Wurlitzer One More Time CD User manual

R
ONE MORE TIME CD
22

WARNING! Although the beam emitted by the laser diodes is nearly invisible, it may cause severe damage to
the human eye. Use an infrared indicator to check the laser beam.
ATTENTION!
The CD mechanism and many ICs are extremely susceptible to electrostatic discharges. The photo diodes
and the laser diode are more sensitive to discharges than MOS ICs. Careless handling may immediately de-
stroy components or can drastically reduce life expectancy of these components so that it will lead to failure af-
ter several weeks or even months of use.
Before you touch the player, discharge your hands and tools by touching a grounded metal part of the jukebox,
such as the amplifier or the mechanism chassis. Make sure that you are connected via a wrist wrap with resis-
tance to the same potential as the chassis of the jukebox. Keep parts and tools at the same potential.
If you remove the player in case of repair or for transport, short the harness with a short circuit plug.
When repairing, observe all valid safety rules. Do not change the original condition of the jukebox. Use original
spare parts only.
This manual belongs to machines equipped with program versiones 4.09 (or higher).
Subject to alterations.
CLASS
LASER PRODUCT
1
3122 110 03420
ESD

OMT CD – Edition: 12.05.2005 1
1 Unpacking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
1.1 Unlocking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
1.2 Removal of mechanism shipping guards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
1.3 Removal of motor book shipping guards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
1.4 Power on. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
2 Loading compact discs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
2.1 CD handling precautions - CD and player cleaning. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
2.2 Inserting CDs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
2.3 Programming number of CDs in the carrier . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
3 Coin operation or free play? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
3.1 Coin operation and coin return . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
3.2 Price settings. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
3.3 Examples . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
3.4 Color codes of coin input . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
3.5 Free play. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
3.6 Test credit. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
4 Track selection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
4.1 How to select a track. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
4.2 The button R. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
4.3 The display flashes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
4.4 I do not like this track - the button CANCEL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
5 Volume, sound and balance control. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
5.1 Volume, sound and balance control - amplifier K99 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
5.1.1 The infrared remote control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
5.2 Volume, sound and balance control - amplifier F91. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
5.2.1 The infrared remote control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
5.3 Pre-settings for volume. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
5.3.1 Pre-settings for bass and treble. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
6 Programming short view . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
7 Jukebox programming. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
7.1 Call up service programs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
7.2 How to leave service programs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
7.3 Programming of time functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
7.3.1 Clock setting, level 2 button 0 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
7.3.2 Set date, level 2 button 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
7.3.3 Set year and weekday, level 2 button 2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
7.4 Automatic random select (Playstimulator) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
7.4.1 Programming start and stop time. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
7.5 Back Ground Music (BGM) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
7.5.1 Number of BGM CDs and repeat time. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
7.5.2 Start position for BGM CDs and configuration. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
7.5.3 BGM time zones at different weekdays. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
7.6 HappyHour pricing (additional bonus plays) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
7.6.1 Programming of the HappyHour start and stop time, level 2 button 6. . . . . . . . . . . . . . . . . . . . . . . . . . 30

OMT CD – Edition: 12.05.2005
2
7.6.2 Programming of the additional bonus plays, level 2 button 7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
7.7 Number of tracks played successively on the same disc, level 2 button 3. . . . . . . . . . . . . . . . . . 31
7.8 Album selection and memory reset by power off, level 2 button 9 . . . . . . . . . . . . . . . . . . . . . . . . 32
7.9 Disabling single tracks. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
8 Data retrieval . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
8.1 Retrieval of least popular discs (flops), level 1 button 0. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
8.2 Top Tunes, level 1 button 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
8.3 Cash box contents, level 1 button 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
8.4 Total number of plays, level 1 button 3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
8.5 CLEAR ALL counters (reset to 0 0 0 0), level 1 button 3 + reset. . . . . . . . . . . . . . . . . . . . . . . . . . . 35
8.6 Memory of not playable CDs, level 1 button 6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
9 Amplifier K99 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
9.1 Device description of the amplifier K99 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
9.2 Technical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
9.3 Verification of power voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
9.4 Position of fuses and plug connectors. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
9.5 The first power ON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
9.6 Volume control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
9.7 The infrared remote control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
9.8 Treble and bass control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
9.9 Automatic volume correction. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
9.10 Background Music - volume attenuation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
9.11 External speaker connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
9.12 External amplifier connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
9.13 Disabling the internal mute circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
9.14 Input selector. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
10 Amplifier F91 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
10.1 Verification of power voltage. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
10.2 Position of fuses and plug connectors on the power amp board . . . . . . . . . . . . . . . . . . . . . . . . . 45
10.3 The first power ON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
10.4 Pre-settings for volume, bass, treble . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
10.4.1 Pre-settings for volume . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
10.4.2 Pre-settings for bass and treble . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
10.5 Speaker connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
10.5.1 The operating mode STEREO . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
10.6 Connecting external speakers in operating mode 2-CHANNEL . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
10.7 BGM mode - volume attenuation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
10.8 Automatic volume control (AVC) and clipping stage. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
10.9 Overdrive protection. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
10.10 Overload protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
10.11 Tape input . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
11 70v output transformer (0043157) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
11.1 Hints of connectable speaker loads . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53

OMT CD – Edition: 12.05.2005 3
11.2 Determination of the connectable speaker power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
11.3 Hints for speaker connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
11.4 Connection of 70v systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
12 Amplifier I84 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
12.1 Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
12.2 Volume control. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
12.3 Automatic loudness controller. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
12.4 Treble and bass control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
12.5 Slide switch ’Stereo/2-Kanal’ . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
12.6 Maximum amplifier load and external speakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
12.7 Connection of external speakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
12.8 Infrared remote control. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
12.9 Infrared remote control with selection buttons . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
13 Function tests . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
13.1 Digital display test / EPROM-version, level 1 button 4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
13.2 CD carrier control check, level 1, button 8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
13.3 Gripper arm motor test, level 1, button 7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
13.4 CD player check (START), level 1, button 6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
13.5 Jump to NEXT track, level 1, button 0 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
13.6 Jump to PREVIOUS track, level 1, button 9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
13.7 STOP playing, level 1, button 5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
14 Description of S&CC price setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
15 Integrated test program of the CD-PRO player . . . . . . . . . . . . . . . . . . . . . . . . . 65
15.1 Access to the player functions without S&CC unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
15.2 Test functions CD-PRO. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66
15.3 Special test functions of the CD-PRO player . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67
16 Functional description of the mechanism . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
16.1 Abbreviations. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
16.2 Functional description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
16.2.1 Power supply. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
16.2.2 S&CC supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
16.2.3 CD-PRO supply. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
16.2.4 Digital display. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
16.2.5 Number of plays and cash counter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
16.2.6 Selection and CD carrier . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
16.2.7 Start / counting process. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
16.2.8 CD transfer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
16.2.9 Mute off . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
16.2.10 Play . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
16.2.11 Cancel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
16.2.12 CD return. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70
16.2.13 New selection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70
17 Error messages and remedy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70
17.1 Failures with illumination, display and power system generally . . . . . . . . . . . . . . . . . . . . . . . . . . 71

OMT CD – Edition: 12.05.2005
4
17.2 Faults with the coin system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72
17.3 Faults by selection entry . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73
17.4 Repetitive apply of selected or non-selected CDs to turntable . . . . . . . . . . . . . . . . . . . . . . . . . . . 75
17.5 Failures in the system carrier - gripper arm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75
17.6 Failures with sound reproduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
17.7 CD not properly returned to carrier. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
18 Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78
18.1 Microfone kit (part no. 0006953) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78
18.2 BGM-Connector. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78
19 Wiring and connection diagrams. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
19.1 Wiring diagram door - illumination . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
19.2 Connection diagram OMT CD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80
19.3 Board layout Selection & Credit Computer. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
19.4 Wiring diagram Selection & Credit Computer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82
19.5 Board layout CDM12 SC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83
19.6 Wiring diagram CDM12 SC. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
19.7 Wiring diagram 24V distributor interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
19.8 Wiring diagram motor page system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86
19.9 Wiring diagram bubble tubes. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
19.10 Wiring diagram K99 - power supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 88
19.11 Wiring diagram K99 - output transformer. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
19.12 Wiring diagram K99 - pre-amplifier . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90
19.13 Wiring diagram K99 - sound control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91
19.14 Wiring diagram K99 - port A. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92
19.15 Wiring diagram K99 - Mute . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93
19.16 Wiring diagram K99 - power supply Euro 230V . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94
19.17 Wiring diagram K99 - power supply UL/USA 117V. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 95
20 Declaration of Conformity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96

Unlocking
OMT CD – Edition: 12.05.2005 5
OPERATING INSTRUCTIONS
1 Unpacking
1.1 Unlocking
The key is stored in the coin return cup in the
RH cabinet wall. The key WUA 1 unlocks the
cabinet by turning the key clockwise. The lock is
spring loaded, press slightly against the door,
this allows the key to turn easily. The two other
keys with 5 digit number codes unlock the cash
box at the bottom of the RH cabinet wall. In this
box the hand transmitter is located if an infrared
remote control has been installed.
1.2 Removal of mechanism shipping guards
1. The mechanism platform is fixed to cabinet
with one bolt in front LH side (1) and one
bolt back RH side (1). Remove both com-
pletely using a 13mm spanner or a large
screw driver. Possibly you can use the tool
fixed to the lid of the gear box (2).
2. Remove plastic string at the pivot point of
the pressure arm (3).
3. Remove plastic holder securing CD player
chassis (4).
4. Remove foam (5), laser cover (6) securing
laser head in CD player and instruction
plate (7).
5. Remove foam between magnetic pressure
disc and black plastic cover (8).
WUA 1
WUA 1
456734
WUA 1
WUA 1
RCS-K
No.: 0059745
SELECTION
1
23
456
RESET
POWER
OPTION
789
0
-
+
-
+
CANCEL MUTE
MUSIC
INTERN
CHANNEL 1
EXTERN
CHANNEL 2
WUA 1
for door
for cash box
1
1
23
4
5
7
8
6

Removal of motor book shipping guards
OMT CD – Edition: 12.05.2005
6
OPERATING INSTRUCTIONS
1.3 Removal of motor book shipping guards
Cut both plastic strings on both sides of the
book (1).
Press push buttons (2) inside and turn down the
book (3).
Remove elastic band from the motor book sys-
tems (4).
NOTE: Save the removed shipping guards. You
may need them if you decide to move your ma-
chine to another location.
1.4 Power on
NOTE: Make sure that wall socket is grounded
properly.
The CD-jukebox operates on normal household
power outlet. Set mains switch at rear wall of ca-
binet to on position. If the selection and credit
memory is empty the basket turns once and the
left two digits show alternatly a "0". After a short
time the display counts up to the carrier size in
the two RH digits (50 or 00 for 100 discs). After
this the basket stops in position "01". The digital
display shows "0 0 0 0", then "0 0 0 1" when a
basket with 100 CDs is used "0 1 0 1" for a 50
CD carrier.
1
1
2
2
3
34
4
?
o.k.
power switch

CD handling precautions - CD and player cleaning
OMT CD – Edition: 12.05.2005 7
OPERATING INSTRUCTIONS
2 Loading compact discs
2.1 CD handling precautions - CD and player cleaning
Dust, fingerprints or other dirt on the disc surface can
cause skipping, jumping or sticking problems.
Because of this never touch the surface of a disc! Howe-
ver it is rather easy to remove nicotine, dust or finger-
prints.
Nicotine, dust, fingerprints:
Dust can be removed with a lintfree soft cloth. If neces-
sary, remove heavy dirt or fingerprints with a moistened
soft cloth soaked in a solution of water and a detergent.
Never use record cleaning sprays or anti static sprays!
Furthermore, do not use other types of cleaners contai-
ning benzene, thinner or other solvents. These liquids will
cause damage to the surface of discs. Move the cloth
from the inside towards the outside and not in circular
motion.
Removing scratches:
Use a soft cloth and a soft polish.
Laser lens cleaning:
Smoke and dust soils the lens. It can be cleaned with a
cue-tip soaked in a detergent (i.e. Kodak Lens Cleaner,
part no. 0051735). Place the tip on the lens and press
down carefully.
ATTENTION! The whole laser unit is very sensitive!
!Move the cue-tip only in the direction shown in the pic-
ture (perp. to the sledge direction).
!Do not scratch the special treated surface of the
lense.
!Take care that the cleaning solution will not run into
the focus unit.
!Keep away metal parts from the lens unit. A strong magnet is located underneath the lens. It at-
tracts also smallest metal parts and so can block the complete unit.

Inserting CDs
OMT CD – Edition: 12.05.2005
8
OPERATING INSTRUCTIONS
2.2 Inserting CDs
Insert up to 50 or 100 CDs, depending on the
compartments in the carrier. Start with 01. The
"Label" must show always to the left, towards
the next lower number. To achieve the optimum
position for loading, press in steps the lever "ro-
tate carrier". If less than 50 (100) discs are
used, the number of discs used has to be pro-
grammed in the service program level 1, button
5 (see chapter "Programming number of CDs in
the carrier", see page 9).
ATTENTION! For carriers with 100 CDs the po-
sition ’00’ is the 100th CD.
It is recommended to insert the Compact Disc
and then the title page into the appropriate nu-
merical slot position of the motor page system.
The pages can be turned manually by hand wit-
hout any damage to the motor drive. In some
models the transparent dust cover of the record
carrier has to be lifted up at the front, it will rest
in this position.
NOTE: After unpacking or if you turned the pa-
ges manually sometimes it seems that the mo-
torbook does not turn properly. In this case turn
the whole motorbook once forward and back-
ward using the buttons.
It is necessary to reprogramme the number of
CDs in the carrier if a number less than 50 or
100 discs are inserted to avoid the changer me-
chanism operating with empty compartments.
If the number of CDs is programmed correctly
the display will flash when you select an empty
compartment. A flashing display always indica-
tes a wrong selection or not enough credit.
The number of CDs in the carrier has to be pro-
grammed in service level 1, selection button 5,
described as follows.
01
lever
1
2
3
4
5
6
7
8
9
0
R
buttons
to turn the
motor book

Programming number of CDs in the carrier
OMT CD – Edition: 12.05.2005 9
OPERATING INSTRUCTIONS
2.3 Programming number of CDs in the carrier
At the rear wall inside the jukebox cabinet the Selection &
Credit Computer is situated. Some units are equipped
with a metal cover. In this case the slide switch "SER-
VICE" and the button "LT" are accessible through holes.
To programme the number of inserted CDs (service pro-
gram, level 1):
1. Set the slide switch ‘service’ at the SCC-unit to ON.
2. Press ‘LT’ button.
3. Press selection button 5 -hold down- and press se-
lection button R than release both buttons.
4. Enter the number of inserted CDs (without BGM
CDs) with two digits followed by 00, example: 50 for
50 discs
(exception: 100. CDs = 00).
To check the new settings, press selection button 5
again.
Exit the service program:
1. Set the slide switch ‘service’ at the SCC unit to OFF.
2. Press ‘LT’ button.
"The changer starts an initialisation run. After this the
jukebox is ready to operate.
Selection&
CreditComputer
CDM12
CDTower
Netzsicherung
MainsFuse
Netzsicherung
MainsFu
se
210-240V-T4A
100-117V-F6A
210-240V - T4A
100-117V - F6A
Leuchtstofflampen
FluorescentLamps
230V/11
7V
Leuchtstofflampen
FluorescentLamps
230V /11
7V
Verstärker
Amplifier
Verstärker
Amplifier
ExternerHauptschalter
ExternalMainsswitch
Externer Hauptschalter
External Mains switch
Schein-
annehmer
Bill-
acceptor
Schein-
annehmer
Bill-
acceptor
Achtung!
VorAb
nahme derKappedenN
etzstecker
ziehen!
Achtung!
VorAb
nahme derKappeden Netzstecker
ziehen!
Warning!
Shockhazard! Donotopen!
Warning!
Shockhazard!Do
not open!
ZurBeachtung:NurSicherungenmit
gleicherGrößeundgleichemWert
verwenden,umSchädenzuvermeiden.
Caution:Toreducetheriskoffire
replaceonlywithsametypandratingfuses.
Zur Beachtung: NurS
icherungenmit
gleicher Größe und gleichemWert
verwenden, um Schäden zu vermeiden.
Caution: Toreducetherisk of fire
replaceonly with same typand rating fuses.
Netzspannung
50/60Hz
MainsVoltage
50/60cps
Netzspannung
50/60 Hz
Mains Voltage
50/60 cps
240
230
220
210
117
100
240
230
220
210
117
100
CAUTION
CAUTION
TOREDUCETHERISK
OFFIREREPLACEONLY
WITHSAMETYPEAND
RATINGFUSE
TOREDUCETHERISK
OFFIREREPLACEONLY
WITHSAMETYPE AND
RATINGFUSE
B
ass
B
ass
T
reble
T
reble
BGM
BGM
M
S
ONO
TEREO
M
S
ONO
TEREO
ANALHANNEL
TEREO
2-K/2-C
S
ANALHA
NNEL
TEREO
2-K /2-C
S
S
F
ICHERUNG
USE
S
F
ICHERUNG
USE
F1-F4
F1-F4
100-240V
50Hz/60Hz
100-240V
50Hz/60Hz
117V
60Hz
117V
60Hz
3,0AMP
250VAC
SLOWBLOW
3,0AMP
250VAC
SLOWBLOW
T4A
T4A
30V~
AC
30V~
AC
F1
F1
26V~
AC
26V~
AC
F2
F2
26V~
AC
26V~
AC
F3
F3
12V=
DC
12V=
DC
F4
F4
IL
NTERNERAUTSPRECHER
NTERNALPEAKER
IS
IL
IS
NTERNER AUTSPRECHER
NTERNAL PEAKER
O
PTION
O
PTION
O
O
PTION
PTION
RL
EL
ES
8/
80W
XTERNERAUTSPRECHER
XTERNALPEAKER
W
R L
EL
ES
8 /80 W
XTERNER AUTSPRECHER
XTERNALP
EAKER
W
CD-T
CD-T
RAFO
RANSFORMER
CD-T
CD-T
RAFO
RANSFORMER
B-
T
UBBLEUBES
B-T
UBBLEUBES
N
T
ETZTRAFO
RANSFORMER
N
T
ETZTRAFO
RANSFORMER
EE
RWEITERUNG
XTENSION
EE
RWEITERUNG
XTENSION
F
RC
ERNREGLER
EMOTE-ONTROL
F
RC
ERNREGLER
EMOTE-ONTROL
RS232
RS232
BGM
BGM
IR
IR
NFRAROT-E
GLER
NFRARED-EMOTE
IR
IR
NFRAROT-EG
LER
NFRARED-EMOTE
A
O
LR
USGANG
UTPUT
A
O
L R
USGANG
UTPUT
EC
D
IC
D
LR
INGANG
NPUT
ECD
IC
D
L R
INGANG
NPUT
EE3
00mV
XTRA
XTRA
E300mV
I
LR
INGANG
NPUT
EE300mV
E I 300mV
L R
XTRA INGANG
XTRANPUT
M
M
IKROFON
ICROPHONE
M
M
IKROFON
ICROPHONE
M
ECHANIK
M
ECHANISM
M
M
ECHANIK
ECHANISM
DA
RC
ECKELBNEHMEN
EMOVEOVER
DA
RC
ECKELBNEH
MEN
EMOVEOVER
DA
RC
ECKELBNEHMEN
EMOVEOVER
DA
RC
ECKEL BNEHMEN
EMOVE OVER
AVC
AVC
RS232
RS232
M
ICRO
M
ICRO
T
APE
T
APE
M
UTE
M
UTE
A/
D
NZEIGEISPLAY
A/D
NZEIGEISPLAY
BGM
BGM
ok.
ok.
S/
S
CHALTERWITCHES
S/S
CHALTER WITCHES
A/
O
USFF
A/
O
USFF
A/O
USFF
A/O
USFF
E/O
INN
E/O
INN
E/O
IN N
E/O
IN N
AVC
AVC
MODE
MODE
S
TEREO
S
TEREO
2-K/2C
ANAL HANNEL
2-K/2
C
ANALHANNEL
INPUT
INPUT
CD
CD
T
APE
T
APE
BGM
BGM
1
1
3
5
2
2
4
6
I
C1
ntern
hannel
I
C1
ntern
hannel
E
C
xtern
hannel
2
E
C
xtern
hannel
2
Verstärker
Verstärker
K99
99
0056041
0056041
Amplifier
Amplifier
K99
99
C-UL
C-UL
0058484
0058484
0040264
1
2
4
5
T1
10
20
T
+B
M
LT
Memory
ON
OFF
P6
P5
P8
Selection &
Credit Computer
CDM 4I / CDM 12
K
ON
OFF
Service
GP
BS B4 B3 B2 B1 GP+6
BR
00
2
3
4
5
6
2
3
4
5
6
F
2
3
4
5
6
1
0
2
3
4
5
6
1
0
2
3
4
5
6
1
0
7
TT
slide switch
SERVICE button LT

Coin operation and coin return
OMT CD – Edition: 12.05.2005
10
OPERATING INSTRUCTIONS
3 Coin operation or free play?
Both coin operation or free play are adjustible at the
“Selection & Credit Computer” unit. It is located at the
rear wall inside the cabinet underneath the CD-player.
Special jumpers (short wires, located in the accessory
pack of the manual ) are used to be set on the SCC-
unit. As long as no jumper is set in row GP from 0 to F
(free play) the jukebox works with coins only.
3.1 Coin operation and coin return
From factory the jukebox is set to coin operation. If
you insert a certain number of coins according to the
denomination label, the jukebox gives the credits or
plays it is adjusted for.
You will get your change by turning the rotary switch at
the RH side of the jukebox.
If you want to change the play prices you have to
change the jumper settings on the SCC-unit. See ex-
amples in the accessory pack.
3.2 Price settings
In the ’EURO’ version no play prices are pre-
set. Usually the prices are preset by the fac-
tory according to the denomination label in
the accessories. If other combinations are
required, refer to the following examples. For
price setting proceed as follows:
1. Switch on the jukebox.
2. Coin output plugs (1) should be set ac-
cording an separate attached instruction
by connecting to the pin row (2) on the
SCC unit. Pay attention to wiring colors
(refer to chapt. 3.4 on page 11).
3. Set the attached jumpers in B1 to B4
according to the number of the desired
additional bonus plays. (3).
4. Press „LT“ button once (4) to accept the new price/bonus setting.
M
LT
GP
BS B4 B3 B2 B1 GP+6
BR
00
2
3
4
5
6
2
3
4
5
6
F
2
3
4
5
6
1
0
2
3
4
5
6
1
0
2
3
4
5
6
1
0
7
TT
button LT
jumper from 0 to F
in row GP
1
2
3
4
5
6
7
8
9
0
R
2Spiele 1,- DM
5Spiele 2,- DM
14 Spiele 5,- DM
denomination
label
0040264
1
2
4
5
T1
10
20
T
+B
M
LT
Memory
ON
OFF
P6
P5
P8
Selection &
Credit Computer
CDM 4I / CDM 12
K
ON
OFF
Service
GP
BS B4 B3 B2 B1GP+6
BR
00
2
3
4
5
6
2
3
4
5
6
F
2
3
4
5
6
1
0
2
3
4
5
6
1
0
2
3
4
5
6
1
0
7
TT
1
2
4
3

Examples
OMT CD – Edition: 12.05.2005 11
OPERATING INSTRUCTIONS
3.3 Examples
3.4 Color codes of coin input
2$
1$
20ct 50ct10ct
2 plays 1 $
5 plays 2 $
AUS
GPGP + 6 BS B4 B3 B2 B1
F
6
5
4
3
2
0
7
6
5
4
3
2
0
6
5
4
3
2
1
0
6
5
4
3
2
1
0
6
5
4
3
2
1
0
6
5
4
3
2
1
0
T.T.
+2
+3
BR
MLT
1
2
4
5
T1
10
20
+B
T
2$
1$
20ct 50ct10ct
1 play 1 $
3 plays 2 $
AUS
GPGP + 6 BS B4 B3 B2 B1
F
6
5
4
3
2
0
7
6
5
4
3
2
0
6
5
4
3
2
1
0
6
5
4
3
2
1
0
6
5
4
3
2
1
0
6
5
4
3
2
1
0
T.T.
+2
+3
BR
MLT
1
2
4
5
T1
10
20
+B
T
USA
25cts $1.00
$1.00
1play 50cts
3plays$1.00
21 plays $ 5.00
GPGP + 6 BS B4 B3 B2 B1
F
6
5
4
3
2
0
7
6
5
4
3
2
0
6
5
4
3
2
1
0
6
5
4
3
2
1
0
6
5
4
3
2
1
0
6
5
4
3
2
1
0
T.T.
+2
+3
BR
MLT
1
2
4
5
T1
10
20
+B
T
USA
25cts $1.00
$1.00
1play 50cts
3plays$1.00
18 plays $ 5.00
GPGP + 6 BS B4 B3 B2 B1
F
6
5
4
3
2
0
7
6
5
4
3
2
0
6
5
4
3
2
1
0
6
5
4
3
2
1
0
6
5
4
3
2
1
0
6
5
4
3
2
1
0
T.T.
+2
+3
BR
MLT
1
2
4
5
T1
10
20
+B
T
GB
1£50p
20p10p
1play 30p
2 plays 50 p
5plays £1
GPGP + 6 BS B4 B3 B2 B1
F
6
5
4
3
2
0
7
6
5
4
3
2
0
6
5
4
3
2
1
0
6
5
4
3
2
1
0
6
5
4
3
2
1
0
6
5
4
3
2
1
0
T.T.
+2
+3
BR
MLT
1
2
4
5
T1
10
20
+B
T
Free Play
GPGP + 6 BS B4 B3 B2 B1
F
6
5
4
3
2
0
7
6
5
4
3
2
0
6
5
4
3
2
1
0
6
5
4
3
2
1
0
6
5
4
3
2
1
0
T.T.
+2
+3
BR
MLT
1
2
4
5
T1
10
20
+B
T
Cash-
flow
111
DIP switches
on interface
10 ct
20 ct
50 ct
1$
2$
off-on
1
2
3
4
5
6
electronical coin validator
mechanical
coin validator
mechanical coin validator
electronical coin validatorelectronical coin validator
NRINRI
G13G13
0.50 red
10ct blue
10p yellow
0.25 blue
2.00 white
50ct orange
2.00 weiß
1$ grey
grey
violet
grey
yellow
green
brown
green
white
1£ brown
1$ orange
50p red
violet
2$ green
1$ yellow
violet
brown
1.00 brown
20ct red
20p orange
InterfaceInterface
CreditCredit
LT
LT
LT
LT
1
1
1
1
2
2
2
2
4
4
4
4
5
5
5
5
T1
T1
T1
T1
10
10
10
10
20
20
20
20
T
T
T
T
+B
+B
+B
+B
SCC
SCC
SCC
SCC
EURO
AUS
GB
USA

Free play
OMT CD – Edition: 12.05.2005
12
OPERATING INSTRUCTIONS
3.5 Free play
To set the jukebox to free play:
1. In case there are already jumpers in the rows GP
and BS, notice their position (for later resetting to
coin operation) and remove them.
2. Set a jumper from 0 to F (free play) in the row GP on the SCC unit.
3. Press ‘LT’ button.
4. Now one track is selectable without coin insertion.
5. In between two to six plays are selectable by setting an additional jumper in the row ‘BS’ (Bonus
Step) from 0 to 2 or from 0 to 6.
6. Up to 47 tracks are pre-selectable by setting a jumper in the row ‘BS' from 0 to 7.
3.6 Test credit
For repair and test purposes it is possible to give test credits.
By touching the test credit button you get one credit also
shown in the digital display. You can terminate un-used cre-
dits by pressing the LT button.
In jukeboxes with an electronical coin validator you can find
the test credit button on the coin validator interface board.
In jukeboxes with mechanical coin validator the test credit
button is mounted over the return lever inside.
M
LT
GP
BS B4 B3 B2 B1 GP+6
BR
00
2
3
4
5
6
2
3
4
5
6
F
2
3
4
5
6
1
0
2
3
4
5
6
1
0
2
3
4
5
6
1
0
7
TT
row BS button LT

Test credit
OMT CD – Edition: 12.05.2005 13
OPERATING INSTRUCTIONS
pulse
plays from
GP:
from bonus
step
plays
B1...B4
total plays
inserted
money
1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. 17. 18. 19. 20. 21. 22. 23. 24. 25.
Price settings:
1
2
4
5
T1
10
20
T
+B
...............
...............
...............
...............
...............
...............
...............
...............
...............
test credit
GND
+35 V !

How to select a track
OMT CD – Edition: 12.05.2005
14
OPERATING INSTRUCTIONS
4 Track selection
4.1 How to select a track
If credit exists or free play is set you can select tracks by means of the buttons 0 - 9 on the keyboard.
First enter the number of the CD with two digits, then the track with two digits too. Example: CD 2,
track 9: Enter 0 - 2 - 0 - 9 (Exception: CD 100 = 00.)
4.2 The button R
You can delete wrongly entered numbers up to the
third digit by means of the button R (Reset). But after
having entered the fourth digit the jukebox stores and
executes a selection. By pressing the button R the
available credit will be displayed for a few seconds.
4.3 The display flashes
After entering the fourth digit of a selection the jukebox starts to search
and play the selected CD immediately. If the display flashes the entered
selection was not valid. Check:
!if credit is available or
!if the selection is higher then the programmed number of CDs in the carrier
If you select a higher track number than available on a CD the jukebox overcounts the tracks and
starts at the beginning.
Example: CD 03 contains 17 tracks. But selected track is 0 - 3 - 1 - 9. The jukebox plays track 02 of
CD 03.
A maximum of 25 tracks per CD can be selected!
button R

I do not like this track - the button CANCEL
OMT CD – Edition: 12.05.2005 15
OPERATING INSTRUCTIONS
4.4 I do not like this track - the button CANCEL
If you do not like a track you can cancel it by pressing
the button 'CANCEL' at the rear side of the jukebox or at
the remote control. The jukebox stops playing or plays
the next track if a selection has already been made.
You can terminate all selections only by pressing the but-
ton LT on the SCC unit .
CANCEL
MUTE
MIN MAX
MIN MAX
CANCEL
MUTE
0058407
MIN MAX
I
C
NTERN
HANNEL 1
MIN MAX
E
C
XTERN
HANNEL 2
VOLUME
BASS
TREBLE
BALANCE
-+
MODE PRESET
CANCEL MUTE
button
CANCEL
control
terminal F91
control
terminal K99

Volume, sound and balance control - amplifier K99
OMT CD – Edition: 12.05.2005
16
OPERATING INSTRUCTIONS
5 Volume, sound and balance control
5.1 Volume, sound and balance control - amplifier K99
Volume control
You can control the volume of the jukebox from different
points at the same time:
1. With the pots Vol.1 and Vol.2 on the amplifier.
2. With an optional connectable IR remote control.
3. With the pots of the control box at the rear side of the
jukebox.
The device from which the volume is altered last determines
it.
The volume control unit can be taken out and may be mounted at another place as a remote control.
Its cable may be extended as required with any kind of wire. The voltages of the control wires are 5V
DC.
The control box has two volume knobs (Intern / Channel 1 and Extern / Channel 2). In position ”Ste-
reo” the knob “Intern / Channel 1” is effective for the internal speakers. The knob Extern / Channel 2
is controlling the volume of the RCA outputs for an optional external amplifier. In position ”2 Channel”
of the DIP switch the channels1 (RH) and 2 (LH) are controllable separately.
The pots Vol. 1 and Vol. 2 on the amplifier are not effective if the wire control box is connec-
ted
CAUTION
TO REDUCETHE RISK
OF FIRE REPLACE ONLY
WITH SAMETYPE AND
RATING FUSE
B ass T reble BGM
M
S
ONO
TEREO
ANAL HANNEL
TEREO
2-K / 2-C
S
S
F
ICHERUNG
USE
F1-F4
100-240V
50Hz/60Hz
117 V
60Hz
3,0 AMP
250 V AC
SLOW BLOW
T4A
30V~
AC
F1
26V~
AC
F2
26V~
AC
F3
12V=
DC
F4
IL
NTERNER AUTSPRECHER
NTERNAL PEAKER
IS
O
PTION
O
PTION
RL
EL
ES
8 / 80 W
XTERNER AUTSPRECHER
XTERNAL PEAKER
W
CD-T
CD-T
RAFO
RANSFORMER
B-T UBBLE UBES
N
T
ETZTRAFO
RANSFORMER
E
E
RWEITERUNG
XTENSION
F
RC
ERNREGLER
EMOTE- ONTROL
RS 232
BGM
IR
IR
NFRAROT- EGLER NFRARED- EMOTE
A
O
LR
USGANG
UTPUT
ECD
ICD
LR
INGANG
NPUT
E
E300mV
XTRA
XTRA
E300mV
I
LR
INGANG
NPUT
M
M
IKROFON
ICROPHONE
M ECHANIK
M ECHANISM
DA
RC
ECKEL BNEHMEN
EMOVE OVER
DA
RC
ECKEL BNEHMEN
EMOVE OVER
I
C1
ntern
hannel
E
C2
xtern
hannel
Verstärker K 99
Amplifier K 99 C-UL
AVC
RS232
MICRO
TAPE
MUTE
A/DNZEIGE ISPLAY
BGM
ok.
S/SCHALTER WITCHES
A/OUS FF
A/OUS FF
E/OIN N
E/OIN N
A
A
VC
VC
MODESTEREO 2-K /2CANAL HANNEL
INPUT
CD TAPE
BGM
1
1
3
5
2
2
4
6
SEPARATE
NORMAL
AUTO
VOLUME
RS232
MUTE
HIGH LOW
PARALLEL
SERVICE
AUS/OFF

Volume, sound and balance control - amplifier K99
OMT CD – Edition: 12.05.2005 17
OPERATING INSTRUCTIONS
5.1.1 The infrared remote control
As desired an infrared remote control will be installed
from factory or can be delivered as conversion kit (part
no. 0058809). If it has been installed the hand trans-
mitter is located in the cashbox.
If credit is given or free play is programmed a CD can
be selected with the buttons 0 to 9 and R.
Double button functions as required in the service pro-
grams (i.e. press button 5 -hold down- and press but-
ton R), are impossible. For this you only can use the
keyboard of the jukebox.
You can control the volume by means of the buttons +
and -. In stereo mode the internal +/- buttons control
the volume of the internal speakers. The external +/-
buttons control the volume of the K99 RCA jacks for
an optional external amplifier. In 2-channel mode you
can control the external speakers by the buttons + and
- of the external channel.
Beam the jukebox directly if possible.
You can connect the wire remote control box as well.
The power-on volume level is always set by the chan-
nel 1 and 2 pots on the amplifier or on the control box
(if connected).
Batteries will be delivered. To open the battery com-
partment move the cover like shown in the picture.
Needed battery type and position of the batteries in
the hand transmitter are shown on the casing.
Part no. of the hand transmitter: 0059745.
RCS-K
No.: 0059745
SELECTION
1 23
456
RESET
POWER
OPTION
789
0
-
+
-
+
BATTERY:
IEC LR03
(AAA)
+
+
+
+
CANCEL MUTE
VOLUME
INTERN
CHANNEL 1
EXTERN
CHANNEL 2
selection
music control
battery type
LR03 (AAA)
position
of batteries
buttons
buttons

Volume, sound and balance control - amplifier F91
OMT CD – Edition: 12.05.2005
18
OPERATING INSTRUCTIONS
5.2 Volume, sound and balance control - amplifier F91
The control terminal at the rear
With the control terminal at the rear side of the jukebox
the volume, treble, bass and balance can be controlled
individually.
After power up or if no button has been pressed for ap-
prox. 5 sec or after the button PRESET has been
pressed, the terminal stays in the mode "VOLUME".
The LED "VOLUME" lights. In this mode you can cont-
rol the volume by means of the buttons '+' and '-'.
One LED corresponds to each mode. All modes are
accessible by pressing the ‘mode’ button. With the but-
tons '+' and '-' treble, bass or balance can be cont-
rolled.
The control terminal can be taken out and be used as
a wired remote control.
ATTENTION! Depending on adjusted volume of the
jukebox noise levels of more than 70 dB can be rea-
ched.
The meanings of the buttons...
!MODE: Switches to the next operating mode. After
about 5 seconds without operating any buttons, ‘vo-
lume’ mode is resumed.
!PRESET: Volume, bass, treble, and balance are
set to the pre-set according to DIP switch setting.
Actual mode is set to ‘Volume’.
!CANCEL: Rejects a playing track. If album play is
selected the next track will be played.
!MUTE: As long as this button is activated, the amp-
lifier output is muted.
MODE PRESET
CANCEL MUTE
0039661
VOLUME
BASS
TREBLE
BALANCE
-
+
+/-
+/-
+/-
+/-
VOLUME
BASS
TREBLE
BALANCE
Press button MODE
Press button MODE
Press button MODE
Press button MODE
LED Volume
lights
LED Bass
lights
LED Treble
lights
LED Balance
lights
current
mode