Xtreme X-10 User manual

Page
1
X-10 Electric Scooter
Owner’s Manual
PLEASE BE SAFE WHEN RIDING
ALWAYS WEAR AHELMET AND OBEY ALL LAWS!
X-Treme TM Electric Scooters

Page
2
BATTERY MAINTENANCE and
CHARGING INSTRUCTIONS
1. You MUST charge completely prior to initial use. (Follow
charging instructions in your Product Handbook)
2. Charge immediately after each use.
3. Charge before storage. You must charge every 30 days if not
in use.
4. Charge the unit for 6-8 hours after the light on the charger turns
green.
5. DO NOT allow this unit to deep discharge the battery.
6. For safety purposes, DO NOT charge for over 8 hours.
7. Turn the unit OFF when not in use.
This PRODUCT IS NOT INTENDED FOR EXTREME or
OFF-ROAD Use! Please take care of your X-10!
DO NOT JUMP or ABUSE THIS PRODUCT!
DO NOT RIDE IN WET/ICY CONDITIONS!
Failure to follow these instructions will
VOID YOUR WARRANTY!
IMPORTANT
Failure to follow these INSTRUCTIONS will
VOID YOUR WARRANTY!

Page
3
WARNING
This product does not conform to Federal Motor Vehicle Standards and is not
intended for operation on public streets, roads or highways. Serious injury can
result from the unsafe operations of this product. Operator can minimize these
risks by using certain safety equipment such as: safety helmet, goggles, gloves,
elbow and kneepads and appropriate footwear.
DO NOT operate this product in traffic, on wet, frozen, oily or unpaved surfaces or
under the influence of drugs and/or alcohol. Avoid uneven surfaces, potholes,
surface cracks and obstacles.
DO NOT use a water hose to clean this product. See Product Handbook for more
information.
This product is recommended for riders 14 YEARS OF AGE and older.
SAFETY
Persons without excellent vision, balance, coordination, reflex, muscle and
bone strength and good decision-making capabilities should not use this
product.
Minors without adult supervision should not use this product.
Persons unwilling or unable to take responsibility for their own actions should
not use this product.
The user of this product assumes ALL risks associated with its use. To
minimize these RISKS, the user must wear safety helmet, goggles, gloves,
elbow and kneepads and appropriate footwear.
This product is ELECTRIC! DO NOT ride this product in wet conditions,
puddles or rainy weather.
IMPORTANT
PLEASE READ THIS BEFORE USING THIS PRODUCT
READ THIS FIRST!

Page
4
SAFETY GUIDE
The recommended age for riding this scooter is 14 years old or older.
To avoid damage to the motor and footplate, do not overload the scooter.
Never ride with more than one person.
Inspect your scooter thoroughly before each use for loose or missing parts.
Avoid unintentional starts by turning the scooter off while not in use.
To avoid the risk of a short circuit in the electrical parts, do not use your
X-Treme Electric scooter in the rain and never spray or wash off your scooter
with water.
Do not place the battery near fire or heat.
To avoid damage to the battery, do not use the charger if it has been damaged
in any way.
Keep hands, face, feet and hair away from all moving parts.
Do not touch the motor or wheels while they are rotating.
Brakes are designed to control speed as well as stop the scooter. Practice
braking for proper slowing down and smooth stops.
Maintain your X-Treme X-10 as recommended in this Product Handbook.
Use only quality replacement parts as recommended by the manufacturer.
Inspect the entire scooter prior to each use. Replace any part that is cracked,
chipped or damaged before use.
*NEVER ALLOW CHILDREN TO OPERATE THE SCOOTER WITHOUT ADULT
SUPERVISION.
*NEVER ATTEMPT TO OPERATE THE SCOOTER WHILE UNDER THE
INFLUENCE OF ALCOHOL.
If a situation arises that is not covered in the manual,
proceed with caution and use good judgment.
Contact your dealer or X-Treme (www.x-tremescooters.com/support/)
if you need further assistance
QUICK
REFERENCE
SAFETY GUIDE

Page
5
TABLE OF CONTENTS
IMPORTANT INFORMATION…………………….………………………...……2-3
QUICK REFERENCE……………………………………………………………….4
TABLE OF CONTENTS……………………………….…………….………………5
GETTING TO KNOW YOUR X-TREME X-10………………..…………………..6
PACKAGE CONTENTS…………………………………………………………….7
GETTING STARTED………………..……………………………..………………..7
ASSEMBLY…………………………………………………………………...……...7
CHARGING……………………………………………………………..…………...8
RIDING……………………………………………………………………………….9
STOPPING/BRAKING………………………………………………………………9
FOLDING AND STORAGE……….………………………..……………………….9
TIRES AND WHEELS……….…………………………………….………………10
MAINTENANCE…………………………………………………………………….11
RECOMMENDED TOOLS…………………………………….……………...11
ADJUSTING THE BELT...…..………..……………….………………………11
MAINTENANCE SCHEDULE……………………………………...……………..12
OTHER QUESTIONS….…………………………………………………………..12
GENERAL INFORMATION/TECH SUPPORT………………………………….13
DO NOT RETURN TO STORE!
Do not use this vehicle for the first time until you have inflated the tires to the correct PSI
and completely charged the battery. Failure to follow these instructions may damage your
vehicle and void your warranty.
CALL TOLL FREE OR GO ONLINE
1-800-772-3852 www.x-tremescooters.com/support/
For General Information or Parts Visit www.x-tremescooters.com

Page
6
GETTING TO KNOW YOUR X-TREME X-10

Page
7
PACKAGE CONTENTS
Your X-Treme X-10 comes with the following items in the box. Please locate all
of the following:
1. The X-Treme X-10 Scooter
2. 24V Battery Charger
3. Front Wheel
4. Tool Kit
5. Product Handbook
GETTING STARTED
Please read and understand these instructions and the OPERATING
PROCEDURES section, prior to starting or riding your X-10
Fig. 1
Fig. 2
Fig. 3
Assembly
1. Carefully remove the X-10 from the box.
2. Locate the enclosed front when and attach
it to the front fork of the scooter. See
figure 1.
3. Secure the front wheel using the enclosed
tools to tighten the front wheel nut/bolt. See
figure 2.
4. To unfold the scooter, loosen the handlebar
folding clamp located at the base of the
handlebars. Figure 3
5. Fully extend the handlebars to their upright
position, and then tighten the clamp
securely. Fig. 4
6. Attach Throttle and Brake Handle Grips by
inserting the handle grips into the
handlebar posts until the gold snap pin
clicks into place. Fig. 5
7. Raise the T-handlebar to the desired
position until the gold snap pin locks into
place. Tighten the clamp to secure the
handlebar in place. Fig. 6

Page
8
Fig. 4 Fig. 5
Fig. 6
Charging
Your scooter comes charged out of the carton. We still recommend charging the unit for
6-8 hours prior to it’s first use. We also recommendcharging your scooter after each use
and prior to storage.
WARNING: Do not allow your scooter to go into deep discharge, as this will damagethe
batteries. DO NOT charge your scooter for more than 8 hours!
Fig. 7
Fig. 8
1. Make sure unit is turned off.
2. Open the charging socket cover
located on the left side of the
scooter frame, under the footplate.
(Fig. 7)
3. Locate your Battery Charger. (Fig.
6) Find the charger socket end
that has a single-prong socket and
plug it into the scooter.
4. Next, plug the AC plug into a wall
outlet.
When first plugged in, the charger will have
one red light that will illuminate, indicating
that the charging process has started.
Once the green light on the charger is
illuminated, you may remove the charger
and close the safety cap.

Page
9
Riding
1. Make sure that all of the exposed bolts and screws are tightened.
2. Raise the kickstand to its upright position.
3. Push the on/off switch on the left side of the scooter frame, under the footplate. (Fig. 7)
to the ON position.
4. Put one foot on the deck of the X-10 while pushing off with the other foot, gently rotate
the THROTTLE GRIP, on the right side of the handlebars. The X-10 will begin to move
on its own power.
**Your scooter has a variable speed hand throttle. You can control the speed of your
scooter by the amount of pressure you use when rotating the hand throttle. The more
you rotate, the faster you will go.
Stopping/Braking
To brake, release the THROTTLE GRIP and depress the BRAKE LEVER (on the left side
of the handlebars. Depressing the brake will disengage power to the motor. When the
unit feels like it is loosing power or not accelerating to full speed, the scooter is ready to be
re-charged.
FOLDING & STORAGE
When you are done riding the X-10 you can fold it down for compact storage and
transportation. To fold down the X-10, loosen the handlebar-folding clamp and gently push
down the folding handle. If needed, you may need to detach the left and right handle
grips and lower the T-handlebar prior to folding. See Assembly instructions on page 7.
BRAKING SYSTEM
The X-10 uses a hub brake system on the rear wheel. A hand brake lever on
the left side of the handlebar activates the brakes. Squeezing the hand brake
lever with your left hand will activate the rear brake. Make sure to release the
HAND THROTTLE GRIP when engaging the brakes.
Practice braking on a smooth, dry surface to get used to the feel of the braking
system. Braking distance is affected by wet conditions and loose and uneven
riding surfaces.
Adjusting the Brakes
The Brakes on the X-10 should come fully adjusted from the factory.
However, it may be necessary to adjust the brakes from time to time.

Page
10
Squeaky Brakes
The brakes may squeak before they are broken in. This is normal and will not
affect the function or performance of the brakes. With continued use the
squeak should go away.
TIRE AND WHEELS
The X-Treme X-10 is equipped with resin tires. To avoid un-necessary
damage to the rear tire, do not apply the brakes when going full speed allowing
the rear tire to lock up and drag as it will cause un-even wear on the rear tire
and is not covered under warranty when abused in this manor.
Replacement tires can be obtained at your local X-Treme dealer, through
motorcycle shops, or from the X-Treme website at www.x-tremescooters.com
To adjust the rear brakes:
For brakes that are adjusted too tight:
1. Loosen the tension screw on the
left hand brake lever by rotating it
counter-clockwise until the wheel
spins freely.
For brakes that are adjusted too loose:
1. Tighten the tension screw on the
left hand brake lever by rotating it
clockwise until the wheel has a
slight drag.
For further adjustment, Locate the
adjustment screw on the rear brake hub
located on the rear wheel.
For brakes that are adjusted too tight:
1. Loosen the tension screw on the
rear brake hub by rotating it
clockwise until the wheel spins
freely.
For brakes that are adjusted too loose:
1. Tighten the tension screw on the
rear brake hub by rotating it
counter-clockwise until the wheel
has a slight drag.

Page
11
MAINTENANCE
RECOMMENDED TOOLS
To adjust and service the X-Treme X-10 you will need the following tools:
Allen Wrenches: 3/4/5/6 mm
Wrenches: 8/10/13 mm Open end wrench
Large Adjustable Crescent Wrench
Philips Head Screwdrivers
Oil, Grease or Lubricant
ADJUSTING THE BELT
The belt will come adjusted from the factory. However, it may be necessary to
adjust the belt from time to time. The belt must be well aligned onto the
sprockets in order to avoid uneven wear. This will result in shortened belt life.
How tight should the belt be?
If the belt is skipping or jumping on the sprockets, this is too
loose and may be harmful.
The correct tension is achieved by adjusting the belt from its
loose position to when it becomes lightly tense.
Adjusting the belt too tight may cause the belt to break
Fig. 11
To tighten the belt:
Loosen the nuts on each side of the rear axle
and rotate the tension washer directly under
the nut in the desired direction to either
tighten or loosen the belt tension. When
the desired tension has been obtained,
simply tighten the nuts on each side of the
axle.

Page
12
MAINTENANCE SCHEDULE
Proper care of your X-Treme X-10 will insure optimal performance and longer
life span. The following are a few maintenance suggestions that will keep your
X-Treme X-10 running in top condition:
Daily Maintenance
Perform each time you ride your X-10
Clean the exterior of the unit with a soft, damp rag.
Check that all nuts and bolts are securely tightened.
Check battery charger for any frayed/cut wires.
OTHER QUESTIONS
For additional questions, service instructions, further information and important
phone numbers, please go to the X-Treme website at www.x-tremescooters.com
Thank you for purchasing an X-Treme X-10 and please tell your friends how much
fun you’re having on the X-Treme X-10

Page
13
DO NOT RETURN TO STORE!
IF YOU NEED HELP
CALL TOLL FREE OR GO ONLINE
1-800-772-3852
www.x-tremescooters.com/support/
For General Information or Parts Visit
www.x-tremescooters.com
Revised 6/3/10