Carimali ARMONIA PLUS User manual

QUICK START GUIDE
ARMONIA PLUS/SOFT PLUS
NT-05427-00-EN
ARMONIA SOFT PLUS
ARMONIA PLUS

MACHINE DESCRIPTION
LEGEND
1 PRODUCT CANISTER
2 COFFEE HOPPER / PRODUCT CANISTER
3 COFFEE HOPPER
4 DECAFFEINATED DOOR
5 CARD READER
6 PEOPLE PRESENCE SENSOR
7 DISPLAY TOUCH
8 DOOR LOCK
9 RUBBER PROTECTION
10 ADJUSTABLE COFFEE DISPENSER
11 STEAM WAND
12 GROUNDS BIN
13 DRIP TRAY
Only for US market (ETL Sanitation): The equipment shall be installed with backflow protection to comply
with applicable federal state and local codes.
1
2
3
5
4
6
7
9
8
1
1
10
1
3
1
2

Open the machine front door and power the machine ON by means of the main switch inside the machine
Afterwards check that the machine
door is closed and the ground bin
Press ON to turn he machine ON.
When the boiler temperature of 50°C
(122°F
When the set-
up temperature is reached, the display shows:
To switch OFF the machine press
INFO
STARTING UP
Open the machine front door and power the machine ON by means of the main switch inside the machine
door is closed and the ground bin
and the drip tray are
inserted
(122°F
) is reached, the machine carries
out a group rinsing
up temperature is reached, the display shows:
INFO
i , then press Switch off the machine
Open the machine front door and power the machine ON by means of the main switch inside the machine
inserted
out a group rinsing

FILL IN BEAN HOPPER
Fill in the required amount for daily consumption in order to keep
DISPLAY THE AVAILABL
E
Press the Start key with the machine in SELECT DRINK mode to display the available drinks selection for the SHIFT drink keys:
FILL IN BEAN HOPPER
AND CANISTER
Fill in the required amount for daily consumption in order to keep
coffee and product always fresh
E
SHIFT DRINK SELECTIONS
AND BOILERS TEMPERAT
Press the Start key with the machine in SELECT DRINK mode to display the available drinks selection for the SHIFT drink keys:
AND BOILERS TEMPERAT
URE
Press the Start key with the machine in SELECT DRINK mode to display the available drinks selection for the SHIFT drink keys:

1) COFFEE/CAPPUCCINO/CHOCO DISPENSING
Adjust the dispenser to the correct height and place a cup under it
For SHIFT doses,
swipe to the next page touching the touch screen from right to left
For WAITERS’ CARD
place the smart card above the proper reader before pressing the dose key.
The display shows:
PLEASE NOTE:
a) Press X during dispensing to
stop the selected dose (not av
b)
The cursor indicates the amount of drink being dispensed.
2) HOT WATER DISPENSING
Place a cup under the hot water outlet, and press the hot water
programmed dose is over. The display shows:
For WAITERS’ CARD place the smart card above the proper reader before pressing the dose key.
The display shows:
PLEASE NOTE:
a) Press X during
dispensing to stop the selected dose (not available for Self configuration)
b)
The cursor indicates the amount of drink being dispensed.
c)
Hot water cannot be dispensed simultaneously with steam
DISPENSING
1) COFFEE/CAPPUCCINO/CHOCO DISPENSING
Adjust the dispenser to the correct height and place a cup under it
, then press the touch screen on the
desired dose.
swipe to the next page touching the touch screen from right to left
.
place the smart card above the proper reader before pressing the dose key.
stop the selected dose (not av
ailable for Self configuration)
The cursor indicates the amount of drink being dispensed.
Place a cup under the hot water outlet, and press the hot water
dose key. Dispensing will be automatically stopped once the
programmed dose is over. The display shows:
For WAITERS’ CARD place the smart card above the proper reader before pressing the dose key.
dispensing to stop the selected dose (not available for Self configuration)
The cursor indicates the amount of drink being dispensed.
Hot water cannot be dispensed simultaneously with steam
desired dose.
dose key. Dispensing will be automatically stopped once the

3) DECAFFEINATED DISPENSING (
NOT AVAILABLE FOR SELF
Adjust the dispenser to the correct height and place a cup under it, then open the decaffeinated coffee door, the display sho
- Pour in the powdered coffee
- Close the decaffeinated door
-
Press the touch screen on the desired dose
shows:
PLEASE NOTE:
a) Press X during dispen
sing to stop the selected dose
b)
The cursor indicates the amount of drink being dispensed
c) If the decaffeinated door is not
closed, or if the dose button is not selected, the machine will automatically cancel this function
after 20 seconds. The coffee group will carry out a cleanin
4) EXTRAMILK DISPENSING (
ONLY LM MACHINE, NOT AVAILABLE FOR SELF
Press and keep pressed any milk-
based key
dispensed, the display shows:
Press X to stop the dispensing
NOT AVAILABLE FOR SELF
CONFIGURATION)
Adjust the dispenser to the correct height and place a cup under it, then open the decaffeinated coffee door, the display sho
Press the touch screen on the desired dose
. The
selected dose will be dispensed without the activation of the grinders. T
sing to stop the selected dose
The cursor indicates the amount of drink being dispensed
closed, or if the dose button is not selected, the machine will automatically cancel this function
after 20 seconds. The coffee group will carry out a cleanin
g cycle of the brewing chamber.
ONLY LM MACHINE, NOT AVAILABLE FOR SELF
CONFIGURATION)
based key
having the little bottle icon , after 2 seconds foamed
or steamed
Adjust the dispenser to the correct height and place a cup under it, then open the decaffeinated coffee door, the display sho
ws :
selected dose will be dispensed without the activation of the grinders. T
he display
closed, or if the dose button is not selected, the machine will automatically cancel this function
or steamed
milk will start being

STEAM WAND USE AND C
STEAM WAND
NOT AVAILABLE FOR MACHINE IN SELF CONFIGURATION
WE STRONGLY RECOMMEND TO USE AND CLEAN THE STEAM WAND AS ABOVE SHOWN
1►Before using the steam wand press
the steam key to purge the nozzle
4►After using the steam wand press
the steam key to purge the nozzle
STEAM WAND USE AND C
LEANING
NOT AVAILABLE FOR MACHINE IN SELF CONFIGURATION
WE STRONGLY RECOMMEND TO USE AND CLEAN THE STEAM WAND AS ABOVE SHOWN
6►
DO NOT
any liquid at any time
5►Clean the steam wand by means of a
cloth
2►Use the steam wand to foam or heat
any liquid into the jug by handling the
rubber protection
3
►Press the steam
de
livery before removing the jug
NOT AVAILABLE FOR MACHINE IN SELF CONFIGURATION
WE STRONGLY RECOMMEND TO USE AND CLEAN THE STEAM WAND AS ABOVE SHOWN
DO NOT
leave the steam wand into
any liquid at any time
►Press the steam
button to stop the
livery before removing the jug

DURING WORKING DAY, IF MACHINE LAYS IN STAND
WE STRONGLY RECOMMEND TO CARRY OUT
1
►
Press INFO button
4
►
Insert the black pipe support in the drip
tray grid and press NEXT to confirm
7
►
Once the Power Cleaner is finished
the display shows
POWER CLEANER
DURING WORKING DAY, IF MACHINE LAYS IN STAND
-
BY WITHOUT DISPENSING MILK BASED DRINKS,
WE STRONGLY RECOMMEND TO CARRY OUT
POWER CLEANER
2
►
Press Manual Cleaning
3
►
Press
to confirm
5
►
Insert the silicone tube into the black
pipe support and press NEXT to confirm
6
►
Wait the end of the Power Cleaner.
Afterwards the machine exits the cleaning
menu and it will be ready to
drinks
BY WITHOUT DISPENSING MILK BASED DRINKS,
Press
START next to Power Cleaner
to confirm
Wait the end of the Power Cleaner.
Afterwards the machine exits the cleaning
menu and it will be ready to
dispense

AUTOMATIC CLEANING O
F COFFEE GROUP
AT THE END OF EACH WORKING DAY , AND/OR IN CASE THE MACHINE WILL NOT BE
RECOMMEND TO CARRY OUT AUTOMATIC CLEANING OF THE COFFEE GROUP ,THE MIXER AND THE MILK FROTHER
1
►
Press INFO button
4
►
Press START next to All in one
7
►
Lift the coffee outlets completely
F COFFEE GROUP
- MIXER - MILK FROTHER
-
AT THE END OF EACH WORKING DAY , AND/OR IN CASE THE MACHINE WILL NOT BE
USED SOME TIME, WE STRONGLY
RECOMMEND TO CARRY OUT AUTOMATIC CLEANING OF THE COFFEE GROUP ,THE MIXER AND THE MILK FROTHER
2
►
Press Manual Cleaning
3
►
Press
5
►
Press YES or NO depending if you
want the machine automatically to switch
OFF or not at the end of the cleaning cycle
6
►
Press
want the machine automatically to switch
OFF or not at the end of the cleaning cycle
8
►
Remove and empty the grounds bin
9
►
Clean the grounds bin compartment.
-
STEAM BOILER
USED SOME TIME, WE STRONGLY
RECOMMEND TO CARRY OUT AUTOMATIC CLEANING OF THE COFFEE GROUP ,THE MIXER AND THE MILK FROTHER
Press
SKIP next to Power Cleaner
Press
YES or NO depending if you
want the machine automatically to switch
OFF or not at the end of the cleaning cycle
Clean the grounds bin compartment.

PLEASE NOTE:
a)
Do not interrupt the cleaning cycle. If the cleaning cycle is interrupted by any type of operation unrelated to the
when the machine functioning is set back again, the cleaning cycle will automatically be activated.
b)
Only in case that after the automatic cleaning process of the coffee outlet or the milk frother are not properly dispensing,
out a manual c
leaning; see the following steps.
13
►
Clean the group from any coffee
residues, then close the machine door
15
►
Wait the group cleaning ends, afterwards the machine will carry out mixer and milker
cleaning cycles if present
10
►
Remove and empty also the drip tray.
Only for machines without direct water
discharge
Do not interrupt the cleaning cycle. If the cleaning cycle is interrupted by any type of operation unrelated to the
when the machine functioning is set back again, the cleaning cycle will automatically be activated.
Only in case that after the automatic cleaning process of the coffee outlet or the milk frother are not properly dispensing,
leaning; see the following steps.
1
1
►
Insert cleaning solution into an empty
container having at least 500ml size.
Take the milk feeding tube out of the milk
box, then insert it into the container with
detergent
12
►
Open the machine door
1
4
►
Open the machine door insert the
detergent tablet into the brewing chamber
Wait the group cleaning ends, afterwards the machine will carry out mixer and milker
16
►
Once the
the display shows
machine switches OFF, depending to your
selection previously made
Do not interrupt the cleaning cycle. If the cleaning cycle is interrupted by any type of operation unrelated to the
procedure,
when the machine functioning is set back again, the cleaning cycle will automatically be activated.
Only in case that after the automatic cleaning process of the coffee outlet or the milk frother are not properly dispensing,
carry
Open the machine door
Once the
cleaning cycles are finished
the display shows
select drink page or the
machine switches OFF, depending to your
selection previously made

MANUAL CLEANING OF MILK FROTHER AND COFFEE OUTLET
3
FOR CLEANING OPERATIONS, CARIMALI STRONGLY RECOMMEND TO USE TH
E FOLLOWING DETERGENT
PRODUCTS:
GROUP CLEANING TABLETS MILK FROTHER CLEANER
2
►Remove the coffee outlet from its
holder.
3
►Remove the milk frother from the
coffee outlet and disconnect Silicone
tubes No. -3- and -4.
4
►Disassemble the milk frother in all its
parts (first by turning and then by pulling as
shown in the picture) and wash it either by
hand or in a dishwasher. Make sure that all
the holes are free from milk residues and
also to use provided tools to clean the
holes. Check also that the O-rings are in
good condition
5►Disassemble the coffee outlet (1)
and wash it by hand or in a dishwasher.
Make sure that all the holes are free
from any coffee residues , and also to
use provided tools to clean the holes.
1
►Open the machine door and
remove the coffee outlet cover .

MANUAL CLEANING OF MIXER - ONLY FOR MACHINE WITH INSTANT PRODUCT UNIT
WE STRONGLY RECOMMEND CLEANING THE MIXERS ONCE A DAY
1►Open the dispenser unit door
2
►Remove the pipe from the mixer
3
►Turn the flange 1 anticlockwise,
then remove the mixer 2
4
►
Remove the Decanter
5
►
Rinse the Mixer and the Decanter
in a sink
7
►
Turn the flange clockwise to
reinsert the mixer
8
►Reinsert the pipe from the mixer
6
►
Reinsert the Decanter
2 1

OTHER RECOMMENDED CL
DRIP TRAY CLEANING
CHUTES CLEANING
DISPENSER CLEANING
ONLY FOR MACHINE WITH INSTANT PRODUCT UNIT
Once a day rinse the grounds bin in a
sink.
Once a day rinse the drip tray in a sink.
1►Open the dispenser unit door.
1►Open the decaffeinated door and
remove the chute .
OTHER RECOMMENDED CL
EANING
GROUNDS BIN CLEANING HOPPER
CLEANING
ONLY FOR MACHINE WITH INSTANT PRODUCT UNIT
Once a day rinse the grounds bin in a
sink.
Once a week clean the hopper by means of a
cloth and approved food detergent
4►
Remove the canister
5►
Once a week clean the dispenser
by means of a cloth and approved
food detergent
2►Press the plastic tooth inside ( 1 )
3►Remove the plastic cover ( 2 )
1
2
3►
Once a week clean the coffee chute
by means of a brush and approved
food detergent
2►Once a week clean the
decaffeinated chute by means of a
brush and approved food detergent
CLEANING
Once a week clean the hopper by means of a
cloth and approved food detergent
Remove the canister
Once a week clean the dispenser
by means of a cloth and approved
food detergent
Once a week clean the coffee chute
by means of a brush and approved

MILK FROTHER ADJUSTMENT
FOAM SETTING
The milk frother is equipped with a FOAM REGULATOR which sets the quantity of air needed to froth milk.
Open the machine door turn the ring nut clockwise for thicker foam (small bubbles), or turn it anticlockwise for more voluminous foam
(large bubbles) then lock it with the locknut.
MILK TEMPERATURE SETTING (ONLY FOR MACHINE WITHOUT MTT)
The milk frother is equipped with a MILK TEMPERATURE REGULATOR which reduces the quantity of sucked milk.
Turn the regulator clockwise to increase the milk temperature, or turn it anticlockwise to reduce it.

MACHINE FUNCTIONS ME
1) OPEN DOOR
2) GROUNDS BIN FULL
3) GROUND BIN OUT
4) MISSING COFFEE
5) MISSING DECAFFEINATED
6) DRIP TRAY NOT IN POSITION
7) DRIP TRAY FULL
8) MISSING MILK
9) MILK TANK OUT
IN CASE OF ONE OF THE ABOVE MESSAGES,
IN CASE OF ANY SHUT DOWN ALARM
PLEASE REFER TO YOUR SERVICE CENTER
MACHINE FUNCTIONS ME
SSAGES
IN CASE OF ONE OF THE ABOVE MESSAGES,
THE i BUTTON
LIGHTS UP RED AND A THE MESSAGE IS SHOWN NEXT TO IT
PLEASE REFER TO YOUR SERVICE CENTER
MESSAGE
LIGHTS UP RED AND A THE MESSAGE IS SHOWN NEXT TO IT
MESSAGE

ACCESS THE MAIN SETT
A) ACCESS THE MAIN SETT
ING MENUS WITH PASSW
To enter
the programming environments, a password is required which define the access rights to the different environments.
The password must be composed with 5 numbers.
To insert the passwords proceed as follows:
1) Turn the machine OFF
2) Press SETUP button; the dis
play shows:
3)
Enter one of the following passwords:
-WAITER 6 1 1 1 1
-OWNER 2 2 2 2 2
ACCESS THE MAIN SETT
ING MENUS WITH PASSW
ORD OR SMART
ING MENUS WITH PASSW
ORD
the programming environments, a password is required which define the access rights to the different environments.
The password must be composed with 5 numbers.
play shows:
Enter one of the following passwords:
ORD OR SMART
-CARD
the programming environments, a password is required which define the access rights to the different environments.

After having inserted the password,
the display shows the main menu programming environments:
In case OWNER password
Carimali S.p.A. con socio unico Via Industriale, 1
T: [phone] F: [phone]
www.carimali.com – [e-mail]
the display shows the main menu programming environments:
In case OWNER password
In case WAITER password
Carimali S.p.A. con socio unico Via Industriale, 1
- 24040 Chignolo d'Isola (BG) - Italia
In case WAITER password