B&B Electronics EIR618-2SFP-T User manual

B&B Electronics Mfg Co Inc – 707 Dayton Rd - PO Box 1040 - Ottawa IL 61350 - Ph 815-433-5100 - Fax [phone] – www.bb-elec.com
B&B Electronics – Westlink Commercial Park – Oranmore, Galway, Ireland – Ph [phone] – Fax [phone] – www.bb-europe.com
Product Description
Model EIR618-2SFP-T
Documentation Number: EIR618-2SFP-T_5107m
707 Dayton Road -- P.O. Box 1040 -- Ottawa, IL 61350 USA
Phone [phone] -- General Fax [phone]
Phone [phone] -- General Fax [phone]
Website: www.bb-elec.com
Sales e-mail: [e-mail] -- Fax [phone]
Technical Support e-mail: [e-mail] -- Fax [phone]
European Headquarters
B&B Electronics
Westlink Commercial Park -- Oranmore, Co. Galway, Ireland
Phone [phone] -- Fax [phone]
Website: www.bb-europe.com
Sales e-mail: [e-mail]
Technical Support e-mail: suppo[email protected]
B&B Electronics Mfg. Co. Inc. -- December 2007

Eighteen Port Managed Industrial
Ethernet Switches
User Manual

B&B Electronics Mfg Co Inc
–
707 Dayton Rd - PO Box 1040 - Ottawa IL 61350 - Ph 815-433-5100 - Fax [phone]
–
www.bb-elec.com
B&B Electronics – Westlink Commercial Park – Oranmore, Galway, Ireland – Ph [phone] – Fax [phone] – www.bb-europe.com
The contents of this manual are based on the firmware, kernel
version, and hardware version listed below.
Firmware Version V1.07
Kernel Version V2.07
Hardware Version ----------
Notice

FCC Warning
This Equipment has been tested and found to comply with the limits for a
Class-A digital device, pursuant to Part 15 of the FCC rules. These limits are
designed to provide reasonable protection against harmful interference in a
residential installation. This equipment generates, uses, and can radiate
radio frequency energy. It may cause harmful interference to radio
communications if the equipment is not installed and used in accordance
with the instructions. However, there is no guarantee that interference will
not occur in a particular installation. If this equipment does cause harmful
interference to radio or television reception, which can be determined by
turning the equipment off and on, the user is encouraged to try to correct the
interference by one or more of the following measures:
Reorient or relocate the receiving antenna.
Increase the separation between the equipment and receiver.
Connect the equipment into an outlet on a circuit different from that to
which the receiver is connected.
Consult the dealer or an experienced radio/TV technician for help.
CE Mark Warning
This is a Class-A product. In a domestic environment, this product may cause
radio interference in which case the user may be required to take adequate
measures.

Content
Introduction................................................................1
Features ................................................................... 1
Software Specification.............................................. 3
Package Contents.................................................... 5
Hardware Description................................................6
Physical Dimension.................................................. 6
Front Panel............................................................... 6
Top View .................................................................. 7
LED Indicators.......................................................... 8
Ports......................................................................... 9
Cabling ................................................................... 11
Wiring the Power Inputs ......................................... 14
Wiring the Fault Alarm Contact .............................. 15
Mounting Installation...............................................16
DIN-Rail Mounting.................................................. 16
Wall Mount Plate Mounting .................................... 18
Hardware Installation ..............................................19
Network Application................................................20

B&B Electronics Mfg Co Inc
–
707 Dayton Rd - PO Box 1040 - Ottawa IL 61350 - Ph 815-433-5100 - Fax [phone]
–
www.bb-elec.com
B&B Electronics – Westlink Commercial Park – Oranmore, Galway, Ireland – Ph [phone] – Fax [phone] – www.bb-europe.com
X-Ring Application.................................................. 20
Coupling Ring Application ...................................... 21
Dual Homing Application........................................ 22
Console Management..............................................23
Connecting to the Console Port ............................. 23
Pin Assignment ...................................................... 23
Login in the Console Interface ............................... 24
CLI Management.................................................... 25
Commands Level .............................................................26
Commands Set List ..........................................................27
System Commands Set....................................................27
Port Commands Set .........................................................30
Trunk Commands Set ......................................................32
VLAN Commands Set ......................................................33
Spanning Tree Commands Set ........................................35
QOS Commands Set........................................................38
IGMP Commands Set ......................................................38
Mac / Filter Table Commands Set....................................39
SNMP Commands Set .....................................................40
Port Mirroring Commands Set..........................................42
802.1x Commands Set.....................................................43

TFTP Commands Set.......................................................45
SystemLog, SMTP and Event Commands Set.................45
SNTP Commands Set ......................................................47
X-ring Commands Set ......................................................48
Web-Based Management ........................................50
About Web-based Management ............................ 50
Preparing for Web Management ............................ 50
System Login.......................................................... 51
System Information ................................................ 52
IP Configuration ..................................................... 52
DHCP Server – System configuration.................... 54
DHCP Server – Client Entries ................................ 54
DHCP Server - Port and IP Bindings ..................... 55
TFTP - Update Firmware ....................................... 56
TFTP – Restore Configuration ............................... 56
TFTP - Backup Configuration................................. 57
System Event Log – Syslog Configuration............. 57
System Event Log - SMTP Configuration .............. 58
System Event Log - Event Configuration ............... 59

B&B Electronics Mfg Co Inc
–
707 Dayton Rd - PO Box 1040 - Ottawa IL 61350 - Ph 815-433-5100 - Fax [phone]
–
www.bb-elec.com
B&B Electronics – Westlink Commercial Park – Oranmore, Galway, Ireland – Ph [phone] – Fax [phone] – www.bb-europe.com
Fault Relay Alarm................................................... 61
SNTP Configuration ............................................... 61
IP Security.............................................................. 64
User Authentication................................................ 65
Port Statistics ......................................................... 66
Port Control ............................................................ 67
Port Trunk............................................................... 68
Aggregator setting ............................................................68
Aggregator Information.....................................................70
State Activity.....................................................................70
Port Mirroring.......................................................... 72
Rate Limiting .......................................................... 73
VLAN configuration ................................................ 74
VLAN configuration - Port-based VLAN ...........................74
802.1Q VLAN ...................................................................77
Rapid Spanning Tree ............................................. 80
RSTP - System Configuration ..........................................80
RSTP - Port Configuration................................................81
SNMP Configuration .............................................. 83
System Configuration .......................................................83

Trap Configuration............................................................84
SNMPV3 Configuration ....................................................85
QoS Configuration.................................................. 88
QoS Policy and Priority Type ...........................................88
Port-based Priority............................................................89
COS Configuration ...........................................................90
TOS Configuration............................................................90
IGMP Configuration................................................ 90
X-Ring .................................................................... 92
Security .................................................................. 94
802.1X/Radius Configuration ...........................................94
MAC Address Table .........................................................97
Factory Default....................................................... 99
Save Configuration............................................... 100
System Reboot..................................................... 100
Trouble shooting....................................................101
Technical Specification.........................................102

B&B Electronics Mfg Co Inc
–
707 Dayton Rd - PO Box 1040 - Ottawa IL 61350 - Ph 815-433-5100 - Fax [phone]
–
www.bb-elec.com
B&B Electronics – Westlink Commercial Park – Oranmore, Galway, Ireland – Ph [phone] – Fax [phone] – www.bb-europe.com

ManualDocumentationNumber:EIR618-2SFP-T_5107m 1
B&B Electronics Mfg Co Inc – 707 Dayton Rd - PO Box 1040 - Ottawa IL 61350 - Ph 815-433-5100 - Fax [phone] – www.bb-elec.com
B&B Electronics – Westlink Commercial Park – Oranmore, Galway, Ireland – Ph [phone] – Fax [phone] – www.bb-europe.com
Introduction
This managed industrial switch comes equipped with a proprietary
redundant network protocol—X-Ring which provides an easy way to
establish a redundant Ethernet network. With ultra high-speed recovery time
(less than 300 ms) and a long MTBF (Mean Time Between Failures) the
industrial switch will continue to operate until a Gigabit network infrastructure
has been established, without requiring extra upgrade costs.
In addition to 10/100/1000Base-TX fast Ethernet ports, the switch has SFP
(mini-GBIC) ports. Traditional RJ-45 ports can be used for up linking short
distance (less than 100 m) wide-band paths, while the SFP slots can be
used for the application of wideband uploading and long distance
transmissions adding flexibility
Features
System Interface/Performance
¾RJ-45 ports support Auto MDI/MDI-X Function
¾SFP (mini-GBIC) supports 100/1000 Dual Mode
¾Store-and-Forward Switching Architecture
¾Back-plane (Switching Fabric): 7.2Gbps
¾1Mbits Packet Buffer
¾8K MAC Address Table
¾Wide Operating Temperature (-40oC to 75oC)*
Case/Installation
¾IP-30
¾DIN-Rail and Panel Mount
Power Supply
¾Wide Range Redundant Power Design
¾Reverse Polarity Protection
¾Current Overload Protection

2 Manual Documentation Number: EIR618-2SFP-T_5107m
B&B Electronics Mfg Co Inc – 707 Dayton Rd - PO Box 1040 - Ottawa IL 61350 - Ph 815-433-5100 - Fax [phone] – www.bb-elec.com
B&B Electronics – Westlink Commercial Park – Oranmore, Galway, Ireland – Ph [phone] – Fax [phone] – www.bb-europe.com
Spanning Tree
¾IEEE 802.1d Spanning Tree
¾IEEE 802.1w Rapid Spanning Tree
VLAN
¾Port Based VLAN
¾802.1 Q Tag VLAN
¾GVRP
X-Ring
¾X-Ring, Dual Homing, Couple Ring, and Central Ring Topology
Port Trunk with LACP
QoS (Quality of Service)
¾IEEE 802.1p Class of Service
¾Four priority queues per port
¾Port Base, Tag Base and Type of Service Priority
Bandwidth Control
¾Ingress Packet Filter and Egress Rate Limit
¾Broadcast/Multicast Packet Filter Control
Port Mirror: Monitor traffic in switched networks
¾TX Packet only
¾RX Packet only
¾Both of TX and RX Packet
System Event Log
¾System Log Server/Client
¾SMTP e-mail Alert
¾Relay Alarm Output System Events
Security
¾Port Security : MAC address entries/filter
¾IP Security: IP address security management to prevent intrusion
¾Login Security: IEEE802.1X/RADIUS
SNMP Trap
¾Cold Start, Power status
¾Authentication failure
¾X-Ring topology change
¾Link up / Link down
IGMP with Query mode for Multi Media Application

ManualDocumentationNumber:EIR618-2SFP-T_5107m 3
B&B Electronics Mfg Co Inc – 707 Dayton Rd - PO Box 1040 - Ottawa IL 61350 - Ph 815-433-5100 - Fax [phone] – www.bb-elec.com
B&B Electronics – Westlink Commercial Park – Oranmore, Galway, Ireland – Ph [phone] – Fax [phone] – www.bb-europe.com
TFTP Firmware Update and System Configure Restore and Backup
Provides EFT protection 3,000 VDC for power line
Supports 6,000 VDC Ethernet ESD protection
Software Specification
Management
SNMP v1, v2c and v3 management
Web interface management
Telnet interface management
Command Line Interface (CLI) management
SNMP MIB
RFC 1215 Trap
RFC 1213 MIBII
RFC 1157 SNMP MIB
RFC 1493 Bridge MIB
RFC 2674 VLAN MIB
RFC 1643
RFC 1757
RSTP MIB
Private MIB
VLAN
Port based VLAN
IEEE802.1Q Tag VLAN (256 entries)/VLAN ID (up to 4k in
number which can be assigned from 1 to 4096)
GVRP (256 groups)
Double Tag VLAN (Q in Q)*
Private VLAN**
Port Trunk with
LACP
LACP Port Trunk: 4 Trunk groups/Maximum 4 trunk
members
LLDP** Supports LLDP that allows the switch to advertise its
identity and capabilities on the LAN
Spanning tree IEEE802.1d spanning tree
IEEE802.1w rapid spanning tree.
X-Ring Supports X-Ring, Dual Homing, Couple Ring, and Central
Ring

4 Manual Documentation Number: EIR618-2SFP-T_5107m
B&B Electronics Mfg Co Inc – 707 Dayton Rd - PO Box 1040 - Ottawa IL 61350 - Ph 815-433-5100 - Fax [phone] – www.bb-elec.com
B&B Electronics – Westlink Commercial Park – Oranmore, Galway, Ireland – Ph [phone] – Fax [phone] – www.bb-europe.com
Provides redundant backup feature and the recovery time
below 20ms
Quality of service The quality of service determined by port, Tag and IPv4
Type of Service, IPv4/IPv6 Different Service
Class of service Supports IEEE 802.1p class of service, per port provides
4
priority queues
Port Security Supports 100 entries of MAC address for static MAC and
another 100 for MAC filter
Port mirror
TX packet only
RX packet only,
Both of TX and RX packets
IGMP Supports IGMP snooping v1, v2 and v3
Up to 256 multicast groups and IGMP query
IP Security
Supports 10 IP addresses that have permission to access
the switch management and to prevent unauthorized
intruder
Login Security Supports IEEE-802.1X Authentication/RADIUS
Bandwidth control
Supports ingress packet filter and egress packet limit
The egress rate control supports all of packet type and th
e
limit rates are 100K ~ 250Mbps
Ingress filter packet type combination rules are
Broadcast/Multicast/Unknown Unicast packet,
Broadcast/Multicast, Broadcast packet only and all of
packets
The packet filter rate can be set from 100k to 250Mbps
Flow Control Supports Flow Control for Full-duplex and Back Pressure
for Half-duplex
System Log Supports System log record and remote system log serve
r
SMTP Supports SMTP Server and 6 e-mail accounts for
receiving event alert
Relay Alarm Provides one relay output for port breakdown & power fail
Alarm Relay current carry ability: 1A @ DC24V

ManualDocumentationNumber:EIR618-2SFP-T_5107m 5
B&B Electronics Mfg Co Inc – 707 Dayton Rd - PO Box 1040 - Ottawa IL 61350 - Ph 815-433-5100 - Fax [phone] – www.bb-elec.com
B&B Electronics – Westlink Commercial Park – Oranmore, Galway, Ireland – Ph [phone] – Fax [phone] – www.bb-europe.com
SNMP Trap
Up to 3 Trap stations
Cold start, Port link up, Port link down, Authentication
Failure, Private Trap for power status, Power Alarm
configuration, Fault Alarm, X-Ring topology change
DHCP Provides DHCP Client/DHCP Server function
DNS Provides DNS client feature
Supports Primary and Secondary DNS Server
SNTP Supports SNTP to synchronize system clock in Internet
Firmware update TFTP firmware update
TFTP backup and restore
Configuration
upload and
download
Supports binary configuration file for system quick
installation
Package Contents
Managed Industrial Switch x 1
Pluggable Terminal Block x 1
CD ROM with User manual x 1
Mounting plate x 2
Console Cable (RJ-45 to DB9-Female) x 1

6 Manual Documentation Number: EIR618-2SFP-T_5107m
B&B Electronics Mfg Co Inc – 707 Dayton Rd - PO Box 1040 - Ottawa IL 61350 - Ph 815-433-5100 - Fax [phone] – www.bb-elec.com
B&B Electronics – Westlink Commercial Park – Oranmore, Galway, Ireland – Ph [phone] – Fax [phone] – www.bb-europe.com
Hardware Description
Physical Dimension
(W x D x H) 2.83 x 4.13 x 5.98 in (7.2mm x 10.5mm x 15.2 cm)
Front Panel
Front Panel of the industrial switch

ManualDocumentationNumber:EIR618-2SFP-T_5107m 7
B&B Electronics Mfg Co Inc – 707 Dayton Rd - PO Box 1040 - Ottawa IL 61350 - Ph 815-433-5100 - Fax [phone] – www.bb-elec.com
B&B Electronics – Westlink Commercial Park – Oranmore, Galway, Ireland – Ph [phone] – Fax [phone] – www.bb-europe.com
Top View
Top Panel of the industrial switch

8 Manual Documentation Number: EIR618-2SFP-T_5107m
B&B Electronics Mfg Co Inc – 707 Dayton Rd - PO Box 1040 - Ottawa IL 61350 - Ph 815-433-5100 - Fax [phone] – www.bb-elec.com
B&B Electronics – Westlink Commercial Park – Oranmore, Galway, Ireland – Ph [phone] – Fax [phone] – www.bb-europe.com
LED Indicators
LED Status Meaning
Green Power On
PWR
Off No Power Inputs
Green The switch is the master of the X-Ring group
R.M.
Off The industrial switch is not the master of the
X-Ring group
Green Power Source 1 is Available
PWR1
Off Power Source 1 is Unavailable
Green Power Source 2 is Available
PWR2
Off Power Source 2 is Unavailable
Red Power or port failure
Fault
Off Normal Operation
Green
(Upper LED) Connected to network
Blinking
(Upper LED) Network is active
Off
(Upper LED) Not connected to network
Yellow
(Lower LED) Full duplex
Blinking
(Lower LED) Data packet collision
P1 through 16
Off
(Lower LED) Half duplex or not connected to network
P17/18
(10/100/1000T)
Green
(Upper LED) Connected to network