Volvo V70 SPORT User manual

Instruction No Version Part. No.
30737114 1.2 30737107
Turn - by - turn Navigation System
Instruction No Version Part. No.
30737114 1.2 30737107
Turn - by - turn Navigation System
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 1 / 67

Equipment
A0000162 A0000163 A0000161
M8802108
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 2 / 67

M3905282
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 3 / 67

M3905280
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 4 / 67

M3905281
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 5 / 67

M3905306
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 6 / 67

M8903924
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 7 / 67

M8505122
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 8 / 67

M3905267
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 9 / 67

IMG- 213320
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 10 / 67

INTRODUCTION
Read through all of the instructions before starting installation.
Notifications and warning texts are for your safety and to
minimise the risk of something breaking during installation.
Ensure that all tools stated in the instructions are available
before starting installation.
Certain steps in the instructions are only presented in the form
of images. Explanatory text is also given for more complicated
steps.
In the event of any problems with the instructions or the
accessory, contact your local Volvo dealer.
Note!
The holder for the remote control can only be fitted on cars
without handsfree telephone.
Note!
Model year – 2004 = V70 CH – 458999, XC70 CH –172999
Model year 2005 – = V70 CH 459000 –, XC70 CH 173000 –
Preparations
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 11 / 67

1
A8800136
Preparations
Move the left front seat to its rearmost position
Turn the ignition switch to position 0.
Disconnect the battery negative lead.
Note!
Wait at least five minutes before disassembling the connectors
or removing other electrical equipment.
2A
J3904779
2B
J3904780
Illustration A
Remove the loudspeaker grille as follows:
Insert the tool, Volvo P/N 999 -5919-46 in the joint between the
loudspeaker grille and the dashboard approximately as
illustrated, until it engages.
Twist the tool 90° so that the bent section engages with the
underneath of the loudspeaker grille.
Illustration B
Pull upwards until the loudspeaker grille detaches. The
loudspeaker grille is securely fastened by five clips. Move the
tool closer to the clips to facilitate removal.
Note!
Do not damage the dashboard.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 12 / 67

3
M3902613
Remove the screws (1). Remove the bracket (2).
Place the console to one side, it shall not be used again.
4
M3902614
Applies to cars with centre loudspeakers
Remove the four screws in the loudspeaker (1).
Lift up the loudspeaker. Disconnect the connector (2).
Place the loudspeaker to one side, it shall not be used again.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 13 / 67

5
M8502988
Steps 5 –9 apply to cars up to and including model year –
2004
Remove the panel in front of the gear selector lever. Pry off the
panel using a plastic weatherstrip tool.
6
M4302463
Remove the panel around the gear selector. Press in the catches
at the front edge and lift upwards. First lift at the front edge and
then at the rear edge.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 14 / 67

7
M8503027
Remove the two screws from the dashboard environment panel.
8
M8503045
Angle the dashboard environment panel outwards so that it is
possible to insert a couple of fingers between the centre
console and the reverse of the panel.
Detach the dashboard environment panel by pulling it
downwards while maintaining the same angle. Some force is
required because the panel is tightly installed.
Disconnect the connectors on the reverse of the dashboard
environment panel. Place the dashboard environment panel to
one side.
Note!
If any of the outer hooks break off, these must be repaired. The
method for this can be found in the Workshop Manual in the
section about the dashboard.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 15 / 67

9
M3903036
Remove the screws from the radio bracket.
Pull out the bracket with the radio. Pull the lower corner while
pressing downwards.
Detach the connectors from the radio and from the keypad to the
telephone if fitted. Place the console with the radio to one side.
10
M8504883
Steps 10–12 apply to cars from model year 2005–
Detach the rear edge of the gear selector lever cover together
with the boot until the two clips release. Use a plastic
weatherstrip tool. Remove the gear selector lever cover and the
boot. Pull the panel up until the four clips at the sides release.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 16 / 67

11
M8504884
Engage the handbrake and move the gear selector lever towards
the rear.
Turn the cover panel to the left for better access.
Remove the two screws holding the bracket with the radio and
dashboard environment panel in the centre console.
12
M8504890
Remove the bracket with dashboard environment panel and the
radio from the centre console: Pull the lower edge out and
downwards until it releases from the mounting at the upper
edge. Then fold backwards.
Note!
Do not damage the removed components or the surrounding
panels.
If necessary, the panel around the gear lever selector can be
removed for additional space. The panel is secured with four
catches on the underside along the boot.
Disconnect the connectors from the radio and dashboard
environment panel. Also disconnect the connector from the
phone keypad if applicable. Place the unit to one side.
Preparations, dashboard
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 17 / 67

13
M8503054
Preparations, dashboard
Lock the steering wheel in the lowest, rearmost position.
Remove the rubber seal from the upper steering column cover by
carefully prying the 5 catches loose using a weatherstrip tool.
14
M8502986
Carefully pry out the 2 x clips (2) in the bottom edge of the
combined instrument panel to remove the combined instrument
panel surround.
Pull the surround back until the three clips (1) at the top edge
release.
Note!
Do not damage the dashboard.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 18 / 67

15
M3800760
Remove the four screws for the combined instrument panel.
Pull out the combined instrument panel. Disconnect the connector
on the reverse of the combined instrument panel.
Place the combined instrument panel to one side.
Installing the bracket for the remote control holder
16
M8903878
Installing the bracket for the remote control holder
Steps 16 -18 only apply to cars without handsfree
telephone.
Remove the screw (1) to the visor (the semi-circular section of
the dashboard above the combined instrument panel).
Take the bracket (2) from the kit and fit it as illustrated.
Tighten the bracket using the screw (1) for the semi-circular
section.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 19 / 67

17
M8903879
Press the bracket against the mating surfaces where the three
holes are to be drilled.
Hold the bracket firmly in place. First drill the two marked holes
through the bracket and the dashboard. Use a Ø5 mm (13/64")
diameter drill bit. Use a Ø25 mm (1") diameter drill stop.
Remove any swarf.
18
M8901571
Insert the bracing plate (1) through the hole in the dashboard.
Secure the bracket (2) using two screws (3) from the kit while
pressing the bracket against the mating surfaces.
Tighten the screws so that the bracket is pressed into, and is at
the same level as, the end face of the dashboard.
Drill out the last hole. Use a Ø5 mm (13/64") diameter drill bit.
Remove any swarf.
Insert the bracing plate (5) through the hole in the dashboard.
Secure the bracket using a screw (4) from the kit.
Preparations, passenger compartment and cargo compartment
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Turn - by - turn Navigation System - 30737114 - V1.2
Page 20 / 67