lliiaabbiilliittyy ttoo aannyy ppeerrssoonn oorr eennttiittyy ffoorr aannyy
ppeerrssoonnaall iinnjjuurryy,, pprrooppeerrttyy ddaammaaggee oorr aannyy ootthheerr ddiirreecctt,, iinnddiirreecctt,, ssppeecciiaall,,
oorr ccoonnsseeqquueennttiiaall ddaammaaggeess wwhhaattssooeevveerr,, aarriissiinngg oouutt ooff tthhee uussee ooff tthhiiss
mmaannuuaall oorr aannyy iinnffoorrmmaattiioonn,, rreeccoommmmeennddaattiioonnss oorr ddeessccrriippttiioonnss
ccoonnttaaiinneedd hheerreeiinn.. TThhee pprroocceedduurreess ddeessccrriibbeedd hheerreeiinn sshhoouulldd oonnllyy bbee
uunnddeerrttaakkeenn bbyy ssuuiittaabbllyy qquuaalliiffiieedd ppeerrssoonnnneell.. FFaaiilluurree ttoo iimmpplleemmeenntt tthheessee
pprroocceedduurreess ccoorrrreeccttllyy mmaayy ccaauussee ddaammaaggee ttoo tthhee TThheerrmmoo KKiinngg uunniitt oorr
ootthheerr pprrooppeerrttyy oorr ppeerrssoonnaall iinnjjuurryy..
There is nothing complicated about operating and maintaining our Thermo
King unit, but a few minutes stud ing this manual will be time well spent.
Performing pre-trip checks and enroute inspections on a regular basis will
minimize operating problems. A regular maintenance program will also help
to keep our unit in top operating condition. If factor recommended
procedures are followed, ou will find that ou have purchased the most
efficient and dependable temperature control s stem available.
All service requirements, major and minor, should be handled b a Thermo
King dealer for four ver important reasons:
• The are equipped with the factor recommended tools to perform all
service functions
• The have factor trained and certified technicians
• The have genuine Thermo King replacement parts
• The warrant on our new unit is valid onl when the repair and
replacement of component parts is performed b an authorized Thermo
King dealer

TK 56460-19-OP-EN 3
Customer Satisfaction Survey
Let our voice be heard!
Your feedback will help improve our manuals. The surve is accessible
through an internet-connected device with a web browser.
Scan the Quick Response (QR) code or click or t pe the web address https://
tranetechnologies.iad1.qualtrics.com/jfe/form/SV_2octfSHoUJxsk6x?Q_
CHL=qr&Q_JFE=qdg to complete the surve .
IInnttrroodduuccttiioonn

4TK 56460-19-OP-EN
SSaaffeett ................................................................................................................ 77
Danger, Warning, Caution, and Notice . . . . . . . . . . . . . . . . . . . . . . . . 7
Safet Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Inverter Operation Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Refrigerant Oil Hazards. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Refrigerant Hazards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
FirstAid................................................... 10
Safet Nameplates. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
UUnniitt DDeessccrriippttiioonn...... .... .... .... .... .... .... ...... .... .... .... .... .... .... .... .... .... .... .... .... .... 1133
Unit Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Suggestions to Maximize Run Time . . . . . . . . . . . . . . . . . . . . . . . . . 13
S stem Components. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Batter Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Evaporator/Control Box. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Condenser and Receiver Drier . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
HMI Controller . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Optional Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Control Circuits . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Power Sources. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Truck Integration. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
OEM Batter Pack. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Alternator............................................ 19
Ignition Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Protection Devices . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Air Conditioning S stem . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Electrical S stem Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
MMaannuuaall PPrree--TTrriipp IInnssppeeccttiioonn.. ...... .... .... .... .... .... .... .... ...... .... .... .... .... .... .. 2211
Before Starting the TriPac Envidia Unit . . . . . . . . . . . . . . . . . . . . . . 21
Table of Contents

TK 56460-19-OP-EN 5
OOppeerraattiinngg IInnssttrruuccttiioonnss .... .... .... .... ...... .... .... .... .... .... .... .... .... .... .... .... .... .... 2222
HMI Control Panel Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
HMI Control Panel Displa . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
On/Off Knob . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Mode Selection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Temperature Selection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Fan Selection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Driver Selectable Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Icons ..................................................... 27
Batter Power Indicators. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
S stem Alarm Icons . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Batter Alarm Icon . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Batter Charging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
TruckRunning ........................................ 29
ShorePower.......................................... 31
Recommendations for Maximum Performance and Batter
Run Time when in Cool Mode. . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
PPoowweerr IInnvveerrtteerr ((OOppttiioonnaall)).................................................................... 3333
SSppeecciiffiiccaattiioonnss .... ...... .... .... .... .... .... .... .... .... .... ...... .... .... .... .... .... .... .... .... .... .... 3344
Electrical Control S stem . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
Fuses..................................................... 34
Fuse Locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
Optional AC to DC Power Converter . . . . . . . . . . . . . . . . . . . . . . . . . 36
Optional Power Inverter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
Air Conditioning S stem . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
Optional Heater. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
MMaaiinntteennaannccee IInnssppeeccttiioonn SScchheedduullee ...... .... .... .... .... .... .... .... ...... .... .... 3377
Electrical . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
TTaabbllee ooff CCoonntteennttss