Burley NOMAD RACK Instruction Manual

Burley Cargo Rack Limited Warranty
Burley will repair or replace any cargo rack parts it determines to be defective for
the life of the trailer. The owner of a Burley trailer with cargo rack parts installed must
present the trailer for repair at an authorized Burley dealer, together with an original
sales receipt or similar proof of purchase. This warranty applies to the original owner
and is non-transferable. Burley cannot be responsible for failure due to improper
assembly, modication of parts or instructions, neglect, abuse, accident, and/or
normal wear. The warranty does not cover any trailers used for rental, competition,
or commercial use, nor does it cover cargo rack parts used on anything other than
a Burley trailer.
Burley neither assumes nor authorizes any person to assume any other liability in
connection with Burley trailers, and there are no oral agreements or warranties
collateral to or affecting this agreement.
This warranty gives you specic legal rights. You may also have other rights which
vary from state to state.
Burley Design Cooperative
4020 Stewart Road • Eugene, Oregon 97402 USA
[phone] • Fax [phone]
www.burley.com
Copyright © 2004 by Burley Design Cooperative
“Burley” is a registered trademark of Burley Design Cooperative
rev2: 04/04
Nomad Cargo Rack
Owner’s Instruction and Safety Manual
I. Introduction 2
II. Nomad Cargo Rack Parts and Tools 2
III. Installing the Cargo Rack on Your 2004+
Nomad 3
IV. Installing the Cargo Rack on a
Pre-04 Nomad 5
V. Using Your Cargo Rack 5

2
Burley Nomad Cargo Rack Installation Guide
3
Burley Nomad Cargo Rack Installation Guide
I. Introduction



II. Burley Nomad Cargo Rack Parts and Tools
What You Have:
Tools You Will Need:



III. Installing the Cargo Rack on Your 2004+ Nomad
A. Preparation




   
  
  
(2) Roll bar bolts
(2) Bolts
(2)Concave
Spacers
(2) Flat Spacers
(2) Clamps
(2) Locknuts
Cargo Rack Frame
6
Burley Nomad Cargo Rack Installation Guide
7
Burley Nomad Cargo Rack Installation Guide
Notes

6
Burley Nomad Cargo Rack Installation Guide
7
Burley Nomad Cargo Rack Installation Guide






















Buttons
2
Burley Nomad Cargo Rack Installation Guide
3
Burley Nomad Cargo Rack Installation Guide
B. Roll Bar Bolt Installation

 
 
 


C. Knob Installation:





Roll bar
Hole in trailer
(under cover)
Grommet in
trailer cover Roll bar bolt
1
2

4
Burley Nomad Cargo Rack Installation Guide
5
Burley Nomad Cargo Rack Installation Guide
D. Clamp Installation









E. Reectors Installation




1
2
locknut
clamp
concave
spacer
tube
bolt at
spacer
button
strut
4
Burley Nomad Cargo Rack Installation Guide
5
Burley Nomad Cargo Rack Installation Guide
IV. Installing the Cargo Rack on a Pre-2004 Nomad



V. Using Your Cargo Rack:
Now You Are Ready To Pack!






