Burley d'lite Instruction Manual

Owner’s Instructions and Safety Manual
Compatible with the following models: D’LiteTM, SoloTM, Encore® and Tail Wagon® years 2007 to present
Burley 2-Wheel
Stroller Kit

Congratulations!
By purchasing the Burley 2-Wheel Stroller Kit, you’ve increased the fun and
excitement that you and your family can have with your Burley trailer.
Because of the features and guidelines for using your Burley merit close
attention, it is very important that you familiarize yourself with the Stroller by
reading this entire manual and your Burley Trailer manual before use. If you
have any questions, please contact your Authorized Burley Dealer or check our
website at www.burley.com.
Table of Contents
Introduction
Safety Guidelines
Installing the Stroller on Your Trailer
Attaching Wrist Tether
Using Your Stroller
Maintenance
Replacement Parts
Warranty
2
P2
P3
P4
P4
P4
P5
P5
P5-P6
IMPORTANT:

WARNING
!
Failure to observe all of the safety guidelines in this
manual could result in an accident and serious injury
or death.
Safety Guidelines
Protect Your Children
Never leave your children unattended in the Stroller and always use the handle
bar tether. Use the shoulder harnesses and lap belts to securely hold your
children in the Stroller at all times. For maximum stability and safety, seat a
single child in the center. Periodically check the placement of the shoulder
straps, especially for sleeping children. Make sure children cannot put a finger
into the wheel spokes.
Loading Your Stroller
Do not overload your Stroller. The maximum load limit for children and/or cargo
are 75 lbs. (34 kg.) for the Solo Trailer and 100 lbs. (40 kg.) for all other trailers.
When placing children or cargo into the Stroller, keep the load centered or
forward of the axle. Pack the load as low as possible and make sure items cannot
shift. Loose, heavy objects can injure passengers in the event of a sudden stop or
tip over.
Use Your Flag
Always use the safety flag-it will help make the trailer more visible.
Observe Age and Height Restrictions
The Stroller seat is intended only for children old enough to sit upright and alone.
Adequate neck strength is required to hold his/her head upright. A physician
should evaluate anyone who is of questionable developmental age for using this
Stroller. Never carry a child whose sitting height is above the roll bar, because
their chance of injury is significantly higher in the event of a tip over.
Walk on Suitable Surfaces
Use the Stroller only on paths that are meant for walking. Do not use it on
steep slopes , which make the Stroller unstable. You should be able to maintain
traction and control at all times. Do not maneuver the Stroller over stairs or other
obstacles while your child is inside. Never use your Stroller with inline or roller
skates.
3

Installing the Stroller on Your Trailer
Only install the Stroller when the trailer is unoccupied. Engage the parking
brake on your trailer and detach the trailer tow bar. (See your trailer manual for
instructions for removing the tow bar.)
1. Insert the Stroller arms into the tow bar mounts on both sides of the trailer.
The Stroller wheels should be below the Stroller arms.
2. Line up the holes in the rear of the tow bar mounts with the holes in the
Stroller arms. For 2007-2009 trailers, use the hole farthest from the Stroller
wheel. For 2010 and later trailers, the Stroller arm can be inserted farther and
the second hole used.
3. Insert the retaining pins through the holes and lock into place.
4. Close the tow bar clamps (2009 and later D’Lite and Solo only).
When finished strolling, remove the Stroller from both sides of the trailer. Do not
leave the right side Stroller wheel installed while trailering.
Attaching Wrist Tether
Loop the wrist tether around the handlebar
and slide the end of the tether through the
small loop on the other end. Tighten securely
in the center of the handlebar as shown at right.
Using Your Stroller
Test your Stroller and become comfortable with it before using it with your
children. Secure your children safely as explained in your trailer manual, and
never leave them unattended in the Stroller. Engage the parking brake whenever
you take your children in and out of the trailer.
4
WARNING
!
Never leave children unattended in the Stroller. Always use
your wrist tether. Failure to do so may cause you to lose control
of the Stroller, which may cause an accident and injury.

Maintenance
Before each use, inspect the handle, parking brake, and Stroller for damage. If you have
any questions about the operation and maintenance of your Stroller, please contact your
Authorized Burley Dealer.
Replacement Parts
950182 Tongue/wheel assembly, one side
4016201 Safety Tether (not shown)
Burley Accessory Limited Warranty
This Burley accessory is warranted from the date of purchase against defects in
materials and workmanship as follows: frame and plastic parts for two years.
Your original dated sales or delivery receipt showing the date of purchase is your
proof of purchase.
If a defect in materials or workmanship is discovered during the Limited
Warranty period, we will, at our sole option, repair or replace your product at no
cost to you. This warranty is only valid in the country in which the product was
purchased.
The Limited Warranty extends only to the original retail purchaser of this product
and is not transferable to anyone who obtains ownership of the product from the
original purchaser.
The Limited Warranty does not cover claims resulting from misuse, failure to
follow the instructions, installation, improper maintenance and use, abuse,
alteration, involvement in an accident, and normal wear and tear.
The Limited Warranty does not cover products which are used in rental
operations and Burley will not be liable for any incidental or commercial
damages relating to such use.
5

Burley Accessory Limited Warranty Continued
TO THE GREATEST EXTENT PERMITTED BY LAW, THIS LIMITED WARRANTY
IS EXCLUSIVE AND IN LIEU OF ANY OTHER WARRANTY, WRITTEN OR ORAL,
INCLUDING BUT NOT LIMITED TO ANY EXPRESS OR IMPLIED WARRANTY OF
MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. The duration
of any implied warranties, including any implied warranty of merchantability or
fitness for a particular purpose that may exist during the express warranty period
is expressly limited to the limited warranty period.
Some states and countries do not allow limitations on how long an implied
warranty lasts; therefore, the above limitations and exclusions may not apply to
you.
THE CUSTOMER’S EXCLUSIVE REMEDY FOR BREACH OF THIS LIMITED
WARRANTY OR OF ANY IMPLIED WARRANTY OR OF ANY OTHER OBLIGATION
ARISING BY OPERATION OF LAW OR OTHERWISE SHALL BE LIMITED AS
SPECIFIED HEREIN TO REPAIR OR REPLACEMENT, AT OUR SOLE OPTION. IN
ANY EVENT, RESPONSIBILITY FOR SPECIAL, INCIDENTAL AND CONSEQUENTIAL
DAMAGES IS EXPRESSLY EXCLUDED.
Some states do not allow the exclusion or limitation of incidental or
consequential damages, so the above limitation or exclusion may not apply to
you.
This Limited Warranty gives you specific legal rights, and you may have other
rights that vary from state to state or country.
For warranty service or replacement part information for the USA or
Canada, please contact Burley directly by calling 800-311-5294 or emailing
[e-mail]. For warranty service or replacement part information
outside the USA and Canada please contact the place of purchase for warranty
service. Please be prepared to provide the product model, serial number and a
description of the warranty issue.
Some replacement parts may be available for purchase after this limited
warranty expires. Please visit us at www.burley.com or call us at 541-687-1644
for more information.
6

Burley Design
1500 Westec Drive, Eugene, OR 97402
P. 541.687.1644 or 800.423.8445
F. 541.687.0436
[e-mail]
www.burley.com
©2010 Burley Design LLC
“Burley” is a registered trademark of Burley Design LLC
170235 Burley 2-Wheel Stroller Kit Rev 2