Cleveland 24-SM User manual

Cleveland
™
Project ________________________________
Item __________________________________
Quantity_______________________________
FCSI Section ____________________________
Approval _______________________________
Date __________________________________
1333 East 179 St.,
Cleveland, Ohio,U.S.A. 44110
Tel: [phone]
Fax: [phone]
Web Site:www.ClevelandRange.com
Email: [e-mail]
MODULAR BASES
MODEL:c24-SM
Cleveland Standard Features
nType 430 Stainless Steel exterior enclosure and Table Top
n6" Stainless Steel Legs with level adjustment with flanged
feet
nSolid State steam generator Water Level Controls
nLow Water Power Cut-off
nPressure Limit Controls with 15 psi Safety Valve
nMajor Components serviceable from the front of unit
nSteam Generator empties under pressure (blowdown)
automatically upon each Shut-Down. Automatic Water
Refill on Start-Up
nSeparate "Start/Reset" Illuminated switch controls, plus
Pressure Gauge
nSteam Generator Drain incorporates Water Cooling and
"Jet/Rinsing"
nSteam Generator is complete with Access Hole/Cover Plate
and Sight Glass Gauge
nSecondaryLowWater Cut-Off, factory installed (CALS)
(Required for AZ. AR. CA. CO. CT. DE. FL. GA. HI. IL. IA. KS. MD. MA. MI.
MN. MT. NE. NV. NM. NC. OK. OR. PR. RI. TN. UT. VA. WA. WV., Buffalo, NY,
Wash. DC)
nStandard voltage is 115 volt, 60 Hz, single phase
nSingle cold water connection (no hot water required)
Options & Accessories
pVoltages for controls other than standard
pStainless Steel Base Frame (FSS)
Shall be CLEVELAND, Modular Cabinet Base with Steam Coil Steam
Generator Model _____ -SM. Type 430 Stainless Steel exterior enclosure,
Table Top and four Level Adjustable Legs. Console mounted controls,
Pressure Gauge and "Start/Reset" control switches.Solid State Water Level
Steam Generator Controls. Steam Generator drains under pressure (blow-
down) after each Shut-Down, Automatic Water Fill on Start-Up. 15 psi Safety
Valve.
Short Form Specifications
SECT. VII PAGE 5
0707
MODULAR CABINET BASE
STEAM COIL STEAM GENERATOR
24" (600 MM) or 36" (900 MM) WIDE BASE

3/4” IPS. Do not connect
to common drain.
Do not use PVC pipe for drain.
100 watts
NOTES:
Cleveland Range reserves right of design improvement or modification, as warranted.
Many regional, state and local codes exist and it is the responsibility of the owner and installer to comply with the codes.
Cleveland Range equipment is built to comply with applicable standards for manufacturers. Included among those approval agencies are ASME/N. Bd, NSF and UL.
(NOT TO SCALE)
SECT
.VII P AGE 6
0707
Litho in U.S.A.
WATER QUALITY REQUIREMENT
The recommended minimum water quality standards
whether untreated or pre-treated, based upon 10 hours of
use per day, and a Daily Blowdown, are as follows:
TOTAL DISSOLVED SOLIDS less than 60 parts per million
TOTAL ALKALINITY less than 20 parts per million
SILICA less than 13 parts per million
pH FACTOR greater than 7.5
CHLORINE less than 30 parts per million
Consult a local water treatment specialist for an on site
water analysis for recommendations concerning steam
generator feed water treatment (if required), in order to
remove or reduce harmful concentrations of minerals. The
use of highly mineralized water will mean that more
frequent servicing of the steam generator will be necessary.
The fact that a water supply is potable is not proof that it
will be suitable for the generator.
Right - 3”, Left - 3”, Rear - 3”
(12” on control side if
adjoining wall or equipment
is over 30” high for service
access)
Contact factory for
variances to clearances.