VOLTA VT3 PRO Reference manual

INTRODUCTION AND USER'S GUIDE
www.volta.com.tr
Read this owner's manual carefully before moving your vehicle. Read this owner's manual carefully before moving your vehicle.
vt3 pro

www.volta.com.tr
PREFACE
Driver and Passenger
batteries
• This vehicle is designed for use on flat and asphalt roads. • Read the entire
user manual. • Especially "Warning, Caution, Note and Safety Precautions"
sections
• High efficiency brushless direct current motor •
Electric control unit with indicator that protects against high and low voltages • Braking
with gas cut-off for safe driving • High capacity providing longer range and high
performance
Road condition
Please review it carefully.
This vehicle is designed for environmentally friendly transportation. You will see the
advantages and characteristics of the product in the user manual. General features are
given below;
• This vehicle is designed to carry a maximum of 1 driver. • Please take
care to use the vehicle without exceeding the load limits written on the certificate of
conformity.
Front and rear suspensions providing a pleasant and comfortable ride •
Motorcycle equipment in accordance with European standards
• These headings are written to protect you from serious personal injury or potential accident.
It is obligatory to comply with the maintenance intervals written in the user manual. Otherwise, your
vehicle will be out of warranty conditions. The maintenance intervals for your vehicle and the parts that
need to be replaced/checked are listed in this user manual.
•
WARNING
2
ATTENTION
These headings are written to protect you from serious personal injury and mechanical damage.
•
•
IMPORTANT NOTE
You need to take it to service.
• The nearest authorized person for the first maintenance 1 month after purchasing your vehicle.

Appearance
General
6
information
one
4
Producer
Guarantee
Trustworthy
3and Using
8
Preface
2
7
Control
Taking
Technicial
Specifications
Maintenance and
to use
Storage and
5
3
www.volta.com.tr
6
20
12
19
8
18
21
2 3 4
CONTENTS

Safe Driving Instructions
www.volta.com.tr
4
•
•
Please pay.
Check the tires.
1. SAFE DRIVING
Accessories such as knee pads, elbow pads, glasses, protective gloves are
protective equipment that will reduce your risk of serious injury. However, definitely
put on a helmet before driving your vehicle. • Grasp the grips with both hands
while riding. • Make sure you maintain a safe driving position. • Practice often to gain
experience. • Observe the maximum loading conditions specified in the manual. • Make
sure that the loads in your bags that you attach to the front carrying iron • are light. •
Objects moving while driving will change the vehicle's center of gravity, thus
jeopardizing the driving safety. Take the necessary measures to avoid this situation. •
Avoid acrobatic movements while driving your vehicle. • Avoid high speeds when
turning. • Wet weather lengthens the braking distance and restricts maneuverability.
such
• Make sure the throttle is working properly. • Check all
lighting systems.
Pre-Riding Instructions •
Check the condition of all movement components. • Check all
rotating parts and check oil levels
Always keep your low speed in situations. • Avoid
excessive puddles that may occur in rainy weather. • Never drive the vehicle
under the influence of alcohol and drugs.
• Follow the pre-ride instructions before starting to use. • Most of the accidents
happen because of not being noticed in traffic. To prevent this; Wear clothes that will
reflect the light in traffic and make it easier to be noticed.
• Make sure that all nuts and bolts are sufficiently tightened. • Check that the brake
cable and other cables are not pinched and are working properly.

www.volta.com.tr 5
• Obey the maximum speed limits.
Efficient Driving Instructions
1. SAFE DRIVING
You have noticed that your tire pressures are appropriate.
•
If the following efficient driving instructions are followed, your vehicle's driving range
and efficiency will increase; • Have your vehicle serviced regularly. • Observe the
maximum load limits in the manual. • Take care to use it in suitable weather and road
conditions.

2
5
www.volta.com.tr
3
4
2.OVERALL LOOK
• All parts listed in the user manual are for reference. The manufacturer can make
changes without notice.
6
WARNING
8
6
7
•
1. Front Basket
2. Engine
3. RearWheel
4. Headlight
5. Ignition
6. Throttle
7. Indicator
8. Balance Wheel
1

WARNING
7
All parts listed in the user manual are given as reference. The manufacturer can make
changes without notice.
•
•
1
www.volta.com.tr
2.1. DASHBOARD
4. Display
5. Contact
1. Horn (Optional)
2.Forward-Reverse Gear Button
3.Headlight
5
3
2
4

b
a
www.volta.com.tr
Insert the ignition key into its slot and turn it to the on position. The vehicle will be
ready for driving.
The speed can be increased or decreased with the throttle. Turn the throttle in
direction (a) to increase your speed, or (b) to decrease speed.
Do not carry loads that are not suitable for carrying loads on your vehicle.
Otherwise, these parts will be damaged. • The front carry bag can be used to
carry light loads. • Please do not exceed the permissible load limits. Please do
not carry loads on surfaces that are not suitable for carrying loads on the vehicle.
Otherwise, these parts will be damaged.
• Give the throttle by turning the throttle lever downwards. In this case, your
vehicle will move.
If you turn it again after the vehicle has started, it will turn on the headlights.
8
3. OPERATION AND USE
Acceleration and Deceleration
Headlight Opening
Operating
Loading

10-20mm
•
brake lever free travel distance should be 10 - 20 mm. After this distance, the
braking process should start.
may cause accidents.
• Be careful when braking on downhill descents.
Front Brake Range
Brake levers have brake cutters. In this way, the brake lever performs both
mechanical braking and cuts the energy of the motor.
Campaign
Your vehicle has Disc (Front) and Drum (Rear) brake systems. for brakes,
• Grasp the brake lever with your fingers and gently squeeze it towards you. •
Slowly loosen the brake lever to stop braking • Avoid sudden and hard braking.
Otherwise, your vehicle may skid and
Brake pads should always be replaced with original products. Low quality parts can damage other
parts of the vehicle.
9
ATTENTION
www.volta.com.tr
3. OPERATION AND USE
front and rear brake
Braking

2
one
•
•
•
place it. Arc/
spark may occur while connecting the charger to the vehicle.
There are two warning LEDs on the charger. The first LED is solid red, indicating
that it is working, while the other LED turns red during charging and turns green
when the battery is full. If there is a red and green color in the charger, it means
the battery is full. If your charger has a single LED, it turns red during chargingand turns green when
charging is complete. • Wait until the light on the indicator turns green. • After the
charging is complete, unplug the socket from the charging port and the charger from
the socket. Unplugging the charger will extend the life of the product.
•
•
Charge your empty battery for 7-8 hours with the help of the charger provided. To
charge the vehicle, please follow the instructions below; Make sure your electric
motorcycle is turned off. • First of all, plug the part of the charger indicated with "2"
into the socket. • Then insert the part of the charger indicated with "1" into the charging
port of your vehicle.
•
ATTENTION
WARNING
Your chargers that break down due to voltage differences in your electrical installation may damage your
vehicle. These types of faults are not covered by the warranty. Plugging the charger into the socket first will
protect your vehicle from possible high/low voltage situations. • Charging at least once a month will extend the
life of your battery. • When the battery is fully charged, disconnect it from the charger. a contrary
situation
•
If the battery charge time exceeds the time specified in the manual, please create a fault record.
During the winter months, the performance of the battery may decrease and the normal range of your vehicle may decrease.
10
It may cause your battery to swell.
www.volta.com.tr
3. OPERATION AND USE
Charger

•
•
Your electric vehicle must be turned off while charging. Never
shake your vehicle while charging.
do not combine. Never use any conductor between the anode and the
cathode. It will cause a short circuit. • Avoid contact of your battery with
water. • Protect the batteries from temperatures of 60 degrees and above. •
Do not subject it to physical impacts such as hitting, throwing, dropping.
•
If changes occur, disconnect the battery from your vehicle and drive away.
Do not tamper with the batteries with sharp tools.
• Only use the original charger specially designed for your product.
If leakage occurs and comes into contact with your skin or eyes, rinse immediately
with plenty of water and go to the nearest health institution. • If the battery has physical
effects such as odor, heating, burning, discoloration.
use it.
•
• Do not disassemble the
batteries. • Keep batteries away from children. •
When charging or discharging the anode and cathode of the battery
ATTENTION
If you do not use your electric motorcycle for a month or more, discharge and recharge the batteries at
least once a month. This app helps you maintain battery performance.
11th
Store your electric motorcycle away from the cold, in your garage if possible. This will extend the life of
your battery.
•
Battery
3. OPERATION AND USE
www.volta.com.tr

240-310kPa/35-45 psi
240-310kPa/35-45 psi
14-2.50
Tire Pressure Check
Brake Maintenance
14-2.50
In addition, low-inflated tires can cause an accident as they reduce grip.
•
Your tires will wear out with use. When your tread depth decreases, you should replace it. Depending on
the road, climate and usage conditions, your tire life may be extended or shortened. The user should
regularly check the tire pressure and tread depth. Tires with low tread depth will reduce grip, especially
on wet surfaces. The minimum tread depth is 1.5 mm for the front tire and 2.0 mm for the rear tire. Such
situations cause accidents.
If the tire does not have the correct air pressure, it will wear out more quickly and its life will be shortened.
• If the tire pressure is too low, the tire may come off the rim.
12
WARNING
4. MAINTENANCE AND CONTROL
vt3
•
Dimensions Pressure
Check the pressure levels of your tires daily. Above and below normal tire
pressures will affect the vehicle's handling, acceleration, fuel consumption and
performance.
Brake pads wear out due to the working principle. It must be changed after a
certain time. Security level control and change should be done by authorized
services. Unreplaced brake pads cause poor performance of the brake system,
make noise, and in some cases even break other parts. Brakes should be checked
at every service.
Check your tires daily for punctures, cuts or any other unusual condition. Also on
the rims; can cause air loss in crushing, scratching and tilting. This type of damage
can cause your vehicle to unbalance and shake. In case of such situations, go to
your nearest authorized service and have the damage repaired.
www.volta.com.tr

Insurance Exchange
Cleaning
Drive / Engine Maintenance
Adjusting the Throttle Lever
•
•
•
Using a fuse below the specified capacity may cause the system to be permanently cut off, and using it above
the specified capacity may cause the electronic parts to break down and the cables to be damaged due to high
currents.
•
13
WARNING
Do not use high pressure water while washing your vehicle. It will damage your electrical systems.
Please pay.
• Your vehicle's electronic control unit (driver) is under the rear fairing. Therefore, be careful not
to get water in this area. Make sure that the cables entering this area are not strained and
that the protective plastic does not get hit.
Never lubricate the brake assembly and tires. • Use oil to
clean the metal parts of your vehicle. • Always use standard cleaning materials
when cleaning painted plastic parts. • Rinse with fabrics after cleaning.
• Make sure the vehicle is in the off position.
• Check that the throttle can easily move to the top and bottom.
• Slow down when the road surface is bad. Excessive vibration may cause the cables to break
inside the motor and driver. • Do not allow the water level to reach the level of the engine
in rainy weather. Otherwise, your engine will break down.
The vehicle's charging circuit is protected by a 30A fuse against outside intervention and the
charger's breakdown. In case of malfunction, it must be replaced. For this;
Do not press at once.
• The distance from the highest position to the first throttle response should be between
2 and 6 mm. To adjust this, loosen the jam nut, turn the adjuster and tighten it
again.
•It is recommended to clean your electric vehicle with a wet cloth.
• To avoid deterioration of other parts, use the same accelerator and brake when starting.
Replace with a fuse of equivalent specification.
4. MAINTENANCE AND CONTROL
www.volta.com.tr

•
•
•
If the vehicle has not been used for 1 month or more, check the parts that are likely to corrode, such as
tires and batteries, and start driving before the next use.
• For your personal safety, turn off the engine and raise the vehicle to the rear before any maintenance. Even
if it is a simple maintenance, do not perform the maintenance before the engine is turned off and the
vehicle is on the rear stand.
Please stay away from modifications to make your vehicle safe and long-lasting. Modified vehicles will
endanger the safety of you and the traffic. Always use parts approved by the manufacturer.
14
•
WARNING
Never use very high pressure water while washing your electric motorcycle, high pressure water may
cause some parts of your parts to get water. Parts that receive water will have a reduced lifespan and
may deteriorate.
ATTENTION
• Even if your vehicle runs smoothly, it should be checked by authorized services at
regular intervals. These ranges are detailed in the following pages of the user
manual. Vehicles that have experienced problems or have had an accident should
be taken directly to the authorized service without waiting for the maintenance
interval. In such cases, repairs should definitely be made with the original part. •
Maintenance, repair, modification or any change that will increase the performance of the
vehicle other than the contracted service stations approved by the manufacturer will
cause the product to be out of warranty.
1. Month and 4. Month maintenance is important for your vehicle. After the
first use, the engine parts are now used to each other and it is recommended to
check all the bolts during the first maintenance. • The reliability of your vehicle
depends on the correct first use and first periodic maintenance.
Maintenance Interval
First Care
4. MAINTENANCE AND CONTROL
www.volta.com.tr

Engine and Chassis Number
ATTENTION
Make sure that the engine and chassis numbers on your electric vehicle are the same as those on the
Certificate of Conformity.
15
•
Engine and chassis numbers are for the registration of your vehicle and help our authorized
services in order to provide better service to you in case of need for maintenance / repair.
Chassis number
Engine number
4. MAINTENANCE AND CONTROL
www.volta.com.tr

Periodic Maintenance Tables
•
vt3
Periodic maintenance should be done at contracted technical service stations.
•
16
Vehicles that are not regularly maintained (once every 4 months) will be considered
out of warranty.
•
4. MAINTENANCE AND CONTROL
www.volta.com.tr

16.MONTH(8,000KM)
24.MONTH(12.000KM) 1.MONTHCONTROL
4.MONTH(2.0 00KM)
8.MONTH(4,000KM)
HydraulicDisc
20.MONTH(10.000KM)
12.MONTH(6,000KM)
OnBrakeVehicles
0380 731 25 25 0380 731 25
35 [email protected]
17
Wheel
Back
Chain
wheels
Handlebar
Rear Brake
Gas handle
front and
bearings
(If applicable)
Front
Check the brake discs.
bearings
Suspension
tires
Suspension
Battery
4. MAINTENANCE AND CONTROL
www.volta.com.tr

Vehicle Storage
Commissioning
Assembly
The vehicle is delivered assembled.
Transport
•
•
18
•
Bring the tire pressure of your electric motor vehicle to the ideal tire pressure level.
• Start your electric motor vehicle after completely following the pre-starting instructions.
Make the first use in a traffic-free area. After making sure that all parts of your
electric motor vehicle are working correctly and at full performance, go to the traffic.
•
Cover with a plastic or non-rubber sheet. Take care to store in storage conditions
where the air temperature does not change much. High temperature change can
cause fatigue, deterioration and cracking of many parts of your vehicle.
Do not carry loads that are not suitable for carrying loads on your electric motor
vehicle. Otherwise, these parts will be damaged.
If you are not going to use your electric motor vehicle for a long time during periods
such as winter months, you should take some precautions to protect your vehicle
from malfunctions and abrasions. It would be better to make some repairs before
storage.
Remove the cover from your electric motor vehicle and clean the vehicle.
•
Clean, rinse and dry your electric motor vehicle. Coating the painted surfaces with
protective oil will prolong the life of your paint and ensure that it retains its first
day's shine.
•
5. STORAGE AND HANDLING
www.volta.com.tr

738 mm
Mass
BLDC Hub Motor
40 km
Height
Maximum speed
Battery Type VRLA Gel
85 kg
Parameters
1
45 kg
48V 14Ah
Front Brake
Range
7-8 hours
Electric Motor Maximum Power
1135 mm
Number of Seating Positions
220W
Length
Max Loaded Mass*
48-57V, 1.8A +/- 1.2A
Campaign
1125 mm
Battery Capacity
25 km/h
Engine Type
www.volta.com.tr 19
6.TECHNICAL SPECIFICATIONS
Charger
Charging Time

in case you run into any problems
You can access it from the Service Information System.
Repair time is 45 working days. About your vehicle
Volta Motor Industry and Trade Inc. - Tübitak Technology Free Zone
Tübitak MAM Technology Free Zone Barÿÿ SB. mh. 5001 St.
service station information created by the Ministry
and spare parts information. All authorized
The service life of your Volta brand vehicle is 10 years, maximum
Authorized services by visiting our www.volta.com.tr
www.volta.com.tr
No:3 A/B Gebze / KOCAELÿ / TURKEY
Selamlar Village Selamlar Mevkii Gümüÿova OSB
1.Street Blok No:10 Gümüÿova / DUZCE / TURKEY
Tel: [phone]
Tel: [phone]
20
Wuxi Volta Motor Technology Co., LTD No.
36-37, Yougu Industrial Park, No:58 Jinghong
Road, Xibei Town, Xishan District, Wuxi City
JIANGSU / CHINA
Volta Motor Industry and Trade Inc.
MANUFACTURER
7. MANUFACTURER INFORMATION