Cleveland 24-GM-200 User manual

MODELS:c24-GM-200 c36-GM-300
Cleveland Standard Features
nType 430 Stainless Steel exterior enclosure, Back Splash
and Table Top with #4 finish
nHInged Cabinet Door
n6" Stainless Steel Legs with level adjustment and flanged
feet
nSolid State steam generator Water Level Controls
nLowWater Safety Cut-off
nPressure Limit Controls with 15 psi Safety Valve
nSolid State Electronic SparkIgnition for energy savings
nMajor components serviceable from the front of unit
nNickelguard Steam Generator empties under pressure
(blowdown) automatically upon each Shut-Down. Automatic
Water refill on Start-Up.
nSeparate "Start/Reset" Illuminated switch controls, plus
pressure Gauge
nSteam Generator Drain incorporates Water Cooling
and "Jet Rinsing"
nInsulated steam generator reduces heat loss to work area
nGas Pressure Regulator
nSteam Generator is complete with Access Hole/Cover Plate
and Sight Glass Gauge
nStandard voltage for controls is 115 volt, 60 Hz, single
phase
nSingle Cold water connection (no hot water required)
Options & Accessories
pPower Take-Off Kit (GPTO)
pSecondaryLowWater Cut-Off, factoryinstalled (CALG)
(Required for AZ. AR. CA. CO. CT. DE. FL. GA. HI. IL. IA. KS. MD. MA. MI.
MN. MT. NE. NV. NM. NC. OK. OR. PR. RI. TN. UT. VA. WA. WV., Buffalo, NY,
Wash. DC)
pGas,other than natural
pInsulated Flue for island installation
pStainless Steel Base Frame (SSF)
pBoiler Descaling Pump Kit (107142)
Shall be CLEVELAND, Modular Cabinet Base, Model _____ -GM _____ M,
Nickelguard, BTU gas generator, type 304 Stainless Steel Exterior enclosure,
Table Top and 6" Level Adjustable Legs. Console mounted controls,
Pressure Gauge and Illuminated "Start/Reset" control switches. Solid State
Water Level Steam Generator Controls. Steam Generator drains under pres-
sure (blow-down) after each Shut-Down, Automatic Water Fill on Start-Up. 15
psi Safety Valve.
ShortFormSpecifications
SECT. VII PAGE 3
0707
Cleveland
™
Project ________________________________
Item __________________________________
Quantity_______________________________
FCSI Section ____________________________
Approval _______________________________
Date __________________________________
1333 East 179 St.,
Cleveland, Ohio,U.S.A. 44110
Tel: [phone]
Fax: [phone]
Web Site:www.ClevelandRange.com
Email: [e-mail]
MODULAR BASES
MODULAR CABINET BASE
GAS-FIRED STEAM GENERATOR with NICKELGUARD™
200, 250 or 300M BTU
24" (600MM) or 36" (900MM) WIDE BASE
1
0
0
%
5
Y
e
a
r
B
o
i
l
e
r
W
a
r
r
a
n
t
y
N
i
c
k
e
l
G
u
a
r
d
™

11/2” IPS common drain.
Do not connect other
units to this drain.
Do not use PVC pipe for
drain.
NOTES:
Cleveland Range reserves right of design improvement or modification, as warranted.
Many regional, state and local codes exist and it is the responsibility of the owner and installer to comply with the codes.
Cleveland Range equipment is built to comply with applicable standards for manufacturers. Included among those approval agencies are ASME/N. Bd, NSF and CSA (AGA, CGA).
(NOT TO SCALE)
SECT
.VII P AGE 4
0707
Litho in U.S.A.
WATER QUALITY REQUIREMENT
The recommended minimum water quality standards
whether untreated or pre-treated, based upon 10 hours of
use per day, and a Daily Blowdown, are as follows:
TOTAL DISSOLVED SOLIDS less than 60 parts per million
TOTAL ALKALINITY less than 20 parts per million
SILICA less than 13 parts per million
pHFACTOR greater than 7.5
CHLORINE less than 30 parts per million
Consult a local water treatment specialist for an on site
water analysis for recommendations concerning steam
generator feed water treatment (if required), in order to
remove or reduce harmful concentrations of minerals. The
use of highly mineralized water will mean that more
frequent servicing of the steam generator will be necessary.
The fact that a water supply is potable is not proof that it
will be suitable for the generator.
Right - 6”, Left - 6”, Rear - 6”
(12” on control side if adjoining
wall or equipment is over 30”
high for service access)
For use in non-combustible
locations.
Contact factory for
variances to clearances.
5.0 Amps