Blodgett BLG-30G User manual

BLODGETT OVEN CO ▪44 lakeside Ave ▪Burlington, VT 05446
Tel. [phone] ▪Fax [phone] ▪www.blodgett.com
PARTS LIST
GAS SKILLETS
MODELS: BLG-30G
BLG-40G

FIGURE 1

PARTS LIST, GAS SKILLETS, MODELS BLG-30, BLG-40
FIGURE 1
QUANTITY
ITEM PART NO. DESCRIPTION BLG-30 BLG-40
1 42572 Pan Cover Assembly 1
42573 Pan Cover Assembly 1
2 42909 Pour Lip Strainer 1 1
3 43312 Base Bracket 2 2
4 40452 Bronze Bearing 2 2
5 43311 Pan Tilt Bracket 2 2
6 43442 Lock Washer, 3/8" 5 5
7 43443 Socket Head Screw, 3/8 - 16 x 1" 4 4
8 40739 Thermocouple, 48" 1 1
9 42706 Cord Set - 120V Units 1 1
10 40991 Transformer, 220/240V - 120V, 100 VA
(220V Units)
11
11 40840 Ground Lug 1 1
12 43444 Component Mounting Plate 1 1
13 41093 Ignition Module, 120V 1 1
* 40871 Wire Harness 1 1
14 41127 Operating Temperature Control, 120V 1 1
15 40708 Terminal Block Section 2 2
40707 End Section 1 1
** 16 41859 Fuse, 1 Amp., 250V (220V) 1 1
41861 Fuse, 3 Amp., 250V (120V) 1 1
17 41844 Fuse Holder 1 1
18 42574 Control Panel 1 1
19 43445 Control Decal 1
43446 Control Decal 1
20 40823 Pilot, Ignition, Green, 125V 1 1

PARTS LIST, GAS SKILLETS, MODELS BLG-30, BLG-40
QUANTITY
ITEM PART NO. DESCRIPTION BLG-30 BLG-40
21 40818 Pilot, Temperature, Red, 125V 1 1
22 41881 Potentiometer Shaft Seal 1 1
** 23 40740 Knob (F) 1 1
40828 Knob (C) 1 1
* 40994 Bezel 1 1
24 40438 Potentiometer Spacer 1 1
25 43447 Set Screw, 1/4 - 20 x ½ 1 1
26 43212 Decal - Tilt 1 1
27 43448 Screw, 10 - 32 x 3 1 1
28 42536 Tilt Handle Assembly 1 1
29 42535 Input Shaft 1 1
30 41131 Adjustable Foot 2 2
31 43449 Flanged Adjustable Foot 2 2
32 40127 External Retaining Ring 1 1
33 42539 Special Flat Washer, ½" 1 1
34 43450 Oilite Bushing 2 2
35 42533 Upper Tilt Arm 1 1
36 42598 Liquid Tight Connector/Strain Relief 1 1
* 42599 Liquid Tight Lock Nut 1 1
37 42596 Tilt Limit Switch 1 1
38 42534 Lower Tilt Arm 1 1
39 42597 External Retaining Ring 1 2
40 42802 Key, 8 mm x 10 mm x 5 ½” 1 1
41 41808 Hex Nut, 3/8 - 16 4 4
42 43451 Socket Head Screw, 3/8 - 16 x 1¼ 4 4
43 42587 Gear Box 1 1
44 42537 Output Shaft 1

PARTS LIST, GAS SKILLETS, MODELS BLG-30, BLG-40
QUANTITY
ITEM PART NO. DESCRIPTION BLG-30 BLG-40
42538 Output Shaft 1
45 43452 Key, 8 mm x 10 mm x 1" 1 1
46 41837 Set Screw, 3/8" x 16 UNC x ½ 1 1
47 43453 Socket Head Screw, 3/8 - 16 NC x 1½ 1 1
48 43454 Side Access Panel 1 1
49 43455 Screw, 10 - 32 x 1 2 2
50 43456 Set Screw, 8 - 32 x 5/16 1 1
51 43457 Yoke Pin 1 1
52 43458 Hex Head Screw, 5/16 - 18 UNC x 1 4 4
* 43459 Slit Lock Washer, 5/16" Diameter 4 4
53 43460 Rear Panel 1
43461 Rear Panel 1
54 43462 Screw, 10 - 32 x ½" 2 2
55 41543 Lock Pin 2 2
56 41546 End Lock Plate 2 2
57 43106 Stationary Disc 2 2
58 41100 Core 2 2
59 41526 Spring 2 2
60 43107 Rotary Disc 2 2
61 41520 End Stop Plate 2 2
62 43463 Screw, 1/4 - 20 x 3/4 8 8
63 43464 Hinge Support Assembly 2 2
64 43465 Flue Assembly 1
43466 Flue Assembly 1
65 43467 Socket Head Screw, ½ - 13 x 1" 2 2
66 43468 Lock Washer, ½" 2 2

PARTS LIST, GAS SKILLETS, MODELS BLG-30, BLG-40
* NOT SHOWN.
** SELECT AS REQUIRED.

PARTS LIST, GAS SKILLETS, MODELS BLG-30, BLG-40

PARTS LIST, GAS SKILLETS, MODELS BLG-30, BLG-40
FIGURE 2

PARTS LIST, GAS SKILLETS, MODELS BLG-30, BLG-40
ITEM PART NO. DESCRIPTION BLG-30 BLG-40
1 43469 Lighter Tube 1
43470 Lighter Tube 1
2 43416 High Limit Thermostat 1 1
3 43471 High Limit Cover 1 1
4 43472 90EConnector, 3/8" 1 1
5 41234 Spark/Sensor 1 1
6 43473 Burner Box 1
43474 Burner Box 1
7 43475 Lighter Orifice #56, Natural Gas 1 1
43475 Lighter Orifice #72, LP Gas 1 1
8 40318 Orifice Bulkhead 1 1
9 43476 Bulkhead Bracket 1 1
10 40443 Elbow, 1/4 C x 1/8 MPT 1 1
11 40616 Union Elbow, ½" 2 2
12 43303 Flange Nipple, ½" 1 1
13 41788 Elbow, ½" 1 1
14 41775 Nipple, ½" x 2" 1 1
15 41893 Gas Shut-Off Valve 1 1
16 41773 Close Nipple, ½" 1 1
17 41812 Reducing Coupling, 3/4" x ½" 1 1
** 18 41045 Gas Control, Natural Gas 1 1
41046 Gas Control, LP Gas 1 1
19 43477 Gas Supply Pipe, ½" x 24 - 1/8" 1 1
20 41797 Union, ½" 1 1
21 41790 St. Elbow, ½" 1 1
22 40393 Orifice #51, Natural Gas 8 10
43478 Orifice #60, LP Gas 8 10
23 43479 Manifold Assembly 1

PARTS LIST, GAS SKILLETS, MODELS BLG-30, BLG-40
ITEM PART NO. DESCRIPTION BLG-30 BLG-40
43480 Manifold Assembly 1
24 40424 Connector, 1/4 CC x 1/8 MPT 1 1
25 43481 Burner 8 10

PARTS LIST, GAS SKILLETS, MODELS BLG-30, BLG-40