Zippie VOYAGE User manual

O w n e r ’ s M a n u a l
Zippie®VOYAGE
❏with transit option ❏without transit option
Supplier: This manual must be given to the user of
this wheelchair.
User: Before using this wheelchair read this entire
manual and save for future reference.
VOYAGE

SUNRISE LISTENS
Let us know your address. This will allow us to keep you up to
date with information about safety, new products and options to
increase your use and enjoyment of this Dependent Mobility
Device.
FOR ANSWERS TO YOUR QUESTIONS
Your authorized supplier knows your Zippie product best, and can
answer most of your questions about device safety, use and
maintenance. For future reference, please fill in the following:
Supplier: _______________________________________________________________
Address: _______________________________________________________________
______________________________________________________________________
Telephone: _____________________________________________________________
Serial #: ________________________________________ Date/Purchased:_________
I. INTRODU CTIO N
ENGLIS
2
124267 Rev. B
Thank you for choosing a Zippie product. We want to hear your
questions or comments about this manual, the safety and reliability of
your device, and the service you receive from your supplier.

II. TABLE O F CO NT ENTS
ENGLIS
3124267 Rev. B
III. YOUR DEVICE AND ITS PARTS....................................4
IV. NOTICE– READ BEFORE USE ........................................5
GENERAL WARNINGS......................................................5
A.WEIG T LIMIT................................................................5
B. GETTING TO KNOW YOUR DEVICE......................5
C.TO REDUCE T E RISK OF AN ACCIDENT...........5
D.SAFETY C ECKLIST......................................................5
E. C ANGES AND ADJUSTMENTS...............................5
F. ENVIRONMENTAL CONDITIONS ...........................5
G.STREET USE......................................................................6
.MOTOR VE ICLE SAFETY ...........................................6
I. FOR CAREGIVERS..........................................................6
VI. WARNINGS: FALLS AND TIP-OVERS..........................6
A.CENTER OF BALANCE ................................................6
B. DRESSING OR C ANGING CLOT ES ..................6
C.OBSTACLES ......................................................................6
D.REAC ING OR LEANING...........................................6
E. RAMPS, SLOPES AND SIDE ILLS...............................7
F. TRANSFERS ......................................................................7
G.NEGOTIATING A CURB OR SINGLE STEP............7
.CLIMBING STAIRS ..........................................................7
I. DESCENDING STAIRS ..................................................7
J. ESCALATORS...................................................................7
VII. WARNINGS– COMPONENTS AND OPTIONS .......8
A.BASE FRAME ....................................................................8
B. SUPPORT TRAY AND TRAY SUPPORT ARMS........8
C.FASTENERS.......................................................................8
D.FOOTREST........................................................................8
E. TIRES AND W EELS......................................................8
F. PARKING BRAKE............................................................8
G.UNDERCARRIAGE STORAGE....................................8
.ACCESSORY TRAYS .......................................................8
I. CANOPY...........................................................................8
J. SEATING SYSTEMS.........................................................8
K. PELVIC POSITIONING BELTS .....................................8
L. CUS IONS .......................................................................8
M.TILT AND RECLINE .......................................................9
N.TRANSIT OPTION AND USE: ................................9
VIII. SET–UP AND ADJUSTMENTS ......................................10
A.UNFOLDING AND FOLDING BASE FRAME ......10
B. CASTER W EELS ........................................................11
C.REAR W EELS ..........................................................11
D.PARKING BRAKE OPERATION...............................11
E. SEATING S ELL INSTALLATION ............................12
F. SEATING S ELL REMOVAL.......................................12
G.TILT IN SPACE ANGLE ADJUSTMENT...................12
.RECLINE ADJUSTMENT (OPTIONAL) ..................13
I. SEAT TO BACK ANGLE ADJUSTMENT .................13
J. KNEE ANGLE ADJUSTMENT....................................13
K. CANOPY INSTALLATION AND ADJUSTMENT.........14
L. TELESCOPING STROLLER ANDLE EXTENSION ...14
IX. POSITIONING AND GROWT ADJUSTMENTS ..15
A.POSITIONING AND GROWT ADJUSTMENTS.......15
TOOLS YOU WILL NEED ..............................................15
B. SEAT DEPT ADJUSTMENT .....................................15
C.STANDARD CUS ION ADJUSTMENT .................15
D.ADJUSTABLE CONTOUR CUS ION
ADJUSTMENTS ............................................................16
E. STANDARD PLANAR CUS ION WIT OUT
LATERAL SUPPORTS...................................................16
F. S OULDER STRAP EIG T ADJUSTMENT ......16
G.BACK CUS ION EIG T ADJUSTMENT ...........17
.FOOTREST ADJUSTMENTS ....................................17
I. PELVIC POSITIONING BELT ADJUSTMENTS .....17
J. ANTERIOR TRUNK BUTTERFLY SUPPORT .......18
K. LATERAL TRUNK SUPPORTS ...................................18
L. C OOSING ANTERIOR SUPPORTS ....................19
M. EAD SUPPORTS.........................................................19
N.LATERAL IP BLOCKS...............................................20
O. MEDIAL SUPPORT PADS...........................................20
P. TRAY ARM EIG T ADJUSTMENT........................21
Q.TRAY INSTALLATION AND ADJUSTMENT.........21
R. FOOT STRAP ADJUSTMENT ....................................21
S. S OE OLDER STRAP ADJUSTMENT..................21
T. FOLDING BOOSTER BASE ( EIG T ADJ)..........21
U.VENT/BATTERY TRAYS...............................................22
V. FRONT OR REAR ADD-ON PLATFORM .............22
W.IV SUPPORT POLE / O2 TANK OLDER.............22
X.CUP OLDER, UTILITY OOK ..............................22
X. MAINTENANCE................................................................23
A.NOTES ............................................................................23
B. CLEANING ...................................................................23
C.STORAGE TIPS .............................................................23
D.ORDERING PARTS .....................................................23
XI. SUNRISE LIMITED WARRANTY..................................23

124267 Rev. B 4
ENGLIS
III. Y OU R DEVICE AND IT S P AR TS
III. YOUR DEVICE AND ITS PARTS
ZIPPIE VOYAGE
1. Folding Base Frame
2. Angle Adjustable Backrest
3. Rear Transit ardware (optional)
4. Seating/Frame Interface
5. Front Transit ardware (optional)
6. Rear Wheel
7. Undercarriage Storage
8. Front Caster
9. Adjustable Footplate
10. Seat Cushion
11. Footrest Adjustment Knuckle
12. Seating Shell
13. Adjustable Laterals (optional)
14. Backrest Pad
15. Tilt Lever
16. andle Extension Trigger
17. Recline Lever
Adjustment Ranges:
Tilt
+5° to -45°
Recline
90° to 135°
Push andle eight
39” to 41 1/2”
Seat Depth
5” to 13”
Seat Width (at hip)
6” to 13”
Seat Width (with optional lateral hip supports)
6.5” to 10”
Knee Width
13 1/4”
Knee Width (with optional medial knee supports)
5” - 11”
eadrest Pad eight
13” to 22”
Shoulder eight Adjustment for Belts and arnesses.
Short: 7” to 13”
Tall: 10” -17”
Lower Leg / Footrest Adjustment Range
Lower leg/foot: 1.5” -12”
Footrest angle Adjustment 60° to 260°
Dimensions
Overall Width: 24”
Floor-to-seat height: 24”
Folded height: 12”
Undercarriage storage
Weight Limit: 15lbs
Seating Options
Standard planar seat with/without hip blocks
Contoured wedge seat with/without hip blocks
Contoured anti-thrust (ledge) seat
Adjustable Contour Seat
All features may not be available with some device setups or in
conjunction with other device features. Please consult your suppli-
er for more information. Your authorized supplier can also provide
you with information on accessories.
1
2
3
4
5
6
7
8
9
11
12
13
15
14
17
10
16

V. GE NER A L WA RNINGS
A. WEIG T LIMIT
WARNING
NEVER exceed the weight limit of 60 pounds (27 kilograms), for
the weight of the occupant. If the limit is exceeded, damage to
your device, a fall, tip-over or loss of control may occur and cause
severe injury to the rider and/or others.
B. GETTING TO KNOW YOUR DEVICE
WARNING
Read all instructions before using this product. In particular, you
should be trained in the safe use of this product by your health
care professional.
C. TO REDUCE T E RISK OF AN ACCIDENT
WARNING
1. BEFORE using this device, you should be trained in Its safe use
by your health care advisor.
2. Practice transfers until you know your limits and the extent of
your child’s abilities. ave someone help you to avoid a fall or
tip-over.
3. Be aware that you must develop your own methods for safe
use best suited to your level of function and ability.
4. NEVER try a new maneuver on your own until you are sure
you can do it safely.
5. Get to know the areas where you plan to use your device, look
for hazards and learn how to avoid them.
D. SAFETY C ECKLIST
WARNING
Before each use of the Early Intervention Device.
1. Parking brake must be adjusted to maintain proper perform-
ance. Always engage the parking brake before transferring a
dependent child.
2. Check that the device rolls easily, and that all parts work
smoothly. Check for noise, vibration, or a change in ease of
use, (they may indicate loose fasteners, or other damage).
3. Repair any problem you may encounter. Your authorized
supplier can help you find and correct any problems.
4. Make sure the tire/axle on both sides are fully engaged and
locked. If they are not locked, the wheel may come off and
cause a fall.
5. Never seat your child in the mobility device until it is fully
unfolded and locked.
6. After adjusting handle length check to make sure that it is
locked at the new length.
7. Always use a pelvic positioning belt when child is seated.
8. Never leave your child unattended.
E. C ANGES AND ADJUSTMENTS
WARNING
1. See your health care professional and have them adjust seat-
ing components and accessories as your child grows.
2. Unauthorized modifications or use of parts not supplied or
approved by Sunrise Medical may change the product’s struc-
ture. This will void any warranty and may cause a safety hazard.
F. ENVIRONMENTAL CONDITIONS
WARNING
1. Your mobility device is designed for use on firm, even sur-
faces such as concrete, asphalt, indoor floors and carpeting.
2. Use extra care if you must use this mobility device on a wet
or slick surface. If you are in doubt, ask for help.
3. Do not operate your mobility device in sand, loose soil or
over rough terrain.
124267 Rev. B
5
ENGLIS
IV. NO TICE – REA D B EFORE USE
A. C OOSE T E RIG T DEVICE & SAFETY
OPTIONS
Sunrise provides a choice of many wheelchair styles to meet the
needs of your child. owever, final selection of the type of device,
options, and adjustments rests solely with you and your health care
advisor. Choosing the best early intervention device and set-up for
safety depends on such things as:
1. The child’s disability, strength, balance, coordination, and the
limits of their abilities.
2. The types of hazards that must be overcome in daily use
(where you live and work), and other places you are likely to
use the device.
3. The dependents need of options for their safety and com-
fort.
B. REVIEW T IS MANUAL OFTEN
Before using this device you, and each person who may assist you,
should read this entire manual and make sure to follow all instruc-
tions. Review the warnings often, until they are second nature to
you.
C. WARNINGS
The word “WARNING” refers to a hazard or unsafe practice that
may cause severe injury or death to you or to other persons. The
“Warnings” are in three main sections, as follows:
1. V — GENERAL WARNINGS
ere you will find a safety checklist and a summary of risks
you need to be aware of before you ride this device.
2. VI — WARNINGS — FALLS & TIP-OVERS
ere you will learn how to avoid a fall or tip-over while per-
forming daily activities with the device.
3. VII — WARNINGS — FOR SAFE USE
ere you will learn about practices for the safe use of the
device.
4. VIII — WARNINGS — COMPONENTS & OPTIONS
ere you will learn about the components of the device and
options you can select for safety. Consult your authorized
supplier and your health care advisor to help you choose the
best set-up and options for safe use.
NOTE– Where they apply, you will also find “Warnings” in other sections
of this manual. eed all warnings. If you fail to do so, a fall, tip-
over or loss of control may occur and cause severe injury to the
rider and/or others.

124267 Rev. B 6
ENGLIS
V.
6. NEVER transport this mobility device in the front seat of a
vehicle. This action could risk serious injury or death to the
dependent rider and driver.
7. ALWAYS secure the unoccupied mobility device so that it
cannot roll or shift when being transported in a vehicle.
8. Do not use this product if it has been involved in a motor
vehicle accident. If your device is equipped with the transit
option, refer to Section VII. “Transit Option and Use”.
I. FOR CAREGIVERS
WARNING
1. Work with the child’s health care professional to learn safety
methods best suited to your abilities and those of your child.
2. To prevent injury to your back, use good posture and proper
body mechanics when lifting, or tilting your child.
3. Remind the dependent to lean back when you tilt the mobili-
ty device backward.
4. When you descend a curb or single step, slowly lower the
mobility device in one easy movement.
5. NEVER leave the dependent child alone.
6. When making adjustments to the mobility device, always
engage the parking brake and lock caster wheels to help
minimize unintended movement.
G. STREET USE
WARNING
1. When using this device, avoid street use whenever possible.
2. This product should stay in, and obey all legal pedestrian path-
ways, and laws that apply to pedestrians.
3. Be alert to the danger of motor vehicles in parking lots.
4. At night, or when lighting is poor, use reflective tape or clothing
for maximum visibility.
5. IF you have to cross a road, make eye contact with drivers before
you go forward. When in doubt, yield until you are sure it is safe.
. MOTOR VE ICLE SAFETY
WARNING
1. As indicated on the front cover of this user manual, identify
whether your device has been manufactured with the transit
option installed. If your device is NOT equipped with the transit
option:
2. NEVER use the mobility device seating system as a car seat.
3. ALWAYS move the rider to an approved vehicle seat.
4. ALWAYS secure the rider with proper motor vehicle restraints.
5. In an accident or sudden stop the rider may be thrown from
the mobility device. Mobility device pelvic positioning belts
will not prevent this and further injury may result from these
belts or straps.
VI . WARN IN GS: F AL LS AND TIP- OV ERS
To reduce the risk of a fall or tip over while changing clothes or diapers:
• Rotate the front casters until they point forward.
• Engage the parking brake.
C. OBSTACLES
WARNING
Obstacles and road hazards (such as potholes and broken pavement) can
damage your mobility device and may cause a fall, tip over, or loss of con-
trol. To avoid these risks:
• Scan the area well ahead for danger as you travel with your mobility
device.
• Make sure floor areas ahead are level and free of obstacles.
• Install a ramp at entry or exit doors. Make sure there is not a drop
off at the bottom of the ramp.
D. REAC ING OR LEANING
WARNING
If your child reaches or leans it will affect the center of balance of the mobil-
ity device. This may cause a fall or tip over.
• NEVER allow your child to reach or lean if they must rise up off their
seat for the action.
• If your child must reach, move the mobility device as close as you can
to the object, and rotate the front casters until they are as far for-
ward as possible.
NOTE– To do this: Move your mobility device past the object that the child
might want to reach, then back up alongside it.
A. CENTER OF BALANCE
WARNING
Dependent mobility devices are designed for stability and perform-
ance. The point where this device will tip forward, back, or to the
side depends on its center of balance and stability. The center of
balance is also affected by:
• The seat height and seat angle.
• Backrest angle.
• Changes in your child's body position, postures or weight
distribution.
• Pushing the mobility device on a ramp or slope.
• The use of a backpack or other options, and the amount of
added weight.
• The use of a vents, batteries, oxygen and other options, and
the amount of added weight that these options add to the
device.
To maintain the proper center of gravity and good balance:
• Consult your healthcare advisor and/or supplier to help you
in setting up the mobility device correctly.
• Consult your authorized supplier or healthcare advisor
BEFORE you modify or adjust the mobility device.
B. DRESSING OR C ANGING CLOT ES
WARNING
Your child's weight may shift if you dress your child, or change
your child's clothes while they are seated in the mobility device.

124267 Rev. B
7
ENGLIS
VI.
E. RAMPS, SLOPES AND SIDE ILLS
WARNING
Pushing the mobility device on a slope, including ramps or hills, will
change the center of balance. Some safety reminders include:
1. Do not push this product on a slope steeper than 10%. (A
10% slope means: one foot in elevation for every ten feet of
slope length).
2. Do not turn or change direction on a slope or ramp.
3. For your child's safety, ramps at home and work must meet
all legal requirements for your location.
4. Always stay in the CENTER of the ramp.
5. Use a ramp with guardrails (or raised borders at least 3"
high).
6. Always go straight up and straight down on hills or ramps.
7. Do not stop on a steep slope.
8. Watch for a drop-off at the bottom of a slope or ramp.
9. Do not engage the parking brake to slow or stop your
mobility device.
10. Beware of wet or slippery surfaces, especially on slopes.
11. Do not recline or tilt the shell while going up hills.
12. Ask for help any time you are in doubt of stability.
F. TRANSFERS
WARNING
1. Work with your health care advisor to learn safe transfer
and lifting methods.
2. ave someone help you until you know how to do a safe
transfer of the dependent on your own.
3. Move your child's mobility device as close as you can to the
location you are transferring to.
4. Rotate the front casters until they point forward.
5. Engage the parking brake before you transfer. This keeps the
device stable during the transfer.
6. When transferring a child into the device, make sure they
are placed as far back onto the seat surface as possible. This
will reduce the risk that the mobility device will tip over
and/or move away from you.
G. NEGOTIATING A CURB OR SINGLE STEP
WARNING
Follow the instructions below for descending or climbing a stair or
curb. Do not try to climb a high curb or step more than 4” high, if
the accessory tray, or rear glider platform is installed. Doing so
can risk injury to the caregiver, may cause the device to exceed its
balance point and tip over, and may cause damage to your mobility
device.
To descend a curb or single step going BACKWARD:
1. Stay at the rear of the mobility device.
2. Several feet before you reach the edge of the curb or step,
turn the device around and pull it backward.
3. While looking over your shoulder, carefully step back until
you are off the curb or stair and standing on the lower level.
4. Pull your mobility device toward you until the rear wheels
reach the edge of the curb or step. Then allow the rear
wheels to slowly roll down onto the lower level.
5. When the rear wheels are safely on the lower level, tilt the
mobility device back to its balance point. This will lift the
front casters off the curb or step.
6. Keep the mobility device in balance and take small steps
backward. Turn the mobility device around and gently lower
front casters to the ground.
To climb a step or curb going FORWARD:
1. Stay behind the mobility device.
2. Face the curb and tilt the mobility device up on the rear
wheels so that the front casters clear the curb or step.
3. Move forward, placing the front casters on the upper level as
soon as you are sure they are past the edge.
4. Continue forward until the rear wheels contact the face of
the curb or step. Lift and roll the rear wheels to the upper
level.
. CLIMBING STAIRS
WARNING
1. Do not climb stairs if your mobility device has an accessory
tray installed.
2. Use at least two attendants when moving the occupied
mobility device up stairs.
3. The rider and mobility device should be facing BACKWARD
when moving up the stairs.
4 ALWAYS carry the mobility device by holding the FRAME,
being careful to avoid grabbing the footrest, wheels, tray
parts, and other areas that are meant to detach from the
mobility device.
5. The person at the rear should be in control. e or she
should tilt the mobility device back to its balance point.
6. A second attendant at the front firmly grasps a non-detach-
able part of the front frame and lifts the mobility device up
and over the stair.
7. The attendants should move up one stair at a time until the
landing is reached.
I. DESCENDING STAIRS
WARNING
1. Do not descend stairs if your mobility device has an accesso-
ry tray installed.
2. Use at least two attendants to move an occupied mobility
device down stairs.
3. Move the mobility device with both the device and rider fac-
ing FORWARD down the stairs.
4. The person at the rear is in control. e or she tilts the
mobility device back to the balance point of the rear wheels
and rolls it to the edge of the top step.
5. A second attendant stands on the third step from the top
and grasps the frame. e or she lowers the device one step
at a time by letting the rear wheels roll over the stair edge.
6. The attendants should move down one stair at a time until
the landing is reached.
J. ESCALATORS
WARNING
NEVER use this mobility device on an escalator, even with an
attendant.

VI I. WA RN INGS– CO MPO NENTS AN D OPTIONS
124267 Rev. B 8
ENGLIS
F. PARKING BRAKE
WARNING
Never engage the parking brake to slow or stop this product when
it is moving. To keep the rear wheels from rolling, always engage
the parking brake fully when you transfer your dependent or the
dependent seating system.
G. UNDERCARRIAGE STORAGE
WARNING
This mobility device's storage basket was designed for the addition
of up to 15lbs of additional weight. Excessive weight my cause an
unstable or hazardous condition to exist.
. ACCESSORY TRAYS
WARNING
This mobility device's storage trays were designed for the addition
of Sunrise approved components only. Excessive weight, or a non-
Sunrise accessory, may cause an unstable or hazardous condition
to exist.
I. CANOPY
WARNING
When using the canopy, make sure that it is secure by checking
the clamps that hold it to the base.
J. SEATING SYSTEMS
WARNING
DO NOT change the seating system, or individual components of
your dependent mobility device unless you have first consulted
your health care professional.
K. PELVIC POSITIONING BELTS
WARNING
Use positioning belts ONLY to help support the child's posture.
1. Make sure the rider does not slide down in the mobility
device seat. The belts must be snug, but must not be so tight
that they interfere with breathing. You should be able to
slide your open, flat hand, between the belt and the rider.
2. Use positioning belts with a cooperative rider only. Make
sure that you can remove the belts in an emergency.
3. NEVER use the positioning belts:
• As a restraint.
• On a child who is comatose, agitated or is prone to
seizures.
• As a motor vehicle restraint– except those that are includ-
ed with the transit option for the purpose of occupant
restraint.
L. CUS IONS
WARNING
This mobility device's seating was designed for comfort and pos-
tural support. If seating component modifications are necessary,
consult your healthcare advisor.
VII. WARNINGS: COMPONENTS AND OPTIONS
WARNING
This early intervention device has been tested and approved using
Sunrise accessories. Any accessory that has not been been
expressly approved by Sunrise Medical will void your warranty,
and may add a safety risk to attendant and child.
A. BASE FRAME
WARNING
Inspect cables and engage/release buttons before every use to
make sure they are in good working condition. Be sure that your
base frame is locked before seating your child.
B. SUPPORT TRAY AND TRAY SUPPORT ARMS
WARNING
Before adding or removing a tray to the mobility device be sure to
point front casters to the front of the device and engage parking
brake. This keeps the wheels from rolling when attaching the tray.
1. Do not lift this product by its tray support arms.
2. ALWAYS make certain that the tray is fully locked into place
after adding it to the dependent mobility device.
C. FASTENERS
WARNING
Many of the screws, and nuts on this product are considered to be
special high-strength fasteners. They require periodic checks and
maintenence to ensure the safety of both the user and attendant.
1. Most adjustments that require removing hardware should be
done by your Service provider.
2. Only use fasteners provided by an authorized supplier (or
ones of the same type and strength), as indicated by the
markings on the heads.
3. Do not over- or under-tighten fasteners. If screws or nuts
become loose, tighten them as soon as possible.
D. FOOTREST
WARNING
1. Adjustment of the footbed may cause interference with the
front lower frame in some positions. This interference can
affect the comfort and proper support for the seated
dependent.
2. Avoid putting extra weight on the footbed. The mobility
device may tip forward (or backward if seating system has
been reversed).
3 Never lift this mobility device by the footbeds.
E. TIRES AND W EELS
WARNING
1. Yearly tire inspection for excessive wear is suggested to
ensure good traction in all types of environments.
2. When installing front or rear wheel/tire assembly, slide the
wheels into the axle opening until the quick release lever
pops out, and there is an audible click. Your wheel is now
fully engaged and locked.

124267 Rev. B
9
ENGLIS
VI I.
M. TILT AND RECLINE
WARNING
Using the tilt or recline adjustments triggers before taking the necessary precautions may
effect the balance and stability of your device. BEFORE making these adjustments you must
be aware of the following:
1. The child must be secure in the device.
2. You must rotate the front casters forward, and engage the parking brake.
3. ALWAYS make certain that the dependent mobility device is level and stable before
adjusting the tilt and/or recline.
N. TRANSIT OPTION AND USE:
NOTE– The Zippie Voyage has passed transit testing and is considered to be WC-19 compliant for a
60 lb dependent child secured in a 5 point harness, with a transit strap attached to the rear
frame.
WARNING
1. If possible and feasible, the rider should transfer to the vehicle seat and use the OEM
vehicle-installed restraints.
2. The occupant must be facing the front of the vehicle during transport.
3. Wheelchair Tiedown and Occupant Restraint Systems (WTORS) must be used.
4. A Wheelchair Tiedown that has been tested in accordance with SAE J2249 must also
be used in any transit situation.
5. The Occupant restraint straps provided with the Voyage must be used.
6. For all transit situations, you must use the Transit Strap provided with your device. It
secures the seating shell to the rear frame. It is critical that the strap be threaded
thru the 2 “D” clips as shown in (figure 1) for the safety of the occupant.
5. Mobility device mounted accessories, such as trays and respiratory equipment, and bat-
teries, should be removed, and secured separately. The optional voyage vent tray, oxy-
gen holder, and IV pole must also be removed and secured separately before using as a
seat in a motor vehicle.
6. The occupant must not weigh more than 60 pounds. (27 Kilograms).
7. The location(s) of the front and rear securement points(A) are shown in (figure 2 and
marked with a transit point label for clear identification.
8. Use only with WTORS that have been installed in accordance with the manufacturer's
instructions and SAE J2249. Attach WTORS to the securement points(A) in accor-
dance with the manufacture's instructions and SAE J224
9. The angle of the pelvic belt should be within the preferred zone of 45 to 75 degrees
to the horizontal, or within the optional zone of 30 to 45 degrees to the horizontal
(figure 3)
10. The pelvic belt should be worn low across the front of the pelvis. Position upper
torso belts over the shoulders. The belt(s) should not be held away from the body by
wheelchair components. Ensure that the belts are not twisted.
11. Attach all occupant restraints in accordance with the manufacturer's instructions and
SAE J2249.
NOTE– To obtain a copy of SAE J2249
“Wheelchair Tiedown and Occupant Restraint Systems for Use in Motor Vehicles”
Please contact:
SAE International, 400 Commonwealth Drive
Warrendale, PA 15096-0001
or by phone at (724)-776-4970, or [phone]
321
2
1
3
A

VIII. SE T–U P AN D A DJUSTM ENTS
124267 Rev. B 10
ENGLIS
A. UNFOLDING AND FOLDING BASE FRAME
WARNING
Zippie dependent mobility devices are designed for stability and perform-
ance. When unfolded, the device must be fully open and locked to avoid
injury to the dependent rider. Follow the instructions for unfolding the
device carefully, and double-check that the device is fully locked before
adding the seating shell and rider.
Unfolding:
1. Unsnap the storage lock (A) from around the folded frame. It should
remain attached to the frame for future use.
2. Pull the top and bottom of the frame in opposite directions to open the
frame and upholstery.
3. Set the Frame and upholstery down on a flat surface, and push down on
pivot point (B) until there is an audible “click” to lock the frame.
4. Rear wheels and front casters can now be attached if they are not attached
already.
Folding:
NOTE– Rear wheels, or front casters do not have to be removed for this procedure, but
may be removed to save space for storage. If you decide to leave the front cast-
ers on the device, it may not lock correctly due to interference between the
caster wheels and the push handle. In most cases you should fully retract the
push handle before folding, then you will be able to snap the storage lock easily.
1. Remove the child from the seating shell, then remove the seating shell (refer
to sub-section (F)
2. Pull up on both fold handles (C) at the same time with a gentle tug. This
action will release the frame lock. Continue pulling up on the fold handles
until the frame is fully collapsed. It may be necessary to push the handle
and caster ends of the frame together with light pressure.
3. Snap the storage lock (A) around the upper frame to prevent the frame
from opening when transporting, or storing the frame.
654
457
A
4
5
6
7
C
B