Cornelius JETSPRAY LT1 User manual

YourStandardof ExceUencefor BeverageMerchandisingon Six Continents
Document No . 11341
Revision N 0
December 1994
Printed in the USA
Manufa ctured b y Jet Spray Corpora tion
825 Univers ity Avenue , P.O. Box 8250,Norwood, MA 02062
This manual applies to models of
Serial Numbe r 314936 or higher .
Mmw...
LTI
LTl-WI6
LTl-W25
Instant Liquid Iced Tea Dispenser
J6J=-==-..r
":,::-",,, "'\ ~~rpITS LIST
B

*EXPORT MODEL LT1-W25 REOUIRES A 220/240V 50HZ OUTLET
-1-
5.
J[j
Remove drip tray and grille.
Remove front panel assembly from unit by
lifting up and pulling out from the bottom .
(See sketch.)
4.
3. Place flare gasket in check valve and connect to water
inlet at rear of unit. (See instruction sheet
included with check valve.) Connect a 1/4" 00 copper
water line to the fitting on the check valve and to a
30-125 psig water supply. Water line should be long
enough so that unit can be moved for cleaning.
2. Do not plug in the unit.
1. Place dispenser on a flat, sturdy surface accessible to
a 115 volt 60Hz* outlet and a 30-125 psi water supply.
It is recommended that a shutoff and an 80/100 mesh
strainer be installed in the water line.
A. INSTALLATION INSTRUCTIONS:
A water line is connected to the solenoid valve through a fitting
located on the rear panel of the unit. A one gallon container of
tea concentrate is placed inside the unit through the removable
front panel. A product tube is placed inside the gallon
container of tea concentrate , and runs up to the mixing block.
When the push handle is depressed it closes a switch, acti vating
the solenoid valve, allowing water to pass through the mixing
block. The pressure drop in the mixing valve allows syrup to be
siphoned from its container, mixed with water, and dispensed out
the outlet tube.
BRIEF DESCRIPTION OF HOW THE UNIT WORKS
The Model LT1 is intended for commercial use. It is a compact,
lightweight, countertop unit designed to dispense a mixture of
tea concentrate and water simply by activating a push handle.
The proper electrical outlet, one gallon of tea concentrate, and
a water source are all that is required to set the dispenser
into operation.
Instant Liquid Iced Tea Dispenser
MODEL LT1
© 1994-2014, Cornelius Inc.
Publication Number: 11341IPL

-2-
1. Drip tray, grille, and product tube assembly may be
washed in warm soapy water, such as Joy. Rinse
thoroughly in potable water.
2. Clean the outside of the dispenser with a clean damp
cloth and mild soap.
C. CLEANING UNIT
2. To adjust this ratio for a richer or weaker drink, use
the 1/8" Allen wrench packed in the drip tray.
Adjustments are made through a hole located in the
upper right hand side panel. using the 1/8" Allen
wrench, turn the adjusting screw counterclockwise for
a richer drink and clockwise for a weaker drink.
1. The ratio of concentrate to water is factory set for a
5 to 1 mix.
B. RATIO CONTROL - CONCENTRATE TO WATER
*EXPORT MODEL LT1-W25 REQUIRES A 220/240V 50HZ OUTLET
12. unit is now set for operation.
11. Depress push handle to prime unit.
NOTE: Draw approximately 12 oz. until product line is
full.
10. Turn on power switch, located on rear of unit.
7. Replace front panel assembly.
8. Replace drip tray and grille.
9. Plug power cord into 115 volt 60Hz* outlet.
6. Remove cap and product tube assembly from inside unit.
Place cap and product tube in a full gallon of
concentrate. Slide container of concentrate into unit
making sure that the plastic line from the product tube
assembly is not crimped in any way.
Publication Number: 11341IPL
© 1994-2014, Cornelius Inc.

-3-
MODEL LTl WIRING DIAGRAM
POWER CORD
(.LUE 230/24OV)
WHITE
*Diversey Wyandotte Multi-Chlor or Equivalent Powder of Liquid
Sanitizer
Using a clean one gallon container mix 1/2 teaspoonful
(100 parts/million) of approved powdered chlorine sanitizer*
with four quarts of water. Depress push handle until all
the sanitizing solution has been used.
E. SANITIZING DISPENSER
3. Follow Installation Instructions #7 through #10.
Activate push handle for three to four minutes.
4. Replace cleaning solution with one gallon of potable
water. Rinse valve assembly.
2. Reconnect product tube assembly to mixing valve.
Place other end of product tube assembly in cleaning
solution.
1. Fill a clean one gallon container with warm water
(70'F-100'F) and two ounces of cleaning solution,
such as Joy.
D. CLEANING MIXING VALVE
© 1994-2014, Cornelius Inc.
Publication Number: 11341IPL

-6234
Telephone [phone]
Facsimile 1-800-258-0255
ILLUSTRATED PARTS LIST
LT-1 COLD BEVERAGE DISPENSER
MODEL NO.
A1371
A1456
CORNELIUS INC.
One Cornelius Place
Anoka, MN. 55303-
www.cornelius.com
© 1994-2014, Cornelius Inc.
© 2001-2014, Cornelius Inc.
-4-
Publication Number: 11341IPL

- - -
--.~
-6234
Telephone [phone]
Facsimile 1-800-258-0255
www.cornelius.com
ILLUSTRATED PARTS LIST
LT-1 COLD BEVERAGE DISPENSER
FIGURE 1. GENERAL ASSEMBLY
CORNELIUS INC.
One Cornelius Place
Anoka, MN. 55303-
© 1994-2014, Cornelius Inc.
-5-
Publication Number: 11341IPL

-6234
Telephone [phone]
Facsimile 1-800-258-0255
www.cornelius.com
ILLUSTRATED PARTS LIST
LT-1 COLD BEVERAGE DISPENSER
Item
No. Part No. Name
118805001 Drip Tray (Serial No. 314936 and
Above)
A1500 Drip Tray (Serial No. 3149356 and
Below)
218805002 Cup Rest (Serial No. 314936 and
Above)
318786 Panel Fnt Asy (Serial No. 314936
and Above)
A3506 Panel Fnt Asy (Serial No.
14380-314935)
A1333 Panel Fnt Asy (Serial No. 14380
and Below)
4A3507 Push Handle (Serial No. 14380
and Above)
A1506 Push Handle (Serial No. 14379
and Below)
5A1834 Cap
6A1365 Tube Protector Product
7A1340 Spout Extension
8S8214 Switch Wtr Push Btn
9A5186 Switch Rocker (Serial No. 22622
and Above)
S3004 Switch Toggle (Serial No. 22621
and Below)
10 S3837 Plate Switch
11 S1675 Nut Knurled Ring
12 A1364 Outlet Tube
13 A1909 Block Mixing
14 S9178 Cover Top Panel
15 A1386 Screw Panel (Pack of 4)
16 A1339 Solenoid Valve Asy 120V 60HZ
A1430 Solenoid Valve Asy 220/240V
60HZ
Item
No. Part No. Name
17 S3746 Ring (Pack of 12)
18 S5624 Screw and O-Ring Adjust
19 A2161 Conn Check Valve Union
20 A2557 Valve Chk Inline
21 Item Not Used
22 S4159 Tool Wrench Allen
23 A1724 Fitg Inlet Water
24 S1249 Cord Serv
25 S6778 Foot
26 A1360 Drip Tray
27 A1505 Pin Cotter
28 Item Not Used
29 Item Not Used
30 S9526 Tube S.S.
31 S6410 Screw (Pack of 4)
32 A8807 Panel Fnt Asy (Serial No. 314936
and Above; No Longer Available)
A1333 Panel Fnt Asy (Serial No. 314935
and Below)
33 18805 Drip Tray Ass’y (Serial No.
314936 and Above; No Longer
Available, Order 18805001 and
18805002)
A1503 Drip Tray Ass’y (Serial No.
314935 and Below)
34 A1900 Restrictor Plug
35 A5601 Valve Chk Ball Single
S6783 Valve Chk Kit Ball, Double
CORNELIUS INC.
One Cornelius Place
Anoka, MN. 55303-
-6-
© 1994-2014, Cornelius Inc.
Publication Number: 11341IPL