Aiwa FR-A200 User manual

RADIO RECEIVER
FR-A200
S/M Code No. 09-991-323-3R1
UB
SERVICE MANUAL
REVISION
This Service Manual is the “Revision Publishing” and replaces “Simple Manual”
FR-A200<UB>(S/M Code No.09-991-323-3T1) .
DATA
MODEL CODE : 88RC6-0137(S)

SPECIFICATIONS
Power source AC 120 V, 60 Hz
Output 280 mW (EIAJ)
Power consumption 4 W
Speaker 57 mm, 8 ohms
Frequency range FM : 87.5 - 108 MHz
AM : 530 - 1,710 kHz
Antennas FM line antenna
Ferrite bar antenna for AM
Dimensions (W x H x D) 205 x 160 x 68 mm
(81/8x 63/8x 23/4in.)
Weight` Approx. 680 g (1.5 lbs.)
• Design and specifications are subject to change without
notice

REF. NO PART NO. KANRI DESCRIPTION
NO.
REF. NO PART NO. KANRI DESCRIPTION
NO.
ELECTRICAL MAIN PARTS LIST
88
A
Resistor Code
Chip Resistor Part Coding
Figure
Value of resistor
Chip resistor
Wattage Type Tolerance
1/16W
1/10W
1/8W
1608
2125
3216
5%
5%
5%
CJ
CJ
CJ
Form
LW t
1.6 0.8 0.45
2 1.25 0.45
3.2 1.6
108
118
128
: A
: A
CHIP RESISTOR PART CODE
0.55
Resistor Code
Dimensions (mm)
Symbol
1/16W 1005 5% CJ
1.0 0.5 0.35 104
Lt
W
IC
S1-86A-012-A00 IC,CXA1619AS(RF+1F+AUDIO)
87-A21-201-010 IC,LM8560(CLOCK)
TRANSISTOR
S1-71H-003-E00 TR,A1267-Y
DIODE
82-135-799-080 DIODE,1N4148
S1-722-400-100 DIODE,1N4001
MAIN C.B
B51 S6-45A-010-A00 BATT,SNAP TERMINAL AWG26 RED/B
C9 SC-E10-614-280 CAP,E 10UF-10V
C11 S1-41T-101-0M0 CAP,E 1.0UF-10V
C12 87-010-374-040 CAP,E 47UF-10V
C13 87-010-236-080 CAP,E 1000UF-10V
C16 87-010-264-080 CAP,E 100UF-10V
C17 87-010-236-080 CAP,E 1000UF-10V
C53 87-010-480-080 CAP,E 220UF-16V
C54 87-010-264-080 CAP,E 100UF-10V
CF1 S3-33A-008-A00 AM C/FILTER SFU450B
CF2 S3-32A-012-A00 FM C/FILTER SFE10.7
L1 S2-10A-062-A00 AM ANT COIL 60-10 560UH
L4 S2-24A-032-A00 AM OSC COIL 7-7-2 A106
L5 S2-14A-034-A00 CHOKE COIL 47UH
L53 S2-15A-030-A00 LOADING COIL 4.5P
L54 S2-15A-030-A00 LOADING COIL 4.5P
LD51 S2-00A-008-A00 LED DISPLAY(FRA200)
PVC1 S2-61A-030-A00 PVC ST-505 60P/82P 20PX2
SW1 S2-81A-055-A00 SLIDE SW 2C-2P RG 4MM(BAND)
SW1 S3-23A-025-A00 SPAEKER 8 OHM 0.5W(FRA200)
SW51 S2-81A-056-A00 SLIDE SW 2C-4P RG 4MM(POWER)
SW53 S6-42A-065-A00 TACT SW TS114-16
SW54 S6-42A-065-A00 TACT SW TS114-16
SW55 S6-42A-065-A00 TACT SW TS114-16
SW56 S6-42A-065-A00 TACT SW TS114-16
SW57 S6-42A-065-A00 TACT SW TS114-16
SW58 S6-42A-065-A00 TACT SW TS114-16
T1 S2-20A-025-A00 FM IFT 7-7-2 D30045
T2 S2-22A-028-A00 AM IFT 7-7-2 2B467
TF51 S4-10A-022-A00 POWER TRANS EI-35.120V
VR1 S2-56A-015-A00 VR,50K-B POINT CONTACT
!

SCHEMATIC DIAGRAM _1

WIRING-1
MAIN C.B

WIRING-2
MAIN C.B

TRANSISTOR ILLUSTRATION
B C E
A1267Y

IC BLOCK DIAGRAM
IC,LM8560
IC,CXA1619S

ELECTRICAL ADJUSTMENT
+
-
TP8
TP9
TP4 TP3 TP2 TP1
TP5
TP6
TP7
DC 6.0 V
RADIO
BUZZ
POWER-OFF
POWER-ON
T1
L4
L3 L6
T2
L1
AM
FM
TC2
TC3
TC4
TC1

1. AM IF Adjustment
Setting : • Test point : TP1, 2(IN), TP8, 9(OUT)
T2 . . . . . . . . . . . . . . . . . . . . . 450 kHz
2. FM IF Adjustment
Setting : • Test point : TP2, 3(IN), TP8, 9(OUT)
IT1 . . . . . . . . . . . . . . . . . . . . 10.7 MHz
3. AM FREQ, RANGE Adjustment
Setting : • Test point : L1(IN), TP6, 7, 8, 9(OUT)
L4 . . . . . . . . . . . . . . . . . . . . . 515 kHz
TC4 . . . . . . . . . . . . . . . . . . . . 1750 kHz
4. AM Tracking Adjustment
Setting : • Test point : L1(IN), TP6, 7(OUT)
L1 . . . . . . . . . . . . . . . . . . . . . 600 kHz
TC1 . . . . . . . . . . . . . . . . . . . . 1500 kHz
5. FM FREQ, RANGE Adjustment
Setting : • Test point : TP4, 5(IN), TP6, 7, 8, 9(OUT)
L3 . . . . . . . . . . . . . . . . . . . . 87.0 MHz
TC3 . . . . . . . . . . . . . . . . . . . 109 MHz
6. FM Tracking Adjustment
Setting : • Test point : TP4, 5(IN), TP6, 7(OUT)
TC2 . . . . . . . . . . . . . . . . . . . 106 MHz
PRACTICAL SERVICE FIGURE
<AM SECTION>
Sensitivity Less than 50 dB (600 kHz)
(S/N 10dB) Less than 46 dB (1000/1400 kHz)
S/N (Input 60dB) Less than 21 dB (600 kHz)
Less than 24 dB (1000/1400kHz)
Distortion Less than 3 % (1000 kHz)
Intermediate frequency 450kHz
<FM SECTION>
Sensitivity (3% dist.) Less than 20 dB (88/98/108 MHz)
S/N (at 60dB) Less than 45 dB (98 MHz)
Distortion (at 60dB) Less than 3% (98MHz)
Intermediate frequency 10.7MHz

MECHANICAL EXPLODED VIEW - 1/1
SPEAKER
PVC PLATE
B
A
SPEC
LABEL
5
LED
STOPPER

REF. NO PART NO. KANRI DESCRIPTION
NO.
MECHANICAL PARTS LIST 1/1
Basic color symbol Color Basic color symbol Color Basic color symbol Color
B Black C Cream D Orange
G Green H Gray L Blue
N Gold P Pink R Red
S Silver ST Titan Silver T Brown
V Violet W White Y Yellow
COLOR NAME TABLE
1 S6-73A-030-A00 CAB,TOP(FRA200 D-GRY)
2 S6-74A-040-A00 CAB,BOTTOM(FRA200D-GRY)
3 S6-87A-070-A00 DIAL LENS(FRA200)
4 S6-97A-010-A00 BATT,COVER(FRA200D-GRY)
6 S7-08A-045-A00 KNOB,TUNING(FRA200D-GRY)
7 S7-08A-055-A00 KNOB,VOLUME(FRA200)
8 S7-01A-020-A00 DIAL POINTER(FRA200WHT)
9 S7-08A-065-A00 KNOB,POWER(FRA200)
10 S7-08A-075-A00 KNOB,BAND(FRA200)
11 S7-08A-050-A00 BUTTON CLOCK(FRA200D-GRY)
12 S6-12A-040-A00 ANT HOLDER(FRA200)
13 S6-35A-010-A00 RUBBER FOOT(FRA200B)
A 87-741-097-410 SCREW,+3-12
B 87-741-102-410 SCREW,+3-20

REF. NO PART NO. KANRI DESCRIPTION
NO.
ACCESSORIES LIST
S8-00A-250-A00 INSTRUCTION BOOK(FRA200U)

931196 Printed in Singapore
2–11, IKENOHATA1–CHOME, TAITO-KU, TOKYO 110, JAPAN TEL:[phone]