Baby Trend 1906CT User manual

Shuttle Travel System
MODEL # 1906CT
Instruction Manual
01.06
Convenience through Innovation and thoughtful design
Read all instructions BEFORE assembly and USE of product.
KEEP INSTRUCTIONS FOR FUTURE USE.
Patents pending, US Patent# 6,834,915 6,811,216 6,913,313 6,916,066

WARNING: Please follow all of these instructions to ensure the
safety of your child. Keep these instructions for future reference.
WARNING: Failure to follow these instructions could result in
serious injury or death. Avoid serious injury from falling or sliding out.
Always use the seat belt and insure that the child is properly positioned
according to these instructions.
WARNING: Never leave child unattended.
* Purses, shopping bags, parcels, diaper bags or accessory items may change the balance of the stroller and
cause hazardous unstable conditions.
* The maximum weight that can be carried in the basket is 5 lbs. The maximum weight that can be carried
in the Parent Tray is 3 lbs. Excessive weight may cause a hazardous unstable condition to exist.
* Be certain the stroller is fully erect and latched in the open position before allowing the child near the
stroller.
* Use of the stroller with a child weighing more than 40 pounds will cause excessive wear and stress on the
stroller and may cause a hazardous unstable condition to exist.
* DO NOT use the stroller on stairways or escalators.
* Never allow your stroller to be used as a toy
* To clean use only mild household soap or detergent and warm water on a sponge or clean cloth.
* Check your stroller for loose screws, worn parts, torn material or stitching on a regular basis. Replace or
repair parts as needed
* Discontinue use of stroller should it malfunction or become damaged. Please contact our customer service
Parts Hotline to arrange for repair or obtain replacement parts.
Please: If you experience any difficulty with the use of our product or have a question regarding these instruc-
tions, please contact our Customer Service Department at [phone] between the hours of 8:00 am and
4:30 pm Pacific Coast Time. Please do not return to the store as once it is returned it cannot be resold and the
materials and energy used to make it are wasted.
To Contact Us:
Baby Trend, Inc. Customer Service Hot Line
1567 S. Campus Ave. [phone]
Ontario, CA 91761 8:00 a.m. to 4:30 p.m. Pacific Standard Time
WARNINGS
2

* Remove stroller from box. The front wheels, rear wheels, child tray, parent
tray, and canopy need to be installed prior to use.
* To attach the front wheels, unfold stroller as described in the section
following. See fi gure 1.
* Lean the stroller backwards so that it rests on the handle and rear frame
tubes and the front wheel tubes are pointing upward. Position the front
wheel assembly at the front tube such that the hole in the swivel assembly
will slide onto the front tube. Please see fi gure 2. Push each front wheel
assembly onto the front tube being careful that wheel assembly locks onto
the front leg. Pull on the wheel assembly to ensure that it is securely
attached to the stroller. Please see fi gure 2.
* Lean the stroller forward to rest on the front wheels. Assemble the rear
wheels as follows:
1. Slide the rear wheel housings onto each rear stroller leg until locked
into place. The push button on the forward edge of the leg should
snap into the hole in the housing. Please see fi gure 3.
2. Slide the rear axle through the housings as shown in fi gure 4.
3. Slide each wheel onto the rear axle and secure in place with the
Locking Cap. Snap the solid cap over the Locking Cap. Snap the
Hub Cap onto the wheel. Please see fi gure 5. Please see fi gure 6 for
order assembly.
Pull on each wheel to ensure that each is fi rmly attached to the axle.
* Ensure that the wheels are fi rmly locked into place. Do Not use the stroller
if the wheels are not locked into place, but rather contact our customer
service department immediately at [phone], between the hours of
8:00am and 4:30pm PCT, for assistance.
TO ENSURE SAFE OPERATION OF YOUR STROLLER, PLEASE FOLLOW THESE
INSTRUCTIONS CAREFULLY. RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE.
Car Seat
Front Wheels
Figure 3.
Parent Tray
PARTS
TO ASSEMBLE STROLLER
Slide axle through
Figure 5.
Child Tray
Figure 4.
Rear Axle
Solid Cap
Locking Cap
Rear Wheels
Figure 6.
Stroller
Figure 1.
Base
Car Seat
Figure 2.
Rear Wheel Housing
Hub Cap
Front Wheels
3

* To attach the front child tray, push the angled tray onto the post at the
end of right armrest, while pressing downward on the snap button, until
locked into place. Please see fi gure 7. Rotate the tray downward until
latched onto the left armrest. Please check that the snap button comes
through and securely latches the tray in place. Please see fi gure 8.
* To remove front child tray, press inward on the left side tray release
button and rotate upward on the tray. Please see fi gure 9. Please note
that you may remove the tray completely by depressing the snap button
on the right side as shown in fi gure 10 while pulling forward on the tray.
Please see fi gure 7.
* To attach the parent tray, align the fi ttings on the ends of the parent
tray with the fi ttings on the outsides of the handle, make sure to push
the canopy foward See fi gure 11a. Push downward on the tray until
locked into place. Please see fi gure 11. To remove the parent tray, pull
outward on the bottom edges of the tray and lift upward. Please see
fi gure 12.
* The Drop-Top storage basket swings downward to allow easy access
to the basket contents. Lift upward on the rear tube of the basket to
lock in the up position. Please see fi gure 13. To lower the basket, pull
rearward on the center of the basket tube and press downward. Please
see fi gure 14.
* To remove the canopy, pull outward on the fi ttings on the canopy as
shown in fi gure 15. Push forward on the front frame of the canopy to
open. Please see fi gure 16.
Your stroller is now ready to use.
4
Figure 9.
Figure 7.
Figure 8.
Figure 11. Figure 12.
Figure 13. Figure 14.
Figure 10.
Figure 15. Figure 16.
Front frame
tube
Figure 11a.

5
• The shoulder straps of the 5-point harness have 2 attachment positions.
Select the position that places the shoulder strap level with, or below
the top of the child's shoulder. To access the harness pull apart seat pad.
Please see fi gure 17.
• Carefully place the child in the stroller seat and bring the safety harness
around the child's waist and over the shoulders. Place the crotch strap
between the child's legs. Insert the male end of each shoulder/waist belt
into the buckle on the crotch strap. Tighten the harness to be snug around
the child's waist and over the child's shoulders Please see fi gure 18.
TO SECURE THE CHILD
Shoulder Strap
Squeeze
Crotch Strap
Waist
Strap
Adjust for a
snug fit
• To release, apply pressure to both sides of each male clip until the clip is released. See fi gure
18a. This process requires a moderate amount of effort so as to prevent an accidental release by
your child.
WARNING: Avoid serious injury from
falling or sliding out. Always use the safety
harness.
STRANGULATION HAZARD:
Child can strangle in loose straps. Never leave
child in seat when straps are loose or undone.
Figure 17.
Figure 18.
Figure 18a.

6
ATTACHMENT OF THE BABY TREND INFANT CAR SEAT
* To attach the Baby Trend Infant Car Seat, remove the seat back reclining
strap and pass the strap through the loop on the side of the seat, repeat
for the opposite side. NOTE: make sure the canopy is pushed forward
then rotate each end of the straps to the inside of the canopy frame.
Please see fi gure 19
* Check that the front child tray is fi rmly attached to the stroller
armrests. Pull rearward on the rear edge of the front child tray cover
while lifting upward on the tray cover. Please see fi gure 20 and 21.
Remove the tray cover and store in the pocket in the rear of the seat.
Please see fi gure 22.
* Position the Infant Car Seat, facing toward the rear of the stroller, so
that the seat shell goes into the front tray and latches into place. The
sides of the car seat will rest on fold joints. Please see fi gure 23.
* Bring the seat back reclining strap through the inside of the canopy
frame and pass it through the seat belt slots on the car seat. Snap the two
ends together and tighten for a snug fi t. Please see fi gure 23a.
Check that the Infant Car Seat is fi rmly locked onto the front tray
before using.
* To remove the Infant Car Seat, squeeze the release handle located at the
foot-end of the seat and carefully lift upward on the seat. Please see
fi gure 23b.
Figure 19.
Figure 20.
Figure21.
Figure 22.
Figure 23.
Rest on
fold joints
Locks
into tray
Figure 23a.
Figure 23b.
WARNING: Failure to
follow these car seat attachment
instructions could result in seri-
ous injury or death.

7
* The cover of the child/car seat tray may be fastened in the closed position
after your child outgrows the infant car seat. This will prevent an older
child from opening the child tray. To secure the tray cover, remove the
tray from the stroller as shown in the to remove front child tray section.
Install the tray cover. Place the tray with the lid side down on a soft
fl at surface. Remove the screw stored under the tray as shown in fi gure
24. Insert the screw into the hole in the bottom of the tray and into the
matching hole in the cover. Tighten until snug. Do not over tighten. If
you wish to use the car seat tray function at a later date (for a second
child) remove the screw and store in the tray bottom as before. Please
see fi gure 24.
FRONT CHILD / CAR SEAT TRAY COVER
SEAT BACK POSITIONING
WARNING: The upright position should be
used only for a child that is at least 6 months old.
* The seat has a multiple position recline that is controlled by a strap and
buckle assembly behind the seat. To recline the seat, loosen the strap
through the buckle and adjust to the required recline position. Please see
fi gure 25. To place the seat back in a more upright position, press upward
on the seat back with one hand while pulling the straps through the buckle
with the other. See fi gure 26. The strap will lock automatically.
Strap must go across slot on either side of central seat body when
adjusting seat back height. See fi gure 26a.
BRAKES
WARNING: Always set brakes when the
stroller is not being pushed so that the stroller will
not roll away. Never leave stroller unattended on a
hill or incline as the stroller may slide down the hill.
* To engage brakes, apply light downward pressure to the brake lever
located on each rear wheel. The stroller may require slight forward or
rearward movement in order to line up the teeth on the brake with each
wheel brake cluster. See fi gure 27. Check that the stroller will not move
and that the brakes are properly applied. To release, gently lift up on the
brake lever.
Figure 25.
Figure 26.
Figure 27.
Figure 24.
Screw storage
boss-factory
installed screw
for later use
Hole in tray to lock down lid
after car seat use
on the seat back with one hand while pulling the straps through the buckle
Figure 26a.

Figure 28.
8
* To open the canopy, push forward on the front frame of the canopy. To
close canopy, pull the front edge toward the rear of the stroller until folded.
Always fold the canopy prior to folding the stroller frame. Please see
fi gure 28. The canopy may be moved forward to block the sun or wind.
Push forward on the front frame tube or rearward on the rear frame tube
to adjust. Please see fi gure 29.
CANOPY
TO REMOVE FRONT CHILD TRAY
* To remove front child tray, press inward on the tray release button on the
left armrest and pull up on the tray. Please see fi gure 9. Also, the tray
may be completely removed by depressing the snap button on the right
side as shown in Figure 10 while pulling forward on the tray
BASKET
* The Drop-Top storage basket swings downward to allow easy access to
the basket contents. Lift upward on the rear tube of the basket to lock in
the up position. Please see fi gure 30. To lower the basket, pull rearward
on the center of the basket tube and press downward. Please see fi gure
31.
Figure 29.
Figure 30.
Figure 31.
Front frame
tube
Rear frame
tube

9
TO UNFOLD STROLLER
Figure 33.
TO FOLD STROLLER
Figure 32.
* Close the canopy as described in the Canopy section above. Place seat
back in fully reclined position by unbuckling recline strap. Pull
stroller backward several inches to rotate the front wheels to the
front. Please see fi gure 32. To fold the stroller slide the red fold lock
with your thumb while squeezing the large red fold button in the center
of the handle and push downward on the handle. Once the stroller begins
to fold, release the red handle and pull rearward on the child tray until the
stroller is folded. Please see fi gure 33. Secure the stroller in the folded
position by fastening the fold locking latch, located on the right side of
the stroller at the intersection of the handle and the armrest, over the
extended rivet on the lower frame tube. The latch should easily reach the
rivet. If not, check for interferance-DO NOT force the stroller. Please
see fi gure 34.
Figure 35.
Figure 36.
* Release the folding latch, which is located on the right side. See fi gure
35.
* Lift up on the stroller handle with both hands until the stroller frame is
erect and locked in the open position. See fi gure 36. The stroller has
spring-loaded latches on both sides of the frame. Test that both latches are
fully engaged prior to placing your child in the stroller.
Figure 34.
CAUTION: Read the following section completely before folding your stroller!
WARNING: Failure to
follow these folding instructions
could result in serious injury or
death.

CLEANING SEAT PAD
* The seat pad may be removed for washing. To remove the seat pad, unsnap
the two straps on the rear of the seat as shown in fi gure 37. Unfasten the
seat belt and pull the waist belts and crotch strap through the cutouts in
the pad as shown in fi gure 38. Pull downward on the front edge of the
seat pad to remove from the stroller as shown in fi gure 39. Please see the
care label on the rear of the seat for washing instructions. To re-install the
pad, follow these instructions in reverse order.
IF YOU EXPERIENCE ANY DIFFICULTY IN USING THIS PRODUCT,
PLEASE CONTACT OUR CUSTOMER SERVICE DEPARTMENT AT [phone]
BETWEEN THE HOURS OF 8:00AM AND 4:30PM PACIFIC COAST TIME FOR ASSISTANCE.
STOP
10
Figure 37.
Figure 38.
Figure 39.